Attention 1 .. The diesel engine operators must familiarize themselves with this manual as well as engine construction and strictly follow· the .procedures of operation and maintenance especially' the regulations for safety 0tJera- tion described in this manual. 2. Before operating an engine at full load, the 60 hours running in should be carried out as specified in the manual. . 3. Increase its 'speed gradually after stating a cold engine, never let it run at highs speed abruptly, and don't stop the engine insta.ntly while its cooling water is still hot, also do'n't let ti Ie engine running long time without load. 4.
If the ambient temperature falls below +5°C, drain the cooling water out of the radiator, the lubricating oil cooler and the diesel engine itself completely after stopping the engine. Con- tinuous keeping the water in the oil cooler should be forbid- den. . 5. Never run the diesel engine without and air cleaner so as to .prevent the unfiltered air from entering the cylinders. 6. The engine m·ust be filled with specified grade fuel and ·Iubri- eating oil, and a special and clean container for each oil should 'be used.' The fuel oil should be settled for 72 hours and fil- tered before' using. 7.
The inspection and repair of the components in electrical sys- tem' must be carried out by the person who has a good knowledge, of electricity. 8. The working environment of the diesel engine should be well ventilated to avoid being polluted by waste gas or smoke. 9. The power rating and amending of the diesel engine is ac- cording to GB6072. 1 - 2000 the first section of reciprocating internal combu?tion engine: standard basic condition, the rating and testing method of power, fuel consumption and engine oil consumption. 10. The manufacturing of the diesel engine is according to 'the common techn'ical requirement for low. and middle level powered diesel engine in JB/T8895 -1999 and Q/WCG094