[Integral ABS] Performing bleed test with BMW MoDiTeC Final inspection and function check d Warning: Self-diagnosis is not performed unless both brake levers are in their fully released positions. Prior to the conclusion of the self-diagnosis, only RESIDU- AL BRAKE FUNCTION is available. • Clutch • Check gear shift action. • Handbrake and foot brake • Check lights and signalling equipment:
– Front and rear parking lights – Instrument lighting – Low and high headlight beams, headlight flasher – Brake light (operate brake at front and rear) – Turn signals left/right – Hazard warning flashers – Horn – Indicator and warning lights – Instruments • Where necessary, check function of optional ex- tras: • If necessary, take the motorcycle for a test ride. • Confirm pre-delivery check in Service and Tech- nical Booklet. • See “Checking motorcycle for damage” if defects are found. Performing BMW Integral ABS self-diagnosis: • Release the brake levers if necessary. • Switch on the ignition.
ABS warning light.............................flashes at 4 Hz General warning lamp ........................is continuous – Self-diagnosis is in progress ABS warning light.............................flashes at 1 Hz General warning lamp ...............................goes out – Self-diagnosis successfully completed. Performing a bleed test using the BMW MoDiTeC: • Remove front/rear seat. • Connect the BMW MoDiTeC to the diagnostic connector. d Warning: Avoid rapid and forceful pumping of the brakes when performing maintenance and repair work on the BMW Integral ABS. 00 11 459 Final cleaning • Clean the motorcycle. L Note: Do not use a steam or high-pressure water jet.
The high steam or water pressure could damage seals, the hydraulic system or electrical components. • Perform bleed test. • Perform all requisite repair work. Performing BMW Integral ABS pull-away test: • The ABS warning light must go out when a speed of 5 km/h (approx. 3 mph) is reached. L Note: The ABS warning light and the general warning light must both be OFF after successful self-diagnosis and the pull-away test. 00.20