OM1020 01/02 Introduction - Section 1 Page 1-13 (1) Used for threaded areas (for example, plug, nipple, elbow etc.) which are removable and a pressure of 20 kg/cm 2 (285 psi) or less. (2) Used for threaded areas (for example, stud, etc.) which are not removable and a pressure of 20 kg/cm 2 (285 psi) or less. The sealants and adhesives listed below are manufactured and sold by Three Bond U.S.A., Inc. For information concerning Three Bond products, call or write to: Three Bond U.S.A., Inc. 6184 Schumacher Park Drive West Chester, OH 45069 Telephone: (513) 779-7300 Fax:
(513) 779-7375 SEALANTS AND ADHESIVES Nomenclature Code Three Bond * Applications Adhesives LT-1A TB1521 Used to apply rubber pads, rubber gaskets and cork plugs. LT-1B 1000B - 1000W Used to apply resin, rubber, metallic and non-metallic parts when a fast, strong seal is needed. LT-2 TB1374 Preventing bolts, nuts and plugs from loosening and leaking oil. LT-2A TB2411 Preventing bolts, nuts and plugs from loosening and leaking oil. (1) LT-2B TB2403 Preventing bolts, nuts and plugs from loosening and leaking oil. (2) LT-2C TB2430 or TB2440 Preventing bolts, nuts and plugs from loosening and leaking oil.
(2) LT-3 Main bond Hardening agent TB2001 Provides an airtight, electrically insulating seal. Used for aluminum sur- faces. TB2105 Liquid Gasket LG-1 TB1108B Used with gaskets and packings to increase sealing effect. LG-3 TB1107 Heat-resistant gasket for precombustion chambers and exhaust piping. LG-4 TB1104 Used by itself on mounting surfaces on the final drive and transmission cases. Thickness after tightening: 0.07-0.08 mm (0.0027-0.0032 in) LG-5 TB1110 Used by itself to seal grease fittings, tapered screw fittings and tapered screw fittings in hydraulic circuits of less than 50 mm (2 in) in diameter.
Anti-friction compound LM-P - Applied to bearings and taper shafts to facilitate press-fitting and to pre- vent sticking, burning or rusting. Grease G2-LI - Applied to bearings, sliding parts and oil seals for lubrication, rust preven- tion and facilitation of assembling work. Vaseline - - Used for protecting battery electrode terminals from corrosion. * NOTE: The Part Numbers in this column are NOT KOMATSU numbers. These are vendor designations. PART NUMBERS Three Bond Komatsu TB1374 09940-00030 TB1521 790-129-9030 TB1104 790-129-9020 TB1108B 790-129-9010