05-E2B, 05-E2BG, WSM G GENERAL Replacing Oil Filter Cartridge CAUTION Be sure to stop the engine before changing filter cartridge. 1. Remove the oil filter cartridge with the filter wrench. 2. Apply a slight coat of oil onto the new cartridge gasket. 3. To install the new cartridge, screw it in by hand. Over tightening may cause deformation of rubber gasket. 4. After the new cartridge has been replaced, the engine oil normally decrease a little. Thus see that the engine oil does not leak through the seal and be sure to read the oil level on the dipstick. Then, replenish the engine oil up to the specified level.
IMPORTANT Q To prevent serious damage to the engine, replacement element must be highly efficient. Use only a KUBOTA genuine filter or its equivalent. W1018617 Checking Radiator Hoses and Clamp Bands 1. Check to see if the radiator hoses are properly fixed every 200 hours of operation or every six months, whichever comes first. 2. If the clamp is loose, apply oil to the threads and retighten it securely. 3. The water hose is made of rubber and tens to age. It must be replaced every two years. Also replace the clamp and tighten it securely. (1) Upper Hose (2) Lower Hose W1029518 Checking Intake Air Line 1. Check to see if the intake air hose(s) are properly fixed every 200 hours of operation.
2. If the clamp is loose, apply oil to the threads and retighten it securely. 3. The intake air hose(s) is made of rubber and tends to age. It must be changed every two years. Also change the clamp and tighten it securely. IMPORTANT Q To prevent serious damage to the engine, keep out any dust inside the intake air line. (1) Intake Air Hose (2) Clamp W1029631 [6] CHECK POINTS OF EVERY 400 HOURS Water and dust in fuel are collected in the filter cartridge. So, change the filter cartridge every 400 hours service. 1. Remove the used filter cartridge with filter wrench. 2. Apply a thin film of fuel to the surface of new filter cartridge gasket before screwing on. 3. Then tighten enough by hand.
4. Loosen the air vent plug to let the air out. 5. Start engine and check for fuel leakage. Replacing Fuel Filter Cartridge (Cartridge Type) (1) Fuel Filter Cartridge W1050548 G-14 KiSC issued 06, 2011 A