Caterpillar Cab Manual (EN)

UENR3921-01 April 2014 UENR3921-01 VOL 1 of 4 42 Page, (Dimensions: 56 inches x 35 inches) 38 23 54 55 12M3, 140M3, and 160M3 Electrical System Motor Grader 12M3: N9B1-UP N9F1-UP N9P1-UP N9R1-UP 140M3: N9D1-UP N9G1-UP N9J1-UP N9M1-UP 160M3: N9E1-UP N9K1-UP N9L1-UP N9T1-UP CONN 18 61 1 CONN 19 Volume 1 of 4: Cab © 2014 Caterpillar, All Rights Reserved Printed in U.S.A. HVAC Harness And Wire Electrical Schematic Symbols Symbols Pressure Symbol T Temperature Symbol Level Symbol Flow Symbol Circuit Breaker Symbol Symbols and Definitions Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it. Switch (Normally Open):

A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it. Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component. Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine. Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. Reed Switch: A switch whose contacts are controlled by a magnet.

A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch. Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure. T Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay. Solenoid: A solenoid is an electrical component that is activated by electricity.

It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work. Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches. Harness and Wire Symbols Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes (see sample).

Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness (C1, C2, C3, ...). Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...) AG-C4 111-7898 L-C12 3E-5179 L-C12 3E-5179 Part Number: for Connector Receptacle Part Number: for Connector Plug Plug Pin or Socket Number Receptacle 5A 1 2 Deutsch connector: Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins. Fuse (5 Amps) 9X-1123 Component Part Number 1 Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets. Harness identification code:

This example indicates wire group 325, wire 135 in harness "AG". 325-AG135 PK-14 2 Wire Color Wire Gauge The connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart.

CONN 3 34 CONN 27 7 CONN 28 62 CONN 26 2 8 53 41 51 47 49 50 43 FRONT CONSOLE 24 CONN 29 52 42 45 48 A B 56 CONN 14 19 20 25 29 21 46 28 30 27 31 36 26 CONN 24 CONN 25 CONN 23 VIEW OF AREA “A” (ROTATED FOR CLARITY) VIEW OF AREA “B” (ROTATED FOR CLARITY) LH AND RH OPERATOR CONSOLES 10 9 CONN 17 CONN 22 22 CONN 10 CONN 11 CONN 13 CONN 12 15 CONN 16 16 CONN 15 40 14 37 CONN 20 REAR CAB VIEW CONN 1 3 6 12 13 4 18 CONN 9 CONN 6 CONN 7 17 CONN 5 CONN 21 5 33 CONN 2 EXTERIOR CAB ROOF 32 63 LEFT AND RIGHT DOORS 1 2 11 57 59 58 60 CONN 8 35 44 CONN 4 INTERIOR CAB ROOF Component Location Component Schematic Location Machine Location Actuator - Water Valve B-8 1 Alarm - Action H-1 2 Bussbar B C-7 3 Bussbar C E-7 4 Converter - Communications F-15 5 Converter - Entertainment Radio A-13 6 Diode - Rear Floodlamp Interlock H-1 7 Display - Message G-1 8 ECM - Implement J-9 9 ECM - Steering J-10 10 Fan - Rear Defroster E-15 11 Fuse Block - Switched E-7 12 Fuse Block - Unswitched G-7 13 Ground - Cab 1 B-10 14 Ground - Cab 2 B-10 15 Ground - Cab 3 B-10 16 Ground - Roof 1 C-14 17 Ground - Roof 2 C-14 18 Joystick - LH I-1 19 Joystick - RH D-1 20 Joystick - Mini D-1 21 Module - Flasher G-1 22 Motor - Blower A-8 23 Motor - Up-Down Armrest (LH) J-1 24 Motor - Up-Down Armrest (RH) B-1 25 Motor - Washer (Front) D-9 26 Motor - Washer (LH Door) D-9 27 Motor - Washer (LH Window) C-9 28 Motor - Washer (Rear) C-9 29 Motor - Washer (RH Door) D-9 30 Motor - Washer (RH Window) D-9 31 Motor - Wiper (LH Door or RH Door) J-16 32 Motor - Wiper (Rear) E-15 33 Motor - Wiper (Front) F-15 34 Panel - HVAC D-15 35 Pod - Auxiliary Control E-1 36 Resistor - AccuGrade Sensor CAN C-15 37 Resistor - Blower Motor A-8 38 Resistor - Defroster Fan (Not Shown) F-15 39 Resistor - Steering CAN C-13 40 Sensor - Inching Pedal (Not Shown) E-1 41 Sensor - Operator Present A-2 42 Sensor - Throttle Position (Not Shown) F-1 43 Switch - A/C C-15 44 Switch - Armrest (LH) J-1 45 Switch - Armrest (RH) C-1 46 Switch - Brake Light (Not Shown) F-1 47 Switch - Horn C-1 48 Switch - Inching Pedal (Not Shown) F-1 49 Switch - Key F-1 50 Switch - Parking Brake H-1 51 Switch - Seat Belt A-2 52 Switch - Secondary Steering E-1 53 Switch - Thermal 1 A-8 54 Switch - Thermal 2 A-8 55 Switch - Turn Signal C-1 56 Switch - Wiper (Front) G-15 57 Switch - Wiper (Rear) H-15 58 Switch - Wiper (LH Door) G-15 59 Switch - Wiper (RH Door) G-15 60 Thermostat B-8 61 Window - Front Heated A-15 62 Window - Side Heated I-16 63 Connector Location Connector Number Schematic Location CONN 1 J-15/J-16 CONN 2 B-15 CONN 3 B-15 CONN 4 H-15 CONN 5 I-15 CONN 6 I-15 CONN 7 J-15 CONN 8 E-14 CONN 9 B-13 CONN 10 C-13 CONN 11 C-13 CONN 12 D-13 CONN 13 F-13 CONN 14 D-10 CONN 15 C-10 CONN 16 C-10 CONN 17 B-10 CONN 18 B-10 CONN 19 A-10 CONN 20 G-2 CONN 21 G-2 CONN 22 G-2 CONN 23 G-2 CONN 24 F-2 CONN 25 F-2 CONN 26 D-2 CONN 27 B-2 CONN 28 E-1 CONN 29 H-1

Стр. 1

1 16 H803-P672 E804-P119 E803-P120 G711-P760 BR-18 BU-18 BU-18 YL-18 K758-P75 K789-P55 K788-P56 H807-P677 H804-P471 BU-18 YL-18 GY-18 YL-18 GN-18 L GND BK-16 1 2 WJ-C2 1552273 200-WJ1 BK-14 200-WJ1 BK-14 WJ-C1 3E3382 P-C116 2458025 200-P637 BK-14 M722-P5 M720-P6 K927-P9 K952-P10 OR-18 BU-18 BU-18 BR-18 UENR3921-01 VOL 1 of 4 42 Page, (Dimensions:

56 inches x 35 inches) (32) LH DOOR WIPER MOTOR 389-2249 H MOTOR P B+ T° GN-16 GY-16 BR-16 OR-16 4 6 528-WJ4 526-WJ2 119-WJ5 527-WJ3 PK-14 YL-14 PK-14 GN-14 527-WJ3 119-WJ5 526-WJ2 528-WJ4 PK-14 GN-14 PK-14 YL-14 2 1 4 6 3 5 118-P614 524-P591 GY-14 BU-14 H10 H10 M975-P190 M906-P213 BU-18 BU-18 J 3 5 CONN 1 523-P592 525-P590 BR-14 GY-14 P-C45 3388860 365-6790 J1 (10) STEERING ECM (9) IMPLEMENT ECM 365-6773 J1 P-C41 3388860 103-P329 103-P405 RD-16 RD-16 U701-P4 U700-P3 U702-P1 U703-P2 U704-P7 U705-P8 P988-P674 GN-18 WH-18 GY-18 YL-18 PK-18 PU-18 OR-18 C250-P293 BK-18 P-C38 2234778 10 J LH DOOR WITHOUT HEATED WINDOW 308-P11 YL-18 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 KEY SWITCH - RUN KEY SWITCH - RUN 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 308-P103 YL-18 104-P309 104-P434 104-P406 RD-14 RD-14 RD-14 U736-P211 YL-18 139-P456 139-P460 F505-P640 F506-P641 OR-18 OR-18 GN-18 BU-18 (45) LH ARMREST SWITCH 347-0799 106-P250 106-P164 105-P124 121-P30 RD-16 RD-14 WH-14 WH-14 U744-P72 U745-P76 U742-P154 OR-18 PK-18 WH-18 C250-P284 125-P750 668-P754 668-P753 BU-18 BK-18 RD-18 BU-18 WC-C1 3E3382 P-C115 2458025 893-P12 997-P24 GN-18 OR-18 CAT DATA LINK POS 5V SUPPLY CAT DATA LINK POS 893-P111 GN-18 125-P324 127-P451 122-P133 RD-16 RD-16 BU-14 X725-P128 GY-18 125-P751 RD-18 CONN 1 1 2 WC-C2 1552273 200-WC1 BK-14 200-WC1 BK-14 2 1 4 6 3 5 200-P638 BK-14 M906-P213 A296-P13 BK-14 BU-18 NEG UNSWITCHED BATTERY GEN I STEERING NEG UNSWITCHED BATTERY IMPLEMENT LOCKOUT SWITCH (NC) A295-P113 G767-P127 BK-14 WH-18 131-P417 BR-18 131-P409 131-P487 BR-18 BR-18 GN-18 F505-P640 P-C33 2715590 (24) LH UP-DOWN ARMREST MOTOR NOTE:

SECOND WJ HARNESS CONNECTED AT WC-C2 CONNECTS TO WJ-C1 THIS VOLUME LOC J-15 3 4 6 528-WC4 526-WC2 119-WC5 527-WC3 PK-14 YL-14 PK-14 GN-14 527-WC3 119-WC5 526-WC2 528-WC4 GN-14 PK-14 YL-14 PK-14 119-P613 527-P603 526-P604 528-P602 PK-14 GN-14 YL-14 PK-14 139-P360 OR-18 142-P136 BU-18 139-P456 139-P460 OR-18 OR-18 BU-18 F506-P641 MOTOR 1 2 344-9581 5 WC-C3 3E3376 CONN 7 E804-P119 E803-P120 BU-18 YL-18 892-P14 998-P759 BR-18 BR-18 CAT DATA LINK NEG 5V RETURN HYD OIL INLET TEMP SENSOR NEG UNSWITCHED BATTERY CAT DATA LINK NEG 892-P459 R732-P160 A295-P175 614-P176 BR-18 BR-18 BK-14 PU-18 169-P168 144-P173 148-P500 PK-18 GN-14 WH-14 P-C18 2698225 J1 (63) SIDE HEATED WINDOW 310-2077 1 2 3 4 200-WC6 F503-WC7 200-WC8 F504-WC9 YL-14 BK-14 OR-14 BK-14 200-WC6 F503-WC7 200-WC8 F504-WC9 BK-14 OR-14 BK-14 YL-14 WC-C4 3E3376 1 2 3 4 P-C5 1762946 F503-P461 200-P280 OR-14 BK-14 H803-P672 H804-P471 G711-P760 BU-18 GN-18 BR-18 A296-P15 BK-14 NEG UNSWITCHED BATTERY ECM LOCATION 2 (GND) ECM LOCATION 1 (GND) ECM LOCATION 0 (OPEN) A/C OPERATOR SWITCH HEADLAMP SWITCH 567-P392 WH-18 180-P121 180-P35 RD-14 RD-14 180-P200 RD-18 125-P251 RD-18 R800-P446 U739-P95 L731-P29 X800-P488 OR-16 BR-18 BR-18 OR-18 1 2 3 4 5 6 7 8 9 10 11 12 +V1 STEERING SENSOR #1 GROUND 1 GROUND 2 CONN 6 F504-P292 200-P413 YL-14 BK-14 K788-P56 K758-P75 K789-P55 H807-P677 GY-18 BU-18 YL-18 YL-18 A296-P17 A296-P16 BK-18 BK-18 ECM LOCATION 1 (GND) A295-P179 BK-18 180-P244 180-P256 180-P239 180-P235 180-P199 RD-14 RD-14 RD-14 RD-14 RD-14 180-P117 180-P165 RD-14 RD-16 125-P269 139-P456 139-P460 125-P750 125-P751 OR-18 OR-18 RD-18 RD-18 RD-18 U740-P97 P967-P96 BU-18 PU-18 STEERING SENSOR #2 GROUND 3 RH DOOR WITH HEATED WINDOW K927-P9 K952-P10 M722-P5 M720-P6 BU-18 BR-18 OR-18 BU-18 171-P32 A296-P18 RD-14 BK-18 ECM LOCATION ENABLE (GND) POS UNSWITCHED BATTERY ECM LOCATION ENABLE (GND) POS UNSWITCHED BATTERY N787-P232 180-P199 A295-P228 BK-18 BU-18 RD-14 308-P103 614-P176 567-P392 YL-18 PU-18 WH-18 180-P244 180-P256 RD-14 RD-14 180-P358 RD-14 144-P173 142-P264 GN-14 BU-18 K750-P80 PU-18 BLADE LIFT SENSOR H10 M975-P190 P988-P674 M906-P213 BU-18 OR-18 BU-18 727-P196 N931-P352 U736-P211 GN-18 GY-18 YL-18 HYDRAULIC PUMP PRESS SENSOR STEER VALVE SPOOL POS SGNL SEC STEERING TEST SWITCH HYD PLT SUP FLTR BYP SWITCH HEATED WINDOW SWITCH C572-P282 YL-18 892-P459 709-P67 626-P86 BR-18 OR-18 BU-18 180-P239 180-P235 180-P199 RD-14 RD-14 RD-14 200-P440 538-P275 200-P267 518-P273 BK-14 BR-18 BK-18 OR-18 P-C19 3313578 U703-P2 U702-P1 U700-P3 U701-P4 YL-18 GY-18 GN-18 WH-18 171-P33 171-P34 U742-P154 RD-14 RD-14 WH-18 POS UNSWITCHED BATTERY POS UNSWITCHED BATTERY STEERING VALVE ERROR SIGNAL POS UNSWITCHED BATTERY POS UNSWITCHED BATTERY HEATED MIRROR SWITCH SEATBELT LATCHED SEATBELT UNLATCHED 180-P239 180-P235 U730-P167 U729-P208 A514-P763 RD-14 RD-14 YL-18 BR-18 PU-18 893-P111 A295-P113 A295-P58 A295-P68 GN-18 BK-14 BK-14 BK-14 308-P103 YL-18 539-P271 581-P52 582-P48 540-P270 BU-18 GY-18 PK-18 WH-18 K758-P75 U743-P73 U744-P72 U745-P76 BU-18 GY-18 OR-18 PK-18 1 2 3 4 5 6 7 8 9 10 11 12 J2 ARTICULATION SENSOR WHEEL LEAN SENSOR NEUTRAL ARTICULATION SWITCH (N/O) NEUTRAL ARTICULATION SWITCH (N/C) UPSHIFT SWITCH (N/O) UPSHIFT SWITCH (N/C) DOWNSHIFT SWITCH (N/O) DOWNSHIFT SWITCH (N/C) FNR FORWARD FNR NEUTRAL FNR REVERSE (19) LH JOYSTICK 360-2987 I 1 2 3 4 5 6 7 8 9 10 11 12 AM/FM ENTERTAINMENT RADIO 331-5292 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 A-C2 1728037 U705-P8 U704-P7 U736-P211 U742-P154 PU-18 PK-18 YL-18 WH-18 R800-P50 P967-P49 OR-18 PU-16 8V RETURN 8V SUPPLY A295-P175 A295-P179 A295-P228 A295-P497 BK-14 BK-18 BK-18 BK-14 320-P307 OR-18 322-P308 GY-16 320-P465 320-P466 OR-18 OR-18 646-P126 647-P125 605-P223 606-P224 OR-18 GN-18 YL-16 GY-16 F785-P671 F781-P675 F783-P673 BR-18 GN-18 WH-18 I AUXILIARY INPUT HARNESS 344-5594 KEY SWITCH ON 592-CG6 RD-18 509-CG1 WH-18 508-CG2 WH-18 210-CG3 BK-18 A-C1 3E3388 1 2 3 4 5 6 7 8 P-C109 3313580 508-P577 509-P578 PU-18 WH-18 U744-P72 U745-P76 X725-P128 OR-18 PK-18 GY-18 M722-P5 M720-P6 171-P37 171-P38 OR-18 BU-18 RD-14 RD-14 POS UNSWITCHED BATTERY POS UNSWITCHED BATTERY CIRCLE SIDESHIFT LEFT SOL CIRCLE SIDESHIFT RIGHT SOL PROP DRIVER RETURN 01-04 CIRCLE LEFT SOLENOID CIRCLE RIGHT SOLENOID POS UNSWITCHED BATTERY BLADE PITCH FORWARD SOL BLADE PITCH BACKWARD SOL PULSE WD MOD DR RTN 01-04 POS UNSWITCHED BATTERY 180-P244 180-P256 U751-P262 U752-P263 H861-P279 RD-14 RD-14 WH-18 PU-18 PU-18 A514-P763 C572-P282 A501-P171 A514-P157 YL-18 YL-18 BU-16 YL-18 611-P422 515-P444 567-P392 604-P364 PU-14 GY-12 OR-18 WH-18 668-P655 668-P527 668-P754 668-P753 BU-18 BU-18 BU-18 BU-18 G750-P177 G763-P197 G755-P53 F784-P676 YL-18 BU-18 PU-18 GY-18 AUX IN AM/FM ANTENNA 8E-1118 DIM BATTERY GROUND 210-CG3 BK-18 A513-CG5 YL-18 210-P651 BK-18 K952-P10 U701-P4 U700-P3 BR-18 GN-18 WH-18 E744-P732 E745-P731 F501-P764 YL-18 BU-18 BU-16 614-P104 614-P327 617-P420 614-P310 614-P176 PU-18 PU-18 BR-16 PU-18 PU-18 998-P189 695-P252 696-P253 BR-18 OR-18 GN-18 RF SPEAKER POS RF SPEAKER NEG 509-CG1 WH-18 508-CG2 WH-18 512-CG7 GN-18 511-CG8 GY-18 A513-CG5 YL-18 592-CG6 RD-18 512-CG7 GN-18 511-CG8 GY-18 511-P579 512-P580 592-P595 A513-P398 BR-18 GN-18 BU-18 RD-18 171-P32 171-P33 171-P34 171-P37 171-P38 RD-14 RD-14 RD-14 RD-14 RD-14 H803-P672 M975-P190 H804-P471 A296-P20 A296-P19 BK-14 BK-14 BU-18 BU-18 GN-18 PROP DRIVER RETURN 09-12 NEG UNSWITCHED BATTERY NEG UNSWITCHED BATTERY STEER OIL TEMP SENSOR PRIMARY STEERING RETURN PULSE WD MOD DR RTN 09-12 NEG UNSWITCHED BATTERY NEG UNSWITCHED BATTERY BLADE LEFT RAISE SOL BLADE RIGHT RAISE SOL PWM DR RETURN 05-08 BLADE LEFT LOWER SOL BLADE RIGHT LOWER SOL H862-P472 A295-P497 A295-P58 R900-P59 R902-P60 H863-P183 R901-P61 R903-P62 GY-18 BK-14 BK-14 BU-18 GN-18 BU-18 GY-18 OR-18 F711-P84 F712-P85 G953-P31 G965-P361 YL-18 GN-18 BU-18 PU-18 619-P430 618-P435 GN-14 YL-14 C250-P293 C250-P284 A202-P368 A210-P342 BK-18 BK-18 BK-18 BK-18 U741-P98 T998-P408 OR-18 BR-18 P-C31 1762946 1 2 3 4 J3 STEERING SENSOR #3 +V2 GROUND 4 MIC 1 2 3 4 5 6 7 8 LF SPEAKER POS LF SPEAKER NEG CONN 5 108-P116 104-P153 103-P725 106-P108 RD-16 RD-16 RD-16 WH-16 893-P12 892-P14 308-P11 GN-18 BR-18 YL-18 K927-P9 U702-P1 U703-P2 BU-18 GY-18 YL-18 PROP DRIVER RETURN 05-08 AUXILIARYVALVE #1 SOL B AUXILIARYVALVE #1 SOL A G767-P127 G766-P198 H745-P738 H801-P594 GN-18 BR-18 PU-18 WH-18 626-P86 BU-18 F781-P675 F783-P673 F784-P676 BR-18 GN-18 YL-18 998-P189 BR-18 MICROPHONE HARNESS 353-1634 115-PW410 116-P148 112-PW154 113-P83 RD-4 BR-18 PU-4 RD-16 998-P759 997-P24 A296-P13 BK-14 BR-18 OR-18 U704-P7 U705-P8 PK-18 PU-18 AUXILIARYVALVE #2 SOL B AUXILIARYVALVE #2 SOL A H861-P279 H862-P472 H863-P183 PU-18 GY-18 BU-18 684-P387 OR-18 646-P312 647-P450 OR-18 GN-18 G755-P53 G750-P177 G763-P197 F785-P671 GY-18 BU-18 PU-18 WH-18 P-C77 2234778 ENTERTAINMENT RADIO 120-P130 119-P162 118-P261 YL-14 PK-14 GY-14 A296-P17 A296-P16 A296-P15 BK-18 BK-18 BK-14 K789-P55 K788-P56 E804-P119 E803-P120 YL-18 GY-18 BU-18 YL-18 LEFT PRIMARY STEER SOL RIGHT PRIMARY STEER SOL ARTICULATE LEFT SOLENOID ARTICULATE RIGHT SOLENOID BLADE SIDESHIFT RIGHT SOL WHEEL LEAN LEFT SOL WHEEL LEAN RIGHT SOL BLADE SIDESHIFT LEFT SOL U750-P63 U749-P64 U747-P65 U748-P66 PK-18 BR-18 OR-18 GY-18 J769-P733 J771-P729 J944-P194 J943-P447 YL-18 BU-18 BU-18 GN-18 684-P625 684-P129 OR-18 OR-18 685-P441 BR-14 684-P289 OR-18 K758-P75 L731-P29 K750-P80 H414-P169 BU-18 BR-18 PU-18 YL-18 U734-P382 A202-P368 U735-P388 GN-18 BK-18 GY-18 1 2 3 4 5 6 7 8 9 10 ON OFF 108-P508 RD-18 108-P116 RD-16 124-P147 125-P552 127-P424 124-P510 GN-14 RD-18 RD-18 GN-14 A296-P21 A296-P20 A296-P19 A296-P18 BK-14 BK-14 BK-14 BK-18 N952-P505 A296-P21 BK-14 BU-18 NEG UNSWITCHED BATTERY 10V SUPPLY NEG UNSWITCHED BATTERY 10V SUPPLY A295-P68 709-P67 BK-14 OR-18 K749-P79 K723-P735 K722-P737 K723-P386 PU-18 YL-18 PU-18 WH-18 UNSWITCHED FUSE BLOCK G20 STEERING ECM A20 COMM RADIO CONVERTER G19 FORWARD HORN A19 VIMS/PRODUCT LINK RADIO G18 BACKLIGHT A18 DOME LAMP G17 MONITORING A17 IMPLEMENT ECM G16 AWD ECM A16 G15 IMPLEMENT ECM 3 A15 CAB FRONT FLOOD 2 G14 A14 RH POSITION LAMP G13 POWERED AIR CLEANER A13 LH POSITION LAMP G12 ENTERTAINMENT RADIO CONVERTER A12 KEY SWITCH G11 A11 G10 HEATED SIDE WINDOW A10 HEATED SIDE WINDOW G9 REAR CAB LIGHTS A9 G8 A8 G7 BLADE WORKLIGHTS A7 KEYPAD G6 ACCUGRADE POWER A6 G5 A5 G4 A4 G3 A3 G2 A2 G1 A1 709-P67 OR-18 709-P490 OR-18 P967-P96 R800-P446 T998-P408 PU-18 OR-16 BR-18 125-P269 668-P655 668-P527 RD-18 BU-18 BU-18 (51) PARKING BRAKE SWITCH 329-6791 A B C D E F G H J P-C21 3173176 127-P424 200-P758 RD-18 BK-18 118-P587 118-P588 118-P614 108-P617 108-P526 GY-14 GY-14 GY-14 RD-16 RD-18 118-P261 GY-14 130-P146 141-P149 149-P94 165-P295 GN-18 PK-16 PU-14 YL-18 H728-P410 H729-P411 H730-P419 E575-P341 E929-P27 GY-18 GN-18 WH-18 BR-18 BU-18 P988-P674 H807-P677 OR-18 YL-18 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 STEERING PILOT SUPPLY SOL IMPLEMENT LOCKOUT SWITCH (NO) LH BLADE CUSHION RH BLADE CUSHION LOAD RETURN #01 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 G766-P198 H801-P594 U769-P473 U770-P474 GN-18 PU-18 OR-18 WH-18 M719-P78 K750-P80 L854-P744 L855-P745 GN-18 PU-18 YL-18 GN-18 727-P196 709-P90 709-P101 GN-18 OR-18 OR-18 U741-P98 U740-P97 U739-P95 U734-P382 U735-P388 OR-18 BU-18 BR-18 GN-18 GY-18 125-P251 RD-18 ET SERVICE CONNECTOR CONN 4 893-P429 892-P428 F712-P426 F711-P427 GN-18 BR-18 GN-18 YL-18 119-P599 PK-14 119-P162 PK-14 108-P116 RD-16 170-P114 169-P28 PK-18 RD-18 N952-P505 K777-P506 N931-P352 GY-18 BU-18 GY-18 SOLENOID RETURN IMPLEMENT PLT SUPPLY SOL LOAD RETURN #2 OPT LEVER #1 FLOAT IND OPT LEVER #4 FLOAT IND OPT LEVER #6 FLOAT IND G953-P31 G965-P361 BU-18 PU-18 R732-P160 N787-P232 R900-P59 BR-18 BU-18 BU-18 893-P111 892-P459 GN-18 BR-18 131-P409 131-P487 139-P456 139-P460 BR-18 BR-18 OR-18 OR-18 131-P409 131-P487 139-P456 139-P460 BR-18 BR-18 OR-18 OR-18 X800-P488 U745-P76 U744-P72 U743-P73 OR-18 PK-18 OR-18 GY-18 P-C36 3313582 119-P600 119-P613 PK-14 PK-14 120-P130 124-P147 119-P162 118-P261 PK-14 GY-14 YL-14 GN-14 171-P404 RD-14 171-P37 171-P38 171-P448 RD-14 RD-14 RD-14 Y797-P325 Y798-P545 U753-P320 U768-P369 BR-18 BU-18 YL-18 GN-18 G711-P760 E575-P341 BU-18 BR-18 SEATBELT BEACON RELAY AUXILIARY FLOAT IND U760-P69 U761-P70 U762-P71 PK-18 PU-18 BR-18 R902-P60 R901-P61 R903-P62 T979-P533 GN-18 GY-18 OR-18 YL-18 A295-P113 A295-P58 BK-14 BK-14 A295-P139 BK-18 709-P90 709-P101 A295-P91 A295-P139 BK-18 OR-18 BK-18 OR-18 709-P90 709-P101 A295-P139 A295-P91 OR-18 BK-18 BK-18 OR-18 H414-P169 A210-P342 YL-18 BK-18 1 2 BK-18 PK-18 3E-6328 (2) ACTION ALARM H 120-P612 120-P611 YL-14 YL-14 120-P642 120-P130 YL-14 YL-14 130-P146 127-P424 124-P510 RD-18 GN-14 GN-18 171-P32 171-P33 171-P34 RD-14 RD-14 RD-14 H765-P217 H764-P218 320-P466 WH-18 GY-18 OR-18 LEFT STEERING CYL POS SENSOR RIGHT STEERING CYL POS SENSOR SEC ART ANGLE POS SENSOR ARTICULATION ANGLE POS SENSOR HORN RELAY OPTION LEVER #4 SENSOR OPTION LEVER #3 SENSOR OPTION LEVER #2 SENSOR OPTION LEVER #1 SENSOR HEATED WINDOW RELAY F501-P764 U706-P39 U707-P40 U708-P41 U709-P42 BU-16 BR-18 BU-18 OR-18 WH-18 U706-P39 U707-P40 U708-P41 U709-P42 U710-P43 U711-P708 U712-P414 BR-18 BU-18 OR-18 WH-18 GN-18 GY-18 YL-18 A295-P228 A295-P497 BK-18 BK-14 A295-P530 BK-14 E744-P732 E745-P731 A295-P170 YL-18 BU-18 BK-18 E744-P732 E745-P731 A295-P170 YL-18 BU-18 BK-18 P-C9 3313582 H LH RADIO SPEAKER 6T-7695 - + 508-P577 509-P578 PU-18 WH-18 120-P605 120-P606 120-P581 120-P582 YL-14 YL-14 YL-14 YL-14 120-P642 YL-14 200-P166 200-P260 176-P112 170-P114 200-P131 BK-18 BK-18 BK-18 RD-14 RD-18 179-P107 176-P112 RD-14 RD-14 727-P196 320-P466 GN-18 OR-18 E929-P27 U768-P369 GY-18 BU-18 A295-P175 A295-P179 A295-P68 A295-P531 BK-14 BK-18 BK-14 BK-14 H745-P742 H745-P740 H745-P739 H745-P741 BR-18 BR-18 BR-18 BR-18 H745-P742 H745-P740 H745-P741 H745-P739 BR-18 BR-18 BR-18 BR-18 646-P126 647-P125 OR-18 GN-18 1 2 (7) REAR FLOODLAMP INTERLOCK DIODE 189-3158 124-P652 GN-14 124-P147 124-P510 GN-14 GN-14 200-P418 200-P328 200-P311 BK-18 BK-18 BK-18 200-P166 200-P260 200-P131 180-P200 RD-18 BK-18 BK-18 BK-18 F711-P344 F712-P345 H765-P217 H764-P218 YL-18 GN-18 WH-18 GY-18 U753-P320 X725-P128 BR-18 GY-18 SEC STEERING REQUEST SIGNAL STEERING CONTROL SIGNAL HEATED MIRROR RELAY FRONT HEATED WINDOW RELAY BACKLIGHT CONTROL DIGITAL RETURN 626-P86 H745-P738 A514-P157 A501-P171 BU-18 BR-18 YL-18 BU-16 U747-P65 U748-P66 U743-P73 U730-P167 U729-P208 OR-18 GY-18 GY-18 BR-18 PU-18 A295-P531 BK-14 A295-P91 A295-P354 A295-P170 BK-18 BK-14 BK-18 H764-P212 H765-P335 H745-P743 H801-P594 GY-18 WH-18 BR-18 PU-18 H801-P594 H765-P335 H764-P212 H745-P743 WH-18 GY-18 BR-18 PU-18 P-C22 3313582 RH RADIO SPEAKER 6T-7695 - + 511-P579 512-P580 BR-18 GN-18 200-P393 176-P112 170-P114 130-P146 127-P424 BK-14 RD-14 RD-18 GN-18 RD-18 124-P399 GN-18 200-P462 200-P468 200-P463 BK-18 BK-18 BK-16 200-P418 200-P328 200-P311 BK-18 BK-18 BK-18 U740-P202 U739-P203 R800-P50 P967-P49 BU-18 BR-18 OR-18 PU-16 U744-P72 OR-18 AUTO NEUTRAL ART.

SWITCH (NO) WHEEL LEAN INPUT POSN SENSOR BLADE PITCH INPUT POSN SENSOR OPTION LEVER #6 SENSOR OPTION LEVER #7 SENSOR U743-P73 U764-P74 U711-P708 U712-P414 GY-18 GY-18 GY-18 YL-18 U751-P262 U752-P263 U750-P63 U749-P64 WH-18 PU-18 PK-18 BR-18 H8 FUSE BLOCK PART NUMBERS H8 A295-P499 A295-P395 A295-P396 BK-18 BK-14 BK-14 H861-P279 H862-P472 H863-P183 PU-18 GY-18 BU-18 H861-P279 H862-P472 H863-P183 PU-18 GY-18 BU-18 200-P440 144-P173 BK-14 GN-14 1 2 CONN 29 TO AIR AND HEATED SEAT P-C73 3313580 308-P283 403-P288 210-P489 200-P589 BK-18 BK-18 YL-16 GN-18 200-P462 200-P468 200-P463 200-P589 BK-18 BK-18 BK-16 BK-18 U741-P201 OR-18 U745-P76 PK-18 AUTO NEUTRAL ART.

SWITCH (NC) U760-P69 U761-P70 U762-P71 PK-18 PU-18 BR-18 7.5A 141-2760 RELAY 248-2841 A501-P171 BU-16 J769-P733 J771-P729 J944-P194 J943-P447 YL-18 BU-18 BU-18 GN-18 J769-P733 J771-P729 J944-P194 J943-P447 YL-18 BU-18 BU-18 GN-18 P-C25 2610524 WASHER BATTERY + WIPER BATTERY + 1 2 3 4 5 6 7 8 RD-14 RD-18 BK-18 WH-14 YL-14 BU-14 BR-18 WASH PARK LOW HIGH GROUND 120-P581 120-P582 200-P583 YL-14 YL-14 BK-14 200-P516 BK-18 200-P463 200-P328 BK-16 BK-18 516-P507 517-P475 506-P558 507-P555 PU-16 GN-14 BU-14 WH-16 308-P283 320-P466 OR-18 YL-16 YL-16 308-P523 308-P338 308-P11 YL-16 YL-18 U739-P203 BR-18 STEERING LEVER POS SENSOR #1 CIRC DRIVE LEVER POSN SENSOR BLD SIDESHIFT LVR POSN SENSOR U763-P77 M719-P78 BU-18 GN-18 U764-P74 U763-P77 U765-P81 GY-18 BU-18 WH-18 10A 113-8490 15A 113-8491 20A 113-8492 15A(BRKR) 280-2709 20A(BRKR) 280-2710 A514-P157 YL-18 C542-P493 A514-P763 GN-16 YL-18 K749-P79 K723-P735 K722-P737 K723-P386 PU-18 PU-18 YL-18 WH-18 K749-P79 K723-P735 K722-P737 K723-P386 PU-18 PU-18 YL-18 WH-18 142-P264 200-P267 538-P275 BU-18 BK-18 BR-18 1 2 3 4 +24V SWITCHED GROUND DASH HAZARD OUT (58) REAR WIPER SWITCH 275-7764 504-P585 505-P584 503-P586 507-P555 YL-14 BU-14 BR-14 WH-16 200-P564 BK-14 200-P468 200-P589 BK-18 BK-18 592-P595 592-P596 567-P392 530-P557 529-P556 OR-16 WH-16 BU-18 BU-16 WH-18 308-P407 YL-18 308-P100 YL-18 F711-P344 F712-P345 H764-P218 727-P196 YL-18 GN-18 GY-18 GN-18 U741-P201 K758-P75 H728-P410 OR-18 BU-18 GN-18 STEERING LEVER POS SENSOR #3 ART.

LEVER POS SENSOR AUTO ART.

FORWARD/REVERSE BLADE RIGHT LIFT LVR POSN HYD RETURN FILTER BYPASS OPTION LEVER #5 SENSOR CIRCLE MIRROR (NC) K749-P79 Y779-P362 U710-P43 J944-P194 WH-18 GN-18 GN-18 BU-18 Y934-P726 Y933-P728 Y779-P362 U769-P473 U770-P474 WH-18 YL-18 GN-18 OR-18 WH-18 E744-P732 E745-P731 C572-P282 YL-18 BU-18 YL-18 P967-P96 P967-P495 M719-P78 K750-P80 PU-18 PU-18 GN-18 PU-18 P967-P96 P967-P495 M719-P78 K750-P80 PU-18 PU-18 GN-18 PU-18 P-C24 2813395 200-P280 200-P413 200-P425 BK-14 BK-14 BK-14 614-P715 614-P714 PU-18 PU-18 403-P288 GN-18 308-P276 308-P103 YL-18 YL-18 U741-P201 U740-P202 U739-P203 H765-P217 R800-P50 P967-P49 OR-18 BU-18 BR-18 OR-18 PU-16 WH-18 H729-P411 H730-P419 WH-18 BR-18 AUTO ART.

FORWARD AUTO ART.

OFF OPTION LEVER #8 SENSOR K723-P386 PU-18 Y935-P736 Y936-P727 Y937-P730 OR-18 PK-18 PU-18 F501-P321 F501-P22 F501-P764 BU-16 BU-16 BU-16 R800-P92 R800-P446 R900-P59 OR-18 OR-16 BU-18 R800-P446 R800-P92 R900-P59 OR-16 OR-18 BU-18 P-C56 540-P270 695-P252 696-P253 OR-18 GN-18 WH-18 1 2 3 4 5 6 7 8 9 10 11 12 LEFT TURN INPUT RIGHT TURN INPUT LEFT TURN DASH OUT (22) FLASHER MODULE WASHER BATTERY + WIPER BATTERY + 1 2 3 4 5 6 7 8 RD-14 RD-18 BK-18 WH-14 YL-14 BU-14 BR-18 WASH PARK LOW HIGH GROUND P-C100 3313580 118-P587 118-P588 GY-14 GY-14 200-P618 200-P717 200-P637 BK-16 BK-18 BK-14 617-P421 618-P423 614-P719 668-P227 668-P254 BR-14 YL-14 PU-18 BU-18 BU-18 506-P558 530-P557 529-P556 507-P555 403-P349 403-P402 GN-18 GN-18 PU-16 OR-16 WH-16 WH-16 CIRCLE MIRROR (NO) J943-P447 GN-18 Y938-P734 YL-18 F711-P477 YL-18 F503-P550 OR-14 F711-P704 F711-P479 YL-18 YL-18 R902-P60 R901-P61 R903-P62 U706-P39 U707-P40 U708-P41 U709-P42 U710-P43 GN-18 GY-18 OR-18 BR-18 BU-18 OR-18 WH-18 GN-18 R902-P60 R901-P61 R903-P62 T979-P533 GN-18 GY-18 OR-18 YL-18 T971-P560 T972-P561 122-P133 OR-16 GN-16 BU-14 1762946 1 2 3 4 CONN 20 CONNECTS TO Y-C3 VOL 2 LOC B-16 518-P273 539-P271 605-P223 606-P224 581-P52 582-P48 OR-18 BU-18 YL-16 GY-16 GY-18 PK-18 +24V HAZARD INPUT RIGHT TURN DASH OUT LEFT FRONT TURN OUT RIGHT FRONT TURN OUT LEFT REAR TURN OUT RIGHT REAR TURN OUT 431-8733 (59) LH DOOR WIPER SWITCH 200-P379 524-P591 525-P590 BK-14 BU-14 GY-14 200-P216 200-P131 BK-18 BK-18 H1 680-P286 682-P132 681-P593 BU-14 OR-14 GN-14 567-P392 WH-18 180-P200 RD-18 U740-P202 BU-18 STEERING LEVER POS SENSOR #2 RIGHT INC/DEC SWITCH (NEUTRAL) RIGHT INC/DEC SWITCH (INC) RIGHT INC/DEC SWITCH (DEC) Y935-P736 K723-P735 K722-P737 OR-18 PU-18 YL-18 103-P329 103-P405 RD-16 RD-16 (13) UNSWITCHED FUSE BLOCK 309-9886 F711-P486 YL-18 F711-P483 YL-18 U706-P39 U707-P40 U708-P41 U709-P42 U710-P43 BR-18 BU-18 OR-18 WH-18 GN-18 200-P266 BK-14 275-7764 523-P592 529-P556 BR-14 WH-16 200-P710 200-P716 BK-14 BK-18 200-P216 200-P445 BK-18 BK-14 892-P514 893-P429 892-P428 GN-18 BR-18 BR-18 592-P595 592-P596 614-P543 592-P512 BU-18 BU-16 PU-18 BU-14 567-P392 614-P176 308-P103 PU-18 YL-18 WH-18 K777-P506 GY-18 STEERING PRESSURE SENSOR 2 RIGHT AUTO/MNL SWITCH (NO) RIGHT AUTO/MNL SWITCH (NC) L INCREMENT / DECREMENT SWITCH (NEUT) L INECREMENT SWITCH CIRC SIDESHIFT IP POSN SENSOR BLADE LEFT LVR POSN SENSOR OPTION LEVER #9 SENSOR K750-P80 U765-P81 Y938-P734 J769-P733 Y936-P727 Y934-P726 T979-P533 PU-18 WH-18 YL-18 YL-18 PK-18 WH-18 YL-18 104-P309 104-P434 104-P406 RD-14 RD-14 RD-14 BACKLIGHTING RH POSITION LIGHTS F711-P84 F711-P528 YL-18 YL-18 U739-P95 U740-P97 U711-P44 U730-P167 U729-P208 BR-18 BU-18 GY-18 BR-18 PU-18 U730-P167 U729-P208 U711-P44 GY-18 BR-18 PU-18 3313580 P-C64 P-C79 2698225 P-C101 3313580 200-P569 200-P718 200-P628 BK-14 BK-14 BK-14 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 P-C69 3245680 893-P513 A295-P499 A274-P467 A503-P174 BK-14 PK-14 BK-18 GN-18 614-P719 614-P715 614-P714 PU-18 PU-18 PU-18 709-P490 684-P289 893-P111 892-P459 OR-18 OR-18 GN-18 BR-18 106-P250 106-P164 105-P124 121-P30 RD-16 RD-14 WH-14 WH-14 614-P104 626-P86 200-P166 PU-18 BU-18 BK-18 C2 E1 E2 D1 C1 86 85 30 87A 87 86 85 30 C4 E3 E4 D3 C3 200-P311 614-P310 BK-18 PU-18 F711-P93 F711-P46 YL-18 YL-18 U741-P98 U743-P73 OR-18 GY-18 U741-P98 U740-P97 U739-P95 OR-18 BU-18 BR-18 148-P500 121-P30 A274-P467 BK-14 RD-14 WH-14 1 2 3 4 5 6 7 8 CONN 21 308-P481 A210-P340 127-P242 YL-18 BK-18 RD-16 1 2 3 4 5 6 7 8 9 10 11 12 CAN - KEYSWITCH ON BATTERY - BATTERY + G WASHER BATTERY + WIPER BATTERY + 1 2 3 4 5 6 7 8 RD-14 RD-18 BK-18 WH-14 YL-14 BU-14 BR-18 WASH PARK LOW HIGH GROUND 119-P599 119-P600 PK-14 PK-14 200-P492 200-P159 BK-14 BK-18 200-P260 200-P311 BK-18 BK-18 E748-P504 BK-18 C542-P158 A513-P398 A524-P509 A557-P301 RD-18 GN-18 BR-18 WH-14 617-P51 BR-14 614-P222 614-P176 PU-18 PU-18 A295-P499 A295-P354 A295-P395 A295-P396 BK-18 BK-14 BK-14 BK-14 L DECREMENT SWITCH LEFT AUTO/MNL SWITCH (NO) LEFT AUTO/MNL SWITCH (NC) SIDESHIFT AUTO/MNL SWITCH (NO) SIDESHIFT AUTO/MNL SWITCH (NC) Y933-P728 Y937-P730 J771-P729 E744-P732 E745-P731 YL-18 PU-18 BU-18 YL-18 BU-18 125-P324 127-P451 122-P133 131-P417 RD-16 RD-16 BU-14 BR-18 668-P142 BU-18 87A 87 104-P434 618-P435 RD-14 YL-14 F711-P330 F711-P315 YL-18 YL-18 U750-P63 U747-P65 U749-P64 U748-P66 PK-18 OR-18 BR-18 GY-18 U750-P63 U749-P64 U747-P65 U748-P66 U743-P73 PK-18 BR-18 OR-18 GY-18 GY-18 L854-P748 L855-P749 YL-18 GN-18 CONNECTS TO RV-C3 VOL 2 LOC D-8 539-P271 540-P270 614-P378 BU-18 PU-18 WH-18 ACTION ALARM RH TURN SIGNAL LH TURN SIGNAL G (60) RH DOOR WIPER SWITCH 275-7764 527-P603 526-P604 528-P602 200-P601 GN-14 YL-14 PK-14 BK-14 200-P492 BK-18 200-P166 200-P418 200-P462 BK-18 BK-18 BK-18 F712-P306 F711-P314 F785-P671 F781-P675 GN-18 YL-18 WH-18 BR-18 C568-P476 E529-P299 C546-P318 F503-P461 OR-14 YL-18 WH-14 WH-16 618-P423 617-P421 618-P365 YL-14 BR-14 YL-14 A514-P763 C572-P282 F711-P46 F711-P314 YL-18 YL-18 YL-18 YL-18 H7 142-P136 144-P173 148-P500 139-P360 BU-18 GN-14 OR-18 WH-14 FRONT CAB FLOODS SEAT BELT BEACON F711-P391 YL-18 F711-P427 YL-18 U751-P262 U752-P263 U760-P69 U761-P70 WH-18 PU-18 PK-18 PU-18 U751-P262 U752-P263 U760-P69 U761-P70 WH-18 PU-18 PK-18 PU-18 H414-P169 F712-P703 F711-P704 YL-18 GN-18 YL-18 CAN - CAN + 530-P557 OR-16 200-P379 200-P583 200-P501 BK-14 BK-14 BK-14 U753-P320 X754-P333 X755-P334 308-P337 BR-18 GN-18 WH-18 YL-18 F711-P646 F711-P427 F504-P292 YL-18 YL-14 YL-18 645-P431 646-P140 647-P141 OR-18 GN-18 PK-18 F711-P521 F711-P315 F711-P427 YL-18 YL-18 YL-18 F711-P344 F712-P345 Y797-P325 Y798-P545 YL-18 GN-18 YL-18 GN-18 CAN HIGH CAN LOW STEERING CAN HIGH STEERING CAN LOW ACCUGRADE SENSOR CAN HIGH ACCUGRADE SENSOR CAN LOW CAN HIGH CAN LOW L854-P744 L855-P745 F711-P84 F712-P85 YL-18 GN-18 YL-18 GN-18 320-P307 180-P121 169-P168 OR-18 GY-16 RD-14 PK-18 684-P625 200-P260 OR-18 BK-18 C6 E5 E6 D5 C5 86 85 30 87A 87 86 85 30 87A 87 C8 E7 E8 D7 C7 147-P348 E575-P341 BU-18 PU-18 F711-P452 F711-P344 YL-18 YL-18 U762-P659 U764-P74 U763-P77 BR-18 GY-18 BU-18 U762-P659 U764-P74 U763-P77 BR-18 GY-18 BU-18 709-P101 A295-P170 OR-18 BK-18 3313580 P-C67 1 2 3 4 5 6 7 8 F711-P479 F712-P480 E800-P346 YL-18 GN-18 GN-18 1 2 3 4 5 6 7 8 9 10 11 12 300mA DRIVER CAN - CAN + (8) MESSAGE DISPLAY 369-6072 P-C102 3313580 200-P607 200-P601 200-P281 BK-14 BK-14 BK-14 F712-P648 L854-P746 F712-P426 K436-P366 GN-18 GN-18 GN-18 YL-18 668-P115 668-P357 BU-18 BU-18 668-P559 668-P142 BU-18 BU-18 F712-P316 F712-P47 F711-P646 F712-P306 GN-18 YL-18 GN-18 GN-18 322-P308 611-P422 515-P444 604-P364 PU-14 GY-12 OR-18 106-P250 680-P286 GN-14 WH-14 147-P347 K436-P366 PU-18 GN-18 F711-P502 F711-P485 YL-18 YL-18 U765-P81 Y934-P726 Y933-P728 U769-P473 U770-P474 WH-18 YL-18 OR-18 WH-18 WH-18 U769-P473 U770-P474 U765-P81 OR-18 WH-18 WH-18 T979-P533 K723-P386 G711-P760 BR-18 YL-18 PU-18 CONN 22 439-P439 YL-18 HIGH BEAM PIN PULLER WASHER BATTERY + WIPER BATTERY + 1 2 3 4 5 6 7 8 RD-14 RD-18 BK-18 WH-14 YL-14 BU-14 BR-18 WASH PARK LOW HIGH GROUND 120-P605 120-P606 200-P607 502-P608 501-P609 YL-14 YL-14 BK-14 OR-14 GN-14 200-P639 200-P620 BK-14 BK-16 403-P349 925-P23 N787-P232 P880-P443 GN-18 YL-18 BU-18 GY-18 L855-P747 GN-18 668-P227 668-P254 BU-18 BU-18 F712-P522 F712-P648 G766-P198 F712-P426 GN-18 GN-18 GN-18 GN-18 P-C27 3096831 J2 J2 P-C39 3096831 614-P104 614-P327 617-P420 614-P310 PU-18 PU-18 BR-16 PU-18 F711-P469 F711-P521 YL-18 YL-18 Y935-P736 Y936-P727 Y937-P730 OR-18 PK-18 PU-18 Y935-P736 Y936-P727 Y934-P726 Y933-P728 OR-18 PK-18 WH-18 YL-18 J944-P194 J943-P447 BU-18 GN-18 611-P339 PU-18 (57) FR0NT WIPER SWITCH 275-7764 500-P610 506-P558 BR-14 PU-16 200-P638 200-P711 200-P758 BK-14 BK-14 BK-18 H1 998-P25 N931-P352 R908-P353 A295-P354 997-P24 OR-18 BR-18 GY-18 YL-18 BK-14 200-P393 200-P445 124-P399 BK-14 BK-14 GN-18 680-P286 682-P132 681-P593 GN-14 BU-14 OR-14 H745-P765 H764-P150 H765-P377 G767-P127 GY-18 WH-18 BR-18 WH-18 626-P86 619-P430 618-P435 BU-18 GN-14 YL-14 A608-P302 GY-18 C10 E9 E10 D9 C9 HEADLAMP DIMMER 86 85 30 87A 87 SPARE 86 85 30 87A 87 C12 E11 E12 D11 C11 F711-P646 F711-P314 YL-18 YL-18 Y938-P734 T979-P533 YL-18 YL-18 Y938-P734 Y937-P730 YL-18 PU-18 Y933-P728 Y936-P727 H745-P742 Y934-P726 YL-18 PK-18 BR-18 WH-18 3313580 P-C32 1 2 3 4 5 6 7 8 200-P621 200-P317 200-P756 200-P229 BK-14 BK-18 BK-14 BK-14 YL-18 308-P298 210-P182 210-P57 YL-18 BK-14 BK-14 684-P289 683-P322 685-P381 709-P490 OR-18 OR-18 PU-14 BR-14 L854-P746 L855-P747 N787-P232 YL-18 GN-18 BU-18 646-P312 647-P450 684-P129 684-P387 OR-18 GN-18 OR-18 OR-18 610-P455 611-P422 619-P430 200-P462 OR-14 PU-14 GN-14 BK-18 H8 F712-P478 GN-18 F712-P703 F712-P480 GN-18 GN-18 103-P329 RD-16 CONN 23 CONNECTS TO RF-C3 VOL 2 LOC B-12 P-C7 3313578 P-C15 3313582 +24 V BATTERY IN +24 V SWITCHED IN GROUND 1 2 3 4 5 6 P-C103 2458025 176-P112 RD-14 200-P615 200-P249 BK-14 BK-14 307-P359 OR-16 603-P243 308-P337 609-P184 YL-18 PK-18 843-P207 844-P210 850-P226 849-P230 799-P161 WH-18 GN-18 PU-18 YL-18 WH-18 U711-P707 P967-P180 R800-P220 R732-P160 GY-18 PU-18 OR-18 BR-18 684-P625 A514-P157 C542-P493 685-P441 A501-P171 OR-18 YL-18 GN-16 BU-16 BR-14 F712-P515 GN-18 F712-P484 GN-18 104-P309 104-P406 103-P405 RD-14 RD-14 RD-16 H745-P741 Y937-P730 J771-P729 BR-18 PU-18 BU-18 E800-P346 A210-P326 BK-18 GN-18 RD BK 1 2 SEAT BELT INDICATOR 250-2299 (5) COMMUNICATIONS CONVERTER 348-7842 +12 V SWITCHED OUT GROUND 308-P598 200-P615 A572-P616 PK-14 YL-18 BK-14 200-P629 200-P247 200-P752 BK-14 BK-14 BK-12 Y779-P362 F783-P673 GN-18 GN-18 A504-P234 A507-P237 GN-16 YL-16 892-P394 BR-18 U712-P414 U739-P172 U741-P380 U740-P385 BR-18 OR-18 BU-18 YL-18 H7 F501-P321 F503-P550 F501-P22 BU-16 OR-14 BU-16 PWR AIR CLEANER CAB FR FLOODS 2 F712-P85 F712-P529 GN-18 GN-18 F712-P47 GN-18 106-P250 104-P434 106-P164 105-P124 RD-14 RD-16 WH-14 WH-14 P-C44 R 200-P249 BK-14 200-P631 200-P636 210-P630 210-P651 BK-14 BK-14 BK-16 BK-18 BR-18 892-P524 892-P459 BR-18 Y779-P362 U762-P705 BR-18 GN-18 F712-P519 F711-P502 GN-18 YL-18 134-P454 200-P418 E529-P299 RD-14 BK-18 YL-18 C14 E13 E14 D13 C13 86 85 30 87A 87 86 85 30 87A 87 C16 E15 E16 D15 C15 184-P135 684-P129 200-P131 RD-14 OR-18 BK-18 F712-P647 GN-18 125-P324 127-P451 122-P133 121-P30 RD-16 RD-16 BU-14 RD-14 K723-P735 H745-P743 PU-18 BR-18 3313580 1 2 3 4 5 6 7 8 308-P373 YL-18 P-C3 2458025 1 2 3 4 5 6 BR-16 OR-16 PU-16 YL-16 B S C ST ON OFF (50) KEY SWITCH 255-2752 P-C105 2698222 DOME LAMP 3E-6389 210-P182 210-P57 210-P489 BK-14 BK-14 BK-18 892-P278 892-P187 892-P109 BR-18 BR-18 BR-18 A557-P301 WH-14 682-P132 BU-14 F712-P517 GN-18 F712-P332 F712-P316 GN-18 GN-18 142-P136 169-P168 144-P173 148-P500 BU-18 PK-18 GN-14 WH-14 Y938-P734 J769-P733 K722-P737 Y935-P736 YL-18 YL-18 YL-18 OR-18 CONN 24 CONNECTS TO RF-C4 VOL 2 LOC B-12 307-P359 105-P124 E489-P54 OR-16 RD-16 PK-18 RD-16 NOTE A C B BK-18 WH-18 RD-18 A 200-P618 108-P617 BK-16 RD-16 308-P598 308-P597 YL-18 YL-18 308-P283 308-P298 YL-16 YL-18 X800-P374 604-P436 OR-18 OR-18 892-P428 BR-18 892-P209 BR-18 113-P83 115-PW410 108-P116 112-PW154 RD-4 RD-16 PU-4 RD-16 103-P329 104-P309 104-P406 103-P405 RD-16 RD-14 RD-14 RD-16 HORN SPARE F712-P426 GN-18 180-P165 320-P465 322-P308 RD-16 OR-18 GY-16 H745-P740 BR-18 F P-C108 2458025 403-P288 506-P558 GN-18 PU-16 308-P337 YL-18 124-P399 GN-18 892-P221 BR-18 892-P14 BR-18 120-P130 116-P148 119-P162 118-P261 YL-14 BR-18 PK-14 GY-14 106-P250 104-P434 106-P164 105-P124 RD-14 RD-16 WH-14 WH-14 114-P304 114-P305 320-P307 RD-16 RD-16 OR-18 C18 E17 E18 D17 C17 86 85 30 87A 87 86 85 30 87A C20 E19 E20 D19 C19 F712-P470 F712-P345 GN-18 GN-18 614-P104 611-P422 515-P444 604-P364 PU-18 PU-14 GY-12 OR-18 1762946 P-C49 J844-P415 J766-P403 F702-P188 GY-18 PU-18 GN-18 P-C23 2698222 A B C BK-18 OR-18 BATTERY + GROUND SIGNAL (43) THROTTLE POSITION SENSOR F (34) FRONT WIPER MOTOR H MOTOR L GND BK-16 1 2 200-P621 BK-14 516-P507 517-P475 530-P557 529-P556 507-P555 GN-14 BU-14 OR-16 WH-16 WH-16 U741-P380 U734-P382 E974-P383 F784-P676 OR-18 GN-18 GN-18 YL-18 200-P445 BK-14 200-P393 BK-14 210-P182 BK-14 210-P57 BK-14 892-P514 893-P290 893-P464 BR-18 GN-18 GN-18 124-P510 130-P146 124-P147 141-P149 GN-18 GN-14 PK-16 GN-14 114-P304 114-P305 114-P449 RD-16 RD-16 RD-16 322-P308 GY-16 87 F712-P519 F712-P491 GN-18 GN-18 614-P327 617-P420 614-P310 618-P435 PU-18 BR-16 PU-18 YL-14 H745-P739 E744-P732 E745-P731 BR-18 YL-18 BU-18 1 2 3 4 CONN 25 CONNECTS TO RF-C8 VOL 2 LOC A-12 WH-18 266-1467 295-1120 P B+ T° GN-16 GY-16 BR-16 OR-16 3 4 5 6 120-P612 501-P609 500-P610 502-P608 YL-14 GN-14 BR-14 OR-14 592-P595 592-P596 567-P392 BU-18 BU-16 WH-18 603-P243 PK-18 308-P298 YL-18 308-P337 YL-18 609-P184 YL-18 893-P111 893-P144 GN-18 GN-18 149-P94 155-P26 156-P88 PU-14 RD-14 YL-18 117-P122 117-P622 117-P549 117-P152 RD-14 RD-16 RD-16 RD-14 F712-P562 F712-P522 GN-18 GN-18 646-P312 647-P450 619-P430 OR-18 GN-18 GN-14 P-C83 2698222 (47) BRAKE LIGHT SWITCH 603-P243 614-P715 614-P714 609-P184 PK-18 PU-18 PU-18 YL-18 CONNECTS TO F-C22 VOL 3 LOC D-16 CONN 13 U735-P388 U727-P389 GY-18 YL-18 A507-P237 YL-16 A504-P234 GN-16 893-P277 893-P45 GN-18 GN-18 165-P295 171-P448 172-P453 170-P114 RD-14 RD-14 RD-18 YL-18 121-P30 RD-14 114-P449 125-P324 127-P451 171-P448 RD-16 RD-16 RD-16 RD-14 G20 G19 G18 G17 G16 G15 G14 G13 G12 G11 G10 G9 15A 10A 10A 10A 15A 15A - 15A 15A - 20A 15A - F20 F19 F18 F17 F16 F15 F14 F13 F12 F11 F10 F9 F8 F7 F6 F5 F4 F3 F2 F1 - F40 F39 F38 F37 F36 F35 F34 F33 F32 F31 F30 F29 F28 F27 F26 F25 F24 F23 F22 F21 20A 10A 10A 15A - 15A 15A 10A 10A - 20A - - 10A - - - - - - A20 A19 A18 A17 A16 A15 A14 A13 A12 A11 A10 A9 A8 A7 A6 A5 A4 A3 A2 170-P114 180-P121 108-P116 176-P112 RD-18 RD-14 RD-16 RD-14 F712-P648 F712-P306 GN-18 GN-18 727-P196 F501-P22 C542-P493 685-P441 GN-18 BU-16 GN-16 BR-14 103-P438 RD-18 103-P438 125-P287 105-P124 RD-16 RD-18 RD-18 103-P438 604-P442 RD-18 OR-18 A B C RD-18 BK-18 WH-18 189-0135 NOTE B (39) DEFROSTER FAN RESISTOR 7T-4003 A504-P234 GN-16 617-P421 618-P423 614-P719 BR-14 YL-14 PU-18 U726-P294 GY-18 893-P429 GN-18 893-P296 GN-18 200-P131 200-P166 200-P260 179-P107 176-P112 BK-18 BK-18 RD-14 RD-14 BK-18 H6 122-P133 123-P151 123-P163 123-P138 BU-14 WH-14 WH-16 WH-14 134-P454 172-P453 155-P26 RD-14 RD-14 RD-14 184-P135 104-P406 103-P405 105-P124 RD-14 RD-14 RD-16 RD-16 G767-P127 G766-P198 G953-P31 G965-P361 GN-18 BU-18 PU-18 WH-18 F501-P321 F503-P550 F501-P764 F711-P479 BU-16 OR-14 BU-16 YL-18 103-P725 103-P329 103-P405 RD-16 RD-16 RD-16 125-P313 125-P370 125-P720 125-P721 RD-18 RD-18 RD-18 RD-18 P-C84 1762946 A507-P237 A507-P619 YL-16 YL-16 668-P227 668-P254 680-P286 681-P593 BU-18 BU-18 GN-14 OR-14 A295-P395 A295-P396 683-P322 BK-14 BK-14 PU-14 106-P108 WH-16 104-P153 RD-16 103-P725 RD-16 112-PW154 PU-4 893-P513 893-P331 GN-18 GN-18 893-P12 GN-18 200-P418 200-P328 200-P311 BK-18 BK-18 BK-18 H6 123-P178 RD-16 RD-16 WH-16 133-P205 179-P107 RD-14 RD-14 117-P122 RD-14 H745-P541 BR-18 H745-P743 H745-P739 H745-P741 BR-18 BR-18 BR-18 F711-P483 F712-P484 F711-P704 F712-P480 YL-18 GN-18 YL-18 GN-18 104-P153 104-P309 104-P434 104-P406 RD-16 RD-14 RD-14 RD-14 142-P265 127-P242 131-P409 131-P487 BR-18 BU-18 RD-16 BR-18 E974-P383 A202-P437 BK-18 GN-18 1 2 3 4 BK-18 RD-18 4 2 (49) INCHING PEDAL SWITCH 171-3759 P-C107 3313582 892-P514 892-P428 682-P132 BR-18 BR-18 BU-14 115-PW410 RD-4 116-P148 BR-18 125-P552 RD-18 113-P83 RD-16 E575-P341 BU-18 200-P462 200-P468 200-P463 BK-18 BK-18 BK-16 125-P324 127-P451 131-P417 BR-18 143-P255 183-P257 121-P30 RD-14 RD-14 RD-14 G8 G7 G6 G5 G4 G3 G2 G1 A1 15A - - - - 15A 113-P83 RD-16 H745-P742 H745-P740 BR-18 BR-18 F712-P703 G953-P31 G965-P361 GN-18 BU-18 PU-18 105-P124 RD-16 180-P165 200-P134 307-P359 200-P87 BK-16 RD-16 BK-18 OR-16 U727-P389 YL-18 WH-18 1 NOTE B (11) REAR DEFROSTER FAN 170-5334 1 2 MOTOR WH/RD-14 BK-14 200-P620 BK-16 893-P513 893-P429 A295-P499 A274-P467 BK-18 GN-18 GN-18 BK-14 E929-P27 A202-P356 L731-P29 GY-18 BK-14 BR-18 169-P28 PK-18 141-P149 PK-16 149-P94 PU-14 165-P295 YL-18 997-P24 998-P25 A201-P323 OR-18 BR-18 BK-18 200-P589 680-P286 645-P431 668-P142 GN-14 PK-18 BU-18 BK-18 135-P245 135-P155 135-P156 BU-14 BU-14 BU-14 H745-P540 BR-18 L854-P748 L855-P749 YL-18 GN-18 106-P108 106-P250 106-P164 WH-16 WH-14 WH-14 308-P482 308-P373 308-P481 YL-18 YL-18 YL-18 X800-P291 T998-P412 OR-18 BR-18 P-C40 2698222 A B C OR-18 BK-18 WH-18 +12V GROUND SIGNAL (41) INCHING PEDAL SENSOR A504-P234 A507-P237 A513-P398 A524-P509 GN-16 YL-16 RD-18 BR-18 149-P94 PU-14 180-P200 RD-18 179-P107 RD-14 201-P319 BK-16 A202-P503 A202-P355 A295-P354 A202-P356 BK-18 BK-14 BK-14 BK-18 681-P593 682-P132 683-P322 A503-P174 PU-14 BU-14 PK-14 OR-14 139-P360 133-P205 OR-18 RD-14 115-PW410 RD-4 H745-P738 BR-18 H745-P765 BR-18 180-P200 RD-18 122-P133 121-P30 RD-14 BU-14 125-P269 RD-18 540-P270 539-P271 320-P465 439-P439 YL-18 BU-18 OR-18 WH-18 F843-P384 YL-18 266-1467 (33) REAR WIPER MOTOR H MOTOR L GND BK-16 1 2 P-C113 2458025 200-P639 BK-14 C568-P476 C542-P158 C546-P318 A557-P301 GN-18 WH-14 WH-14 WH-16 229-P225 BK-14 A295-P499 A295-P395 A295-P396 BK-18 BK-14 BK-14 C546-P318 A557-P301 A608-P302 GY-18 WH-14 WH-16 142-P136 144-P173 148-P500 BU-18 GN-14 WH-14 (4) BUSSBAR C 330-3356 H764-P212 H764-P218 H764-P150 GY-18 GY-18 GY-18 308-P103 614-P176 567-P392 320-P466 YL-18 PU-18 OR-18 WH-18 125-P105 RD-18 125-P370 125-P251 125-P750 125-P751 RD-18 RD-18 RD-18 RD-18 604-P364 OR-18 604-P436 OR-18 604-P442 OR-18 727-P196 A296-P367 GN-18 BK-18 P-C4 2234778 1 2 3 4 5 6 7 8 9 10 OFF - TEST 330-5016 P B+ T° GN-16 GY-16 BR-16 OR-16 3 4 6 120-P611 504-P585 505-P584 503-P586 YL-14 YL-14 BU-14 BR-14 E529-P680 E529-P181 YL-14 YL-18 E529-P299 YL-18 618-P365 582-P48 617-P51 581-P52 U768-P369 G755-P53 YL-14 PK-18 BR-14 GY-18 BU-18 GY-18 403-P349 GN-18 307-P359 OR-16 403-P402 GN-18 308-P407 YL-18 A296-P17 A296-P15 A296-P16 BK-18 BK-14 BK-18 K436-P366 E575-P341 F504-P292 E529-P299 YL-18 YL-14 GN-18 BU-18 160-P458 160-P761 160-P762 PU-16 PU-18 PU-16 (12) SWITCHED FUSE BLOCK 309-9886 H765-P335 H765-P217 H765-P377 WH-18 WH-18 WH-18 709-P490 727-P196 684-P289 892-P459 OR-18 GN-18 OR-18 BR-18 125-P123 RD-18 125-P313 125-P287 RD-18 RD-18 611-P339 PU-18 (53) SECONDARY STEERING SWITCH 382-4478 E 5 F503-P461 F504-P292 A503-P174 OR-14 YL-14 PK-14 518-P273 OR-18 519-P397 PK-16 520-P110 WH-18 A296-P350 BK-14 A296-P20 A296-P19 BK-14 BK-14 320-P307 180-P121 169-P168 OR-18 GY-16 RD-14 PK-18 REAR FLOOD HVAC BLOWER H861-P279 H862-P472 H801-P594 PU-18 GY-18 PU-18 893-P111 A295-P354 A295-P395 A295-P396 BK-14 BK-14 BK-14 GN-18 125-P720 125-P721 RD-18 RD-18 668-P343 668-P272 668-P372 614-P378 PU-18 BU-18 BU-18 BU-18 125-P370 668-P372 RD-18 BU-18 E 200-P159 200-P247 BK-14 BK-14 F712-P648 F711-P646 F712-P426 F711-P427 GN-18 YL-18 GN-18 YL-18 570-P572 BU-18 538-P275 BR-18 582-P48 PK-18 581-P52 GY-18 A296-P36 BK-14 A296-P21 BK-14 104-P153 103-P725 106-P108 RD-16 RD-16 WH-16 322-P308 515-P444 GY-12 123-P178 646-P312 OR-18 WH-16 C2 E1 E2 D1 C1 86 85 30 87A 87 86 85 30 C4 E3 E4 D3 C3 124-P510 200-P463 C546-P318 GN-14 BK-16 WH-16 H863-P183 J769-P733 J771-P729 J944-P194 J943-P447 BU-18 YL-18 BU-18 BU-18 GN-18 A514-P763 C572-P282 A295-P499 BK-18 YL-18 YL-18 125-P324 127-P451 125-P552 RD-16 RD-16 RD-18 695-P252 696-P253 668-P722 668-P723 BU-18 BU-18 OR-18 GN-18 200-P393 200-P425 200-P281 BK-14 BK-14 BK-14 K436-P366 L854-P746 L855-P747 GN-18 GN-18 YL-18 H764-P150 H765-P377 U739-P172 G750-P177 GY-18 WH-18 BR-18 BU-18 592-P512 BU-14 614-P543 PU-18 617-P51 BR-14 604-P436 OR-18 A296-P13 A296-P18 A296-P367 BK-14 BK-18 BK-18 403-P288 308-P338 169-P28 125-P552 127-P424 GN-18 YL-16 PK-18 RD-18 RD-18 611-P422 610-P455 PU-14 OR-14 123-P138 683-P322 PU-14 WH-14 87A 87 515-P444 GY-12 H9 K723-P735 K722-P737 K723-P386 PU-18 PU-18 YL-18 F711-P344 F711-P46 F711-P314 F711-P315 YL-18 YL-18 YL-18 YL-18 127-P424 RD-18 127-P242 RD-16 709-P90 799-P494 727-P196 A202-P437 OR-18 BK-18 GN-18 WH-18 308-P482 YL-18 P-C80 2458025 1 2 3 4 5 6 200-P569 200-P629 200-P564 200-P501 BK-14 BK-14 BK-14 BK-14 P-C112 3313582 F843-P384 U740-P385 G763-P197 YL-18 BU-18 PU-18 646-P140 OR-18 647-P141 GN-18 618-P365 YL-14 645-P431 PK-18 A296-P137 A296-P532 BK-18 BK-14 403-P349 403-P402 GN-18 GN-18 614-P104 614-P327 617-P420 614-P310 PU-18 PU-18 BR-16 PU-18 BLADE FLOOD SIDE HTD WDO 1 K749-P79 K750-P80 PU-18 WH-18 L854-P746 YL-18 F712-P47 F711-P646 F711-P427 F711-P521 GN-18 YL-18 YL-18 YL-18 142-P136 BU-18 142-P264 142-P265 BU-18 BU-18 A202-P575 A210-P340 A210-P326 BK-18 BK-18 BK-18 F711-P483 F712-P484 200-P87 YL-18 GN-18 BK-16 CONN 28 CONNECTS TO CT-C4 VOL 2 LOC J-16 200-P711 200-P710 200-P752 200-P756 BK-14 BK-14 BK-12 BK-14 200-P629 A572-P616 BK-14 PK-14 1 2 COMMUNICATION RADIO CONNECTION CONN 8 893-P290 892-P394 U725-P297 GN-18 BR-18 GN-18 668-P115 BU-18 684-P289 OR-18 683-P322 PU-14 A296-P186 A296-P215 BK-14 BK-14 A296-P551 A296-P82 BK-18 BK-18 592-P595 592-P596 614-P222 592-P512 BU-18 BU-16 PU-18 BU-14 646-P312 619-P430 618-P435 626-P86 OR-18 GN-14 YL-14 BU-18 123-P163 647-P450 GN-18 WH-16 C6 E5 E6 D5 C5 86 85 30 87A 87 86 85 30 87A 87 C8 E7 E8 D7 C7 117-P549 F501-P321 RD-16 BU-16 L854-P744 YL-18 L854-P748 L855-P747 YL-18 GN-18 F712-P345 F712-P306 F712-P316 GN-18 GN-18 GN-18 H7 169-P28 PK-18 144-P173 148-P500 GN-14 WH-14 169-P259 PK-18 103-P438 RD-18 A296-P551 A295-P91 A296-P367 A755-P193 BK-18 BK-18 BK-18 PK-18 A274-P467 BK-14 P878-P498 GN-18 685-P381 BR-14 709-P490 OR-18 799-P161 WH-18 843-P207 WH-18 844-P210 GN-18 A503-P174 PK-14 617-P421 618-P365 617-P51 614-P543 BR-14 YL-14 BR-14 PU-18 647-P450 684-P129 684-P387 GN-18 OR-18 OR-18 685-P441 143-P255 BR-14 RD-14 117-P152 F503-P550 RD-14 OR-14 L855-P745 GN-18 N787-P232 M719-P78 BU-18 GN-18 L855-P749 GN-18 F712-P648 G766-P198 F712-P426 F712-P522 GN-18 GN-18 GN-18 GN-18 169-P168 PK-18 180-P165 RD-16 200-P87 BK-16 200-P134 BK-18 105-P124 121-P30 122-P133 BU-14 RD-16 RD-14 C979-P195 C251-P371 C251-P390 E489-P54 BK-18 BK-18 PK-18 OR-18 P-C153 3313579 (36) AUXILIARY CONTROL POD (21) MINI JOYSTICK 200-P159 200-P247 BK-14 BK-14 500-P610 502-P608 501-P609 504-P585 503-P586 BR-14 OR-14 GN-14 YL-14 BR-14 893-P290 GN-18 892-P394 BR-18 850-P226 PU-18 849-P230 YL-18 A513-P398 A513-P400 A513-P401 RD-18 RD-16 RD-14 618-P423 646-P140 647-P141 668-P559 YL-14 OR-18 GN-18 BU-18 H5 H5 684-P625 685-P441 A501-P171 A514-P157 OR-18 BU-16 YL-18 BR-14 P967-P495 P967-P96 P967-P49 PU-18 PU-18 PU-16 H764-P218 H764-P150 G767-P127 H745-P765 GY-18 GY-18 BR-18 WH-18 200-P266 BK-14 200-P440 BK-14 200-P267 BK-18 125-P313 125-P287 125-P251 125-P269 RD-18 RD-18 RD-18 RD-18 F711-P483 E974-P383 F702-P188 F711-P479 YL-18 YL-18 GN-18 GN-18 N952-P542 U706-P39 A296-P551 BK-18 BU-18 BR-18 J1 1 2 3 4 5 6 7 8 9 10 11 12 PRIMARY POWER PRIMARY GND LED PWR PWM #3 PWM #4 PWM #2 LED #1 LED #2 LED #3 MINI AXIS 1 MINI AXIS 2 PWM #1 238-8756 J2 233-3147 JOYSTICK SENSOR 200-P393 200-P425 200-P501 200-P281 BK-14 BK-14 BK-14 BK-14 508-P577 509-P578 505-P584 PU-18 WH-18 BU-14 E489-P54 685-P381 PK-18 BR-14 925-P23 YL-18 997-P24 OR-18 998-P25 BR-18 A557-P301 A608-P302 A514-P763 GY-18 YL-18 WH-14 685-P381 BR-14 998-P25 799-P161 BR-18 WH-18 F501-P321 F503-P550 F501-P22 C542-P493 BU-16 OR-14 BU-16 GN-16 614-P327 PU-18 C10 E9 E10 D9 C9 LH POSN LIGHTS 86 85 30 87A 87 SIDE HTD WDO 2 86 85 30 87A 87 C12 E11 E12 D11 C11 117-P622 RD-16 R732-P160 BR-18 P967-P180 PU-18 L854-P746 H765-P217 H765-P377 YL-18 WH-18 WH-18 308-P338 YL-16 125-P370 125-P720 125-P721 125-P750 125-P751 RD-18 RD-18 RD-18 RD-18 RD-18 F712-P484 F711-P704 F712-P480 GN-18 GN-18 YL-18 180-P165 U708-P41 U709-P42 RD-16 OR-18 WH-18 PRIMARY POWER MINI AXIS1 GND PRIMARY POWER MINI AXIS 2 GND 2 1 4 3 +7V - 13V SUPPLY PWM 5 GROUND #1 200-P569 200-P629 200-P564 BK-14 BK-14 BK-14 511-P579 512-P580 523-P592 524-P591 BR-18 GN-18 BR-14 BU-14 Y797-P535 Y798-P539 M700-P300 YL-18 GN-18 BR-18 A202-P355 BK-18 A202-P356 BK-14 A201-P323 BK-18 C546-P318 C572-P282 C542-P158 C542-P563 GN-18 GN-18 YL-18 WH-16 998-P759 A202-P355 A202-P356 A202-P503 BK-18 BR-18 BK-14 BK-18 103-P329 617-P420 200-P328 RD-16 BR-16 BK-18 133-P205 F501-P22 F504-P292 RD-14 BU-16 YL-14 R800-P446 R800-P92 R800-P50 OR-16 OR-18 OR-18 L855-P747 P967-P49 P967-P180 N787-P232 GN-18 PU-16 PU-18 BU-18 308-P373 308-P482 308-P481 YL-18 YL-18 YL-18 127-P242 142-P265 142-P264 RD-16 BU-18 BU-18 H414-P169 F843-P384 J844-P415 J766-P403 F712-P703 YL-18 YL-18 GY-18 PU-18 GN-18 U760-P69 U761-P70 U762-P659 U707-P40 PK-18 PU-18 BR-18 BU-18 6 5 JOYSTICK LH/RH SENSOR +7V - 13V SUPPLY PWM 6 GROUND #1 200-P710 200-P711 200-P752 200-P756 BK-14 BK-14 BK-12 BK-14 526-P604 527-P603 525-P590 YL-14 GN-14 GY-14 A295-P354 BK-14 A295-P395 BK-14 A295-P396 BK-14 A202-P503 BK-18 E529-P299 F503-P461 F503-P376 E929-P27 OR-16 GY-18 YL-18 OR-14 C542-P158 A296-P551 A296-P82 A296-P367 GN-18 BK-18 BK-18 BK-18 PA-C5 7T5957 OR-18 F712-P519 F711-P502 604-P364 GN-18 YL-18 P-C11 1552267 NOT USED A B C R900-P59 R901-P61 BU-18 GY-18 R800-P220 OR-18 U711-P707 R800-P50 R800-P220 R732-P160 GY-18 OR-18 OR-18 BR-18 320-P465 OR-18 322-P308 GY-16 144-P173 148-P500 169-P259 GN-14 PK-18 WH-14 M719-P78 K749-P79 N952-P542 BU-18 GN-18 WH-18 U711-P44 U710-P43 GY-18 GN-18 J2 A274-P467 BK-14 528-P602 PK-14 A B C D E F G H J P-C71 3313593 799-P161 A202-P503 WH-18 BK-18 A513-P400 RD-16 A296-P137 BK-18 A296-P186 BK-14 A296-P215 BK-14 F711-P427 F504-P292 F711-P314 YL-18 YL-18 YL-14 C542-P563 F503-P376 F503-P461 GN-18 OR-16 OR-14 506-PA1 200-PA2 PU-16 BK-16 MOTOR 1 2 223-3383 (26) FRONT WASHER MOTOR REAR CAB LIGHTS HEATED MIRROR R902-P60 R903-P62 U706-P39 U707-P40 U708-P41 U709-P42 U710-P43 T979-P533 GN-18 OR-18 BR-18 BU-18 OR-18 WH-18 GN-18 YL-18 U740-P202 U739-P203 U739-P172 U712-P414 BU-18 BR-18 BR-18 YL-18 403-P288 403-P349 403-P402 GN-18 GN-18 GN-18 200-P87 200-P134 180-P165 200-P266 BK-18 RD-16 BK-14 BK-16 T998-P412 R908-P353 U706-P39 U707-P40 U708-P41 U709-P42 U710-P43 BR-18 BU-18 OR-18 WH-18 GN-18 BR-18 YL-18 (35) HVAC PANEL 248-4220 501-P609 500-P610 GN-14 BR-14 P967-P180 R732-P160 N952-P99 PU-18 BR-18 BU-18 A513-P401 RD-14 A608-P302 GY-18 A514-P763 YL-18 F712-P426 F711-P521 F711-P646 F712-P306 YL-18 GN-18 GN-18 YL-18 N952-P542 T998-P185 T971-P560 T972-P561 BR-18 OR-16 GN-16 BU-18 PA-C4 7T5957 108-P116 112-PW154 RD-16 PU-4 200-P589 684-P387 183-P257 RD-14 BK-18 OR-18 C14 E13 E14 D13 C13 86 85 30 87A 87 86 85 30 87A 87 C16 E15 E16 D15 C15 160-P761 160-P762 A514-P157 PU-18 PU-16 YL-18 U741-P201 U741-P380 U740-P385 OR-18 OR-18 BU-18 592-P595 515-P444 BU-18 GY-12 308-P481 308-P482 308-P373 200-P440 200-P267 YL-18 YL-18 YL-18 BK-14 BK-18 P-C43 2698225 J1 D 504-P585 503-P586 505-P584 502-P608 YL-14 BR-14 BU-14 OR-14 T998-P185 A296-P186 F702-P188 C978-P192 G946-P191 BR-18 BK-14 GN-18 BR-18 OR-18 A755-P193 PK-18 G766-P198 F712-P522 G434-P102 F712-P648 GN-18 GN-18 GN-18 BU-18 X800-P374 OR-18 530-PA3 200-PA4 OR-16 BK-16 MOTOR 1 2 223-3383 (30) RH DOOR WASHER MOTOR 115-PW410 116-P148 113-P83 RD-4 BR-18 RD-16 681-P593 OR-14 C542-P493 GN-16 U711-P708 GY-18 U711-P707 U711-P44 GY-18 GY-18 U762-P705 Y779-P362 BR-18 GN-18 592-P512 592-P511 592-P596 BU-14 BU-18 BU-16 604-P364 320-P465 322-P308 OR-18 GY-16 OR-18 U711-P44 U727-P389 U760-P69 U761-P70 GY-18 YL-18 PK-18 PU-18 709-P90 K749-P79 A295-P91 OR-18 WH-18 BK-18 1 2 3 4 5 6 7 8 9 10 11 12 +V1 BLADE LIFT SENSOR GROUND 1 D HIGH 511-P579 512-P580 509-P578 508-P577 BR-18 GN-18 WH-18 PU-18 CONNECTS TO F-C23 VOL 3 LOC B-16 CONN 12 K L M N O P Q R S T U V W X J766-P403 C979-P195 A755-P193 PU-18 PK-18 OR-18 A756-P214 A757-P248 BU-18 GY-18 G767-P127 H728-P410 H729-P411 H730-P419 GN-18 WH-18 BR-18 WH-18 506-P558 530-P557 529-P556 507-P555 PU-16 OR-16 WH-16 WH-16 506-P558 PU-16 P-C90 1743089 PA-C1 1552252 1 2 3 4 5 6 7 8 9 10 11 12 506-PA1 200-PA2 530-PA3 200-PA4 529-PA5 200-PA6 T972-PA7 200-PA8 T971-PA9 200-PA10 507-PA11 200-PA12 PU-16 BK-16 OR-16 BK-16 WH-16 BK-16 GN-16 BK-16 OR-16 BK-16 WH-16 BK-16 PA-C7 7T5957 120-P130 124-P147 119-P162 118-P261 YL-14 GN-14 PK-14 GY-14 HEAD LAMP FRONT HTD WDO U730-P167 U729-P208 U712-P414 BR-18 PU-18 YL-18 604-P364 OR-18 611-P336 PU-14 614-P378 611-P336 611-P339 PU-14 PU-18 PU-18 U762-P659 U764-P74 U763-P77 U765-P81 BR-18 GY-18 BU-18 WH-18 799-P494 M719-P78 A202-P575 U763-P77 U764-P74 WH-18 GN-18 BK-18 BU-18 GY-18 +V2 BLADE SIDESHFT SENSOR GROUND 2 CIRCLE DRIVE SENSOR BLADE PITCH SENSOR 1 2 3 4 5 6 7 8 9 10 11 12 P-C20 2698225 124-P652 C546-P318 GN-14 WH-16 523-P592 525-P590 524-P591 BR-14 GY-14 BU-14 J844-P415 A296-P215 A756-P214 A758-P204 GY-18 BK-14 BU-18 BR-18 C978-P192 G946-P191 E748-P504 A758-P204 BR-18 BR-18 OR-18 BK-18 H745-P765 H764-P150 H765-P377 GY-18 WH-18 BR-18 T971-P560 T972-P561 OR-16 GN-16 200-P145 BK-16 200-P246 BK-16 530-P557 OR-16 529-P556 WH-16 529-PA5 200-PA6 WH-16 BK-16 MOTOR 1 2 223-3383 (27) LH DOOR WASHER MOTOR 130-P146 141-P149 124-P510 GN-18 PK-16 GN-14 104-P309 200-P468 645-P431 RD-14 BK-18 PK-18 C18 E17 E18 D17 C17 86 85 30 87A 87 86 85 30 87A C20 E19 E20 D19 C19 135-P156 135-P155 A501-P171 BU-14 BU-14 BU-16 U739-P95 U739-P172 BR-18 BR-18 614-P104 611-P422 614-P543 PU-18 PU-14 PU-18 611-P339 614-P378 PU-18 PU-18 617-P432 618-P433 619-P430 646-P126 BR-16 YL-16 GN-14 OR-18 X800-P291 OR-18 P-C151 MEDIUM-HIGH 516-P507 517-P475 C568-P476 E529-P680 GN-14 BU-14 WH-14 YL-14 527-P603 526-P604 528-P602 GN-14 YL-14 PK-14 R800-P220 L914-P89 229-P225 OR-18 BU-18 BK-14 P880-P443 P878-P498 L914-P89 U725-P297 GY-18 GN-18 BU-18 GN-18 K777-P506 H864-P219 K436-P366 L854-P746 L855-P747 YL-18 GN-18 GY-18 GN-18 GN-18 200-P145 BK-16 200-P246 BK-16 200-P241 BK-16 200-P241 BK-16 200-P240 BK-16 T971-P560 OR-16 T972-P561 GN-16 PA-C6 7T5957 147-P347 147-P363 147-P348 PU-18 PU-18 PU-18 610-P455 OR-14 87 A503-P174 PK-14 U739-P203 U740-P97 U740-P385 BR-18 BU-18 BU-18 614-P222 614-P327 614-P310 PU-18 PU-18 PU-18 647-P125 GN-18 668-P272 668-P343 BU-18 BU-18 617-P432 BR-16 1977259 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 U765-P81 WH-18 P-C46 3313578 CIRCLE SIDESHFT SENSOR (20) RH JOYSTICK 348-6995 614-P719 200-P718 200-P628 PU-18 BK-14 BK-14 K777-P506 A757-P248 GY-18 GY-18 U726-P294 GY-18 N787-P232 N788-P236 M792-P285 BU-18 PK-18 BU-18 200-P233 BK-16 200-P231 BK-16 200-P233 BK-16 200-P231 BK-16 507-P555 WH-16 T972-PA7 200-PA8 GN-16 BK-16 MOTOR 1 2 223-3383 (31) RH WINDOW WASHER MOTOR 149-P94 165-P295 155-P26 156-P88 PU-14 YL-18 RD-14 YL-18 U741-P98 U740-P202 U741-P380 OR-18 BU-18 OR-18 617-P51 BR-14 617-P520 BR-14 617-P432 BR-16 668-P534 668-P722 668-P723 BU-18 BU-18 BU-18 605-P223 606-P224 YL-16 GY-16 C979-P195 A755-P193 OR-18 PK-18 1 2 3 4 5 6 7 8 9 10 11 12 J2 THROTTLE RESISTOR (N/O) THROTTLE RESISTOR (N/C) DIFF LOCK SWITCH (N/O) MEDIUM 592-P596 210-P630 A524-P509 BU-16 BK-16 BR-18 200-P247 200-P756 200-P635 BK-14 BK-14 BK-14 PW-C1 3612945 A756-P214 A757-P248 BU-18 GY-18 N952-P99 BU-18 N931-P352 GY-18 N952-P505 BU-18 200-P240 BK-16 CONN 14 PA-C3 7T5957 171-P448 172-P453 170-P114 RD-14 RD-14 RD-18 122-P133 142-P136 120-P130 BU-14 BU-18 YL-14 G20 G19 G18 G17 G16 G15 G14 G13 G12 G11 G10 G9 A20 A19 A18 A17 A16 A15 A14 A13 A12 A11 A10 A9 A8 A7 A6 A5 A4 A3 A2 G1 A1 15A 15A 10A F20 F19 F18 F17 F16 F15 F14 F13 F12 F11 F10 F9 F8 F7 F6 F5 F4 F3 F2 F1 - - F40 F39 F38 F37 F36 F35 F34 F33 F32 F31 F30 F29 F28 F27 F26 F25 F24 F23 F22 F21 15A 7.5A 10A - 15A - 15A 10A 10A 15A 10A 15A 15A 7.5A - - - - 123-P151 160-P458 131-P417 PU-16 BR-18 WH-14 U747-P65 U748-P66 U743-P73 OR-18 GY-18 GY-18 U741-P201 OR-18 617-P421 617-P420 BR-14 BR-16 668-P559 BU-18 668-P754 BU-18 618-P433 799-P496 YL-16 WH-18 CONN 26 CONNECTS TO U-C4 VOL 4 LOC C-8 R908-P353 YL-18 LOW 200-P159 200-P710 200-P569 BK-14 BK-14 BK-14 (17) ROOF GROUND 1 CONN 11 1 2 3 4 5 6 7 115-PW410 112-PW154 RD-4 PU-4 C978-P192 E748-P504 BK-18 A758-P204 BR-18 BR-18 P967-P180 R732-P160 PU-18 BR-18 N952-P542 BU-18 T971-PA9 200-PA10 OR-16 BK-16 MOTOR 1 2 223-3383 (28) LH WINDOW WASHER MOTOR H6 200-P166 179-P107 176-P112 200-P131 BK-18 RD-14 RD-14 BK-18 116-P148 124-P147 130-P146 141-P149 149-P94 BR-18 GN-14 GN-18 PK-16 PU-14 10A 10A 10A 15A - - 15A 10A - - - - - - 25A 106-P164 169-P168 119-P162 PK-18 PK-14 WH-14 U750-P63 U749-P64 PK-18 BR-18 618-P423 618-P435 YL-14 618-P518 YL-14 YL-14 BU-18 668-P372 668-P655 668-P527 668-P753 BU-18 BU-18 BU-18 611-P336 X754-P333 619-P430 A202-P567 PU-14 BK-18 GN-18 GN-14 200-P501 200-P711 BK-14 BK-14 CONNECTS TO FA-C1 VOL 3 LOC B-14 P880-P443 P878-P498 G946-P191 L914-P89 GY-18 GN-18 OR-18 BU-18 T998-P185 R800-P220 U712-P414 U711-P707 GY-18 BR-18 OR-18 YL-18 200-P574 BK-16 200-P576 BK-16 PA-C2 7T5957 200-P260 200-P328 200-P311 BK-18 BK-18 BK-18 144-P173 165-P295 156-P88 GN-14 YL-18 YL-18 U751-P262 U752-P263 U760-P69 U761-P70 WH-18 PU-18 PK-18 PU-18 618-P365 YL-14 618-P433 YL-16 685-P441 685-P381 BR-14 BR-14 685-P375 BR-14 X755-P334 925-P23 YL-18 WH-18 200-P564 200-P425 200-P393 BK-14 BK-14 BK-14 U725-P297 U726-P294 GN-18 GY-18 U753-P320 U739-P172 U741-P380 U740-P385 BR-18 BR-18 OR-18 BU-18 200-P143 BK-14 507-PA11 200-PA12 BK-16 223-3383 WH-16 MOTOR 1 2 (29) REAR WASHER MOTOR 200-P418 200-P462 200-P468 200-P463 BK-18 BK-18 BK-18 BK-16 148-P500 147-P363 PU-18 WH-14 G8 G7 G6 G5 G4 G3 G2 135-P245 139-P360 118-P261 BU-14 OR-18 GY-14 U762-P71 BR-18 U762-P659 U762-P705 BR-18 BR-18 646-P140 OR-18 619-P430 GN-14 799-P496 727-P196 799-P494 GN-18 WH-18 WH-18 H764-P212 GY-18 P-C37 2234778 A B C D E F G H J P-C26 3595180 124-P399 519-P397 GN-18 PK-16 C542-P563 GN-18 U762-P705 U768-P369 X800-P374 BR-18 BU-18 OR-18 680-P286 645-P431 668-P142 200-P589 GN-14 PK-18 BU-18 BK-18 104-P406 104-P434 103-P405 RD-14 RD-14 RD-16 - U764-P74 U763-P77 U765-P81 U769-P473 U770-P474 GY-18 BU-18 OR-18 WH-18 WH-18 647-P141 646-P312 647-P450 GN-18 OR-18 GN-18 647-P125 646-P126 GN-18 OR-18 998-P189 998-P118 A202-P437 A202-P368 BR-18 BK-18 BK-18 BR-18 3313575 P-C50 695-P252 142-P265 696-P253 OR-18 BU-18 GN-18 1 2 3 4 5 6 7 8 9 10 LEFT OFF RIGHT P-C61 2234778 403-P402 H864-P219 850-P226 GN-18 GN-18 PU-18 E929-P27 GY-18 C979-P195 OR-18 C572-P282 YL-18 E489-P54 PK-18 Y797-P538 Y797-P535 YL-18 YL-18 Y779-P362 GN-18 Y797-P325 YL-18 308-P276 YL-18 P-C68 2458025 1 2 3 4 5 6 683-P322 682-P132 681-P593 A503-P174 PU-14 BU-14 PK-14 OR-14 108-P116 105-P124 106-P164 RD-16 RD-16 WH-14 - 112-PW154 PU-4 Y937-P730 Y779-P362 PU-18 GN-18 685-P441 BR-14 685-P381 BR-14 668-P559 BU-18 A210-P326 A202-P575 A202-P567 A210-P340 BK-18 BK-18 BK-18 BK-18 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 125-P313 668-P272 668-P343 125-P287 RD-18 BU-18 BU-18 RD-18 (56) TURN SIGNAL SWITCH 367-5212 C 1 2 3 4 5 6 7 8 9 10 E529-P181 YL-18 200-P752 200-P281 200-P525 BK-14 BK-12 BK-14 (18) ROOF GROUND 2 CONNECTS TO FA-C14 VOL 3 LOC B-14 CONN 10 843-P207 844-P210 849-P230 GN-18 YL-18 WH-18 F503-P376 OR-16 E974-P383 GN-18 F702-P188 GN-18 Y798-P547 Y798-P539 GN-18 GN-18 Y798-P545 GN-18 892-P278 893-P277 F711-P46 F712-P47 172-P453 BR-18 GN-18 YL-18 GN-18 RD-14 CONN 15 CONNECTS TO CK-C4 VOL 2 LOC H-16 C546-P318 A557-P301 A608-P302 GY-18 WH-14 WH-16 112-PW154 117-P122 113-P83 PU-4 RD-14 RD-16 (3) BUSSBAR B 330-3356 Y935-P736 Y938-P734 Y934-P726 Y933-P728 OR-18 YL-18 WH-18 YL-18 799-P161 WH-18 727-P196 GN-18 799-P494 WH-18 A296-P82 A296-P367 A210-P342 BK-18 BK-18 BK-18 U701-P4 U700-P3 U703-P2 U702-P1 GN-18 WH-18 YL-18 GY-18 C (44) A/C SWITCH 284-3662 567-P392 WH-18 A274-P467 BK-14 K L M N P 520-P110 G434-P102 N788-P236 M792-P285 BU-18 PK-18 BU-18 WH-18 F712-P306 GN-18 F711-P314 YL-18 F711-P521 YL-18 F712-P522 GN-18 E529-P299 F504-P292 K436-P366 E575-P341 YL-18 YL-14 GN-18 BU-18 117-P152 117-P549 117-P622 118-P261 119-P162 RD-14 RD-16 RD-16 GY-14 PK-14 Y936-P727 PK-18 998-P759 998-P25 BR-18 BR-18 998-P118 998-P189 799-P496 BR-18 BR-18 WH-18 C251-P371 C251-P390 C250-P293 C250-P284 A296-P551 BK-18 BK-18 BK-18 BK-18 BK-18 U750-P63 U749-P64 U747-P65 U748-P66 PK-18 BR-18 OR-18 GY-18 P-C34 1710596 108-P508 668-P227 668-P254 108-P526 RD-18 BU-18 BU-18 RD-18 A201-P323 BK-18 F775-P258 BU-18 F781-P675 BR-18 F783-P673 GN-18 F784-P676 YL-18 998-P759 172-P453 155-P26 156-P88 BR-18 RD-14 RD-14 YL-18 155-P26 RD-14 P-C72 1519277 123-P151 124-P510 131-P417 GN-14 BR-18 WH-14 7.5A 141-2760 RELAY 248-2841 FUSE BLOCK PART NUMBERS A202-P355 A202-P356 A202-P503 BK-18 BK-14 BK-18 F711-P479 F711-P483 F711-P704 YL-18 YL-18 YL-18 M720-P6 M722-P5 U751-P262 U752-P263 BU-18 OR-18 WH-18 PU-18 320-P465 200-P134 OR-18 BK-18 A B C BK-18 BR-18 YL-18 1 2 3 4 (48) HORN SWITCH 283-6947 P-C106 2698222 Y797-P538 Y798-P547 YL-18 GN-18 F843-P384 YL-18 F785-P671 WH-18 G434-P102 BU-18 F711-P315 F712-P47 F711-P46 GN-18 YL-18 YL-18 308-P100 156-P88 G434-P102 YL-18 YL-18 BU-18 1 2 3 4 CONN 16 CONNECTS TO CJ-C10 VOL 2 LOC E-16 135-P156 135-P155 135-P245 133-P205 BU-14 BU-14 BU-14 RD-14 10A 113-8490 15A 113-8491 20A 113-8492 A202-P206 BK-14 BK-16 A202-P274 F712-P480 G953-P31 G965-P361 F712-P484 F712-P703 GN-18 GN-18 GN-18 BU-18 R902-P60 R901-P61 R903-P62 GN-18 GY-18 OR-18 (37) ACCUGRADE SENSOR CAN RESISTOR A B C P-C87 2698222 L854-P746 L855-P747 YL-18 GN-18 (40) STEERING CAN RESISTOR 134-2540 A B C G755-P53 GY-18 G750-P177 BU-18 G763-P197 PU-18 G766-P198 GN-18 T971-P560 T972-P561 F712-P316 GN-18 OR-16 GN-16 P-C131 1743089 144-P173 139-P360 147-P347 GN-14 OR-18 PU-18 A202-P575 BK-18 L854-P748 L855-P749 YL-18 GN-18 PU-18 U705-P8 U704-P7 K788-P56 K789-P55 R900-P59 PU-18 PK-18 GY-18 YL-18 BU-18 C251-P390 F510-P626 BK-18 BR-18 P-C35 2234778 1 2 3 4 5 6 7 8 9 10 134-2540 P-C8 3313575 H728-P410 GN-18 H729-P411 WH-18 H730-P419 BR-18 G767-P127 WH-18 892-P187 893-P144 BR-18 GN-18 1 2 3 4 5 6 7 8 9 10 11 12 160-P458 160-P761 160-P762 156-P88 147-P348 PU-18 PU-16 PU-18 PU-16 YL-18 H9 H9 A202-P437 A202-P368 A202-P567 BK-18 BK-18 BK-18 T971-P560 T972-P561 T998-P412 T998-P408 N952-P542 OR-16 GN-16 BR-18 BR-18 BU-18 M906-P213 BU-18 131-P409 131-P487 F509-P627 BR-18 BR-18 PU-18 (46) RH ARMREST SWITCH P-C128 2458025 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 H764-P150 GY-18 H765-P377 WH-18 H745-P765 BR-18 H864-P219 GN-18 998-P759 172-P453 155-P26 156-P88 BR-18 RD-14 RD-14 YL-18 843-P207 844-P210 H864-P219 850-P226 849-P230 F711-P315 F712-P316 WH-18 GN-18 GN-18 PU-18 YL-18 YL-18 GN-18 CONN 17 CONNECTS TO CJ-C11 VOL 2 LOC E-16 170-P114 169-P168 165-P295 RD-18 PK-18 YL-18 SWITCHED FUSE BLOCK G20 FRONT/REAR WIPERS A20 REAR WORKLIGHTS G19 SIDE WIPERS A19 RH ARMREST ADJUST G18 FLASHER MODULE A18 HEATED MIRROR G17 A17 G16 WAVES A16 RH DOOR WIPER G15 HVAC A15 G14 SNOW WING FLOOD/BEACON A14 CAB FRONT FLOOD G13 DEFROST FAN A13 CENTERSHIFT/BLADE CUSHION G12 ENGINE COMPONENTS A12 ALL WHEEL DRIVE G11 A11 SEAT G10 A10 DIFF LOCK G9 ACCUGRADE A9 LH DOOR WIPER G8 SEATBELT BEACON A8 FRONT HEATED WINDOW G7 A7 LH ARMREST ADJUST G6 A6 G5 A5 G4 A4 G3 A3 G2 A2 G1 A1 A210-P342 A210-P340 A210-P326 BK-18 BK-18 BK-18 X800-P291 X800-P488 OR-18 OR-18 R800-P92 P967-P495 570-P572 H801-P594 OR-18 PU-18 BU-18 PU-18 C251-P371 125-P720 668-P722 668-P723 BU-18 BK-18 RD-18 BU-18 347-0799 CONNECTS TO WAVS SYSTEM VOL 2 LOC J-14 CONN 3 1 2 3 4 5 6 200-P317 130-P146 BK-18 GN-18 U712-P414 YL-18 J844-P415 GY-18 J766-P403 PU-18 K777-P506 GY-18 F712-P47 F711-P315 F712-P316 F711-P46 YL-18 GN-18 YL-18 GN-18 N788-P236 M792-P285 A201-P323 PK-18 BU-18 BK-18 180-P121 176-P112 200-P131 RD-14 RD-14 BK-18 H7 A210-P106 BK-14 A296-P82 BK-18 CONN 27 125-P721 RD-18 U711-P707 210-P57 165-P295 A296-P137 GY-18 BK-18 BK-14 YL-18 L731-P29 BR-18 N787-P232 BU-18 M700-P300 BR-18 M792-P285 BU-18 T971-P560 T972-P561 OR-16 GN-16 200-P311 614-P310 618-P435 515-P444 200-P463 BK-18 PU-18 YL-14 GY-12 BK-16 104-P153 103-P725 106-P108 RD-16 RD-16 WH-16 A296-P367 BK-18 A296-P551 BK-18 439-P439 605-P223 606-P224 539-P271 540-P270 YL-16 GY-16 BU-18 YL-18 WH-18 K927-P9 K952-P10 H862-P472 BU-18 BR-18 GY-18 CONNECTS TO U-C1 VOL 4 LOC D-8 F510-P626 BR-18 P-C51 2715590 MOTOR 1 2 (25) RH UP-DOWN ARMREST MOTOR SYMBOL DESCRIPTION P-C120 3313582 P880-P443 P878-P498 E748-P504 GY-18 GN-18 BK-18 N931-P352 GY-18 P967-P180 PU-18 N952-P99 BU-18 N788-P236 PK-18 682-P132 684-P129 A501-P171 BU-14 OR-18 BU-16 169-P28 125-P552 127-P424 PK-18 RD-18 RD-18 C250-P238 C251-P303 BK-16 BK-16 C251-P371 C251-P390 C250-P293 C250-P284 BK-18 BK-18 BK-18 BK-18 696-P253 695-P252 GN-18 OR-18 H861-P279 H863-P183 PU-18 BU-18 F509-P627 PU-18 344-9581 CIRCUIT CONNECTED CIRCUIT NOT CONNECTED RH JOYSTICK LAMP 250-8335 RD BK 1 2 614-P715 200-P716 PU-18 BK-18 H728-P410 H729-P411 H730-P419 A513-P400 GN-18 WH-18 BR-18 RD-16 R908-P353 YL-18 R800-P220 OR-18 R732-P160 BR-18 210-P489 201-P319 BK-16 516-P507 517-P475 GN-14 BU-14 BK-18 516-P507 517-P475 210-P489 201-P319 BK-16 GN-14 BU-14 BK-18 201-P319 BK-16 200-P440 200-P266 BK-14 BK-14 (14) CAB GROUND 1 C546-P318 A514-P157 C542-P493 A503-P174 YL-18 GN-16 PK-14 WH-16 403-P288 308-P338 403-P349 403-P402 GN-18 YL-16 GN-18 GN-18 C542-P158 C542-P563 C542-P493 GN-18 GN-18 GN-16 H414-P169 YL-18 169-P259 439-P439 PK-18 YL-18 WIRE GROUP COLOR DESCRIPTIONS ELECTRICAL CONNECTION TO MACHINE STRUCTURE P-C121 3313582 U762-P705 L914-P89 709-P490 A507-P237 OR-18 YL-16 BR-18 BU-18 U711-P707 GY-18 U727-P389 YL-18 T998-P185 BR-18 U712-P414 YL-18 519-P397 520-P110 C568-P476 A524-P509 BR-18 PK-16 WH-14 WH-18 519-P397 520-P110 C568-P476 A524-P509 PK-16 WH-18 BR-18 WH-14 F501-P22 F501-P321 E575-P341 BU-18 BU-16 BU-16 592-P595 592-P596 614-P222 592-P512 BU-18 BU-16 PU-18 BU-14 F501-P22 BU-16 539-P271 439-P439 BU-18 YL-18 F775-P258 322-P308 BU-18 GY-16 GROUND CIRCUIT WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF B INTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT LH JOYSTICK LAMP 250-8335 RD BK 1 2 614-P714 200-P717 PU-18 BK-18 C542-P563 141-P149 A504-P234 GN-18 GN-16 PK-16 U739-P172 BR-18 U734-P382 GN-18 U740-P385 BU-18 U735-P388 GY-18 C251-P303 200-P712 200-P134 200-P267 BK-12 BK-18 BK-18 BK-16 (15) CAB GROUND 2 H7 F504-P292 F503-P550 K436-P366 YL-14 OR-14 GN-18 H7 617-P421 618-P365 617-P51 614-P543 BR-14 YL-14 BR-14 PU-18 F501-P321 F503-P550 F501-P764 BU-16 OR-14 BU-16 605-P223 606-P224 695-P252 696-P253 540-P270 YL-16 GY-16 OR-18 GN-18 WH-18 U769-P473 U770-P474 OR-18 WH-18 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON VOLTAGE CONVERTER OUTPUT CIRCUIT B CIRCUIT GROUPING DESIGNATION H# CONNECTOR P-C124 3313593 169-P28 570-P572 H745-P765 A514-P763 PK-18 BU-18 YL-18 BR-18 U762-P705 BR-18 U753-P320 BR-18 U768-P369 BU-18 U741-P380 OR-18 518-P273 538-P275 307-P359 OR-18 BR-18 OR-16 H5 H5 646-P140 618-P423 647-P141 OR-18 YL-14 GN-18 F503-P376 F503-P461 OR-16 OR-14 F711-P479 YL-18 H414-P169 YL-18 U736-P211 H765-P335 H803-P672 YL-18 BU-18 WH-18 STARTING CIRCUIT AWD CIRCUIT ATCH WIRE, CABLE, COMPONENT A B C D E F G H J K L M N 308-P597 A295-P499 617-P421 200-P635 YL-18 BK-18 BR-14 BK-14 116-P148 U725-P297 U726-P294 A202-P355 BK-18 BR-18 GN-18 GY-18 X754-P333 GN-18 X755-P334 WH-18 X800-P374 OR-18 570-P572 582-P48 581-P52 BU-18 PK-18 GY-18 200-P87 BK-16 CM-C7 2470281 668-P559 998-P25 799-P161 685-P381 BU-18 BR-18 BR-14 WH-18 F712-P480 GN-18 F711-P483 YL-18 F712-P484 GN-18 F711-P704 YL-18 307-P359 OR-16 998-P118 M975-P190 X725-P128 685-P375 BR-18 BU-18 GY-18 BR-14 HEATER AND AIR CONDITIONER CIRCUIT TURN SIGNAL / WIPER WASHER CIRCUIT BLADE, SPADE, RING OR SCREW TERMINAL SPLICE 403-P288 200-P636 170-P114 GN-18 BK-14 RD-18 CONNECTS TO PE-C22 VOL 2 LOC G-1 CONN 9 106-P108 603-P243 684-P289 609-P184 PK-18 OR-18 YL-18 WH-16 Y779-P362 GN-18 Y797-P538 YL-18 Y797-P535 YL-18 Y798-P539 GN-18 A755-P193 C979-P195 604-P436 925-P23 A274-P467 YL-18 PK-18 OR-18 BK-14 OR-18 C250-P238 A210-P106 BK-14 BK-16 (16) CAB GROUND 3 210-CM13 592-CM11 BK-18 BU-18 A B C D E F SIGNAL Vs (GROUND) Vs (+12V) (1) WATER VALVE ACTUATOR 998-P759 A202-P355 A202-P356 A202-P503 BK-18 BR-18 BK-14 BK-18 G953-P31 BU-18 G965-P361 PU-18 F712-P703 GN-18 518-P273 538-P275 570-P572 582-P48 581-P52 OR-18 BR-18 BU-18 PK-18 GY-18 E804-P119 E803-P120 P988-P674 H807-P677 BU-18 YL-18 OR-18 YL-18 CAT DATA LINK CAN DATA LINK CONN 2 603-P243 892-P514 893-P513 200-P631 PK-18 BR-18 GN-18 BK-14 F503-P376 C572-P282 OR-16 YL-18 Y798-P547 GN-18 F702-P188 E489-P54 E974-P383 GN-18 GN-18 PK-18 A524-CM12 BR-18 245-1596 HARNESS TABLE A296-P367 A296-P551 A296-P82 BK-18 BK-18 BK-18 N952-P542 BU-18 L854-P748 YL-18 L855-P749 GN-18 T971-P560 OR-16 T972-P561 GN-16 604-P436 925-P23 YL-18 OR-18 H804-P471 G953-P31 G965-P361 GN-18 BU-18 PU-18 STEERING CONTROL CIRCUIT STEERING CAN DATA LINK ACCUGRADE SENSOR CAN DATA LINK ABBREV COLOR CONNECTS TO J-C25 VOL 2 LOC H-11 O F712-P648 C542-P158 680-P286 GN-18 GN-18 GN-14 647-P141 646-P140 229-P225 A608-P302 GN-18 OR-18 GY-18 BK-14 F781-P675 F783-P673 F784-P676 F775-P258 BU-18 BR-18 GN-18 YL-18 H3 200-P712 BK-12 515-P444 GY-12 P-C138 1779646 CM-C3 1779641 1 2 515-CM4 200-CM1 GY-12 BK-12 200-CM1 210-CM13 BK-12 BK-18 519-CM2 520-CM9 PK-16 WH-16 ID PART# CHG LOC DESCRIPTION C542-P158 C542-P563 F503-P376 F503-P461 GN-18 GN-18 OR-16 OR-14 T998-P185 BR-18 T998-P412 T998-P408 BR-18 BR-18 E489-P54 A755-P193 C979-P195 A274-P467 PK-18 OR-18 BK-14 PK-18 U742-P154 WH-18 OTHER COLOR DESCRIPTIONS RD WH OR YL PK BK GY PU BU RED WHITE ORANGE YELLOW PINK BLACK GRAY PURPLE BLUE P R S T U V W X Q F711-P646 609-P184 681-P593 YL-18 YL-18 OR-14 C978-P192 G946-P191 A756-P214 A757-P248 BU-18 GY-18 BR-18 OR-18 F785-P671 G755-P53 G750-P177 F843-P384 GY-18 BU-18 YL-18 WH-18 200-P87 200-P134 200-P266 200-P267 BK-16 BK-18 BK-14 BK-18 CONN 18 GY-12 515-CM7 515-CM5 GY-12 °T (61) THERMOSTAT 3E-5464 CG 200-5728 02 ENTERTAINMENT RADIO I-15 T998-P185 T971-P560 T972-P561 N952-P542 BR-18 OR-16 GN-16 BU-18 X800-P374 OR-18 X800-P488 X800-P291 OR-18 OR-18 H3 F781-P675 F783-P673 F784-P676 F775-P258 E974-P383 F702-P188 BU-18 GN-18 GN-18 BR-18 GN-18 YL-18 P-C2 HIGHWAYS 682-P132 200-P525 K436-P366 A557-P301 BU-14 BK-14 GN-18 WH-14 538-P275 A758-P204 BR-18 BR-18 J844-P415 J766-P403 G763-P197 PU-18 GY-18 PU-18 200-P440 BK-14 516-P507 GN-14 520-P110 WH-18 CM-C1 3E3388 3313580 P-C16 1 2 3 4 5 6 7 8 516-CM14 520-CM9 GN-14 WH-16 515-CM4 GY-12 516-CM14 517-CM8 GN-14 BU-14 515-CM5 GY-12 MOTOR (23) BLOWER MOTOR CM P 276-9015 04 HVAC 438-3115 00 MAIN CAB A-10 F-13 X800-P374 OR-18 F785-P671 WH-18 A296-P82 M700-P300 BK-18 BR-18 2733288 1 2 BK-18 BK-18 345-8057 (42) OPERATOR PRESENT SENSOR 618-P423 YL-14 F775-P258 518-P273 103-P725 BU-18 OR-18 RD-16 U727-P389 M700-P300 R908-P353 L731-P29 YL-18 BR-18 YL-18 BR-18 H4 515-P444 200-P712 BK-12 GY-12 517-P475 BU-14 592-P511 BU-18 A524-P509 BR-18 517-CM8 592-CM11 A524-CM12 BU-14 BU-18 BR-18 519-CM2 520-CM9 592-CM11 PK-16 WH-16 BU-18 200-CM1 BK-12 324-6125 PA 331-6861 02 WASHER MOTOR D-10 G755-P53 G750-P177 F843-P384 G763-P197 GY-18 BU-18 YL-18 PU-18 P-C6 1 2 P-C14 1519278 A503-P174 200-P229 PK-14 BK-14 614-P543 201-P319 308-P407 F711-P521 F712-P522 113-P83 PU-18 BK-16 YL-18 YL-18 GN-18 RD-16 U735-P388 X754-P333 X755-P334 U734-P382 GN-18 WH-18 GN-18 GY-18 A210-P106 592-P511 C250-P238 C251-P303 BK-16 BK-16 BK-14 BU-18 C568-P476 WH-14 210-P489 BK-18 519-P397 PK-16 CONN 19 C568-CM10 519-CM2 210-CM13 WH-14 PK-16 BK-18 517-YA1 BU-14 C568-CM10 A524-CM12 BR-18 WH-14 517-CM8 BU-14 °T PW 374-5512 00 UNWITCHED/SWITCHED POWER C-6 M700-P300 L731-P29 J844-P415 J766-P403 BR-18 GY-18 PU-18 BR-18 U730-P167 U729-P208 A295-P139 BK-18 BR-18 PU-18 2698222 A C B BK-18 GN-18 WH-18 1 2 3 4 (52) SEAT BELT SWITCH 381-4538 (62) FRONT HEATED WINDOW 325-9402 180-P200 G766-P198 RD-18 GN-18 (55) THERMAL SWITCH 2 133-9012 WC 365-5588 00 RH DOOR I-15 R908-P353 U734-P382 U735-P388 U727-P389 YL-18 GN-18 GY-18 YL-18 A 645-P431 G767-P127 125-P552 PK-18 RD-18 WH-18 515-CM7 GY-12 516-CM14 GN-14 C568-CM10 WH-14 515-CM6 GY-12 X754-P333 X755-P334 GN-18 WH-18 A 200-P445 104-P153 668-P115 BK-14 RD-16 BU-18 (54) THERMAL SWITCH 1 133-9012 °T (38) BLOWER MOTOR RESISTOR 125-9740 THIS SCHEMATIC IS FOR THE 12M3, 140M3, AND 160M3 MOTOR GRADER ELECTRICAL SYSTEM HVAC 200-P87 200-P134 200-P266 BK-16 BK-18 BK-14 VOLUME 1 of 4:

MAIN CAB CALLOUTS +24V UNSWITCHED 1 P-C30 2458025 308-P298 200-P393 179-P107 YL-18 BK-14 RD-14 H4 H4 200-P267 515-P444 200-P440 BK-18 GY-12 BK-14 MEDIA NUMBER: UENR3921-01 Callout Number (Machine Location from Component Locations Table) (52) VALVE GP - CONTROL 138-1234 Component Name (6) ENTERTAINMENT RADIO CONVERTER 340-7161 592-P512 210-P182 A513-P401 RD-14 BU-14 BK-14 592-P511 C250-P238 C251-P303 A210-P106 BU-18 BK-14 BK-16 BK-16 Components are shown installed on a fully operable machine with the key and engine off, transmission shifter in neutral and with parking brake set. Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.

SCHEMATIC PART NUMBER: 417-8801, CHANGE: 00, VERSION: - Part Number H3 H3 16 1 Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic. 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 2 3 4 5 6 7 8 15A(BRKR) 20A(BRKR) 280-2709 280-2710 BR GN BROWN GREEN WJ 357-0728 01 J-15 DOOR WITH WIPER MOTOR +24V SWITCHED GROUND +12V UNSWITCHED +12V SWITCHED GROUND 2 3 4 5 6 15 14 13 12 11 10 9 8 7 6 5 4 3 2

Стр. 2

UENR3921-01 April 2014 UENR3921-01 VOL 2 of 4 42 Page, (Dimensions: 56 inches x 35 inches) 12M3, 140M3, and 160M3 Electrical System Motor Grader 12M3: N9B1-UP N9F1-UP N9P1-UP N9R1-UP 140M3: N9D1-UP N9G1-UP N9J1-UP N9M1-UP 160M3: N9E1-UP N9K1-UP N9L1-UP N9T1-UP Volume 2 of 4: Additional Cab Components © 2014 Caterpillar, All Rights Reserved Printed in U.S.A. Harness And Wire Electrical Schematic Symbols Symbols Pressure Symbol T Temperature Symbol Level Symbol Flow Symbol Circuit Breaker Symbol Symbols and Definitions Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it. Switch (Normally Open):

A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it. Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component. Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine. Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. Reed Switch: A switch whose contacts are controlled by a magnet.

A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch. Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure. T Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay. Solenoid: A solenoid is an electrical component that is activated by electricity.

It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work. Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches. Harness and Wire Symbols Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes (see sample).

Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness (C1, C2, C3, ...). Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...) AG-C4 111-7898 L-C12 3E-5179 L-C12 3E-5179 Part Number: for Connector Receptacle Part Number: for Connector Plug Plug Pin or Socket Number Receptacle 5A 1 2 Deutsch connector: Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins. Fuse (5 Amps) 9X-1123 Component Part Number 1 Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets. Harness identification code:

This example indicates wire group 325, wire 135 in harness "AG". 325-AG135 PK-14 2 Wire Color Wire Gauge The connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart.

75 76 74 CONN 17 CONN 16 CONN 15 90 113 VIEW OF AREA “A” A CONN 36 CONN 35 77 AWD AND IMPLEMENT 3 ECM CONN 37 CONN 2 CONN 39 83 71 88 ROOF 101 99 108 100 114 107 106 105 96 102 109 115 91 103 92 86 104 93 111 112 CONN 9 72 80 THE CONNECTOR FOR AUX LEVER #6 IS 79 LOCATED DIRECTLY INSIDE (TOWARD OPERATOR) OF THE CONNECTOR FOR AUX LEVER #7 (80) SWITCH PANEL CONN 45 97 94 73 95 110 98 CONN 38 CONN 25 CONN 40 CONN 24 CONN 23 89 CONN 44 CONN 41 NOT SHOWN 81 CONN 43 CONN 42 CONN 21 87 TOP OF CAB ROOF ACCUGRADE 1 2 85 84 CONN 20 AUXILIARY WIPERS CONN 3 82 WAVS SYSTEM 78 70 CONN 28 MSS SYSTEM Component Location Component Schematic Location Machine Location Coil - MSS Exciter J-15 70 Control - Product Link (300) J-7 71 Diode - Rear Cab Interlock E-1 72 Display - CB460 E-10 73 ECM - AWD F-14 74 ECM - Implement 3 J-14 75 Ground - Cab 1 C-15 76 Ground - Cab 2 H-15 77 Keyreader - MSS J-15 78 Lever - Auxiliary #6 F-1 79 Lever - Auxiliary #7 F-1 80 Module - Grade Control Power Supply C-9 81 Module - WAVS Display J-12 82 Motor - Air Cleaner F-9 83 Motor - Side Window Wiper (LH) B-13 84 Motor - Side Window Wiper (RH) A-13 85 Port - 12V Auxiliary E-1 86 Radio - CR924 B-10 87 Radio - Product Link Communications (121SR) I-10 88 Resistor - CAN (GPS) E-8 89 Sensor - AWD Position Sensor C-15 90 Switch - Auto Articulation D-4 91 Switch - Auto Differential Lock F-4 92 Switch - Autoshift D-4 93 Switch - Blade Control (LH) B-11 94 Switch - Blade Control (RH) B-11 95 Switch - Blade Cushion H-4 96 Switch - Blade Offset (LH) C-11 97 Switch - Blade Offset (RH) C-11 98 Switch - Centershift Pin J-4 99 Switch - Defrost Fan Blower Speed I-4 100 Switch - DPF Regeneration I-4 101 Switch - Floodlight F-4 102 Switch - Fog Light (Rear) G-4 103 Switch - Hazard E-4 104 Switch - Head/Tail Lights H-4 105 Switch - Headlight Dimmer I-4 106 Switch - Heated Glass J-4 107 Switch - Heated Mirrors H-4 108 Switch - Hydraulic Lockout E-4 109 Switch - Sideshift Auto/Manual C-11 110 Switch - Throttle Lock E-4 111 Switch - Throttle Lock Set D-4 112 Switch - Variable Shift Control (AWD) B-15 113 Switch - Warning Beacon G-4 114 Switch - Work Light F-4 115 Connector Location Connector Number Schematic Location CONN 2 H-11 CONN 3 J-14 CONN 9 G-1 CONN 15 H-16 CONN 16 E-16 CONN 17 E-16 CONN 20 B-16 CONN 21 D-8 CONN 23 C-12 CONN 24 C-12 CONN 25 B-12 CONN 28 J-16 CONN 35 H-16 CONN 36 D-16 CONN 37 I-10 CONN 38 D-10 CONN 39 H-9 CONN 40 D-8 CONN 41 C-8 CONN 42 C-8 CONN 43 B-8 CONN 44 B-8 CONN 45 C-5

Стр. 3

1 16 CONN 28 CONN 3 CT-C4 3E3382 308-CT1 200-CT2 F711-CT3 F712-CT4 YL-18 BK-18 YL-18 GN-18 CT-C1 1552264 1 2 3 4 5 6 7 8 CAN POS GROUND KEY SWITCH ON POS SPLY GROUND TRIGGER #1 TRIGGER #2 TRIGGER #3 PRODUCT LINK OFF - PULL 1 2 3 4 5 6 7 8 9 10 PE-C10 2234778 YL-18 BK-18 YL-18 GN-18 CONNECTS TO P-C80 VOL 1 LOC E-1 T901-CT8 T902-CT9 1 2 3 4 5 6 308-CT1 200-CT2 F711-CT3 F712-CT4 CAN NEG EXCITER COIL SIG (78) MSS KEYREADER 310-5289 CONNECTS TO P-C128 VOL 1 LOC B-15 WA-C3 1607690 (99) CENTERSHIFT PIN SWITCH 169-PE44 F775-PE141 PK-18 BU-18 J YL-18 PK-18 EXCITER COIL RTDG 1 2 3 4 280-4244 125-PE26 668-PE99 RD-18 BU-18 J UENR3921 VOL 2 of 4 42 Page, (Dimensions:

56 inches x 35 inches) T901-CT8 T902-CT9 YL-18 PK-18 VIDEO SIG VIDEO GND 12 VDC POS FEED GND COAX CORE COAX SAFEGUARD RED WHITE CAMERA CABLE AS 251-8248 COAX CORE COAX SAFEGUARD RED WHITE CAMERA CABLE AS 1 251-8248 VIDEO SIG VIDEO GND 12 VDC POS FEED GND 893-WA4 892-WA5 GN-18 BR-18 T901-CT8 T902-CT9 YL-18 PK-18 T901-CT8 T902-CT9 YL-18 PK-18 CT-C3 1552269 1 2 BK-18 BK-18 (70) MSS EXCITER COIL 205-8257 (82) WAVS DISPLAY MODULE 344-2733 PE-C3 2234778 MSS ATCH WAVS SYSTEM N957-WA19 PK-18 OFF - ON 9 10 H745-PE186 C572-PE133 YL-18 BR-18 (107) HEATED GLASS SWITCH 236-4630 125-PE28 200-PE58 BK-18 RD-18 N960-WA18 OR-18 F503-PE138 668-PE108 OR-16 BU-18 308-CK1 YL-18 CK-C1 1471445 365-6765 J1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 KEY SWITCH - RUN (75) IMPLEMENT ECM 3 BATTERY POS 1 2 3 4 5 6 7 8 9 10 11 12 WA-C2 1552252 170-WA2 A295-WA15 RD-18 BK-18 N970-AW20 YL-18 (71) PRODUCT LINK CONTROL (300) 386-3993 PE-C17 2234778 KEY SWITCH RUN BATTERY NEG R-TERM RS-232 TXD 403-WA13 308-WA11 N957-WA19 GN-18 YL-18 PK-18 170-WA1 170-WA2 RD-18 RD-18 170-WA3 RD-18 N973-WA21 BR-18 OFF - ON 1 2 3 4 5 6 7 8 9 10 P878-PE40 E748-PE6 P880-PE39 GN-18 BK-18 GY-18 (88) 121SR PRODUCT LINK COMMUNICATION RADIO 336-3545 RS-232 RXD RS-232 GND RS-232 DTR RS-232 DCD N973-WA21 N970-WA20 N979-WA17 N960-WA18 BR-18 YL-18 GN-18 OR-18 200-WA22 BK-14 F712-WA7 N979-WA17 GN-18 (101) DPF REGENERATION SWITCH 327-6999 125-PE145 RD-18 893-CK2 GN-18 CAT DATA LINK POS 403-WA10 403-WA13 308-WA8 308-WA18 GN-18 GN-18 YL-18 YL-18 403-WA14 308-WA12 GN-18 YL-18 GN-16 668-PE146 125-PE13 668-PE43 BU-18 RD-18 BU-18 A297-CK3 BK-14 NEG UNSWITCHED BATTERY 893-WA4 892-WA5 GN-18 BR-18 PE-C2 2234778 892-CK4 BR-18 CAT DATA LINK NEG 170-J11 A295-J24 RD-18 BK-18 WA-C1 3E5179 J-C22 1552252 1 2 3 4 5 6 7 8 9 10 11 12 170-WA1 A295-WA9 RD-18 BK-18 A295-WA9 A295-WA15 BK-18 BK-18 A295-WA16 BK-18 FAST OFF SLOW 1 2 3 4 5 6 7 8 9 10 141-PE150 A504-PE124 PK-16 GN-16 I A297-CK5 BK-14 NEG UNSWITCHED BATTERY 893-J29 892-J30 403-J28 308-J27 GN-18 BR-18 GN-18 YL-18 893-WA4 892-WA5 F711-WA6 F712-WA7 403-WA10 308-WA8 GN-18 BR-18 YL-16 GN-16 GN-18 YL-18 F711-WA6 F712-WA7 N957-WA19 N960-WA18 YL-16 GN-16 PK-18 OR-18 (100) DEFROST FAN BLOWER SPEED SWITCH 367-5211 A507-PE125 141-PE41 YL-16 PK-16 I A297-CK6 BK-16 ECM LOCATION 0 (GND) F712-J31 F711-J32 GN-18 YL-18 N973-WA21 N970-WA20 N979-WA17 BR-18 YL-18 GN-18 F711-WA6 170-WA3 YL-16 RD-18 125-PE37 668-PE91 668-PE111 125-PE38 RD-18 BU-18 BU-18 RD-18 106-PE3 WH-18 104-PE2 103-PE1 RD-18 RD-16 172-CK8 A297-CK7 BK-16 RD-14 ECM LOCATION 2 (GND) POS UNSWITCHED BATTERY 200-J4 BK-14 CONN 37 200-WA22 BK-14 403-WA14 GN-18 106-PE4 WH-18 106-PE7 WH-18 A297-CK9 BK-16 ECM LOCATION ENABLE (GND) OFF - ON 9 10 PE-C5 2234778 A608-PE128 645-PE85 GY-18 PK-18 116-PE10 116-PE11 BR-18 BR-18 116-PE9 BR-18 172-CK10 172-CK11 RD-14 RD-14 POS UNSWITCHED BATTERY POS UNSWITCHED BATTERY (106) HEADLIGHT DIMMER SWITCH 284-3649 125-PE18 125-PE23 125-PE34 125-PE27 RD-18 RD-18 RD-18 RD-18 125-PE157 RD-18 A295-WA16 BK-18 668-PE94 125-PE16 668-PE52 BU-18 RD-18 BU-18 125-PE116 125-PE36 125-PE33 125-PE35 125-PE32 RD-18 RD-18 RD-18 RD-18 RD-18 308-WA12 YL-18 125-PE55 RD-18 125-PE17 RD-18 172-CK27 172-CK32 RD-14 RD-14 172-CK10 172-CK11 RD-14 RD-14 172-CK12 172-CK13 U713-CK14 E789-CK16 U714-CK15 RD-14 RD-14 PK-18 PU-18 PU-18 POS UNSWITCHED BATTERY POS UNSWITCHED BATTERY AUX VALVE #3 PORTB SOL AUX VALVE #3 PORTA SOL PULSE WD MOD DR RETURN 1-4 AUX VALVE #4 PORTB SOL AUX VALVE #4 PORTA SOL 200-WA22 BK-14 CASE GROUND WIRE FOR REMOTE GROUNDING OFF - ON 1 2 3 4 5 6 7 8 9 10 PE-C13 2234778 125-PE30 125-PE31 125-PE19 125-PE69 RD-18 RD-18 RD-18 RD-18 125-PE157 RD-18 172-CK32 RD-14 172-CK8 172-CK12 172-CK13 RD-14 RD-14 RD-14 U715-CK17 U716-CK18 BR-18 BU-18 (96) BLADE CUSHION SWITCH 169-PE45 570-PE71 PK-18 BU-18 125-PE22 125-PE25 125-PE24 RD-18 RD-18 RD-18 125-PE156 RD-18 308-CK1 893-CK2 892-CK4 YL-18 GN-18 BR-18 A297-CK19 A297-CK20 BK-14 BK-14 NEG UNSWITCHED BATTERY NEG UNSWITCHED BATTERY AUX VALVE #5 PORTB SOL AUX VALVE #5 PORTA SOL PULSE WD MOD DR RETURN 5-8 AUX VALVE #6 PORTB SOL AUX VALVE #6 PORTA SOL JA-C2 1552269 249-5487 125-PE15 200-PE50 RD-18 BK-18 125-PE16 125-PE14 125-PE15 RD-18 RD-18 RD-18 1 2 3 4 5 6 CK-C4 3E3382 308-CK1 893-CK2 892-CK4 172-CK27 F711-CK23 F712-CK35 YL-18 GN-18 BR-18 RD-14 YL-16 GN-16 A297-CK34 BK-14 A297-CK3 A297-CK6 A297-CK26 BK-14 BK-14 BK-16 U717-CK21 U718-CK22 E790-CK36 OR-18 WH-18 GN-18 PK-18 J-C32 1552269 JA-C1 3E3364 200-JA6 617-JA2 BR-14 BK-14 1 2 LH LICENSE PLATE LAMP 259-0134 668-PE110 570-PE72 BU-18 BU-18 125-PE20 125-PE21 125-PE28 125-PE38 RD-18 RD-18 RD-18 RD-18 125-PE29 125-PE156 125-PE12 RD-18 RD-18 RD-18 H CONNECTS TO P-C68 VOL 1 LOC C-10 CONN 15 A297-CK29 BK-14 A297-CK5 A297-CK7 A297-CK19 BK-14 BK-16 BK-14 U719-CK24 U720-CK25 GY-18 A B C D E F G H J K L M N J-C25 3112812 200-J46 617-J17 BR-14 BK-14 617-J53 200-J51 BR-14 BK-14 CONN 39 1 2 617-JA1 200-JA4 BR-14 BK-14 617-JA1 200-JA4 BR-14 BK-14 617-JA2 617-JA3 200-JA6 200-JA5 BR-14 BR-14 BK-14 BK-14 JA-C3 1552269 RH LICENSE PLATE LAMP 259-0134 PE-C14 2234778 125-PE67 125-PE37 125-PE145 RD-18 RD-18 RD-18 125-PE139 125-PE12 RD-18 RD-18 PE-C22 1607689 H A297-CK9 A297-CK20 BK-16 BK-14 200-J26 308-J27 A295-J24 BK-14 YL-18 BK-18 J-C2 1552269 200-JA5 617-JA3 BR-14 BK-14 1 2 OFF - ON 1 2 3 4 5 6 7 8 9 10 H745-PE185 A514-PE127 YL-18 BR-18 125-PE26 125-PE13 125-PE55 RD-18 RD-18 RD-18 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 A B C D E F G H J CK-C3 3595180 U718-CK22 U717-CK21 U714-CK15 U713-CK14 U715-CK17 U716-CK18 U719-CK24 U720-CK25 E790-CK36 E789-CK16 WH-18 OR-18 PU-18 PK-18 BR-18 BU-18 GN-18 GY-18 PK-18 PU-18 A297-CK28 A297-CK29 A297-CK34 BK-14 BK-14 BK-14 A297-CK26 BK-14 NEG UNSWITCHED BATTERY 200-J12 892-J30 893-J29 403-J28 170-J11 BK-14 BR-18 GN-18 GN-18 RD-18 K436-J42 200-J41 BK-18 GN-18 1 2 TO SEAT BELT BEACON (108) HEATED MIRRORS SWITCH 236-4630 125-PE14 RD-18 125-PE181 125-PE187 RD-18 RD-18 125-PE139 RD-18 687-PE175 BU-18 A297-CK28 BK-14 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 CONNECTS TO P-C124 VOL 1 LOC B-15 CONN 2 F712-J31 C542-J16 603-J13 GN-14 PK-14 GN-18 617-J52 BR-14 J-C19 1552269 1 2 LH FWD POSITION LAMP 212-3924 200-PE49 668-PE100 C542-PE132 BK-18 BU-18 GN-18 169-PE44 PK-18 141-PE41 165-PE70 PK-16 YL-18 A296-PE166 U711-PE170 U712-PE169 210-PE172 BK-18 GY-18 YL-18 BK-14 CONNECTS TO CL-C1 VOL 4 LOC E-3 CONN 35 (77) CAB GROUND 2 P Q O 680-J54 F711-J32 YL-18 GN-14 200-J8 BK-14 J-C17 1552269 PE-C1 2234778 169-PE45 PK-18 169-PE46 PK-18 P880-PE39 165-PE70 E748-PE6 GY-18 YL-18 BK-18 K L M N P E789-CK16 PU-18 R S T U V W X 682-J55 A557-J44 609-J40 681-J20 WH-14 YL-14 BU-14 OR-14 200-J12 BK-14 200-J7 200-J8 BK-14 BK-14 200-J5 C542-J14 BK-14 GN-14 1 2 LH HEATED MIRROR 259-4759 TAIL OFF HEAD/TAIL 1 2 3 4 5 6 7 8 9 10 104-PE2 645-PE86 RD-18 PK-18 200-PE59 180-PE159 BK-18 RD-18 180-PE47 200-PE155 180-PE160 RD-18 BK-18 RD-18 P878-PE40 H728-PE177 H730-PE179 H729-PE178 WH-18 A513-PE171 GN-18 RD-14 GN-18 U713-CK14 E790-CK36 F711-CK23 F712-CK35 GN-16 PK-18 PK-18 YL-16 K436-J42 618-J25 200-J4 YL-14 BK-14 GN-18 200-J57 BK-14 200-J45 200-J1 BK-14 BK-14 C542-J15 GN-14 J-C15 1552269 (105) HEAD/TAIL LIGHTS SWITCH 367-5209 614-PE80 614-PE79 125-PE24 125-PE25 PU-18 PU-18 RD-18 RD-18 200-PE51 200-PE135 BK-18 BK-18 200-PE155 BK-18 L914-PE68 U762-PE161 709-PE162 BU-18 BR-18 OR-18 BR-18 U714-CK15 U715-CK17 U716-CK18 U717-CK21 U718-CK22 U719-CK24 PU-18 BR-18 BU-18 OR-18 WH-18 GN-18 200-J2 200-J5 200-J35 BK-14 BK-14 BK-14 200-J6 BK-14 J-C13 1552269 1 2 RH HEATED MIRROR 259-4759 668-PE103 125-PE22 668-PE101 BU-18 RD-18 BU-18 200-PE57 200-PE49 BK-18 BK-18 200-PE165 BK-18 A514-PE127 C542-PE132 A504-PE124 141-PE41 A507-PE125 YL-18 GN-18 GN-16 PK-16 YL-16 U720-CK25 GY-18 200-J58 BK-14 200-J3 200-J6 200-J10 BK-14 BK-14 BK-14 682-J21 200-J2 BU-14 BK-14 1 2 LH FRONT WORK LAMP 1 290-5749 PE-C20 2234778 200-PE58 200-PE50 BK-18 BK-18 200-PE56 200-PE165 BK-14 BK-18 570-PE73 169-PE46 H745-PE184 BU-18 PK-18 BR-18 200-J46 200-J57 BK-14 BK-14 200-J34 BK-14 J-C30 1552269 OFF - ON 10 603-PE74 116-PE10 PK-18 BR-18 229-PE61 229-PE62 229-PE63 BK-18 BK-18 BK-18 609-PE77 603-PE74 116-PE9 U726-PE148 U725-PE147 A202-PE151 YL-18 PK-18 BR-18 GY-18 GN-18 BK-18 200-J58 BK-14 200-J33 200-J41 BK-14 BK-18 682-J37 200-J35 BU-14 BK-14 J-C11 1552269 1 2 LH FRONT WORK LAMP 2 219-6488 (114) WARNING BEACON SWITCH 237-9736 518-PE66 OR-16 229-PE64 BK-18 CONN 9 CONNECTS TO P-C8 VOL 1 LOC B-13 200-J26 BK-14 200-J51 200-J9 200-J38 BK-14 BK-14 BK-14 681-J22 200-J1 OR-14 BK-14 1 2 LH REAR WORK LAMP 234-4325 668-PE93 125-PE19 BU-18 RD-18 570-PE71 570-PE72 BU-18 BU-18 684-PE119 106-PE7 C572-PE133 F503-PE138 OR-18 WH-18 YL-18 OR-16 G 609-J40 YL-14 603-J13 PK-14 609-J39 609-J18 YL-14 YL-14 J-C9 1552269 603-PE74 PK-18 570-PE73 BU-18 647-PE89 646-PE88 A608-PE128 GN-18 OR-18 GY-18 G 617-J17 BR-14 617-J52 617-J53 BR-14 BR-14 681-J23 200-J33 OR-14 BK-14 1 2 RH REAR WORK LAMP 234-4325 OFF - ON 1 2 3 4 5 6 7 8 9 10 PE-C21 2234778 609-PE76 116-PE11 YL-18 BR-18 609-PE76 609-PE75 YL-18 YL-18 C978-PE134 A756-PE129 A757-PE130 229-PE64 BR-18 BU-18 GY-18 BK-18 680-J54 GN-14 618-J25 YL-14 680-J19 GN-14 680-J36 200-J34 GN-14 BK-14 J-C28 1552269 1 2 RH FRONT WORK LAMP 2 219-6488 (103) REAR FOG LIGHT SWITCH 284-3619 125-PE20 RD-18 614-PE79 614-PE123 PU-18 PU-18 609-PE77 614-PE84 YL-18 PU-18 G946-PE144 A758-PE131 OR-18 BR-18 681-J20 OR-14 680-J36 681-J22 681-J23 GN-14 OR-14 OR-14 J-C7 1552269 614-PE83 125-PE21 200-PE51 668-PE109 BK-18 BU-18 PU-18 RD-18 614-PE78 614-PE82 614-PE81 614-PE80 PU-18 PU-18 PU-18 PU-18 F775-PE141 518-PE66 103-PE1 BU-18 OR-16 RD-16 682-J55 BU-14 682-J21 682-J37 BU-14 BU-14 680-J19 200-J3 GN-14 BK-14 1 2 RH FRONT WORK LAMP 1 290-5749 609-PE75 YL-18 645-PE85 614-PE83 PK-18 PU-18 614-PE84 PU-18 C542-J16 GN-14 A557-J44 WH-14 C542-J15 C542-J14 GN-14 618-J25 YL-14 J-C5 1552269 1 2 RH FWD POSITION LAMP 212-3924 OFF - ON 8 9 10 PE-C23 2234778 645-PE86 PK-18 645-PE87 PK-18 K436-J42 GN-18 GN-14 200-J10 BK-14 J-C3 1552269 (92) AUTO DIFFERENTIAL LOCK SWITCH A202-PE176 L914-PE68 165-PE70 BK-18 BU-18 YL-18 668-PE92 BU-18 647-PE89 646-PE88 GN-18 OR-18 G766-PE142 G767-PE143 180-PE47 125-PE29 GN-18 WH-18 RD-18 RD-18 603-J13 200-J7 PK-14 BK-14 1 2 FLASH STROBE BEACON LAMP 284-3757 293-9136 125-PE69 668-PE112 200-PE135 498-PE113 RD-18 BU-18 BK-18 WH-18 668-PE106 668-PE96 668-PE97 668-PE98 BU-18 BU-18 BU-18 BU-18 668-PE153 BU-18 645-PE87 104-PE2 668-PE102 PK-18 RD-18 BU-18 200-J9 609-J18 BK-14 YL-14 J-C1 1552269 1 2 SNOW WING LAMP 1 319-7379 498-PE113 WH-18 668-PE53 668-PE109 668-PE112 BU-18 BU-18 BU-18 200-PE56 BK-14 F711-CK23 F712-CK35 YL-16 GN-16 CAN HIGH CAN LOW J-C26 1552269 PE-C8 2234778 668-PE95 668-PE105 668-PE104 BU-18 BU-18 BU-18 PE-C31 2304011 CK-C2 1471446 J2 609-J39 200-J38 YL-14 BK-14 1 2 SNOW WING LAMP 2 319-7379 REAR/BLADE OFF BLADE 1 9 10 125-PE17 668-PE107 668-PE95 125-PE31 614-PE82 125-PE30 614-PE78 200-PE57 647-PE89 646-PE88 OR-18 RD-18 BU-18 BU-18 RD-18 PU-18 RD-18 PU-18 BK-18 GN-18 668-PE107 668-PE101 668-PE103 668-PE100 BU-18 BU-18 BU-18 BU-18 668-PE152 668-PE153 BU-18 BU-18 180-PE160 U762-PE161 RD-18 BR-18 RD BK 1 2 AUXILIARY LEVER #6 FLOAT INDICATOR 279-5308 AUXILIARY IMPLEMENT ATCH 200-J45 A557-J44 BK-14 WH-14 J-C31 1552269 1 2 (115) WORK LIGHT SWITCH 367-5210 668-PE94 668-PE108 BU-18 BU-18 PE-C34 2397352 F MOTOR 324-5355 (83) AIR CLEANER MOTOR 668-PE93 668-PE110 668-PE111 668-PE91 BU-18 BU-18 BU-18 BU-18 668-PE102 668-PE152 668-PE42 BU-18 BU-18 BU-18 709-PE163 U711-PE170 A296-PE167 OR-18 BK-18 GY-18 1 PWR POS 279-9675 (79) AUXILIARY LEVER #6 F ROOF PE-C18 2234778 668-PE54 668-PE146 668-PE43 BU-18 BU-18 BU-18 668-PE140 668-PE42 BU-18 BU-18 CJ-C1 1471445 365-6765 J1 (74) AWD ECM FRONT/REAR OFF FRONT 1 2 3 4 5 6 7 8 9 10 684-PE115 106-PE4 687-PE173 614-PE123 OR-18 WH-18 BU-18 PU-18 668-PE99 668-PE52 BU-18 BU-18 PE-C35 2305010 308-CJ20 YL-18 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 KEY SWITCH - RUN (102) FLOODLIGHT SWITCH 367-5210 125-PE116 668-PE106 668-PE53 125-PE18 614-PE81 125-PE36 RD-18 BU-18 BU-18 RD-18 PU-18 RD-18 668-PE182 668-PE183 BU-18 BU-18 684-PE119 OR-18 709-PE164 U712-PE169 A296-PE168 OR-18 BK-18 YL-18 1 2 3 4 5 6 PWR POS GROUND AUX LEVER #7 (80) AUXILIARY LEVER #7 J718-CJ15 J719-CJ16 OR-18 PU-18 RIGHT FRONT MOTOR SPEED #1 RIGHT FRONT MOTOR SPEED #2 684-PE115 687-PE173 OR-18 BU-18 684-PE8 687-PE174 687-PE175 OR-18 BU-18 BU-18 247-0740 J713-CJ18 J717-CJ17 893-CJ21 GN-18 BR-18 BU-18 LEFT FRONT MOTOR SPEED #1 LEFT FRONT MOTOR SPEED #2 CAT DATA LINK POS PE-C12 2234778 709-PE163 709-PE164 OR-18 OR-18 PE-C16 7T5957 A201-CJ22 BK-14 UNSWITCHED BATTERY #1 NEG (73) CB460 DISPLAY RU-C2 2485358 349-4610 RV-C7 1740502 UNLOCK - LOCK 1 2 3 4 5 6 7 8 9 10 A202-PE176 BK-18 709-PE162 A202-PE151 OR-18 BK-18 A513-PE171 210-PE172 RD-14 BK-14 1 2 117-2311 (86) 12V AUXILIARY PORT A B C D E F G H J K L M N P R S T U V W X Y Z AA BB CC DD EE FF GG HH II JJ KK MM NN PP QQ RR (89) GPS CAN RESISTOR 134-2540 A B C L857-RV48 L856-RV47 GN-16 YL-16 (109) HYDRAULIC LOCKOUT SWITCH 284-3623 G766-PE142 G767-PE143 180-PE159 GN-18 RD-18 WH-18 A202-PE120 A296-PE5 BK-18 BK-18 A296-PE167 A296-PE168 BK-18 BK-18 PE-C4 3313582 892-CJ23 BR-18 CAT DATA LINK NEG BTRY POS BTRY NEG 121-RU9 A274-RU22 BK-18 RD-18 668-PE105 125-PE32 125-PE33 668-PE104 BU-18 RD-18 RD-18 BU-18 A504-PE124 A507-PE125 GN-16 YL-16 A296-PE166 BK-18 684-PE8 687-PE174 OR-18 BU-18 1 2 189-3158 (72) REAR CAB INTERLOCK DIODE G434-CJ36 A201-CJ26 BU-18 BK-14 HYDRAULIC OIL TEMP (AWD) UNSWITCHED BATTERY #2 NEG ACCUGRADE SENSOR CAN LOW ACCUGRADE SENSOR CAN HIGH GPS CAN HIGH GPS CAN LOW RS232-2 TXD RS232-2 RXD L854-RU3 L855-RU4 YL-18 GN-18 RU-C1 2253854 RV-C1 2253861 A608-PE128 A756-PE129 A514-PE127 GY-18 BU-18 YL-18 A201-CJ25 BK-18 ECM LOCATION 2 (GND) L857-RU6 N961-RU16 N958-RU14 L856-RU5 GN-18 OR-18 PK-18 YL-18 121-RU9 RD-18 156-RU19 T744-RU23 121-RU9 A274-RU20 RD-18 BK-18 YL-18 WH-18 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 A274-RV92 148-RV57 121-RV2 BK-14 YL-14 RD-14 OFF - ON 1 2 3 4 5 6 7 8 9 10 PE-C6 2234778 C542-PE132 C572-PE133 A757-PE130 A758-PE131 GN-18 GY-18 BR-18 YL-18 E CJ-C10 1552272 155-CJ29 A201-CJ24 BK-18 RD-14 ECM LOCATION ENABLE (GND) AWD SWITCH (CREEP) AWD SWITCH (OFF) UNSWITCHED BATTERY #1 POS RS232-1 RXD E753-RU17 WH-18 156-RU8 156-RU10 A274-RU22 A274-RU25 BK-18 BK-18 YL-18 YL-18 156-RU19 YL-18 T744-RV32 WH-14 (104) HAZARD SWITCH 518-PE66 103-PE1 OR-16 RD-16 F503-PE138 C978-PE134 E748-PE6 OR-16 BR-18 BK-18 E CONNECTS TO P-C72 VOL 1 LOC C-10 CONN 16 1 2 3 4 155-CJ58 308-CJ20 156-CJ41 RD-14 YL-18 YL-18 F747-CJ34 823-CJ35 OR-16 GN-16 RS232-1-TXD E752-RU11 156-RU8 YL-18 YL-18 YL-18 E752-RU11 E752-RU12 YL-18 YL-18 E752-RU15 A274-RU20 BK-18 236-4616 125-PE67 668-PE54 RD-18 BU-18 G766-PE142 G767-PE143 G946-PE144 F775-PE141 GN-18 WH-18 OR-18 BU-18 G434-CJ36 BU-18 155-CJ32 155-CJ31 RD-14 RD-14 UNSWITCHED BATTERY #4 POS UNSWITCHED BATTERY #2 POS AWD SWITCH (MANUAL) ETHERNET 10/100 RX POS ETHERNET 10/100 RX NEG ETHERNET 10/100 TX POS ETHERNET 10/100 TX NEG SWITCHED POWER U804-RU BR-18 E753-RU17 E753-RU18 WH-18 WH-18 E753-RU50 WH-18 N960-RU21 L870-RU OR-18 BK-18 L870-RV10 N960-RV20 BK-18 OR-18 H728-PE177 H730-PE179 H729-PE178 GN-18 BR-18 WH-18 1 2 3 4 5 6 7 8 9 10 11 12 CJ-C11 1552252 893-CJ21 892-CJ23 F711-CJ47 F712-CJ48 843-CJ1 844-CJ2 H864-CJ3 850-CJ4 849-CJ5 N788-CJ38 M792-CJ39 A201-CJ100 GN-18 BR-18 YL-16 GN-16 WH-18 GN-18 GN-18 PU-18 YL-18 PK-18 BU-18 BK-18 155-CJ52 155-CJ58 RD-14 RD-14 155-CJ32 155-CJ31 155-CJ30 RD-14 RD-14 RD-14 718-CJ37 M792-CJ39 N788-CJ38 BU-16 BU-18 PK-18 RIGHT FRONT CHARGE FLTR SW LEFT FRONT CHARGE FLTR SW +8v SUPPLY 8v RETURN UNSWITCHED BATTERY #5 POS UNSWITCHED BATTERY #3 POS LEFT FRONT DR PUMP FWD SOL LEFT FRONT DR PUMP REV SOL U805-RU U803-RU U802-RU BU-18 GN-18 WH-18 T744-RU7 T744-RU1 WH-18 WH-18 T744-RU23 WH-18 U802-RU U804-RU N957-RU13 PK-18 WH-18 BR-18 U802-RV13 N957-RV31 PK-18 WH-18 MNL OFF AUTO 1 2 3 4 5 6 7 8 9 10 PE-C7 2234778 A758-PE131 BR-18 H745-PE185 H745-PE186 BR-18 BR-18 H745-PE184 BR-18 CONN 17 155-CJ60 155-CJ46 RD-16 RD-16 155-CJ28 RD-14 155-CJ30 155-CJ28 T800-CJ56 J767-CJ57 OR-18 GY-18 RD-14 RD-14 RS232-0 RXD RS232-0-TXD N957-RU13 N960-RU21 PK-18 OR-18 L857-RU6 L856-RU5 L870-RU L854-RU3 L855-RU4 GN-18 YL-18 BK-18 YL-18 GN-18 L854-RU3 L855-RU4 YL-18 GN-18 L854-RV36 L855-RV35 U804-RV24 YL-16 GN-16 BR-18 121-RV11 121-RV2 148-RV57 YL-14 RD-14 RD-14 229-PE62 A757-PE130 BK-18 GY-18 U726-PE148 U725-PE147 P878-PE40 P880-PE39 L914-PE68 GY-18 GN-18 GN-18 GY-18 BU-18 CONNECTS TO P-C131 VOL 1 LOC B-10 156-CJ33 156-CJ42 156-CJ41 YL-18 155-CJ29 155-CJ49 RD-16 RD-14 843-CJ1 844-CJ2 H864-CJ3 850-CJ4 849-CJ5 WH-18 GN-18 GN-18 PU-18 YL-18 PULSE WD MOD DRIVER RETURN RT-C2 2305008 N957-RU13 N958-RU14 PK-18 PK-18 N961-RU16 N958-RU14 L857-RU6 L856-RU5 GN-18 YL-18 OR-18 PK-18 N961-RV41 N958-RV42 L856-RV39 L857-RV40 OR-18 PK-18 YL-16 GN-16 L854-RV36 148-RV12 A274-RV50 A274-RV92 BK-14 YL-16 BK-14 YL-14 (111) THROTTLE LOCK SWITCH 360-1767 229-PE61 668-PE96 125-PE23 A756-PE129 BU-18 RD-18 BU-18 BK-18 YL-18 YL-18 RIGHT FRONT DR PUMP FWD SOL RIGHT FRONT DR PUMP REV SOL LEFT LIGHTBAR 286-9124 RS232 GND 1 2 3 4 RS232 RX PWR GND 156-RT1 T744-RT2 N977-RT3 N978-RT14 BU-18 WH-18 PU-18 PU-18 AWAKE GND AWAKE RS232-0 GND T744-RU7 L870-RU A274-RU25 WH-18 BK-18 BK-18 N961-RU16 N960-RU21 U805-RU U803-RU U802-RU U804-RU OR-18 OR-18 BU-18 GN-18 WH-18 BR-18 E753-RU50 E752-RU15 YL-18 WH-18 E752-RV34 E753-RV33 YL-18 WH-18 L854-RV45 L855-RV46 L856-RV39 L855-RV35 YL-16 GN-16 YL-16 GN-16 125-PE35 668-PE97 RD-18 BU-18 210-PE172 A513-PE171 RD-14 BK-14 843-CJ1 844-CJ2 308-CJ20 718-CJ37 823-CJ35 GN-16 WH-18 GN-18 YL-18 BU-16 845-CJ13 846-CJ12 E797-CJ14 A201-CJ27 A201-CJ44 BK-14 BK-14 OR-18 PK-18 WH-18 UNSWITCHED BATTERY #5 NEG UNSWITCHED BATTERY #3 NEG LEFT FRONT DR MOTOR SOL RIGHT FRONT DR MOTOR SOL PULSE WD MOD DRIVER RETURN 156-RT1 156-RT5 156-RT9 BU-18 BU-18 BU-18 156-RT12 BU-14 U805-RU U803-RU BU-18 GN-18 CONN 40 U803-RV23 U805-RV25 GN-18 BU-18 L857-RV48 L856-RV47 L857-RV40 GN-16 YL-16 GN-16 PE-C9 2234778 U762-PE161 U711-PE170 U712-PE169 BR-18 GY-18 YL-18 A201-CJ27 A201-CJ59 A201-CJ53 BK-14 BK-14 BK-14 850-CJ4 849-CJ5 845-CJ13 846-CJ12 PU-18 YL-18 OR-18 PK-18 CENTER LIGHTBAR 286-9124 PWR GND 1 2 3 4 RT-C3 2305008 156-RT5 T744-RT6 BU-18 WH-18 N977-RT11 N977-RT7 N977-RT3 PU-18 PU-18 PU-18 N977-RT4 PU-18 WH-14 N977-RT4 N978-RT16 T744-RT8 156-RT12 BU-14 RT-C1 3E3388 1 2 3 4 5 6 7 8 RU-C3 1552264 T744-RU1 156-RU10 WH-18 YL-18 T744-RV32 WH-14 SET/ACCEL - NO CHANGE 1 2 3 4 5 6 7 8 9 10 229-PE63 G946-PE144 C978-PE134 BK-18 OR-18 BR-18 893-CJ21 892-CJ23 GN-18 BR-18 RS232 GND RS232 RX N977-RT7 N978-RT15 PU-18 PU-18 N978-RT13 N978-RT15 N978-RT14 PU-18 PU-18 PU-18 N978-RT16 PU-18 PU-18 PU-18 E752-RU12 E753-RU18 YL-18 WH-18 E752-RV34 E753-RV33 L870-RV10 YL-18 WH-18 BK-18 121-RV37 RD-18 (112) THROTTLE LOCK SET SWITCH 229-2580 125-PE34 RD-18 U711-PE170 210-PE172 A513-PE171 GY-18 RD-14 BK-14 A201-CJ27 A201-CJ59 A201-CJ53 BK-14 BK-14 BK-14 A201-CJ53 A201-CJ100 BK-14 BK-18 A201-CJ26 A201-CJ25 A201-CJ24 BK-14 BK-18 BK-18 RT-C4 2305008 T744-RT10 T744-RT2 T744-RT6 WH-18 WH-18 WH-18 T744-RT8 WH-14 CONN 38 N958-RV42 N960-RV20 N957-RV31 PK-18 OR-18 PK-18 121-RV4 121-RV2 121-RV11 121-RV5 RD-14 RD-14 RD-14 RD-14 668-PE98 BU-18 U762-PE161 U712-PE169 BR-18 YL-18 CJ-C5 3313593 A201-CJ45 A201-CJ50 A201-CJ59 BK-18 BK-16 BK-14 A201-CJ22 A201-CJ40 A201-CJ44 BK-14 BK-14 BK-14 155-CJ49 RD-16 A201-CJ40 BK-14 DRIVER ENABLE 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 UNSWITCHED BATTERY #4 NEG RIGHT LIGHTBAR 286-9124 RS232 RX PWR GND 1 2 3 4 N977-RT11 156-RT9 T744-RT10 PU-18 BU-18 WH-18 N961-RV41 U802-RV13 U803-RV23 U804-RV24 OR-18 GN-18 BR-18 WH-18 148-RV57 148-RV12 121-RV3 YL-14 YL-14 RD-14 148-RV58 YL-14 PE-C15 2234778 D A B C D E F G H J E797-CJ14 J713-CJ18 J717-CJ17 J719-CJ16 J718-CJ15 N806-CJ6 N805-CJ19 A433-CJ11 N820-CJ8 L955-CJ10 N814-CJ7 846-CJ12 845-CJ13 WH-18 BR-18 BU-18 PU-18 OR-18 BR-18 BU-18 YL-18 GY-18 OR-18 BU-18 PK-18 OR-18 A433-CJ11 A753-CJ9 A201-CJ27 YL-18 PU-18 BK-14 N814-CJ7 A753-CJ9 L955-CJ10 BU-18 PU-18 OR-18 LEFT AWD CLUTCH FWD SOL ON/OFF DRIVER RETURN RIGHT AWD CLUTCH FWD SOL RIGHT AWD CLUTCH REV SOL RS232 GND N978-RT13 PU-18 U805-RV25 BU-18 A274-RV50 BK-14 A274-RV79 A274-RV14 BK-14 BK-14 OFF - ON 1 2 3 4 5 6 7 8 9 10 A202-PE120 U725-PE147 U726-PE148 BK-18 GN-18 GY-18 D E797-CJ14 F747-CJ34 G434-CJ36 BU-18 OR-16 WH-18 A433-CJ11 N820-CJ8 M902-CJ54 M901-CJ64 OR-16 YL-16 YL-18 GY-18 LEFT AWD CLUTCH REV SOL AWD SYSTEM INDICATOR AWD ENGAGED INDICATOR LIGHT BARS CB460 DISPLAY A274-RV92 BK-14 (93) AUTOSHIFT SWITCH 249-5478 660-PE149 106-PE3 PU-18 WH-18 K L M H864-CJ3 J713-CJ18 J717-CJ17 G858-CJ43 GN-18 BR-18 BU-18 OR-18 RV-C3 3E3388 A274-RV77 A274-RV59 A274-RV1 BK-14 BK-14 BK-14 200-PE59 125-PE27 668-PE92 660-PE149 RD-18 BU-18 PU-18 BK-18 CONNECTS TO AF-C3 VOL 4 LOC F-5 CONN 36 N O P Q R S T U V W X T800-CJ56 J767-CJ57 A753-CJ9 156-CJ33 A201-CJ45 OR-18 GY-18 PU-18 YL-18 BK-18 J718-CJ15 J719-CJ16 F711-CJ47 F712-CJ48 J767-CJ57 YL-16 GN-16 GY-18 OR-18 PU-18 CONNECTS TO P-C64 VOL 1 LOC G-2 CONN 21 1 2 3 4 5 6 7 8 148-RV12 121-RV11 A274-RV50 BK-14 YL-14 RD-14 L854-RV36 YL-16 L854-RV84 L854-RV27 YL-16 YL-16 L955-CJ10 M792-CJ39 OR-18 BU-18 L854-RV45 L855-RV46 YL-16 GN-16 L854-RV45 L854-RV21 YL-16 YL-16 L854-RV49 YL-16 1 2 3 4 5 6 7 8 9 10 PE-C24 2234778 A296-PE5 H731-PE180 H728-PE177 BK-18 GY-18 GN-18 N805-CJ19 N788-CJ38 M902-CJ54 M901-CJ64 PK-18 OR-16 YL-16 BU-18 L854-RV76 YL-16 L855-RV28 GN-16 RV-C6 3595180 (91) AUTO ARTICULATION SWITCH 419-0845 H730-PE179 H731-PE180 BR-18 GY-18 156-CJ42 155-CJ60 155-CJ46 YL-18 RD-16 RD-16 N814-CJ7 N806-CJ6 N820-CJ8 T800-CJ56 OR-18 BU-18 BR-18 GY-18 N806-CJ6 N805-CJ19 G858-CJ43 OR-18 BR-18 BU-18 LEFT AWD CLUTCH PRESS SNSR RIGHT AWD CLUTCH PRESS SNSR AWD CONTROL DIAL POS SNSR RF-C5 1552267 GT-C2 3R9965 GT-C1 2304010 RV-C10 2304009 L855-RV35 L855-RV26 GN-16 GN-16 L855-RV83 L855-RV51 GN-16 GN-16 L873-RV9 T745-RV16 L874-RV6 T748-RV7 148-RV58 A274-RV14 YL-14 BK-14 A B C D E F G H J K L M N P H729-PE178 125-PE181 668-PE182 668-PE183 WH-18 RD-18 BU-18 BU-18 823-CJ35 718-CJ37 GN-16 BU-16 A201-CJ27 A201-CJ59 A201-CJ53 BK-14 BK-14 BK-14 H745-RF11 E744-RF10 E745-RF9 BR-18 YL-18 BU-18 A B C BK-18 BR-18 WH-18 1 2 3 4 253-1789 (110) AUTO/MANUAL SIDESHIFT SWITCH POS BTRY 1 GND POS BTRY 2 GND A B C D E F G H 121-GT1 A274-GT2 121-GT3 A274-GT4 RD-14 BK-14 RD-14 BK-14 121-GT1 A274-GT2 121-GT3 A274-GT4 RD-14 BK-14 RD-14 BK-14 1 2 3 4 5 6 7 8 9 10 11 12 121-RV4 121-RV3 A274-RV77 BK-14 RD-14 RD-14 L855-RV46 L855-RV78 GN-16 GN-16 GY-14 YL-14 OR-14 PK-14 CONN 45 125-PE187 RD-18 A201-CJ61 A201-CJ62 BK-18 BK-16 A201-CJ50 BK-16 A274-RV59 BK-14 L856-RV47 L856-RV56 YL-16 YL-16 L856-RV44 YL-16 L854-RV27 L855-RV28 YL-16 GN-16 CONNECTS TO RE-C1 VOL 4 LOC C-5 SWITCH PANEL G858-CJ43 F747-CJ34 OR-18 OR-16 RF-C3 3E3388 H745-RF13 K723-RF12 BR-18 PU-18 RF-C7 2234778 1 2 3 4 5 6 7 8 9 10 POS BTRY 3 GND 121-GT5 A274-GT6 RD-14 BK-14 121-GT5 A274-GT6 RD-14 BK-14 121-RV5 A274-RV1 RD-14 BK-14 L856-RV39 L857-RV55 YL-16 GN-16 L856-RV29 YL-16 L857-RV30 L856-RV29 GN-16 YL-16 M902-CJ54 M901-CJ64 OR-16 YL-16 (76) CAB GROUND 1 CONN 23 1 2 3 4 5 6 7 8 H745-RF4 Y934-RF2 Y936-RF1 BR-18 WH-18 PK-18 E772-RF16 Y935-RF14 E772-RF16 GN-18 OR-18 GN-18 (98) RH BLADE OFFSET SWITCH (81) GRADE CONTROL POWER SUPPLY MODULE 226-9169 CONN 41 RV-C10 AND RV-C11 ARE CONNECTED WHENEVER POWER MODULE IS NOT USED L857-RV48 L857-RV43 GN-16 GN-16 L857-RV30 GN-16 C A201-CJ61 156-CJ42 BK-18 YL-18 CJ-C6 1552267 A B C BK-18 OR-18 POWER GROUND SIGNAL CONNECTS TO P-C32 VOL 1 LOC F-2 Y933-RF3 H745-RF6 Y937-RF7 J771-RF5 YL-18 BR-18 PU-18 BU-18 K722-RF15 YL-18 249-5483 L872-GR1 T744-GR2 BK-14 BK-14 GR-C1 2304009 RV-C11 2304010 L872-RV94 BU-14 E753-RV33 E752-RV34 L870-RV10 WH-18 YL-18 BK-18 L857-RV40 L872-RV74 L872-RV94 GN-16 BU-16 BU-14 SYMBOL DESCRIPTION ABBREV COLOR C G858-CJ43 OR-18 WH-18 373-4327 (90) AWD POSITION SENSOR SWITCHED POWER 1 SWITCHED POWER RTN 1 SWITCHED POWER 2 SWITCHED POWER RTN 2 AWAKE AWAKE RTN SWITCHED POWER 3 SWITCHED POWER RTN 3 A B C D E F G H L872-GR1 T744-GR2 L873-GR3 T745-GR4 L870-GR5 T744-GR6 BK-14 BK-14 BK-14 BK-14 BK-14 BK-14 1 2 3 4 5 6 7 8 9 10 11 12 T744-RV95 WH-14 N961-RV41 N958-RV42 N960-RV20 N957-RV31 OR-18 PK-18 OR-18 PK-18 L872-RV82 BU-14 L873-RV9 L874-RV6 GY-14 OR-14 BK GY PU BR GN BU BLACK GRAY PURPLE BROWN GREEN BLUE CJ-C7 1552269 RF-C4 3E3388 K723-RF12 H745-RF13 Y935-RF14 K722-RF15 PU-18 BR-18 OR-18 YL-18 H745-RF4 Y934-RF2 BR-18 WH-18 RF-C2 2234778 L873-GR3 T745-GR4 L870-GR5 T744-GR6 BK-14 BK-14 BK-14 BK-14 L873-RV9 T745-RV16 L870-RV10 T744-RV22 GY-14 YL-14 BK-18 WH-16 U802-RV13 U803-RV23 U805-RV25 GN-18 BU-18 WH-18 T744-RV75 T744-RV95 WH-16 WH-14 WH-14 T744-RV81 155-CJ60 M902-CJ54 RD-16 OR-16 1 2 RD BK AWD SYSTEM INDICATOR LED 242-3282 CONNECTS TO P-C44 VOL 1 LOC F-2 CONN 24 1 2 3 4 5 6 7 8 Y936-RF1 E771-RF8 PK-18 BU-18 1 2 3 4 5 6 7 8 9 10 GR-C2 6D5257 L874-GR7 T748-GR8 OR-14 PK-14 L874-GR7 T748-GR8 OR-14 PK-14 L874-RV6 T748-RV7 OR-14 PK-14 U804-RV24 BR-18 T744-RV19 WH-18 CJ-C8 1552269 H745-RF19 Y938-RF18 J769-RF17 BR-18 YL-18 YL-18 Y933-RF3 E771-RF8 BU-18 YL-18 249-5483 (97) LH BLADE OFFSET SWITCH CONN 42 121-RV4 121-RV3 RD-14 RD-14 T744-RV32 T744-RV22 WH-14 WH-16 T745-RV16 T748-RV7 YL-14 155-CJ46 M901-CJ64 RD-16 YL-16 RD BK 1 2 AWD ENGAGED INDICATOR LED 250-2299 GRADE CONTROL POWER MODULE 121-RV37 121-RV5 A274-RV59 A274-RV1 BK-14 RD-14 BK-14 RD-18 PK-14 CJ-C9 1552273 F711-CJ47 F712-CJ48 YL-16 GN-16 CAN HIGH CAN LOW CONN 25 1 2 3 4 RF-C8 3E3376 E745-RF9 E744-RF10 H745-RF11 BU-18 YL-18 BR-18 RF-C1 1552267 RY-C1 1678987 RY-C2 3E5179 RV-C13 1552253 L855-RV26 L854-RV21 YL-16 L854-RV76 A274-RV77 YL-16 BK-14 GN-16 SPLICE 823-CJ35 F747-CJ34 A201-CJ62 GN-16 OR-16 BK-16 1 2 3 4 5 6 BK BK BK BK 4 3 1 1471446 CJ-C2 J2 CONNECTS TO P-C49 VOL 1 LOC F-2 Y937-RF7 H745-RF6 J771-RF5 BU-18 PU-18 BR-18 A B C BK-18 BR-18 WH-18 1 2 3 4 253-1789 (94) LH BLADE CONTROL SWITCH COMM TX (CAT) GROUND POWER A B C D E F G H L872-RY1 T744-RY4 N961-RY8 N958-RY7 BU-16 WH-16 OR-18 PK-18 L855-RY5 L854-RY6 GN-16 YL-16 L872-RY1 T744-RY2 N961-RY8 L854-RY6 L855-RY5 BU-16 WH-16 OR-18 YL-16 GN-16 1 2 3 4 5 6 7 8 9 10 11 12 L854-RV76 L855-RV78 T744-RV75 N961-RV41 L872-RV74 YL-16 GN-16 OR-18 BU-16 WH-16 L855-RV78 L857-RV55 L856-RV56 GN-16 GN-16 YL-16 BLADE, SPADE, RING OR SCREW TERMINAL 718-CJ37 BU-16 2 185-6335 (113) VARIABLE SHIFT CONTROL (AWD) SWITCH RF-C9 1552267 (87) CR924 RADIO 305-6192 COMM TX (3RD PARTY) SENSOR CAN HIGH COMM RX (CAT) L854-RY6 YL-16 N958-RY7 N961-RY8 L872-RY1 PK-18 OR-18 BU-16 N958-RY7 PK-18 E752-RV34 N958-RV42 L857-RV55 L856-RV56 YL-18 PK-18 GN-16 YL-16 L872-RV74 L872-RV82 L873-RV9 L872-RV94 GY-14 BU-14 BU-16 BU-14 CALLOUTS ALL-WHEEL DRIVE ATCH J769-RF17 Y938-RF18 H745-RF19 YL-18 YL-18 BR-18 A B C BK-18 BR-18 WH-18 1 2 3 4 253-1789 (95) RH BLADE CONTROL SWITCH SENSOR CAN LOW COMM RX (3RD PARTY) L855-RY5 GN-16 T744-RY4 WH-16 T744-RY2 T744-RY3 WH-16 WH-16 T744-RY3 WH-16 E753-RV33 WH-18 T744-RV19 T744-RV75 L874-RV6 T744-RV22 OR-14 WH-16 WH-16 WH-18 CONN 43 T745-RV16 T744-RV95 T748-RV7 YL-14 PK-14 WH-14 Callout Number (Machine Location from Component Locations Table) (52) VALVE GP - CONTROL 138-1234 Component Name ACCUGRADE CONTROL PANEL 1 2 3 4 5 6 7 8 9 10 11 12 RV-C2 2370164 L872-RV82 T744-RV19 N960-RV20 BU-14 WH-18 OR-18 Part Number B Y-C1 1552267 U802-RV13 U803-RV23 U804-RV24 U805-RV25 L854-RV21 YL-16 WH-18 GN-18 BR-18 BU-18 B T971-Y7 200-Y2 122-Y1 OR-14 BK-16 BU-14 A B C ETHERNET RADIO CONNECTION CONN 44 (84) LH SIDE WINDOW WIPER MOTOR 451-0116 N957-RV31 121-RV37 L855-RV26 PK-18 RD-18 GN-16 CONN 20 1 2 3 4 Y-C3 3E3376 200-Y6 T972-Y8 T971-Y7 122-Y5 BK-14 GN-14 OR-14 BU-14 200-Y6 122-Y5 BK-14 BU-14 122-Y1 BU-14 200-Y2 BK-16 200-Y4 BK-16 122-Y3 BU-14 CONNECTS TO P-C56 VOL 1 LOC G-2 OR-14 T971-Y7 T972-Y8 GN-14 CAB Y-C2 1552267 T972-Y8 200-Y4 122-Y3 GN-14 BK-16 BU-14 A B C H L GND T° P B+ MOTOR (85) RH SIDE WINDOW WIPER MOTOR 451-0116 AUXILIARY SIDE WINDOW WIPERS A A THIS SCHEMATIC IS FOR THE 12M3, 140M3, AND 160M3 MOTOR GRADER ELECTRICAL SYSTEM VOLUME 2 of 4:

ADDITIONAL CAB COMPONENTS MEDIA NUMBER: UENR3921 NOTE A: POWER LEAD FROM VOLTAGE CONVERTER TO 2-WAY COMMUNICATIONS RADIO SHOULD BE 12 AWG OR LARGER. Components are shown installed on a fully operable machine with the key and engine off, transmission shifter in neutral and with parking brake set. Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations. SCHEMATIC PART NUMBER: 417-8801, CHANGE: 00, VERSION: - NOTE B: THE SWITCH CONTACT STATE SHOWN OCCURS WHEN PEDAL IS NOT PRESSED. 16 1 Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

15 14 13 12 11 10 9 8 7 6 5 4 3 2 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 CDL POS CDL NEG RS232 PORT1-TXD RS232 PORT1-RXD RS232 PORT1-DTR RS232 PORT1-DCD RS232 PORT1-GND CAN LOW CAN HIGH BATTERY POS R-TERM BATTERY NEG KEY SWITCH RUN 1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 3 4 5 6 7 8 2 3 4 5 6 GROUND AUX LEVER #6 CIRCUIT CONNECTED CIRCUIT NOT CONNECTED ELECTRICAL CONNECTION TO MACHINE STRUCTURE INTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT H# CONNECTOR CIRCUIT GROUPING DESIGNATION ATCH WIRE, CABLE, COMPONENT RD WH RED WHITE OR YL PK ORANGE YELLOW PINK HARNESS TABLE ID PART# CHG LOC DESCRIPTION CJ CK CT 366-9658 366-9659 360-5667 02 02 00 E-18 J-18 L-18 AWD IMPLEMENT ECM 3 MACHINE SECURITY SYSTEM (MSS) GR 360-2969 00 A-9 LH GRADE CONTROL POWER MODULE GT 360-2968 00 B-9 RH GRADE CONTROL POWER MODULE J JA 366-9416 355-5084 03 00 H-14 G-11 ROOF LICENSE PLATE PE RF 448-4274 360-2972 00 01 J-1 B-13 SWITCH PANEL ACCUGRADE POD RT 296-1067 00 D-10 LIGHT BAR RU 252-5190 03 E-8 FRONT CHASSIS RV 374-5511 01 D-7 ACCUGRADE HARNESS RY 314-2820 02 C-9 ACCUGRADE RADIO WA 367-9324 00 J-12 PRODUCT LINK Y 235-6175 03 A-6 WIPER MOTOR 2 3 4 5 6 3 4 6 GND MOTOR T° B+ P WIRE GROUP COLOR DESCRIPTIONS GROUND CIRCUIT WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON VOLTAGE CONVERTER OUTPUT CIRCUIT AWD CIRCUIT MACHINE SECURITY CONTROL CIRCUIT ACCUGRADE CIRCUIT HEATER AND AIR CONDITIONER CIRCUIT TURN SIGNAL / WIPER WASHER CIRCUIT IMPLEMENT CONTOL CIRCUIT IMPLEMENT 3 CONTROL CIRCUIT STEERING CONTROL CIRCUIT CAT DATA LINK CAN DATA LINK PRODUCT LINK GPS CAN DATA LINK ACCUGRADE SENSOR CAN DATA LINK ETHERNET OTHER COLOR DESCRIPTIONS HIGHWAYS 2 4 5 6 5 4 6 15 14 13 12 11 10 9 8 7 6 5 4 3 2

Стр. 4