Caterpillar BK-14 — инструкция

SENR4706 April 1990 1 7 1 4 10 11 10 5 6 28 7 16 C 13 5 29 12 14 2 3 11 17 D A 8 8 9 15 25 12 21 23 24 9 18 19 22 B 6 4 20 26 2 13 3 27 D11N Tractor Electrical System 22 4 D 74Z730-UP B C A 12 25 7 11 10 3 9 1 13 9 1 13 3 4 5 6 27 28 8 8 20 2 7 21 5 12 18 Vehicle locations are repeated for connectors located close together. * = Connector is located at the component. 19 16 15 26 24 29 6 2 14 11 10 23 17 VEHICLE HARNESS CONNECTOR AND COMPONENET LOCATIONS C32095P2 © 1990 Caterpillar All Rights Reserved Printed in U.S.A. Electrical Schematic Symbols And Definitions Harness And Wire Electrical Schematic Symbols A AA 1 T Typical representation of a Deutsch connector.

The plug contains all sockets and the receptacle contains all pins. Typical representation of a Sure-Seal connector. The plugand receptacle contain both pins and sockets. Pressure Temperature Level Symbol Flow Symbol Plug Receptacle Symbol Symbol 2 Pin or Socket Number Normally open switch that will close with an increase of a specific condition (temp-press-etc.). Wire, Cable, or Harness Assembly Identification Component Part Number Single Wire Connector Normally open switch that is closed due to an applied condition, and will open again with a specific decrease in that condition.

325-PK-14 C A A AA 9X-1123 325-PK-14 Socket Pin Wire Color Normally closed switch that will open with an increase of a specific condition. 200-BK-14 Normally closed switch that is open due to an applied condition, and will close again with a specific decrease in that condition. Circuit Number Identification Wire Gauge The circle indicates that the component has screw terminals and a wire can be disconnected from it. Electrical Schematic Symbols And Definitions FUSE - A component in an electrical circuit that will open the circuit if too much current flows through it. No circle indicates that the wire cannot be disconnected from the component.

REED SWITCH - A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch. This indicates that the component has a wire connected to it that is connected to ground. SENDER - A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure. T RELAY (Magnetic Switch) - A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it.

The electromagnet can open or close the switch part of the relay. This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. CIRCUIT BREAKER (C/B) - A component in an electrical circuit that will open the circuit if too much current flows through it. This does not destroy the circuit breaker and it can be reset to become part of the circuit again. SOLENOID - A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work.

Vehicle locations are repeated for components located close together. A = Components in operator compartment - Front dash. B = Components in operator compartment - Right console. C = Components in operator compartment - Left console. D = Components in operator compartment. MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is activated by electricity and held latch by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

Harness Connector Location Chart Vehicle Schematic Vehicle Schematic Connectors 30 Contacts Location 1 Harness And/Or Components YY - 9N4539 Ether Control Location F-12 Connectors 5 Contacts Location 5 Harness And/Or Components A - 6T0856 H - 6Y0059 Location C-3 25 Contacts 2 B - 6Y2905 D - 6Y4224 E-4 10 B - 6Y2905 C - 3T3596 E-1 20 Contacts 3 D - 6Y4224 Diagnostic Connector F-6 1 BBB - 9N4623 YY - 9N4539 F-10 * D - 6Y4224 Operator Monitor (EMS) F-5 6 E - 6Y2907 N - 7T5368 A-7 * E - 6Y2907 Fire Suppression Control B-3 11 J - 9W7709 K - 7T6055 F-8 15 Contacts 2 D - 6Y4224 H - 6Y0059 F-4 1 YY - 9N4539 GGG - 8E0790 E-11 10 Contacts 4 P - 7T9222 Q - 7T9218 C-7 5 YY - 9N4539 ZZ - 9N4537 D-4 8 Contacts 5 A - 6T0856 B - 6Y2905 C-3 4 Contacts * A - 6T0856 Ripper Pin Puller Solenoid A-9 * CC - 8E3006 Overspeed Monitor E-6 * C - 3T3596 Dual Tilt Solenoid E-1 * CC - 8E3006 Overspeed Monitor F-6 12 D - 6Y4224 F - 3T7147 C-6 4 P - 7T9222 Q - 7T9218 C-7 * E - 6Y2907 Discharge Switch B-3 7 Contacts 6 A - 6T0856 U - 6T2215 A-7 13 H - 6Y0059 J - 9W7709 F-7 5 AAA - 9N4538 YY - 9N4539 C-4 13 H - 6Y0059 XX - 9W7012 E-7 7 B - 6Y2905 H - 6Y0059 F-3 * P - 7T9222 Front Wiper Motor D-7 8 E - 6Y2907 M - 7T5569 B-3 * P - 7T9222 Left Wiper Motor E-7 * M - 7T5569 Fire Suppression Monitor E-7 * P - 7T9222 Right Wiper Motor B-6 6 Contacts 2 B - 6Y2905 E - 6Y2907 C-3 * T - 3T6373 Rear Wiper Motor D-9 * E - 6Y2907 Fire Detection Switch B-3 9 E - 6Y2907 VV - 7T5570 A-2 * VV - 7T5570 Fire Detection Switch C-2 Off Vehicle Switch Specifications Part No.

Function Actuate Deactuate Normal Condition 3T9343 Power Train Filter Press (EMS) 210 ± 70kPa (30 ± 10 psi) - - N.O. 6T4949 Engine Oil Press (EMS) 93 ± 21 kPa (13.5 ± 3.0 psi) 69 ± 21 kPa (10.0 ± 3.0 psi) N.O. 6T6085 Nitrogen Actuator Press (Fire) 1930 ± 138kPa (279.5 ± 20.0 psi) 1655 ± 138kPa (240.5 ± 20.0 psi) N.O. 7N4447 Fuel Filter Press (EMS) 119 ± 14kPa (17.0 ± 2.0 psi) - - N.C. 7N9560 Power Train Oil Temp (EMS) 129.4 ± 2.8°C (265 ± 5°F) 118.3°C MIN (245°F MIN) N.C. 7N9785 Engine Coolant Temp (EMS) 107.2 ± 2.8°C (225 ± 5°F) 91.0°C MIN (196°F MIN) N.C. 7T4371 Discharge Press (Fire) 93 ± 21 kPa (13.5 ± 3.0 psi) 69 ± 21 kPa (10.0 ± 3.0 psi) N.O.

7T4785 Fire Detection Temp 193.3 ± 8°C (380 ± 15°F) - - N.O. 8C5436 Agent Press (Fire) 2270 kPa MAX (330 psi MAX) 1655 ± 138kPa (240 ± 20 psi) N.O. 9G1300 Hydraulic Temp (EMS) 110.0 ± 2.8°C (230 ± 5°F) 101.7°C MIN (215°F MIN) N.C. 9G3341 Power Train Filter Temp (EMS) 51.7 ± 2.8°C (125 ± 5°F) 43.0°C MIN (110°F MIN) N.C. 9X3040 Engine Coolant Flow (EMS) 362 ± 29 mN (45.6 mm ID point) (1.3 ± .1 oz, 1.8 in ID point) 303 mN MIN (1.1 oz MIN) N.O.

9X4276 Fuel Press (EMS) 93.0 ± 20.8 kPa (14.0 ± 3.0 psi) 68.9 ± 20.8 kPa (10.0 ± 3.0 psi) Wire Description Chart Wire Number Wire Color Description Wire Wire Description Number Color Accessory Circuits 500 BR WIPER - FRONT (PARK) 501 GN WIPER - FRONT (LO) 502 OR WIPER - FRONT (HI) 503 BR WIPER - REAR (PARK) 504 YL WIPER - REAR (LO) 505 BU WIPER - REAR (HI) 510 YL WASHER - PRIMER 513 OR A/C COMPRESSOR/REFRIGERANT PRESS.

SW 515 GY BLOWER MOTOR (HI) 516 GN BLOWER MOTOR (MEDIUM) 517 BU BLOWER MOTOR (LO) 521 YL A/C SW TO REFRIGERANT SW 522 WH A/C CLUTCH TO THERMOSTAT SW 523 BR WIPER - LEFT (PARK) 524 BU WIPER - LEFT (LO) 525 GY WIPER - LEFT (HI) 526 YL WIPER - RIGHT (PARK) 527 GN WIPER - RIGHT (LO) 528 PK WIPER - RIGHT (HI) 533 OR FIRE SUPPR HEAT SENSOR/TEST SW 534 WH FIRE SUPPR HEAT SENSOR/TEST SW 553 YL PITCH SOL TO TRIGGER SW - DUAL TILT 554 PK MOMENTARY SW TO SINGLE TILT SOL- DUAL TILT Lighting Circuits 600 BR DASH LAMP BASIC 608 GN FLOOD LAMP - REAR 609 YL FLOOD LAMP - SIDE 610 OR HEAD LAMP BASIC 633 BU ATTACH LIGHTING CKT Control Circuits 779 WH COUPLER ENGAGE SOL 780 PU COUPLER DISENGAGE SOL 788 YL ENG SPEED (+) 803 BU AUTO FIRE SUPPR SYSTEM SW POWER 805 PK AUTO FIRE SUPPR BRAKE SW 807 BR AUTO FIRE SUPPR NITROGEN SW TO CONT 808 PU AUTO FIRE SUPPR NITROGEN SW TO NITROGEN SW 809 GN AUTO FIRE SUPPR SYSTEM WARNING CKT 810 BU AUTO FIRE SUPPR SYSTEM FAILURE CKT 811 GY AUTO FIRE SUPPR TEST CKT 812 GN AUTO FIRE SUPPR NITROGEN ACTUATOR SOL 813 PK AUTO FIRE SUPPR AGENT CYLINDER SW TO NITROGEN SW 814 YL AUTO FIRE SUPPR AGENT SW TO AGENT SW 816 BR AUTO FIRE SUPPR ALARM 919 GN ENG OVERSPEED TEST SW A717 OR START AID SENSOR SUPPLY A718 PU START AID COOLANT SENSOR SIGNAL A720 PK START AID ENGINE SPEED SIGNAL B922 WH START AID LAMP RESET SW #1 B923 YL START AID LAMP RESET SW #2 B941 GY START AID CONT SOL 1 & 2 RET B943 PK START AID CONT LAMP 1 OUTPUT B944 PU START AID CO NT ALARM OUTPUT B945 WH START AID CONT SENSOR 1 B946 YL START AID CONT SENSOR 2 B948 BR START AID CONT SENSOR 4 B954 YL START AID CONT TEST SW INPUT B998 BU START AID CONT LAMP 2 OUTPUT Wire Color Description Power Distribution Circuits 101 102 105 107 108 109 112 113 114 116 121 123 124 146 174 177 184 RD BU BR WH BU OR PU OR GN BR YL WH GN GY PK OR BU BATTERY HEAD LAMP KEY SW ENG SHUT-DOWN/AUTO FIRE SUPPR CONT AUX CKT ALTERNATOR OUTPUT (+) TERM.

MAIN POWER RELAY OUTPUT OPR MON PANEL/VMIS B+ SWITCHED WARNING HORN (FORWARD) AUX CKT BACKUP ALARM/LAMP AUX CKT A/C AUX CKT AUX CKT MAIN BKR AUX CKT Ground Circuits 200 201 203 207 209 237 245 246 247 BK BK BK BK BK BK BK BK BK MAIN CHASSIS OPR MON PANEL/VMIS/CMS CHASSIS DIAGNOSTIC STARTER DIAGNOSTIC FIRE SUPP SYSTEM GROUND KBI ETHER CONT GROUND ETHER CONT HARNESS CODE 0 ETHER CONT HARNESS CODE 1 ETHER CONT HARNESS CODE 2 248 BK ETHER CONT HARNESS CODE 3 Basic Machine Circuits 301 302 304 306 307 308 310 311 312 313 314 321 322 326 327 328 BU OR WH GN OR YL PU WH PK GY PU BR GY PU PK OR STARTER NO.1 SOL STARTER NO.1 RESISTOR TO DIAGNOSTIC STARTER RELAY NO.1 OUTPUT STARTER RELAY COIL TO NEUT START SW OR KEY SW KEY SW TO NEUT START SW OR VMIS SENSOR MODULE MAIN POWER RELAY COIL START AID SW TO START AID SOL START AID SOL TO TEMP SW STARTER NO.2 SOL TO RESISTOR STARTER NO.2 RESISTOR TO DIAGNOSTIC STARTER RELAY NO.2 OUTPUT BACKUP ALARM/LAMP/TRAVEL ALARM WARNING HORN (FORWARD) KEY SW "C" TERM.

Стр. 1

12 1 BLOWER 9G8697 MOTOR MOTOR WH/RD-14 BK-14 2 1 WH/RD-14 BK-14 K K 515-GY-14 200-BK-14 2 1 BLOWER 9G8697 200-BK-14 L16 L16 609-YL-14 609-YL-14 2 1 FLOOD LAMP 9W1279 AUX START RECEPTACLE 522-WH-14 THERMOSTAT SW 9X5445 L11 L8 OPERATOR STATION D H L8 L11 KK AA MM H RD-00 RESISTOR 6T2217 304-WH-8 G S RD-00 W/ATCH HEAD LAMP REPLACE HARNESS LL WITH HARNESS X 522-WH-14 K J J H 5 4 522-WH-14 -T 609-YL-14 16 L17 PWR TN FLTR 17 426-BR L17 2 1 307-OR 306-GN L8 426-BR 121-YL 608-GN-14 124-GN-14 201-BK 200-BK-14 513-OR-14 521-YL-14 609-YL-14 NEG POS NEG POS BB EE BK-00 BK-00 ZZ DISCONNECT SW BK-00 BK-00 1 2 MTR BAT DD ETHER BOTTLE RESET SW 1 3T3133 WASHER PUMP 7T8891 RESISTOR 9G1950 517-BU-14 516-GN-14 515-GY-14 200-BK-14 516-GN-14 3 2 1 515-GY-14 124-GN-14 521-YL-14 3 1 2 200-BK-14 B HEAD LAMP 9W1282 HEAD LAMP 8C5512 F + BATTERY A K M YY 308-YL 308-YL 308-YL YY 1 BBB - + MOTOR 517-BU-14 517-BU-14 4 200-BK 2 1 610-OR-14 610-OR-14 F GROUND RESET SW 1 SENSOR 1 S B922-WH B945-WH 237-BK 237-BK BR B922-WH B945-WH 237-BK BR 4 5 2 3 510-YL-14 200-BK-14 L6 L6 L5 516-GN-14 521-YL-14 515-GY-14 513-OR-14 522-WH-14 608-GN-14 121-YL 200-BK 200-BK RESET SW 4 RESET SW 3 SENSOR 2 SOL RET 3&4 CAT LINK + CAT LINK - G F C P Y Z 105-BR 124-GN-14 C X 1 2 LL C RESET SW 2 L B923-YL 105-BR B923-YL YY 2 CCC ETHER BOTTLE RESET SW 2 3T3133 608-GN-14 321-BR 121-YL 608-GN-14 608-GN-14 121-YL 321-BR 321-BR 200-BK 200-BK 121-YL 608-GN-14 L11 L8 L11 200-BK 610-OR-14 SOL 4 B998-BU OUT LAMP 2 TEST SW START B V R N T E B954-YL 306-GN L1 L1 1 3 BR BR FLOOD LAMP 9W1279 L7 L B OUT LAMP 1 MANUAL OUT HORN X B944-GN B946-OR B943-PK AIR CONDITIONER CLUTCH SOLENOID 7N4296 522-WH-14 513-OR-14 -T MOTOR H S2 S1 DUAL TILT SOLENIOD 6T8208 SPARE ENG SPD COOL TEMP SENSOR +V O I W H D A718-PU A720-PK A717-OR L2 L2 608-GN-14 321-BR 121-YL BK-14 BK/PK-14 L 2 1 H L7 L7 513-OR-14 SOL RET 1&2 SOL 2 SOL 1 a J 310-PU 334-BU B941-GY 105-BR H BACKUP ALARM 3T1815 OPERATOR STATION 200-BK-14 LEFT WIPER 9X3392 GN 3 1 GY BR OR 4 2 B 1 2 BK 200-BK 554-PK 553-YL 200-BK 3 WH 2 WH 1 BK 4 CODE 2 CODE 0 CODE 1 U SOL 3 e d c b 246-BK 248-BK 247-BK L3 L3 2 1 NN NEUTRAL/START SW 9W1581 2 1 306-GN XX H L8 L8 P 524-BU-14 108-BU-14 523-BR-14 525-GY-14 C CODE 3 ETHER CONTROL 9X5303 245-BK BK/PK BK/PK 2 1 XX 200-BK 321-BR 307-OR 4 3 L7 7T3821 B 1 2 4 3 5 C 322-GY 200-BK 554-PK 553-YL 610-OR-14 E BK-14 BLOWER SW 6P3236 PK PK 3 2 1 E 803-BU 805-PK L11 L11 FIRE SUPPRESSION MONITOR 6T5618 L14 E EEE 1 2 3 2 1 YY 246-BK 245-BK L3 L5 L5 3 4 5 2 1 BACKUP ALARM SW 3W5541 BU BU 326-PU 803-BU 809-GN 7 6 5 4 3 2 1 BU-18 +V (IN) ALERT ALARM TEST SYS FAIL GY-18 PU-18 311-WH B 1 FORWARD HORN 7T0970 FENDER GND GGG 237-BK 3 5 4 237-BK 248-BK 247-BK L6 516-GN-14 B 521-YL-14 515-GY-14 124-GN-14 BRAKE SW 7T5093 L12 816-BR 810-BU 811-GY BR-18 GN-18 201-BK 406-PU 200-BK 2 200-BK 610-OR-14 517-BU-14 209-BK 113-OR M OR-18 BK-18 + BATTERY GROUND -T COOLANT SW 7N9785 200-BK 322-GY FORWARD HORN 7T0969 L12 L12 441-OR B -T COOLANT SENDER 6N5926 ETHER SOLENOID 1 9X7137 BU 1 2 YY 310-PU B941-GY B941-GY OPERATOR STATION U 633-BU-10 U L14 COOLANT SENSOR 9X0377 BK 3 2 1 ACCESSORY SW 7N8000 146-GY-10 15A 174-PK-6 114-GN L14 L A718-PU ZZ C GN-18 SIGNAL YY RD DUAL TILT SW 9X7095 PITCH CONTROL SW 9X7093 WH SINGLE/ DUAL TILT SW 9X7094 U 200-BK-14 -T MOTOR H 237-BK 308-YL B A OR-18 BK-18 GROUND V+ 334-BU B941-GY 2 1 ETHER SOLENOID 2 9X7137 BK BU REAR WIPER 9X3392 L5 4 3 2 1 15A MOTOR L H GN YL GN GY BR OR 4 A720-PK A717-OR GROUND A C A717-OR A720-PK 237-BK GROUND ZZ B SIGNAL V+ SIGNAL V+ D -T 510-YL-14 200-BK-14 YL GN RD 2 3 1 V 184-BU 553-YL 554-PK L9 174-PK-10 174-PK-10 P 3 1 2 ENGINE SPEED SENSOR 6T4361 D GN GY BR OR 4 24V TO 12V CONVERTER 9G6981 184-BU 200-BK + BATTERY GROUND RD-18 BK-18 2 1 U 501-GN-14 108-BU-14 500-BR-14 502-OR-14 608-GN-14 T T 3 1 2 S CAB GND +12 VOLT GROUND WH/RD-18 WH/BK-18 2 1 WH/BK-18 WH/RD-18 200-BK-18 788-YL-18 CC BK WH 1 2 RIPPER FLOOD LAMP 8C5582 200-BK-14 504-YL-14 503-BR-14 108-BU-14 505-BU-14 Q ETHER OUT ALARM 9G9813 3 FFF D P L12 L43 L43 ENGINE OVERSPEED SENSOR 9X5393 510-YL-14 RD BK DDD 2 1 237-BK B944-GN L30 2 1 108-BU-14 102-BU-14 U COLOR ABBREV FAULT ALARM 9G9813 2 1 410-WH 201-BK BK RD RD WH OR YL PK BK PINK YELLOW ORANGE WHITE RED Q T FIRE ALARM 9G9813 BK RD NITROGEN ACTUATOR SOLENOID 8T8590 2 1 N L13 BR PU GY BROWN PURPLE GRAY BLACK BK BK 1 2 UU UU 209-BK 812-GN 2 1 N 812-GN 209-BK 816-BR 812-GN 209-BK L10 Q Q P P 4 6 5 3 8 7 1 2 3 4 5 6 7 2 1 9 8 10 BLUE GREEN BU GN L1 2 1 BK 1 2 UU 808-PU 813-PK UU N 808-PU 808-PU 813-PK 108-BU-14 102-BU-14 526-YL-14 527-GN-14 528-PK-14 108-BU-14 200-BK-14 523-BR-14 524-BU-14 525-GY-14 108-BU-14 108-BU-14 502-OR-14 501-GN-14 500-BR-14 SYMBOL DESCRIPTION C B946-OR B944-GN NITROGEN ACTUATOR SW 6T6085 BK 813-PK DETECTION SW BLADE, SPADE, RING, OR SCREW TERMINAL C B998-BU B954-YL 306-GN B943-PK 308-YL 237-BK 105-BR 108-BU-14 108-BU-14 108-BU-14 CIRCUIT NOT CONNECTED CIRCUIT CONNECTED L4 108-BU-14 505-BU-14 504-YL-14 503-BR-14 REAR WIPER SW 3T6655 RIGHT WIPER SW 3T6655 LEFT WIPER SW 3T6655 FRONT WIPER SW 3T6655 -T ELECTRICAL CONNECTION TO VEHICLE STRUCTURE INTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT Q Q Q Q OR-18 WH-18 CONNECTOR B H B W P L 510-YL-14 B H B W P L 510-YL-14 B H B W P L 510-YL-14 B H B W P L L10 W/ATCH HEAD LAMP REPLACE HARNESS LL WITH HARNESS X ATCH WIRE, CABLE, COMPONENT Q L13 1 6 3 533-OR 534-WH VV LOC IDENT PART NO.

C-3 A HARNESS AS.

6T0856 CHG 06 NOTE 108-BU-14 502-OR-14 501-GN-14 500-BR-14 200-BK 610-OR-14 1 2 C X E-4 D E-1 3T3596 C E-4 6Y2905 B 6Y4224 02 01 00 01 00 02 00 04 05 04 523-BR-14 524-BU-14 525-GY-14 108-BU-14 G F-4 6Y0059 H C-5 3T7147 F B-3 6Y2907 E E-6 9W3076 CAB GND 526-YL-14 527-GN-14 528-PK-14 108-BU-14 E-9 9G6259 L F-8 K F-8 J 9W7709 7T6055 B 200-BK-14 102-BU-14 DOME LAMP SW 7N8000 Q C-7 C-7 P B-7 7T5568 N B-3 7T5569 M 7T9218 7T9222 00 02 05 02 02 01 01 02 04 02 B 102-BU-14 102-BU-14 WH-18 PP 307-OR 105-BR COOLANT TEMP GAGE 4W0483 LAMP 5D0019 3T0376 SYS FAIL ALERT OFF (KEY) SHUT DN ID + BAT OUT 10 9 6 16 19 810-BU 809-GN 326-PU 803-BU HEAD LAMP 9W1282 D-9 3T6373 T B-5 8V4950 R V B-7 B-7 U S 9W0793 6T2215 9W0179 D-9 200-BK-14 OPERATOR STATION BK-18 D D 326-PU 308-YL AAA GND 200-BK - + 403-GN 308-YL 112-PU-6 112-PU 1 6 3 2 5 4 E 420-OR L43 B-5/D-1/D-4 00 8E3006 CC 6T6112 X B-1/F-1 MOTOR -T L H 308-YL 308-YL L22 L22 SERVICE METER 6T7337 308-YL L22 SHUT DN SOL BRAKE 15 3 1 327-PK 107-WH 805-PK 803-BU L39 L39 534-WH 533-OR 533-OR 534-WH FUEL FILTER SW 7N4447 201-BK 109-OR-4 403-GN 201-BK 412-BU 200-BK 610-OR-14 610-OR-14 1 ZZ YY C-9 UU 9W9786 A-2 7T5570 VV XX 01 01 01 9N4539 9W7012 00 04 00 C-4 D-4 F-12 E-7 RIGHT WIPER 9X3392 BATTERY START (KEY) DSCH PRESS.

DSCH PR MON DSCH PR + DETECT OUT 8 18 20 5 306-GN 328-OR 328-OR L40 L40 BU-18 RD-18 BK-18 2 1 B 201-BK BK RD 209-BK-14 327-PK-14 2 C C-4 DDD AAA 9N4538 9N4537 9N4540 01 OPERATOR STATION DETECT IN DETECT OUT DETECT IN 13 14 17 4 803-BU 534-WH 534-WH 533-OR FUEL SW 9X4276 3 413-BR 200-BK LL WIRE AS.

L2 L4 L4 L2 E FIRE SUPPRESSION CONTROL 6T5619 533-OR L42 L42 201-BK 405-GY ALT 8N0999 STD 2 1 B A-5 3W1569 W Z F-2 Y 3S8624 D-5 9W5750 01 01 00 00 01 05 00 01 02 00 01 L10 174-PK-6 B B ALT + R A-1/F-1 9W2176 LL HH E-9 7T8147 NN A-3/F-3 7G0530 MM 9W4736 B-4 L9 U 609-YL-14 609-YL-14 200-BK 608-GN-14 442-GY 404-YL 322-GY 410-WH 184-BU 553-YL 554-PK 201-BK L38 BK-00 RD-00 ENGINE OIL SW 6T4949 BK RD B 2 1 200-BK-4 ENGINE SHUTDOWN SOLENOID 7W5967 E-6 SS D-5 RR B-7 PP 9W3623 3T2539 9G7285 HYDRAULIC SENDER 8N3844 404-YL E N U V 1 4 3 5 2 A A 4 3 5 7 6 1 200-BK 2 3 2 1 174-PK-6 A L23 L23 L38 412-BU 201-BK HEAD LAMP 8C5511 CCC BBB D-6 TT EEE 6Y6852 9N4623 3T2524 8R7105 E-12 00 00 00 F-10 F-10 A 442-GY A 201-BK HYDRAULIC SW 9G1300 -T A 808-PU 209-BK 816-BR 813-PK 812-GN 201-BK 410-WH 322-GY 780-PU 779-WH 184-BU 184-BU 554-PK 553-YL 174-PK-6 E W E 2 1 L42 L42 533-OR 534-WH 533-OR 534-WH 4 1 6 3 2 5 533-OR 534-WH 533-OR 534-WH B 1 2 BK-18 BK-18 01 8E0790 3T1794 GGG FFF E-11 D-8 01 A A -T 200-BK 779-WH 780-PU 442-GY 404-YL 201-BK 322-GY 410-WH 184-BU 553-YL 554-PK BK-18 2 1 BK-18 AGENT SW 8C5436 USE WIRE AS.

WITH ONE AGENT CYLINDER 2 1 BK A MM FF BB EE RD-00 BK-00 VV E THIS SCHEMATIC IS FOR THE D11N TRACTOR (9X8157 CHG 01) COOLANT SW 9X3040 A-3/F-3 BB F-3 6T5267 AA CABLE AS.

9G0549 01 01 02 02 00 01 02 04 RIPPER PIN PULLER SOLENOID 9G9988 442-GY 780-PU 200-BK 200-BK 779-WH S1 BK BK WH WH 2 3 4 1 404-YL 780-PU 779-WH 201-BK 404-YL 201-BK L23 L23 814-YL 12 V BATTERY 9G2648 NEG POS NEG POS BK-00 12 V BATTERY 9G2648 A-3 9W5472 FF A-3/F-3 6T5266 EE F-2 6T5268 DD S2 608-GN-14 200-BK 608-GN-14 608-GN-14 442-GY 200-BK 803-BU 813-PK 2 1 E BK-18 BK-18 AGENT SW 8C5436 816-BR 209-BK 803-BU 812-GN 807-BR 807-BR 808-PU 609-YL-14 FLOOD LAMP 9W1279 COMPONENTS ARE SHOWN INSTALLED ON A FULLY OPERABLE MACHINE WITH THE KEY AND ENGINE OFF, AND XMSN SHIFTER IN NEUTRAL F-2 6T5269 KK F-3 6T5264 JJ F-2 6T5265 GG WW 00 6Y6584 E-4 FLOOD LAMP 9W1279 808-PU 808-PU 813-PK 803-BU 209-BK 816-BR 812-GN 209-BK 816-BR 812-GN E 807-BR 808-PU BK 2 1 NITROGEN ACTUATOR SW 6T6085 BK NOTE A:

NORMALLY OPEN BEFORE REFRIGERANT CHARGE UNLESS OTHERWISE SPECIFIED ALL WIRE IS 16 GA 2 1 NOTE C: FUSES 10A-3K8782 15A-8M8948 NOTE B:

NORMALLY OPEN BEFORE INSTALLATION D31880 11 10 9 8 7 6 5 4 3 2 2 5 3 1 L20 49 7 8 1 6 1 1 1 1 1 D 426-BR 413-BR 404-YL 2 121-YL 608-GN-14 442-GY 124-GN-14 3 201-BK 200-BK-14 5 410-WH 1 420-OR 0 418-WH 4 H D H 60 12 L26 101-RD-4 101-RD-6 101-RD-6 17 L19 L20 L35 H-8 BK OR -8 GY L32 L35 101-RD-4 101-RD-6 101-RD-6 304-W 207- 302- 314-PU 313- L33 L33 521-YL-14 513-OR-14 310-PU 311-WH 311-WH 610-OR-14 200-BK L28 412-BU 406-PU L36 5 55 54 3- -P YK L 322-GY 403-GN 441-OR 201-BK L37 3271 -0 P9 K-O -1R 4-4 209-BK-14 405-GY 201-BK 413-BR L34 420-OR 426-BR 201-BK 424-GY 443-YL L32 L27 L27 L28 L24 L28 L 36 L28 L36 610-OR G 200-BK L37 L37 L34 L32 112-PU-6 200-BK-14 200-BK-14 L12 L29 237-BK 308-YL 237-BK A718-PU 237-BK A717-OR A720-PK 26 112-PU-14 L21 177-OR-14 L31 L12 3 2 4 1 L29 ED LK LU RN R L13 L14 RIPPER PIN PULLER SW 6T6970 1 2 FORWARD HORN SW 3T2357 L9 L9 B ST S ON C OFF R C OFF R 1 0 9 8 7 6 5 4 3 2

Стр. 2