Caterpillar Monitoring System Manual (EN)

Component Identifiers (CID¹) Module Identifier (MIDІ) Caterpillar Monitoring System (MID No. 030) CID Component Machine Code Machine Codes Harness And Wire Electrical Schematic Symbols D7R 35 RENR3662-02 July 2006 Related Electrical Service Manuals Symbols 0096 Fuel Level Sender 0248 Data Link 21 SI Alternator: 132-2156 (70A) SENR4757 Title Form Number 0263 Sensor Power Supply 0271 Action Alarm 42MT Electric Starting Motor: 6V-5227 SENR3581 Engine Control: SENR5003 Pressure Symbol Temperature Symbol Level Symbol Flow Symbol Circuit Breaker Symbol T 0324 Action Lamp 0600 Hydraulic Oil Temperature Sensor 0819 Display Data Link Drive Train Control:

SENR8367 0821 Display Power Supply 826 Torque Converter Oil Temperature Sensor Caterpillar Monitoring System: SENR2014 Starting and Charging: SENR2947 Symbols And Definitions Engine Electronic Control Module (MID No. 036) Event Codes Fuse - A component in an electrical circuit that will open the circuit if too much current flows through it. 0001 Injector Cylinder 1 CID Component Number Event Description E017 High Engine Coolant Temperature Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it.

0002 Injector Cylinder 2 0003 Injector Cylinder 3 E025 High Inlet Air Temperature 0004 Injector Cylinder 4 0005 Injector Cylinder 5 E027 High Intake Air Temperature E035 Loss Of Coolant Flow Warning Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component. 0006 Injector Cylinder 6 0041 8 Volt DC Supply E039 Low Engine Oil Pressure E100 Low Engine Oil Pressure ¹The FMI is a diagnostic code that indicates what type of failure has occurred. Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine.

0091 Throttle Switch 0110 Engine Oil Pressure E190 Engine Overspeed E265 User Defined Shutdown 0168 System Voltage 0172 Intake Manifold Air Temp E272 Inlet Air Restriction Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. 0174 Fuel Temperature 0190 Engine Speed Signal Connector Location 0253 Personality Module 0261 Engine Timing Connector Number D7R Series II Track-Type Tractor FTC Electrical System Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

0262 5 Volt Sensor Supply 0264 Decel Throttle Position Signal CONN 1 CONN 2 Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure. 0266 Crank Without Inject Inputs 0268 Check Programmable Paramaters CONN 3 CONN 4 T 0273 Turbo Outlet Pressure 0274 Atmospheric Pressure CONN 5 CONN 6 Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.

0275 Right Turbo Inlet Pressure 0291 Engine Cooling Fan Solenoid CONN 7 CONN 8 AFG1-529 ACS1-632 ADW1-532 BRP1-738 BPK1-512 BNM1-516 0296 Transmission ECM 0342 Secondary Engine Speed Signal CONN 9 CONN 10 CONN 11 Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work. 0544 Engine Cooling Fan Speed Signal 0545 Ether Start Relay CONN 12 CONN 13 0799 Need Service Tool Update 1599 Engine Fan Pull Solenoid 1600 Engine Fan Push Solenoid Power Train Control System (MID No.

113) CID Component CONN 14 CONN 15 MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches. CONN 16 CONN 17 CONN 18 CONN 19 0070 Parking Brake Switch 0168 Electrical System Voltage 0177 Transmission Oil Temperature Sensor CONN 20 CONN 21 Harness And Wire Symbols 0190 Engine Speed Sensor 0248 CAT Data Link CONN 22 CONN 23 1 2 Deutsch connector: Typical representation of a Deutsch connector.

The plug contains all sockets and the receptacle contains all pins. Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets. 0254 Electronic Control Module 0269 Sensor Power Supply CONN 24 CONN 25 Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...) 0298 Service Brake Pedal Switch 0299 Transmission Lever Position Sensor CONN 26 CONN 27 Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness.

(C1, C2, C3, .....) 0368 Autoshift Switch 0468 Service Brake Pedal Position Sensor CONN 28 CONN 29 AG-C4 111-7898 L-C12 3E-5179 C-C4 130-6795 AG-C3 130-6795 Part Number for Connector Plug Part Number For Connector Receptacle 0490 Implement Lockout Switch 0618 Parking Brake Switch - Brake Backup CONN 30 CONN 31 CONN 32 325-AG135 PK-14 5A 0621 Downshift Switch 0622 Upshift Switch CONN 33 CONN 34 Socket Pin Receptacle Fuse (5 Amps) 0623 Direction Switch 0650 Harness Code CONN 35 CONN 36 Single Wire Connector Pin or Socket Number 9X-1123 Component Part Number 0668 Transmission Shift Lever 0671 Transmission Output Speed Sensor I CONN 37 CONN 38 Harness identification code:

This example indicates wire 135 in harness "AG". Plug 200-L32 BK-14 0672 Torque Converter Output Speed Sensor 0673 Transmission Output Speed Sensor II CONN 39 CONN 40 Ground Connection Circuit Identification Number Wire Color Wire Gauge 0674 Transmission Intermediate Speed Sensor I 0675 Transmission Intermediate Speed Sensor II CONN 41 CONN 42 © 2006 Caterpillar All Rights Reserved Printed in U.S.A.

0676 Left Track Steering Lever Position Sensor 0677 Right Track Steering Lever Position Sensor CONN 43 CONN 44 0681 Parking Brake Solenoid 0689 Left Brake Solenoid CONN 45 CONN 46 0690 Right Brake Solenoid 0691 Reverse Clutch Solenoid Valve I 0692 Forward Clutch Solenoid Valve II CONN 47 CONN 48 0693 Speed 3 Clutch Solenoid Valve III 0694 Speed 2 Clutch Solenoid Valve IV CONN 49 CONN 50 0695 Speed 1 Clutch Solenoid Valve V 0697 Priority Valve Solenoid CONN 51 CONN 52 CONN 53 0698 Left Steering Clutch Solenoid 0699 Right Steering Clutch Solenoid CONN 54 CONN 55 0718 Transmission System 0722 Secondary Brake Solenoid CONN 56 CONN 57 CONN 58 ¹ The CID is a diagnostic code that indicates which component is faulty.

1488 Implement Lever Detent CONN 59 І The MID is a diagnostic code that indicates which electronic control module diagnosed the fault. The connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart. 39 8 5 1 37 54 7 RENR3662-02 20 Page 43 14 52 36 48 A 35 4 13 47 51 55 ¹ At room temperature unless otherwise noted. 45 11 6 Off Machine Switch Specification Part No. Function Actuate Deactuate Contact Position 42 24 25 30 43 46 53 55 41 45 44 A 5 6 54 31 27 28 26 34 38 B C 29 14 22 23 32 50 47 52 3 15 20 10 9 35 1 8 13 7 49 40 36 A = Located inside of cab.

Стр. 1

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 106-ML1 PU-18 ML-C1 3E5179 MP-C2 1130580 1 2 1 2 MP-C3 1552252 200-MP24 BK-18 106-MP25 RD-18 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 M-C5 3E6286 200-MR2 BK-14 200-M63 BK-14 609-MR1 YL-14 609-M191YL-14 M-C7 1552269 MR-C1 1552269 1 2 1 2 MR-C2 3E3364 LH FENDER FLOOD 1355549 WH-18 BK-18 1 2 H-4 H-4 CBL-AW1 RD-00 CBL-AW1 RD-00 CBL-AW1 RD-00 200-G9 BK-14 322-G5 GY-14 G-C4 1552269 1 2 FWD HORN HI 1747875 1 2 PRODUCT LINK 2096417 HDD INPUT -BAT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 +BAT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 ML-C2 7X6222 106-ML1 PU-18 200-ML2 BK-18 308-ML3 YL-18 FORWARD CLUTCH 1608408 1 2 P-C3 1552269 752-P13 YL-18 TRANSMISSION 200-ML2 BK-18 403-ML4 GN-18 3 4 5 6 7 8 9 10 11 12 MP-C5 3E5179 NOTE G 3 4 5 6 7 8 9 10 11 12 403-MP22 GN-18 308-MP23 YL-18 CONN 19 H-4 CONN 26 3E3364 NOTE G CBL-AT2 BK-00 CBL-AT2 BK-00 CBL-AT2 BK-00 CONN 40 109-HF1 RD-0 109-HF1 RD-0 200-C1 BK-14 C-C2 1552267 CONN 54 G-C1 3E3370 A B C A B C 200-G3 BK-14 200-G2 BK-14 200-G8 BK-14 200-G1 BK-14 200-G1 BK-14 G-C5 1552269 ALTERNATOR IN KEY SW INPUT 308-ML3 YL-18 403-ML4 GN-18 REVERSE CLUTCH 1608408 1 2 P-C4 1552269 975-P18 WH-18 751-P12 GN-18 CONN 31 CONN 17 106-MP25 RD-18 106-M79 RD-18 CBL-AT1 RD-00 P N FUSE PANEL A-C4 1642336 610-C2 OR-14 322-C3 GY-18 322-G4 GY-14 610-G7 OR-14 322-G6 GY-14 322-G5 GY-14 610-G11 OR-14 610-G10 OR-14 200-G2 BK-14 322-G6 GY-14 1 2 FWD HORN LO 1747876 1 2 H-20 I CAT DATA LINK + SENSOR SUPPLY HDD GND -BAT +BAT 893-ML6 GN-18 FIRST GEAR CLUTCH 1608408 1 2 P-C5 1552269 975-P17 WH-18 975-P16 WH-18 900-P11 PU-18 754-P9 BU-18 752-P13 YL-18 751-P12 GN-18 893-ML6 GN-18 892-ML5 BR-18 893-MP21 GN-18 892-MP20 BR-18 403-MP22 GN-18 308-MP23 YL-18 200-MP24 BK-18 403-M177 GN-18 200-M212 BK-18 308-M169 YL-18 G730-M35 PK-18 975-M23 WH-18 M-C4 1552272 1 2 3 4 SERVICE BRAKE DUMP 1722392 GN-18 GN-18 NEG POS NEG POS CBL-AP1 RD-00 CBL-AN1 RD-00 AUX START 1704857 JCT BLK 9W0742 112-A32 PU-14 15A DRIVETRAIN 6T3643 140-A26 BU-14 302-A36 OR-18 207-A37 BK-18 302-A36 OR-18 302-A36 OR-18 207-A37 BK-18 310-A39 PU-18 203-A15 BK-18 306-A40 GN-18 105-A41 RD-18 203-A15 BK-18 304-A21 WH-18 101-A34 RD-18 1 2 3 4 5 6 7 8 9 10 11 12 200-M74 BK-10 200-M21 BK-14 200-M160 BK-10 CN-C4 1552269 PRELUBE OIL PRESS SW D6 D7 1059152 304-C50 WH-8 C-C15 1552269 RESISTOR S 3E7842 200-C6 BK-14 200-C11 BK-18 200-C10 BK-18 200-C1 BK-14 ETHER START AID RLY 3E5239 87A 610-G11 OR-14 200-G9 BK-14 G-C222 1552269 I CAN DATA LINK - CAN DATA LINK + CAN LINK SHIELD CAT DATA LINK - 892-ML5 BR-18 NOTE E SECOND GEAR CLUTCH 1608408 1 2 P-C6 1552269 975-P15 WH-18 755-P10 OR-18 975-P18 WH-18 900-P11 PU-18 755-P10 OR-18 NOTE E E901-P8 GN-18 P-C1 1086177 A B A B C D E F G H J K L MP-C1 1086259 E901-MP1 GN-18 CONN 18 106-M79 RD-18 M-C6 1552272 12V BATTERY 1535700 (STD) 9X9731 (ATCH) 12V BATTERY2 1535700 (STD) 9X9731 (ATCH) 112-A11 PU-14 15A ENG ECM SWITCHED 6T3643 150-A29 RD-14 101-A22 RD-14 310-A39 PU-18 105-A41 RD-18 109-A9 RD-18 101-A34 RD-18 207-A37 BK-18 109-A9 RD-18 308-A38 YL-18 MODULE GROUND 200-M149 BK-10 200-M107 BK-10 200-M172 BK-10 A447-CN1 PK-18 200-CN5 BK-18 1 2 BK-18 BK-18 302-C45 OR-18 301-C39 BU-18 1 2 108-C13 BU-16 108-C13 BU-16 30 1 87 85 86 5 C-C8 9X1054 3 4 610-G10 OR-14 200-G8 BK-14 CONN 58 1 2 G-C6 3E3364 NOTE G CYLINDER/SWEEP LIGHTING RS-232C Tx DATA RS-232C GND THIRD GEAR CLUTCH 1608408 1 2 P-C7 1552269 975-P14 WH-18 975-P14 WH-18 754-P9 BU-18 975-P17 WH-18 975-P16 WH-18 975-P15 WH-18 975-P20 WH-18 975-P19 WH-18 E902-P7 PU-18 E903-P6 YL-18 E904-P5 BR-18 E905-P4 BU-18 E906-P3 OR-18 C D E F G H J K L M N P R S T E902-MP2 PU-18 E903-MP3 YL-18 E904-MP4 BR-18 E905-MP5 BU-18 E906-MP6 OR-18 893-MP21 GN-18 892-MP20 BR-18 E900-MP12WH-18 E901-MP1 GN-18 E902-MP2 PU-18 E900-M38 WH-18 E901-M39 GN-18 E902-M40 PU-18 892-M161 BR-18 893-M165 GN-18 403-M177 GN-18 308-M169 YL-18 200-M212 BK-18 892-M161 BR-18 893-M165 GN-18 G731-M37 GY-18 975-M25 WH-18 1 2 3 4 PARK BRAKE DUMP 1722392 GN-18 GN-18 101-AA1 RD-0 101-A22 RD-14 102-A33 RD-14 101-A12 RD-14 101-A34 RD-18 112-A42 PU-18 306-A40 GN-18 304-A21 WH-18 308-A38 YL-18 112-A42 PU-18 310-A39 PU-18 A-C24 155-2252 NOTE G 200-M152 BK-14 200-M207 BK-14 201-M127 BK-18 200-M178 BK-14 CONN 45 301-CN4 BU-4 200-CN6 BK-18 200-CN2 BK-18 CF-C3 1552269 CN-C1 3E3364 G S CBL-AW1 RD-00 H-14 310-C7 PU-18 310-C12 PU-18 310-C9 PU-18 200-C10 BK-18 310-C9 PU-18 F710-C31 BR-18 2 RS-232C Rx Data BK-18 WH-18 XMSN INTMED SP 1 1932550 1 2 PP-C1 1552269 E903-PP3 YL-18 E902-PP4 PU-18 NOTE E E907-P2 GY-18 755-P10 OR-18 752-P13 YL-18 751-P12 GN-18 E907-MP7 GY-18 751-MP9 GN-18 752-MP10 YL-18 755-MP8 OR-18 E903-MP3 YL-18 E904-MP4 BR-18 E905-MP5 BU-18 E906-MP6 OR-18 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 E903-M41 YL-18 E904-M42 BR-18 E905-M43 BU-18 E906-M44 OR-18 751-M46 GN-18 975-M30 WH-18 975-M29 WH-18 F789-M116 YL-18 M-C8 1552269 1 2 RIGHT STEER CLUTCH 1744909 CBL-AM1 BK-00 15A ENG ECM UNSWITCHED 6T3643 102-A33 RD-14 306-A8 GN-18 140-A26 BU-14 A-C1 1130580 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 M-C3 3E6286 140-M5 BU-14 306-M109 GN-18 CONN 39 MODULE 1 GROUND 201-M91 BK-18 201-M151 BK-18 A447-CF4 PK-18 200-CF2 BK-18 1 2 1 2 A447-CN1 PK-18 200-CN2 BK-18 H-14 MTR BAT MOTOR STARTER 2071556 (STD) 6V-0890 (ATCH) 101-CN3 RD-4 F710-C31 BR-18 310-C12 PU-18 C-C4 1552269 1 2 ETHER START VALVE 3E6332 WH-18 PU-18 2 1 ANTENNA CABLE ANTENNA CABLE PROD LINK ANTENNA CABLE AS 2084701 BK-18 WH-18 XMSN INTMED SP 2 1932550 1 2 PP-C2 1552269 PP-C3 1552269 E905-PP5 BU-18 E904-PP6 BR-18 PP-C5 1552264 CONN 16 1 2 1 2 3 4 5 6 7 8 P-C2 3E3388 E900-P1 WH-18 975-P20 WH-18 900-P11 PU-18 754-P9 BU-18 M N P R S T E900-MP12WH-18 754-MP11 BU-18 900-MP13PU-18 975-MP14WH-18 975-MP15WH-18 E907-MP7 GY-18 751-MP9 GN-18 752-MP10 YL-18 754-MP11 BU-18 751-M46 GN-18 752-M47 YL-18 754-M48 BU-18 E907-M45 GY-18 900-M50 PU-18 752-M47 YL-18 754-M48 BU-18 755-M49 OR-18 975-M164 WH-18 M-C11 1552269 3E3364 NOTE G 112-A11 PU-14 BUSS BAR A 1667418 FUSE BLOCK 1901030 FUSES:

9W1441 15A 9W1442 10A 9W1446 20A 1395345 5A 111-A3 YL-14 114-A6 RD-18 184-A7 BU-14 308-A10 YL-18 308-M80 YL-18 114-M72 RD-18 102-M61 RD-14 103-M77 RD-14 CONN 44 101-CF6 RD-4 CF-C4 1275483 CF-C5 1275484 1 1 CN-C2 1275484 CN-C3 1275483 200-CN6 BK-18 101-CN3 RD-4 229-C49 BK-14 207-C17 BK-18 403-C4 GN-18 200-C11 BK-18 CYL LIGHTS (STD/WD) BK-18 WH-18 XMSN OUT.

SP 1 1932550 1 2 PP-C4 1552269 E901-PP1 GN-18 E900-PP2 WH-18 E900-PP2 WH-18 E903-PP3 YL-18 E901-PP1 GN-18 E902-PP4 PU-18 E905-PP5 BU-18 3 4 5 6 7 8 E901-P8 GN-18 E902-P7 PU-18 E903-P6 YL-18 E905-P4 BU-18 E900-P1 WH-18 975-P19 WH-18 NOTE E 755-MP8 OR-18 900-MP13 PU-18 975-MP14 WH-18 975-MP15 WH-18 975-M30 WH-18 975-M29 WH-18 900-M50 PU-18 755-M49 OR-18 E900-M38 WH-18 E901-M39 GN-18 E902-M40 PU-18 E903-M41 YL-18 F788-M120 PU-18 975-M125 WH-18 3E3364 NOTE G 1 2 LEFT STEER CLUTCH 1744909 203-AG1 BK-18 MAIN RELAY 1670138 BUSS BAR B 1667419 105-A23 RD-18 KEY 15A FORWARD HORN 15A 114-A6 RD-18 158-A25 BR-14 207-A37 BK-18 116-A1 RD-14 160-A28 PU-18 103-A18 RD-12 116-M88 RD-14 158-M192 BR-14 207-M156 BK-18 103-M77 RD-14 160-M201 PU-18 106-M218 RD-18 104-M78 YL-14 105-M98 RD-18 106-M79 RD-18 106-M134 RD-18 200-M107 BK-10 301-CF7 BU-4 1 1 CONN 43 301-CN4 BU-4 CBL-AV1 BK-0 AY CBL-AT2 BK-00 109-HF1 RD-0 ALT + R ALTERNATOR 70A1855294 (STD) 75A 1890768 (ATCH) 100A 1764257 (ATCH) 100A 1940849 (ATCH) TP-C3 1552269 1 2 TP-C4 3E3364 200-TP4 BK-14 609-TP3 OR-14 CYL FLOOD STD2 1470319 1 2 PROD LINK ANTENNA 2076797 BK-18 WH-18 XMSN OUT.

SP 2 1932550 1 2 E904-PP6 BR-18 E907-PP7 GY-18 E907-PP7 GY-18 E906-PP8 OR-18 E906-PP8 OR-18 TRANSMISSION E904-P5 BR-18 E906-P3 OR-18 E907-P2 GY-18 NOTE E E904-M42 BR-18 E905-M43 BU-18 E906-M44 OR-18 E907-M45 GY-18 M-C12 1552269 DISCONNECT SW 7N0718 A-C2 3E3364 112-A42 PU-18 198-A5 RD-18 105-A41 RD-18 SERVICE BRAKE 15A 3 4 1 2 PRODUCT LINK 15A 106-A35 RD-18 198-A5 RD-18 302-A36 OR-18 108-A4 BU-16 124-A14 GN-14 198-M71 RD-18 302-M157 OR-18 124-M104 GN-14 108-M65 BU-16 108-M100 BU-16 108-M83 BU-16 108-M83 BU-16 102-M61 RD-14 200-M172 BK-10 PRELUBE RELAY 1790006 CE CYLINDER LIGHTS (10) FOR WDA 1 2 1 2 3 4 5 6 1 2 YL RD MOTOR CONSOLE MOTOR 1494889 J-C9 3E3364 DRIVE TRAIN CONTROL 140-J37 BU-14 176-J78 YL-18 J-C7 1552273 JA-C1 3E3382 CONN 20 751-M46 GN-18 752-M47 YL-18 754-M48 BU-18 755-M49 OR-18 F792-M20 WH-18 975-M24 WH-18 M-C14 1552269 1 2 LEFT BRAKE 1744909 CBL-AR1 BK-00 BUSS BAR C 1667417 FLYBACK DIODE 1893158 1 2 BK-18 BK-18 1 2 A-C7 1552269 308-A19 YL-18 200-A47 BK-18 110-A45 RD-14 197-A13 RD-14 5 6 AUX 3 15A AUX 4 10A FENDER FLOODS 15A FRONT FLOODS 15A 116-A1 RD-14 NOTE B 115-A46 RD-14 110-A45 RD-14 310-A39 PU-18 186-A44 RD-14 197-A13 RD-14 130-A43 GN-18 310-M84 PU-18 197-M86 RD-14 186-M208 RD-14 130-M176 GN-18 113-M135 OR-18 115-M205 RD-14 114-M72 RD-18 113-M99 OR-18 113-M75 OR-18 150-M62 RD-14 207-M156 BK-18 200-M178 BK-14 130-M176 GN-18 108-M65 BU-16 301-CF7 BU-4 101-CF6 RD-4 CF-C1 1552273 1 2 FRAME GROUND ENGINE BLOCK FRAME GROUND TN-C1 3E3364 1 2 610-TN4 OR-14 610-TN3 OR-14 200-TN5 BK-14 TN-C2 1552269 CYLINDER FLOOD 1 1470319 H CONSOLE SW 1107880 1 2 176-J78 YL-18 200-J81 BK-18 140-J70 BU-14 140-J71 BU-18 140-J64 BU-18 202-J41 BK-14 140-J49 BU-14 J-C1 1010205 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 GROUND + BATTERY PARK BRAKE DUMP VALVE THIRD GEAR CLUTCH 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 J-C2 3E6287 G730-J85 PK-18 754-J23 BU-18 321-J32 BR-18 306-J33 GN-18 200-J81 BK-18 278-J55 BK-18 277-J54 BK-18 276-J53 BK-18 1 2 3 4 5 6 1 2 3 4 5 6 200-JA1 BK-18 200-JA2 BK-18 200-JA3 BK-18 200-JA4 BK-18 111-7003 FTC-PLUG E900-M38 WH-18 E901-M39 GN-18 900-M50 PU-18 F791-M19 BU-18 975-M27 WH-18 3E3364 NOTE G 1 2 RIGHT BRAKE 1744909 START RELAY 1251302 308-A24 YL-18 200-A48 BK-18 186-A44 RD-14 24V-12V CONVERTER 20A 7 9 10 REAR FLOODS 15A 8 103-A18 RD-12 NOTE A 113-A2 OR-18 105-A23 RD-18 115-A46 RD-14 115-M205 RD-14 113-M135 OR-18 105-M98 RD-18 116-M88 RD-14 130-M176 GN-18 124-M104 GN-14 310-M84 PU-18 302-M157 OR-18 304-M96 WH-8 H-8 H-13 307-CF3 OR-18 A447-CF4 PK-18 200-CF2 BK-18 4 2 3 5 1 6 2 3 4 BK-16 GN-16 WH-16 YL-16 RD-16 PRESSURE SW (NC) GROUND KEY SWITCH (START) CRANKING MOTOR CTRL KEY SWITCH (RUN) 1 2 200-TN2 BK-14 200-TN5 BK-14 610-TN1 OR-14 610-TN4 OR-14 200-TN6 BK-14 610-TN3 OR-14 TN-C3 1552269 1 2 CYLINDER FLOOD 1 1470319 H LEFT STEERING LEVER POS 2144863 YL-18 BK-18 OR-18 +V GROUND SIGNAL J-C10 1552267 A B C 140-J77 BU-14 140-J63 BU-14 975-J39 WH-18 892-J35 BR-18 752-J22 YL-18 202-J52 BK-18 GROUND + BATTERY DATA LINK - FORWARD CLUTCH SOLENOID RETURN INCHING PEDAL SENSOR PRIORITY VALVE SOL RIGHT STEER SENSOR DIRECTION SENSOR SOLENOID RETURN K978-J48 BU-18 975-J50 WH-18 F843-J4 YL-18 851-J76 WH-18 830-J80 OR-18 G939-J58 PK-18 280-J57 BK-18 279-J56 BK-18 J-C12 9X4391 M-C36 1030213 CONN 21 E902-M40 PU-18 E903-M41 YL-18 E904-M42 BR-18 E905-M43 BU-18 E906-M44 OR-18 200-M114 BK-18 200-M114 BK-18 200-M212 BK-18 200-M212 BK-18 BK-18 BK-18 1 2 A-C3 1552269 306-A20 GN-18 304-A30 WH-8 304-A21 WH-18 111-A3 YL-14 184-A7 BU-14 11 12 AUX 6 10A AUX 1 10A WINCH 15A AUX 5 5A 160-A28 PU-18 130-A43 GN-18 150-A29 RD-14 176-A27 YL-14 102-A33 RD-14 104-A31 YL-14 102-M61 RD-14 150-M62 RD-14 150-M62 RD-14 104-M78 YL-14 176-M183 YL-14 140-M5 BU-14 140-M6 BU-14 140-M58 BU-18 140-M3 BU-14 140-M202 BU-18 103-M77 RD-14 403-M162 GN-18 893-M174 GN-18 892-M182 BR-18 113-CF1 BR-18 337-CF5 WH-18 PRELUBE TIMER D6 D7 1403108 1 5 6 310-C7 PU-18 108-C13 BU-16 200-C6 BK-14 322-C3 GY-18 403-C4 GN-18 SWEEP LIGHTING (08) 200-TN6 BK-14 TM-C2 1552269 RIGHT STEERING LEVER POS 2144863 J-C11 1552267 A B C 828-J79 WH-18 G939-J82 PK-18 893-J36 GN-18 G731-J30 GY-18 755-J24 OR-18 751-J21 GN-18 SERV BRAKE DUMP VALVE SECOND GEAR CLUTCH REVERSE CLUTCH DATA LINK + UNUSED XRANS SUMP TEMP SNSR LEFT STEER SENSOR IMPLMENT DETENT K977-J47 PK-18 334-J6 BU-18 828-J79 WH-18 E901-J14 GN-18 E900-J13 WH-18 E902-J15 PU-18 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 E900-M38 WH-18 E901-M39 GN-18 E902-M40 PU-18 E907-M45 GY-18 140-M3 BU-14 140-M6 BU-14 202-M198 BK-18 202-M148 BK-14 202-M76 BK-18 202-M148 BK-14 200-M81 BK-18 200-MC1 BK-6 101-A12 RD-14 200-A16 BK-18 104-A31 YL-14 15 16 13 14 AUX 2 15A A/C CONDENSOR 20A 158-A25 BR-14 200-A17 BK-18 106-A35 RD-18 200-M81 BK-18 106-M218 RD-18 N931-M133 GY-18 158-M144 BR-14 158-M192 BR-14 158-M185 BR- 14 113-M99 OR-18 113-M75 OR-18 108-M100 BU-16 105-M98 RD-18 610-C2 OR-14 F710-C31 BR-18 1 2 TM-C1 3E3364 1 2 610-TM1 OR-14 610-TM4 OR-14 610-TM3 OR-14 200-TM5 BK-14 610-TM4 OR-14 WDA FLOOD 2 1470319 YL-18 BK-18 OR-18 +V GROUND SIGNAL G939-J84 PK-18 830-J80 OR-18 140-J87 BU-14 F780-J65 PK-18 F788-J28 PU-18 280-J57 BK-18 G939-J60 PK-18 G939-J59 PK-18 SWITCH/SENSOR RETURN SWITCH/SENSOR RETURN + V SENSOR PARK BRAKE SW (N.C.) HARNESS CODE 4 LEFT STEER CLUTCH RIGHT BRAKE SOLENOID XRANS OUT SP - UNUSED UNUSED UNUSED E901-J14 GN-18 F791-J26 BU-18 709-J46 OR-18 E906-J19 OR-18 E905-J18 BU-18 E904-J17 BR-18 E903-J16 YL-18 E903-M41 YL-18 E904-M42 BR-18 E905-M43 BU-18 E906-M44 OR-18 176-M115 YL-18 202-M148 BK-14 202-M76 BK-18 200-M114 BK-18 202-M198 BK-18 202-M76 BK-18 MODULE 2 GROUND CASE GND 101-AA1 RD-0 BUSS BAR D 1698681 135A ALT BKR 1712213 109-A9 RD-18 124-A14 GN-14 RPR PIN/SEAT/WINCH 15A BLOWERS 20A 17 18 EMS II 10A WIPERS 10A 108-A4 BU-16 201-M145 BK-18 160-M201PU-18 176-M115 YL-18 114-M72 RD-18 115-M205 RD-14 116-M88 RD-14 124-M104 GN-14 1 2 3 BK-18 BK-18 REFRIGERANT SWITCH 1145333 1 2 CH-C2 1552269 513-CH3 OR-14 521-CH1 YL-14 200-TM2 BK-14 200-TM5 BK-14 200-TM6 BK-14 610-TM3 OR-14 200-TM6 BK-14 TM-C3 1552269 1 2 WDA FLOOD 2 1470319 WH-18 BK-18 OR-18 +BAT GROUND SIGNAL DIRECTION SENSOR 2144862 J-C8 1552267 A B C 140-J70 BU-14 G939-J83 PK-18 419-J66 YL-18 F781-J75 BR-18 900-J25 PU-18 F789-J29 YL-18 FIRST GEAR CLUTCH DOWNSHIFT SW (N.O.) PARK BRAKE SW (N.O.) RIGHT STEER CLUTCH LEFT BRAKE SOLENOID SERVICE BRAKE POS XRANS OUT SP + E900-J13 WH-18 F792-J27 WH-18 F790-J31 BR-18 754-J23 BU-18 E907-J20 GY-18 755-J24 OR-18 752-J22 YL-18 751-J21 GN-18 751-M46 GN-18 752-M47 YL-18 754-M48 BU-18 755-M49 OR-18 E907-M45 GY-18 334-M200 BU-18 306-M109 GN-18 321-M7 BR-18 202-M198 BK-18 200-M81BK-18 BUSS BAR A 1667418 BUSS BAR B 1667419 176-A27 YL-14 19 20 113-A2 OR-18 101-A12 RD-14 109-HF1 RD-0 186-M208 RD-14 176-M183 YL-14 176-M184 YL-18 186-M92 RD-14 176-M112 YL-14 186-M85 RD-14 140-M58 BU-18 158-M185 BR-14 160-M201 PU-18 176-M184 YL-18 140-M202 BU-18 GN-18 GN-18 A/C CLUTCH 1343998 1 2 CH-C3 1552269 3E3364 NOTE G 522-CH5 WH-14 513-CH4 OR-14 522-C16 WH-14 521-C15 YL-14 CYLINDER LIGHTS (10) FOR CONSTRUCTION APPL 851-J76 WH-18 F782-J68 OR-18 F783-J1 GN-18 F848-J10 OR-18 X743-J3 GY-18 UPSHIFT SW (N.C.) BI DIRECTION N.O.

IMPL LOCKOUT SWITCH REVERSE SW (N.O.) XRANS INPUT SP - 2F 2R IND LAMP UNUSED XRANS INT SP + E902-J15 PU-18 E909-J44 WH-18 973-J7 BR-18 900-J25 PU-18 X743-J3 GY-18 176-J78 YL-18 200-J81 BK-18 F842-M199 BU-18 176-M115 YL-18 200-M114 BK-18 900-M50 PU-18 337-M136 WH-18 709-M15 OR-18 892-M8 BR-18 450-M175 YL-18 140-M6 BU-14 140-M3 BU-14 106-M79 RD-18 106-M134 RD-18 CONN 38 304-A30 WH-8 A-C5 1275486 1 1 M-C15 1275485 304-M96 WH-8 198-M71 RD-18 197-M86 RD-14 200-M81 BK-18 198-M71 RD-18 200-M152 BK-14 200-M74 BK-10 200-M149 BK-10 3E3364 NOTE G 522-CH2 WH-14 CH-C1 1552269 CONN 46 C-C3 3E3364 TX-C1 3E3364 1 2 610-TX1 OR-14 610-TX4 OR-14 610-TX3 OR-14 200-TX5 BK-14 610-TX4 OR-14 TX-C2 1552269 WDA FLOOD 2 1470319 COM REVERSE SW 1236377 NC NO COM NC NO J-C3 1261710 F782-J68 OR-18 F786-J72 GY-18 J994-J88 GY-18 F784-J67 YL-18 277-J54 BK-18 276-J53 BK-18 UNUSED UNUSED AUTO DNSHIFT IND DOWNSHIFT SW (N.C.) UPSHIFT SW (N.O.) HARNESS CODE 1 HARNESS CODE 0 XRANS INPUT SP + XRANS OUT SP Q + UNUSED UNUSED E908-J43 BR-18 E906-J19 OR-18 G848-J9 GN-18 F846-J8 PU-18 973-J7 BR-18 F843-J4 YL-18 334-J6 BU-18 977-J5 YL-18 977-M113 YL-18 334-M200 BU-18 F843-M214 YL-18 893-M9 GN-18 975-M69 WH-18 975-M110 WH-18 975-M168 WH-18 176-M112 YL-14 200-M131 BK-14 176-M115 YL-18 158-M144 BR-14 200-M21 BK-14 BUSS BAR E 1698680 BUSS BAR E 1698680 BLOCK AS 1724863 109-HF2 RD-0 101-AA2 RD-0 200-M97 BK-14 200-M131 BK-14 200-M172 BK-10 200-M107 BK-10 200-M207 BK-14 201-M127 BK-18 201-M151 BK-18 201-M91 BK-18 201-M145 BK-18 DIODE 1068704 1 2 CH-C4 1552269 513-CH6 OR-14 522-CH7 WH-14 1 2 C-C101 1552269 NOTE G 1 2 1 2 521-C15 YL-14 522-C16 WH-14 1 2 200-TX2 BK-14 200-TX5 BK-14 200-TX6 BK-14 610-TX3 OR-14 200-TX6 BK-14 TX-C3 1552269 1 2 WDA FLOOD 2 1470319 SHIFT CONTROL 1250583 G939-J74 PK-18 J992-J89 YL-18 J993-J90 PK-18 F785-J62 WH-18 278-J55 BK-18 UNUSED UNUSED HARNESS CODE 2 XRANS OUT SP Q - XRANS INT SP Q - UNUSED 2F 1R IND LAMP UNUSED E907-J20 GY-18 E905-J18 BU-18 J994-J88 GY-18 G848-J9 GN-18 F849-J11 WH-18 F848-J10 OR-18 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 F849-M118 WH-18 F848-M117 OR-18 975-M32 WH-18 975-M30 WH-18 975-M29 WH-18 321-M7 BR-18 306-M109 GN-18 200-M160 BK-10 H-6 BUSS BAR D 1698681 BUSS BAR D 1698681 203-A15 BK-18 A-C6 1552269 1 2 1 2 AG-C1 3E3364 203-AG1 BK-18 101-AA1 RD-0 200-M18 BK-12 892-M122 BR-18 200-M130 BK-18 200-M105 BK-18 308-M80 YL-18 403-M194 GN-18 893-M111 GN-18 3E3364 NOTE G ENGINE NN-C2 7E6513 ENGINE G 4 3 2 1 UPSHIFT SW 1327450 GN-20 PK-20 WH-20 J-C5 1552273 F786-J72 GY-18 977-J5 YL-18 F850-J12 PK-18 F849-J11 WH-18 279-J56 BK-18 IMPLEMENT LOCKOUT SW BI DIRECTION N.C.

AUTO DOWNSHIFT SW HARNESS CODE 3 REVERSE SW (N.C.) ENGINE SPEED SENSOR XRANS INT SP Q + XRANS INT SP - BACK UP ALARM E904-J17 BR-18 E903-J16 YL-18 F846-J8 PU-18 450-J45 YL-18 321-J32 BR-18 K977-J47 PK-18 G848-J9 GN-18 G939-J58 PK-18 G939-J38 PK-18 G939-J40 PK-18 F792-J27 WH-18 F791-J26 BU-18 G731-J30 GY-18 F789-J29 YL-18 F788-J28 PU-18 F788-M120 PU-18 F791-M19 BU-18 F789-M116 YL-18 G731-M36 GY-18 F792-M20 WH-18 975-M33 WH-18 975-M34 WH-18 975-M31 WH-18 975-M23 WH-18 892-M8 BR-18 403-M177 GN-18 592-M73 BU-14 892-M123 BR-18 203-AG1 BK-18 203-AG1 BK-18 FUSE PANEL CONN 37 207-M156 BK-18 302-M157 OR-18 306-M109GN-18 304-M96 WH-8 201-M145 BK-18 N931-M133GY-18 106-M79 RD-18 140-M6 BU-14 140-M3 BU-14 106-M134 RD-18 XMSN SUMP TEMP SNSR 1187226 A B C GROUND +8V OR-18 BK-18 WH-18 A B C C-C5 1552267 709-C60 OR-18 G939-C55 PK-18 A701-NN1 GY-16 L983-NN19 WH-16 1 2 INJECTOR 1 1906017 N-C4 3E3370 A B C G 1 2 6 F783-J1 GN-18 F785-J62 WH-18 G939-J2 PK-18 140-J64 BU-18 J995-J91 PU-18 140-J37 BU-14 UNUSED + BATTERY ECB CONTROL 1729389 UNUSED 1F 2R IND LAMP F847-J51 YL-18 140-J37 BU-14 K978-J48 BU-18 975-J50 WH-18 975-J92 WH-18 F790-J31 BR-18 321-J32 BR-18 306-J33 GN-18 337-J34 WH-18 F790-M57 BR-18 321-M7 BR-18 306-M109 GN-18 337-M136 WH-18 140-M3 BU-14 975-M25 WH-18 975-M66 WH-18 893-M9 GN-18 893-M124 GN-18 892-M161 BR-18 893-M165 GN-18 101-AA1 RD-0 310-M84 PU-18 308-M80 YL-18 403-M194 GN-18 176-M115 YL-18 158-M144 BR-14 176-M112 YL-14 SIGNAL C-C16 1552269 K977-C61 PK-18 K737-NN13 BR-16 K739-NN16 BU-16 NN-C3 7E6513 NOTE C N940-N49 BU-16 N941-N42 YL-16 A745-N12 WH-16 FUEL PRESS SNSR CONNECTOR (CAPPED) 4 3 2 1 DOWNSHIFT SW 1327419 YL-20 RD-20 BR-20 3 4 5 F781-J75 BR-18 F784-J67 YL-18 G939-J69 PK-18 140-J49 BU-14 202-J41 BK-14 306-J33 GN-18 306-J33 GN-18 337-J34 WH-18 337-J34 WH-18 176-J78 YL-18 176-J78 YL-18 200-J81 BK-18 200-J81 BK-18 975-J39 WH-18 975-J93 WH-18 893-J36 GN-18 892-J35 BR-18 140-J37 BU-14 G939-J38 PK-18 892-M8 BR-18 G939-M181 PK-18 893-M9 GN-18 975-M27 WH-18 975-M164 WH-18 975-M24 WH-18 975-M29 WH-18 20A CONVERTER 403-M177 GN-18 403-M162 GN-18 592-M73 BU-14 200-M160 BK-10 200-M131 BK-14 200-M21 BK-14 200-M81 BK-18 GN-18 GN-18 D7 PRIORITY VALVE 1361679 1 2 975-C59 WH-18 K978-C58 BU-18 A701-NN1 GY-16 A702-NN2 PU-16 A702-NN2 PU-16 A703-NN3 BR-16 L983-NN18 WH-16 1 2 INJECTOR 2 1906017 996-N40 GN-16 N-C5 3E3370 A B C OR-18 BK-18 WH-18 BACKUP SP/TMG SNSR 1296628 GROUND +V 279-J56 BK-18 278-J55 BK-18 277-J54 BK-18 276-J53 BK-18 202-J52 BK-18 851-J76 WH-18 851-J76 WH-18 G730-J86 PK-18 G730-J86 PK-18 830-J80 OR-18 830-J80 OR-18 828-J79 WH-18 828-J79 WH-18 277-J54 BK-18 276-J53 BK-18 202-J52 BK-18 202-J41 BK-14 202-J41 BK-14 140-J49 BU-14 E908-J43 BR-18 E909-J44 WH-18 G939-J40 PK-18 975-J92 WH-18 G939-M12 PK-18 E908-M11 BR-18 E908-M11 BR-18 E909-M13 WH-18 202-M148 BK-14 975-M33 WH-18 E909-M13 WH-18 977-M113 YL-18 975-M125 WH-18 975-M30 WH-18 975-M110 WH-18 +24V SWITCHED IN UNUSED 1 2 3 4 5 6 20A CONVERTER 1843579 PLUG M-C25 HERE WHEN 20A CONV IS USED 186-MG1 WH-14 WHEN USED PLUG INTO M-C20 892-M8 BR-18 403-M177 GN-18 306-M109 GN-18 592-M73 BU-14 ECPC XMSN IP SP 1932250 BK-18 WH-18 1 2 C-C17 1552269 E909-C57 WH-18 E908-C56 BR-18 NOTE E A704-NN4 GN-16 A705-NN5 BU-16 A706-NN6 GY-16 K738-NN9 GN-16 A703-NN3 BR-16 NN-C4 7E6513 1 INJECTOR 3 1906017 N944-N38 PU-16 F732-N56 PK-16 N-C7 1552269 N-C6 3E3364 1 2 SIGNAL WH/BU-18 10 11 3 4 5 6 7 8 1 2 12 9 10 11 J-C6 1552252 755-J24 OR-18 752-J22 YL-18 751-J21 GN-18 280-J57 BK-18 G939-J38 PK-18 G939-J38 PK-18 G939-J40 PK-18 G939-J40 PK-18 G939-J58 PK-18 G939-J58 PK-18 751-J21 GN-18 280-J57 BK-18 279-J56 BK-18 278-J55 BK-18 K977-J47 PK-18 G730-J42 PK-18 709-J46 OR-18 450-J45 YL-18 450-M175 YL-18 K977-M16 PK-18 709-M15 OR-18 G730-M35 PK-18 F790-M57 BR-18 F791-M19 BU-18 F789-M116 YL-18 F788-M120 PU-18 450-M175 YL-18 UNUSED +12V MEMORY OUT UNUSED UNUSED MG-C2 1779654 200-MG2 BK-12 CONV BKR 1 3T2662 MG-C1 1779649 892-M8 BR-18 892-M122 BR-18 892-M182 BR-18 892-M123 BR-18 892-M161 BR-18 893-M9 GN-18 893-M124 GN-18 892-M123 BR-18 TC OUT TEMP SENDER 4W9972 1 2 200-PT1 BK-18 PT-C1 3E3364 1 2 C-C18 1552269 CONN 47 443-C51 YL-18 K737-NN11 BR-16 K737-NN13 BR-16 K737-NN14 BR-16 K739-NN17 BU-16 K739-NN17 BU-16 K739-NN15 BU-16 K738-NN9 GN-16 L984-NN21 OR-16 2 NOTE C F724-N4 PU-16 F732-N31 PK-16 1 2 CABLE AS.

7X1695 ADAPTER 6V3093 F732-N56 PK-16 WH-18 YL-18 PK-18 RD-18 BR-18 3 4 5 6 7 8 G939-J73 PK-18 419-J66 YL-18 F780-J65 PK-18 893-J36 GN-18 892-J35 BR-18 G731-J30 GY-18 F789-J29 YL-18 F788-J28 PU-18 893-J36 GN-18 892-J35 BR-18 755-J24 OR-18 752-J22 YL-18 K978-J48 BU-18 F847-J51 YL-18 202-J52 BK-18 140-J49 BU-14 975-J93 WH-18 K978-M17 BU-18 140-M6 BU-14 202-M76 BK-18 975-M34 WH-18 F848-M117 OR-18 F842-M199 BU-18 F849-M118 WH-18 F843-M214 YL-18 F792-M20 WH-18 E793-M167 BU-18 975-M69 WH-18 709-M15 OR-18 E794-M158 YL-18 H-7 +24V BATTERY IN GROUND +12V OUTPUT 1 2 3 4 1 2 3 4 592-MG4 BU-12 592-MG5 BU-12 592-MG6 BU-12 592-MG7 BU-14 200-MG2 BK-12 186-MG1 WH-14 592-MG5 BU-12 CONV BKR 2 3T2662 15A 592-MG3 BU-12 186-MG1 WH-14 592-MG7 BU-14 592-MG3 BU-12 200-MG2 BK-12 1 2 3 4 892-M161 BR-18 893-M165 GN-18 893-M111 GN-18 893-M174 GN-18 104-M78 YL-14 893-M165 GN-18 ENGINE SP 1895746 BK-18 WH-18 ° T 1 2 C-C19 1552269 450-C53 YL-18 201-C52 BK-18 K739-NN7 BU-16 L983-NN12 WH-16 K739-NN16 BU-16 L983-NN19 WH-16 L983-NN18 WH-16 A704-NN4 GN-16 NN-C5 7E6513 1 INJECTOR 4 1906017 WHEN USED PLUG INTO N-C7 TRANSDUCER-MAGNETIC 6V2197 GY-18 OR-18 GN-18 BK-18 BU-18 VI-18 1 2 140-J71 BU-18 306-J33 GN-18 975-J39 WH-18 900-J25 PU-18 X743-J3 GY-18 977-J5 YL-18 900-J25 PU-18 F789-J29 YL-18 F788-J28 PU-18 J992-J89 YL-18 J993-J90 PK-18 J995-J91 PU-18 F850-J12 PK-18 F850-M217 PK-18 G730-M35 PK-18 F850-M217 PK-18 K977-M16 PK-18 E908-M11 BR-18 K978-M17 BU-18 E909-M13 WH-18 592-MG6 BU-12 15A N931-M133 GY-18 893-M9 GN-18 893-M124 GN-18 197-M86 RD-14 186-M92 RD-14 186-M85 RD-14 G939-C54 PK-18 NOTE E L984-NN10 OR-16 L984-NN21 OR-16 L984-NN20 OR-16 L984-NN20 OR-16 NN-C6 7E6513 2 N-C8 3E3370 A B C 12 9 G730-J86 PK-18 337-J34 WH-18 977-J5 YL-18 F850-J12 PK-18 F850-J12 PK-18 F849-J11 WH-18 F849-J11 WH-18 F848-J10 OR-18 F848-J10 OR-18 G731-J30 GY-18 NOTE E NOTE E G731-M59 GY-18 G731-M36 GY-18 G731-M37 GY-18 592 BU-14 RECEPTACLE AS 1855627 1 2 3 4 1 2 3 4 M-C20 1779654 200-M18 BK-12 186-M85 RD-14 200-M97 BK-14 200-M18 BK-12 200-M105 BK-18 200-M130 BK-18 L985-NN8 YL-16 L985-NN23 YL-16 L985-NN23 YL-16 L985-NN22 YL-16 A705-NN5 BU-16 1 2 INJECTOR 5 1906017 996-N41 GN-16 N944-N39 PU-16 999-N30 WH-16 OR-18 BK-18 WH-18 SP/TMG SNSR 1296628 GROUND +5V SIGNAL F PARKING BRAKE SW 1180639 J994-J88 GY-18 J992-J89 YL-18 J992-J89 YL-18 J993-J90 PK-18 J993-J90 PK-18 J995-J91 PU-18 J995-J91 PU-18 DRIVE TRAIN CONTROL J994-J88 GY-18 X743-J3 GY-18 K978-M17 BU-18 G939-M181 PK-18 G939-M12 PK-18 K977-M16 PK-18 201-M147 BK-18 200-M206 BK-14 200-M166 BK-14 200-M203 BK-18 201-M142 BK-18 M-C25 1552273 592-M188 BU-12 592-M73 BU-14 592-M73 BU-14 K737-NN14 BR-16 K739-NN15 BU-16 NN-C7 7E6513 NOTE C N940-N50 BU-16 CONN 56 N-C9 1042921 A B C NG-C2 1042921 NG-C1 3E3370 A B C 997-NJ1 OR-16 993-NJ2 BR-16 A745-NJ3 WH-16 OR-18 BK-18 WH-18 INLET AIR TEMP 1078618 GROUND +5V F ROPS A/C M-C31 7T5957 200-M206 BK-14 158-M144 BR-14 106-M134 RD-18 200-M131 BK-14 201-M154 BK-18 290-M139 BK-18 202-M198 BK-18 291-M141 BK-18 10A CONVERTER 2090381 +24 V BATTERY IN +24 V SWITCHED IN GROUND +12 V MEMORY OUT +12 V SWITCHED OUT GROUND 1 2 3 4 5 6 1 2 3 4 5 6 308-M216 YL-18 186-M92 RD-14 200-M130 BK-18 104-M78 YL-14 197-M86 RD-14 186-M92 RD-14 186-M85 RD-14 H-5 A706-NN6 GY-16 L985-NN22 YL-16 1 2 INJECTOR 6 1906017 C967-N9 BU-16 N941-N44 YL-16 SIGNAL ROPS CONDENSOR RLY 3E5239 3 4 87A 30 1 TC-C4 9X1054 CONN 1 CONN 2 CONN 15 12V OUTLET 1 1172311 1 2 M-C26 7T5957 592-M73 BU-14 200-M21 BK-14 201-M154 BK-18 201-M142 BK-18 200-M21 BK-14 201-M147 BK-18 308-M169 YL-18 447-M150 PK-18 521-M159 YL-14 334-M200 BU-18 337-M136 WH-18 A513-M94 PK-18 200-M105 BK-18 200-M105 BK-18 592-M128 BU-18 200-M18 BK-12 200-M97 BK-14 200-M130 BK-18 CONN 48 FLEXXAIRE FAN (CUSTOM PRODUCT) CY-C2 1552267 A B C BK-18 RD-18 WH-18 1 2 3 4 FLEXXAIRE FAN SW 1339405 A745-N12 WH-16 995-N13 BU-16 N941-N48 YL-16 N940-N51 BU-16 N-C10 1042921 COOLANT TEMP SENS 1022240 A B C A B C OR-18 BK-18 WH-18 GROUND +5V SIGNAL ROPS COND 1741495 MOTOR BK-14 WH/RD-14 TC-C1 1552269 1 2 200-TC6 BK-14 158-TC1 BR-14 593-TC8 GN-14 5 86 85 87 2 TC-C2 3E3370 A B C TF-C2 1552267 A B C 158-TF1 BR-14 521-TF2 YL-14 200-TF3 BK-14 TF-C1 1552267 A B C A B C T-C4 3E3370 A B C 155-2267 NOTE G 521-T14 YL-14 158-T15 BR-14 12V OUTLET 2 1172311 1 2 592-M129 BU-14 200-M131 BK-14 SEAT SUSPENSION 1912933 291-M141 BK-18 447-M150 PK-18 521-M159 YL-14 290-M139 BK-18 592-M129 BU-14 608-M155 GN-14 609-M204 YL-14 H-11 ACCESSORY POWER CONNECTOR (UNSWITCHED) CONN 36 1 2 M-C21 1552269 200-M97 BK-14 197-M86 RD-14 308-M216 YL-18 200-M87 BK-14 592-M73 BU-14 H-10 998-CJ7 BR-18 N942-CJ4 OR-18 CJ-C2 3E3364 1 2 1 2 CY-C1 1552269 N942-CY1 OR-18 998-CY2 BR-18 A701-NN1 GY-16 A702-NN2 PU-16 A703-NN3 BR-16 A704-NN4 GN-16 A705-NN5 BU-16 A706-NN6 GY-16 K739-NN7 BU-16 L985-NN8 YL-16 K738-NN9 GN-16 L984-NN10 OR-16 K737-NN11 BR-16 L983-NN12 WH-16 A751-N3 YL-16 A746-N19 PK-16 A747-N17 GY-16 F732-N31 PK-16 N-C11 3E3370 A B C ROPS COND 2 1741495 TC-C3 1552269 593-TC8 GN-14 593-TC7 GN-14 593-TC9 GN-14 200-TC5 BK-16 200-TC3 BK-14 521-TC2 YL-16 T-C104 1552267 NOTE G 200-T13 BK-14 MONITOR SERVICE CONNECTOR CONN 14 1 2 M-C30 1965330 290-M139 BK-18 291-M141 BK-18 RD-16 MOTOR BK-16 608-M155 GN-14 609-M204 YL-14 592-M129 BU-14 E735-M140 PU-18 592-M73 BU-14 977-M113 YL-18 975-M168 WH-18 630-M64 GY-16 780-M171 PU-18 779-M170 WH-18 ACCESSORY POWER CONNECTOR (SWITCHED) 3E3364 NOTE G 1 2 M-C27 3E3364 104-M78 YL-14 200-M87 BK-14 A513-M94 PK-18 592-M128 BU-18 592-M188 BU-12 998-CJ6 BR-18 CJ-C3 1552272 3 4 GN-18 BK-18 FLEXXAIRE FAN SOL 3E9205 BK-18 GN-18 COIL S-1 996-N40 GN-16 996-N1 GN-16 994-N8 GY-16 F724-N4 PU-16 995-N13 BU-16 A746-N19 PK-16 N941-N43 YL-16 N940-N52 BU-16 OR-18 YL-18 GN-18 GROUND +5V SIGNAL TURBO OUTLET PRESS.

1619927 MOTOR BK-14 WH/RD-14 1 2 200-TC4 BK-14 593-TC7 GN-14 ROPS A/C 200-TC6 BK-14 200-TC4 BK-14 158-T15 BR-14 200-T7 BK-14 3 4 E735-M140 PU-18 E735-M140 PU-18 201-M142 BK-18 M-C24 1552269 E793-M167 BU-18 E794-M158 YL-18 892-M123 BR-18 893-M124 GN-18 F790-M57 BR-18 F842-M199 BU-18 F843-M214 YL-18 CONN 35 1552269 NOTE G F708-CJ2 YL-18 F709-CJ3 BU-18 998-CJ5 BR-18 1 2 COIL S-2 N-C2 1552252 NN-C1 3E7990 1 2 3 4 5 6 7 8 9 10 11 12 1 2 3 4 5 6 7 8 9 10 11 12 CONN 53 C967-N9 BU-16 999-N30 WH-16 996-N41 GN-16 N941-N47 YL-16 N940-N53 BU-16 N-C12 3E3370 A B C OR-18 YL-18 GN-18 ATM PRESSURE 1946722 GROUND +5V ROPS LIGHTING (STD,WD) CONN 3 200-T8 BK-14 200-T6 BK-14 200-T13 BK-14 CONN 13 M-C18 9W1951 A B C D E F G H J 106-M134 RD-18 201-M147 BK-18 NOTE E 176-M112 YL-14 200-M203 BK-18 200-M166 BK-14 3E3364 NOTE G 1 2 1 2 200-M14 BK-14 200-M153 BK-14 G731-M59 GY-18 F849-M118 WH-18 F850-M217 PK-18 F848-M117 OR-18 H-6 CONN 42 C-C7 1552272 CJ-C1 3E3376 A701-N6 GY-16 A702-N10 PU-16 A703-N15 BR-16 A704-N18 GN-16 A705-N23 BU-16 A706-N28 GY-16 L985-N22 YL-16 L984-N14 OR-16 L983-N5 WH-16 N940-N50 BU-16 N940-N52 BU-16 N940-N49 BU-16 A747-N17 GY-16 N-C13 3E3370 A B C NJ-C2 1042921 CONN 55 SIGNAL NJ-C1 3E3370 A B C ENGINE OIL PRESS.

1619930 E 1 2 TR-C1 1552269 1 2 608-TR2 GN-14 200-TR4 BK-14 TR-C3 3E3376 1 2 1 2 T-C3 1552272 200-T6 BK-14 608-T4 GN-14 200-T17 BK-14 200-T18 BK-14 200-T10 BK-14 DATALINK SERVICE CONNECTOR 892-M123 BR-18 893-M124 GN-18 630-M64 GY-16 321-M7 BR-18 200-M160 BK-10 G939-M12 PK-18 G939-M181 PK-18 H-7 H-7 H-11 998-C47 BR-18 N942-CJ4 OR-18 N942-C20 OR-18 F708-C18 YL-18 F709-C19 BU-18 1 2 3 4 1 2 3 4 F709-CJ3 BU-18 998-CJ1 BR-18 998-CJ5 BR-18 F708-CJ2 YL-18 N940-N29 BU-16 N940-N51 BU-16 N940-N53 BU-16 N940-N54 BU-16 N940-N54 BU-16 N940-N55 BU-16 994-N8 GY-16 N941-N45 YL-16 A B C 997-NJ1OR-16 993-NJ2BR-16 A745-NJ3WH-16 OR-18 YL-18 GN-18 GROUND +5V SIGNAL E FUEL TANK FLOOD LIGHT 1 1470319 609-TR3 YL-14 200-TR1 BK-14 TR-C2 1552269 T-C101 3E3376 NOTE G 3 4 3 4 3 4 200-T18 BK-14 609-T21 YL-14 200-T22 BK-16 200-T16 BK-14 CONN 12 T-C7 3E5179 M-C23 1552252 E794-M158 YL-18 E793-M167 BU-18 780-M171 PU-18 779-M170 WH-18 975-M110 WH-18 516-EE2 GN-14 OPERATOR PLATFORM EE-C1 1698668 BLOWER1 1741504 BK-14 WH/RD-14 JE-C1 1552264 1 2 3 4 5 6 7 8 JM-C1 1552264 1958710 D7 EEC CODE PLUG E-C17 3E3388 CONN 30 OPERATOR PLATFORM C-C100 3E3376 NOTE G N942-CJ4 OR-18 998-CJ6 BR-18 998-CJ7 BR-18 N941-N45 YL-16 N941-N43 YL-16 N941-N44 YL-16 N941-N42 YL-16 N940-N55 BU-16 N-C14 1042921 OR-18 BK-18 WH-18 FUEL TEMP SENS 1022240 A B C A B C GROUND +5V 1 2 608-T3 GN-14 608-T4 GN-14 521-T14 YL-14 321-T24 BR-18 630-T9 GY-16 158-T15 BR-14 200-T10 BK-14 608-T1 GN-14 521-T14 YL-14 3 4 5 6 7 8 9 10 11 12 3 4 5 6 7 8 9 10 11 12 1 2 1 2 608-M155 GN-14 521-M159 YL-14 158-M144 BR-14 200-M153 BK-14 176-M112 YL-14 200-M166 BK-14 C568-EE7 WH-14 517-EE1 BU-14 BLOWER RESISTOR 1259740 A B C D 515-EE3 GY-14 200-EE9 BK-14 1 2 MOTOR 201-JM1 BK-18 270-E70 BK-18 271-E58 BK-18 272-E63 BK-18 273-E67 BK-18 1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 200-JE1 BK-18 184-6633 D7 STD CODE PLUG 201-C52 BK-18 CONN 52 N944-N38 PU-16 N944-N24 PU-16 N941-N25 YL-16 N941-N46 YL-16 N941-N46 YL-16 N941-N47 YL-16 N941-N48 YL-16 A751-N3 YL-16 SIGNAL TV-C1 1552269 1 2 ROPS FLOOD LAMP STD WD 1 1470139 TV-C3 3E3376 T-C5 1552272 CONN 4 609-T21 YL-14 608-T1 GN-14 447-T11 PK-18 201-T12 BK-18 200-T16 BK-14 609-T19 YL-14 609-M204 YL-14 200-M206 BK-14 201-M154 BK-18 447-M150 PK-18 200-HH7 BK-16 200-HH6 BK-16 LEFT WASHER 7T8891 1 2 MOTOR 529-HH3 WH-16 4 SPEED BLOWER SW 1571361 E-C2 1552273 515-EE6 GY-14 515-EE3 GY-14 515-EE4 GY-14 515-EE5 GY-14 200-EE8 BK-14 515-EE4 GY-14 EE-C2 1698668 1 2 BLOWER2 1741504 MOTOR BK-14 WH/RD-14 201-JM2 BK-18 201-JM3 BK-18 274-E65 BK-18 275-E60 BK-18 201-E71 BK-18 200-JE3 BK-18 200-JE4 BK-18 200-JE2 BK-18 103-E55 RD-18 103-E7 RD-18 CONN 41 M-C33 3E3370 NOTE G A B C 997-C28 OR-18 993-C29 BR-18 C-C6 3E3370 A B C A B C OR-18 YL-18 GN-18 TURBO INLET PRESS SENS 1619926 GROUND +5V NOTE E 975-C59 WH-18 709-C60 OR-18 450-C53 YL-18 443-C51 YL-18 C-C13 1552264 1 2 1 2 3 4 5 6 7 8 N-C3 3E3385 F700-N11 BU-16 N944-N39 PU-16 FUEL TANK FLOOD LIGHT 2 1470319 1 2 608-TV2 GN-14 609-TV3 YL-14 200-TV4 BK-14 200-TV1 BK-14 1 2 3 4 1 2 3 4 3 4 200-T17 BK-14 609-T20 YL-14 608-T3 GN-14 200-T8 BK-14 609-T20 YL-14 609-T19 YL-14 779-T5 WH-18 780-T2 PU-18 779-T5 WH-18 200-T7 BK-14 630-T9 GY-16 200-M14 BK-14 630-M64 GY-16 779-M170 WH-18 780-M171 PU-18 FRONT WASHER 7T8891 HH-C2 3T4412 1 5 4 3 WH-14 6 BK-14 GY-14 GN-14 BU-14 1 6 5 4 3 2 6 1 5 4 3 124-E30 GN-14 C568-E25 WH-14 516-E27 GN-14 515-E26 GY-14 200-EE10 BK-14 200-EE9 BK-14 200-EE8 BK-14 522-EE12 WH-14 200-EE11 BK-14 + BATTERY GROUND 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 E-C7 8T9834 201-E57 BK-18 113-E74 OR-18 NOTE E 201-E71 BK-18 411-E1 PK-18 201-E99 BK-18 201-E71 BK-18 600-E94 BR-18 103-E36 RD-14 105-E5 RD-18 113-M99 OR-18 307-M143 OR-18 337-M138 WH-18 M-C32 1552267 A B C CF-C2 3E3370 A B C 307-CF3 OR-18 113-CF1 BR-18 337-CF5 WH-18 H-13 F714-C30 PK-18 SIGNAL F708-C18 YL-18 F709-C19 BU-18 E909-C57 WH-18 E908-C56 BR-18 G939-C55 PK-18 G939-C54 PK-18 F702-C27 GN-18 F714-C30 PK-18 3 4 5 6 7 8 F713-N27 OR-16 F702-N26 GN-16 F704-N20 OR-16 F714-N2 PK-16 E799-N7 BR-16 TV-C2 1552269 1 2 T-C100 3E3376 NOTE G 975-T23 WH-18 780-T2 PU-18 447-T11 PK-18 201-T12 BK-18 321-T24 BR-18 975-T23 WH-18 T-C8 3E3364 1 2 1 2 M-C10 1552269 975-M110 WH-18 2 1 MOTOR HH-C3 3T4412 506-HH4 PU-16 2 BR-14 2 567-E29 WH-14 517-E28 BU-14 CONN 27 THERMOSTAT 3E5464 ° T CAT DATA LINK + HARNESS CODE 5 HARNESS CODE 1 ACTION ALARM 271-E58 BK-18 275-E60 BK-18 893-E59 GN-18 410-E37 WH-18 ACTION LAMP 1230304 1 2 C E-C25 1182765 663-E103 GY-18 113-E74 OR-18 200-E95 BK-18 307-M143 OR-18 337-M137 WH-18 337-M136 WH-18 FOR ENGINE PRELUBE PLUG CF-C1 INTO M-C32 CONN 49 997-C28 OR-18 993-C29 BR-18 F714-C30 PK-18 K977-C61 PK-18 K978-C58 BU-18 108-C13 BU-16 T920-N21 YL-16 F701-N16 BR-16 ADEM-II ENGINE CONTROL 1457806 ROPS FLOOD LAMP STD WD 2 1470139 OPERATOR PLATFORM CONN 11 321-M7 BR-18 REAR WASHER 7T8891 200-HH5 BK-16 522-E92 WH-14 522-E92 WH-14 200-E93 BK-14 C568-E25 WH-14 E-C14 1552273 1 2 3 4 5 6 1 2 3 4 5 6 EE-C3 3E3382 C568-EE7 WH-14 HYD OIL TEMP FUEL LEVEL 10 442-E62 GY-18 447-E61 PK-18 411-E113 PK-18 201-E99 BK-18 201-E52 BK-18 200-E97 BK-18 200-E105 BK-18 200-E104 BK-18 113-M99 OR-18 103-M77 RD-14 105-M98 RD-18 H-7 975-M69 WH-18 709-M15 OR-18 450-M175 YL-18 NOTE E M-C22 3E6286 C-C1 1130580 998-C47 BR-18 N942-C20 OR-18 207-C17 BK-18 304-C50 WH-8 200-C6 BK-14 302-C45 OR-18 C-C14 3E6286 12 18 12 18 J1 (A KEY) J2 (B KEY) OPTIONAL ACTIVE SP/TMG PWR TURBO INLET PRESSURE 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 1 2 3 4 N-C1 3E6287 F724-N4 PU-16 A751-N3 YL-16 F714-N2 PK-16 996-N1 GN-16 E799-N7 BR-16 F700-N11 BU-16 CAB 200-HH8 BK-16 2 1 MOTOR HH-C4 3T4412 507-HH1 WH-16 E-C21 3E7996 A/C SW 1259257 A B A B 600-E81 BR-18 200-E82 BK-18 515-E26 GY-14 517-E28 BU-14 516-E27 GN-14 200-E93 BK-14 522-E92 WH-14 522-EE12 WH-14 200-EE10 BK-14 515-EE6 GY-14 516-EE2 GN-14 517-EE1 BU-14 CAT DATA LINK - HARNESS CODE 2 ACTION LAMP SPI LOAD 14 12 13 15 11 272-E63 BK-18 892-E64 BR-18 411-E79 PK-18 C414-E40 BU-18 411-E79 PK-18 RESISTOR 1166203 1 2 E-C15 1552269 663-E103 GY-18 411-E1 PK-18 291-E75 BK-18 290-E76 BK-18 201-E57 BK-18 403-E69 GN-18 201-E53 BK-18 NOTE E E-C1 1030213 M-C2 9X4391 CONN 34 NOTE E 115-M205 RD-14 116-M88 RD-14 108-M100 BU-16 114-M72 RD-18 113-M75 OR-18 200-M203 BK-18 200-M166 BK-14 E909-M13 WH-18 E908-M11 BR-18 E794-M158 YL-18 E793-M167 BU-18 310-M84 PU-18 200-M178 BK-14 302-M157 OR-18 610-M186 OR-14 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 522-C16 WH-14 310-C7 PU-18 610-C2 OR-14 302-C45 OR-18 200-C6 BK-14 521-C15 YL-14 522-C16 WH-14 310-C7 PU-18 403-C4 GN-18 322-C3 GY-18 102-C22 RD-14 F715-C32 PU-18 E793-C40 BU-18 229-C49 BK-14 892-C43 BR-18 1 2 3 4 5 6 7 8 9 10 11 1 2 3 4 5 6 7 8 9 10 11 ATA DATALINK - THROTTLE SW (LOW IDLE) CAT DATALINK - +BATTERY (UNSWITCHED) GROUND +BATTERY (SWITCHED) ATA DATALINK + THROTTLE SW (LOW IDLE PARITY) CAT DATALINK + 3.5A DRVR & OPT SOL RTRN} ENGINE OIL PRESSURE INLET AIR TEMP BOTTOM SP/TMG-/TDC PROBE - FUEL TEMPERATURE INJECTOR COMMON 1 & 2 INJECTOR 1 6 7 8 9 10 11 12 13 14 15 16 C967-N9 BU-16 994-N8 GY-16 E799-N7 BR-16 A701-N6 GY-16 L983-N5 WH-16 F713-N27 OR-16 F704-N20 OR-16 F702-N26 GN-16 F701-N16 BR-16 D LEFT SPEAKER 6T7695 RIGHT WASHER 7T8891 2 1 MOTOR 530-HH2 OR-16 2 3 1 4 3 2 5 567-E29 WH-14 KEY START SW 1428858 R E-C6 1552272 OPERATOR SW INPUT HARNESS CODE 4 16 17 20 19 18 E735-E23 PU-18 274-E65 BK-18 LIGHT PIPE2 1239294 600-E94 BR-18 426-E66 BR-18 443-E68 YL-18 442-E62 GY-18 447-E61 PK-18 124-E30 GN-14 608-E32 GN-14 113-E74 OR-18 201-E15 BK-18 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 113-M75 OR-18 608-M155 GN-14 201-M151 BK-18 124-M104 GN-14 140-M58 BU-18 158-M185 BR-14 124-M104 GN-14 140-M202 BU-18 200-M206 BK-14 201-M154 BK-18 201-M142 BK-18 201-M147 BK-18 102-M61 RD-14 K978-M17 BU-18 K977-M16 PK-18 322-M90 GY-18 522-M193 WH-14 108-M65 BU-16 521-M67 YL-14 322-C3 GY-18 521-C15 YL-14 108-C13 BU-16 610-C2 OR-14 F710-C31 BR-18 229-C49 BK-14 150-C8 RD-14 F716-C33 WH-18 E794-C44 YL-18 893-C5 GN-18 A701-N6 GY-16 A702-N10 PU-16 A703-N15 BR-16 A704-N18 GN-16 T920-N21 YL-16 F714-N2 PK-16 A701-N6 GY-16 D -+ 509-HA10 WH-18 508-HA11 PU-18 504-HA3 YL-18 HA-C1 1552273 1 2 4 GN-16 GND MOTOR L H HH-C5 3T4412 6 C D D C 200-E83 BK-18 521-E84 YL-18 200-E82 BK-18 124-E30 GN-14 567-E29 WH-14 ST ON OFF B S C YL-16 OR-16 BR-16 PU-16 1 2 3 4 1 2 3 4 307-E4 OR-18 105-E5 RD-18 308-E3 YL-18 326-E51 PU-18 POWERTRAIN FILTER HARNESS CODE 3 SENSOR SUPPLY SERVICE 23 22 24 273-E67 BK-18 290-E76 BK-18 426-E66 BR-18 1 2 C E-C18 3T3158 200-E95 BK-18 600-E98 BR-18 600-E96 BR-18 663-E101 GY-18 663-E102 GY-18 610-E33 OR-14 116-E35 RD-14 200-E16 BK-14 115-M205 RD-14 115-E8 RD-14 200-E93 BK-14 200-M207 BK-14 200-M152 BK-14 200-M152 BK-14 116-M88 RD-14 610-M186 OR-14 200-M203 BK-18 198-M71 RD-18 160-M201 PU-18 176-M184 YL-18 308-M169 YL-18 202-M198 BK-18 291-M141 BK-18 334-M200 BU-18 290-M139 BK-18 150-M62 RD-14 108-M65 BU-16 207-M156 BK-18 200-M178 BK-14 130-M176 GN-18 E794-M158 YL-18 E793-M167 BU-18 E793-C40 BU-18 F715-M1 PU-18 403-M162 GN-18 403-C4 GN-18 130-M176 GN-18 F715-C32 PU-18 E794-C44 YL-18 229-C49 BK-14 F710-C31 BR-18 F717-C34 YL-18 N942-C20 OR-18 13 14 15 16 17 13 14 15 16 17 THROTTLE SW (HIGH IDLE) FLEXXAIRE FAN MAN PURGE SW HYD FAN (CAT PROP VALVE) COOLANT TEMPERATURE COOLANT FLOW SWITCH INJECTOR COMMON 3 & 4 INJECTOR 2 995-N13 BU-16 A745-N12 WH-16 F700-N11 BU-16 A702-N10 PU-16 A746-N19 PK-16 A747-N17 GY-16 A745-N12 WH-16 A705-N23 BU-16 A706-N28 GY-16 A702-N10 PU-16 A703-N15 BR-16 A704-N18 GN-16 A705-N23 BU-16 T-C2 1552269 B B H 108-HA1 BU-16 108-HA1 BU-16 505-HA2 BU-18 200-HA5 BK-16 505-HA2 BU-18 503-HA4 BR-18 3 5 6 BR-16 GY-16 BK-16 OR-16 B+ P T° H-C3 1552273 NOTE H CONN 22 HH-C1 3E3382 521-E100 YL-18 521-E85 YL-14 200-E83 BK-18 521-E85 YL-14 200-E93 BK-14 1 2 3 4 WH-18 RD-18 BK-18 A B C E-C24 1552267 TC OUT TEMP SPI CLOCK 26 27 28 E708-E46 PK-18 443-E68 YL-18 600-E96 BR-18 LIGHT PIPE 1239294 893-E59 GN-18 892-E64 BR-18 E735-E23 PU-18 N931-E80 GY-18 609-E31 YL-14 307-E4 OR-18 105-E5 RD-18 308-E3 YL-18 308-M132 YL-18 307-M143 OR-18 103-M77 RD-14 310-M84 PU-18 609-M187 YL-14 105-M98 RD-18 200-M179 BK-14 200-M207 BK-14 200-M149 BK-10 200-M63 BK-14 447-M150 PK-18 521-M159 YL-14 337-M136 WH-18 H-11 H-8 304-M96 WH-8 302-M157 OR-18 F718-M2 BU-18 F717-M53 YL-18 F716-M52 WH-18 F702-M56 GN-18 F702-C27 GN-18 F716-C33 WH-18 F717-C34 YL-18 F718-C42 BU-18 150-C8 RD-14 102-C22 RD-14 F721-C38 GY-18 F718-C42 BU-18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 19 20 21 22 23 24 START AID SW THROTTLE SW (HIGH IDLE PARITY) OPTIONAL RETARDER SOL LO/HI ATMOSPHERIC PRESSURE INJECTOR 3 18 19 20 21 22 23 24 A747-N17 GY-16 F701-N16 BR-16 A703-N15 BR-16 L984-N14 OR-16 A751-N3 YL-16 E799-N7 BR-16 F700-N11 BU-16 F701-N16 BR-16 A706-N28 GY-16 L985-N22 YL-16 L984-N14 OR-16 L983-N5 WH-16 D7 FUEL LVL SNDR 1578851 PK-18 BK-18 1 2 447-T11 PK-18 201-T12 BK-18 108-HA29 BU-16 108-HA28 BU-16 108-HA27 BU-16 W P L REAR WIPER SW 3T6655 504-HA3 YL-18 HA-C3 1552252 CONN 10 H-C1 3E5179 REAR WIPER 1477979 507-H1 WH-18 507-HH1 WH-16 530-H2 OR-18 530-HH2 OR-16 200-H5 BK-18 1 2 3 4 5 6 1 2 3 4 5 6 200-HH5 BK-16 REAR FLOODS SW 3E9314 A B 600-E81 BR-18 522-E92 WH-14 ETHER START AID SW 1339405 998-E111 BR-18 F721-E107 GY-18 HARNESS CODE 0 ALTERNATOR CLEAR 32 31 30 33 29 270-E70 BK-18 403-E69 GN-18 1 2 C E-C19 3T3158 600-E98 BR-18 200-E97 BK-18 105-E5 RD-18 410-E37 WH-18 103-E36 RD-14 630-E73 GY-16 108-E56 BU-16 600-M51 BR-18 600-E114 BR-18 630-M64 GY-16 108-M100 BU-16 200-M22 BK-18 200-M87 BK-14 200-M166 BK-14 200-M74 BK-10 608-M155 GN-14 592-M129 BU-14 609-M204 YL-14 630-M64 GY-16 892-M182 BR-18 403-M162 GN-18 893-M174 GN-18 998-M82 BR-18 A700-M54 OR-18 F721-M60 GY-18 892-M182 BR-18 892-C43 BR-18 F721-C38 GY-18 998-C26 BR-18 A700-C24 OR-18 A700-C24 OR-18 F720-C37 GN-18 F719-C36 BR-18 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 CRANK W/O INJECT (N.C.) CRANK W/O INJECT (N.O.) TURBO OUTLET PRESSURE USER SHUTDOWN INJECTOR 4 25 26 F704-N20 OR-16 A704-N18 GN-16 A746-N19 PK-16 F704-N20 OR-16 F702-N26 GN-16 F713-N27 OR-16 A746-N19 PK-16 A747-N17 GY-16 A745-N12 WH-16 ME-C2 3E3364 BACKUP ALARM 1236449 BK-18 BK-18 ME-C1 1552269 CONN 5 T-C9 1552269 507-HA20 WH-18 503-HA4 BR-18 508-HA11 PU-18 525-H14 GY-18 525-HA12 GY-18 501-H18 GN-18 501-HA16 GN-18 500-HA17 BR-18 500-H17 BR-18 1 2 3 4 5 6 7 8 9 10 11 12 1 2 3 4 5 6 7 8 9 10 11 12 508-H26 PU-18 506-HH4 PU-16 506-H4 PU-18 529-H3 WH-18 529-HH3 WH-16 H-C4 1552273 L E-C22 3E7996 1 A B 200-E87 BK-18 600-E86 BR-18 REAR FLOODS/RIPPER 1004423 INSTRUMENT SUPPLY SPI DATA 37 36 291-E75 BK-18 C413-E43 YL-18 E707-E49 GN-18 113-E74 OR-18 200-E105 BK-18 200-E104 BK-18 307-E4 OR-18 308-E3 YL-18 201-E21 BK-18 201-E38 BK-18 326-E51 PU-18 G939-E2 PK-18 G939-M121 PK-18 893-E59 GN-18 892-E64 BR-18 893-M111 GN-18 892-M122 BR-18 200-M190 BK-14 201-M151 BK-18 201-M91 BK-18 200-M206 BK-14 779-M170 WH-18 G731-M59 GY-18 F790-M57 BR-18 780-M171 PU-18 E735-M140 PU-18 326-M4 PU-18 998-C35 BR-18 521-M67 YL-14 322-M90 GY-18 443-M10 YL-18 443-M10 YL-18 308-M215 YL-18 201-M93 BK-18 150-M62 RD-14 102-M61 RD-14 450-M175 YL-18 201-M93 BK-18 893-M174 GN-18 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 150-C8 RD-14 443-C51 YL-18 201-C52 BK-18 893-C5 GN-18 102-C22 RD-14 E794-C44 YL-18 E793-C40 BU-18 F702-C27 GN-18 F708-C18 YL-18 FLEXXAIRE FAN PULL SOL DIGITAL SENSOR RETURN ANALOG SENSOR RETURN COOLANT FLOW SW RETURN INJECTOR COMMON 5 & 6 INJECTOR 5 28 29 30 31 32 33 34 35 36 37 38 39 40 T920-N21 YL-16 L985-N22 YL-16 A705-N23 BU-16 N944-N24 PU-16 994-N8 GY-16 994-N8 GY-16 F724-N4 PU-16 F724-N4 PU-16 995-N13 BU-16 995-N13 BU-16 F732-N31 PK-16 F732-N31 PK-16 F714-N2 PK-16 A751-N3 YL-16 KW-C1 1552267 1 2 KW-C2 1552269 1 2 321-ME1 BR-18 975-ME2 WH-18 1 2 1 2 T-C1 3E3370 A B C 321-T24 BR-18 975-T23 WH-18 CONN 6 B B H 528-HA7 PK-18 509-HA10 WH-18 523-HA14 BR-18 523-H12 BR-18 524-HA13 BU-18 524-H13 BU-18 502-HA15 OR-18 502-H19 OR-18 509-H25 WH-18 200-H6 BK-18 527-H8 GN-18 1 2 4 BR-16 GY-16 BK-16 GN-16 GND B+ P T° MOTOR H 2 3 4 3 2 5 5 600-E11 BR-18 651-E10 PK-14 3 2 HYDRAULIC FILTER EMS III 1547443 (US) 1847766 (G) 38 40 39 N931-E80 GY-18 290-E76 BK-18 201-E57 BK-18 201-E52 BK-18 201-E53 BK-18 998-E111 BR-18 E735-E22 PU-18 977-E18 YL-18 442-E62 GY-18 447-E61 PK-18 N931-E80 GY-18 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 447-M150 PK-18 442-M126 GY-18 F848-M117 OR-18 N931-M133 GY-18 201-M145 BK-18 201-M93 BK-18 201-M142 BK-18 201-M147 BK-18 F843-M214 YL-18 F842-M199 BU-18 F849-M118 WH-18 522-M193 WH-14 998-M102 BR-18 610-M186 OR-14 G939-M196 PK-18 G939-M197 PK-18 G939-C55 PK-18 E908-M11 BR-18 E908-C56 BR-18 450-C53 YL-18 G939-C54 PK-18 F714-C30 PK-18 F708-C18 YL-18 F709-C19 BU-18 993-C29 BR-18 ENGINE ANALOG SENSOR RETURN DECELERATOR PEDAL F713-N27 OR-16 F702-N26 GN-16 N941-N25 YL-16 996-N1 GN-16 996-N1 GN-16 C967-N9 BU-16 C967-N9 BU-16 999-N30 WH-16 999-N30 WH-16 L983-N5 WH-16 RENR3662-02 20 Page BK-18 BK-18 WINCH SOL 1529095 A B C 780-KW2 PU-18 779-KW4 WH-18 780-KW1 PU-18 780-KW3 PU-18 A B C 780-T2 PU-18 779-T5 WH-18 200-T7 BK-14 W P L RIGHT WIPER SW 3T6655 527-HA8 GN-18 102-HA24 RD-18 102-H21 RD-18 528-H9 PK-18 526-H7 YL-18 108-H22 BU-16 3 5 6 OR-16 RIGHT WIPER 1171881 6 6 D C 6 5 GAGE CLUSTER 1666928 OR-18 BK-18 GN-18 WH-18 YL-18 BU-18 +V DISPLAY GROUND CLOCK DATA LOAD HARNESS CODE 1 2 3 4 5 6 E-C9 1552273 E707-E48 GN-18 291-E75 BK-18 426-E66 BR-18 403-E69 GN-18 410-E37 WH-18 F721-E107 GY-18 F848-E14 OR-18 G939-E17 PK-18 G939-E19 PK-18 F849-E13 WH-18 291-E75 BK-18 290-E76 BK-18 A513-E77 PK-18 F848-E14 OR-18 521-E85 YL-14 522-M193 WH-14 201-M28 BK-18 G939-M12 PK-18 A513-M94 PK-18 521-M68 YL-14 F848-M117 OR-18 290-M139 BK-18 291-M141 BK-18 201-M26 BK-18 201-M127 BK-18 201-M154 BK-18 975-M168 WH-18 G939-M181 PK-18 F850-M217 PK-18 977-M113 YL-18 998-M82 BR-18 998-M70 BR-18 998-M55 BR-18 A700-M54 OR-18 K978-M17 BU-18 K977-M16 PK-18 E909-M13 WH-18 975-M69 WH-18 709-M15 OR-18 K977-C61 PK-18 E909-C57 WH-18 975-C59 WH-18 709-C60 OR-18 K978-C58 BU-18 F718-C42 BU-18 F717-C34 YL-18 F716-C33 WH-18 F715-C32 PU-18 F721-C38 GY-18 892-C43 BR-18 A700-C24 OR-18 997-C28 OR-18 F709-C19 BU-18 FLEXXAIRE FAN PUSH SOL DIGITAL SENSOR +8V ANALOG SENSOR POWER +5V ENGINE ANALOG SENS PWR +5V OPTIONAL ACTIVE S/T INJECTOR 6 A706-N28 GY-16 N940-N29 BU-16 999-N30 WH-16 N940-N29 BU-16 N944-N24 PU-16 N941-N25 YL-16 L985-N22 YL-16 L984-N14 OR-16 N944-N24 PU-16 N940-N29 BU-16 N941-N25 YL-16 T-C103 1552267 NOTE G 530-HA21 OR-18 526-HA9 YL-18 108-H10 BU-16 108-H28 BU-16 108-H20 BU-16 108-H15 BU-16 524-H13 BU-18 H-C6 1552273 4 GN-16 GND MOTOR L H LAMP SW 1753950 608-E32 GN-14 630-E73 GY-16 USE THIS SW WHEN RIPPER FLOOD INSTALLED BK-18 RD-18 WH-18 1 2 3 4 A B C E-C11 1552267 F849-E13 WH-18 F849-E13 WH-18 201-E52 BK-18 C414-E41 BU-18 C413-E42 YL-18 E708-E45 PK-18 443-E68 YL-18 442-E62 GY-18 447-E61 PK-18 663-E101 GY-18 426-E66 BR-18 E735-E24 PU-18 522-E92 WH-14 F849-M118 WH-18 977-M113 YL-18 592-M95 BU-18 426-M101 BR-18 E735-M140 PU-18 202-M198 BK-18 290-M139 BK-18 291-M141 BK-18 307-M143 OR-18 H-12 F716-M52 WH-18 F715-M1 PU-18 F702-M56 GN-18 326-M4 PU-18 207-M156 BK-18 308-M215 YL-18 207-C17 BK-18 993-C29 BR-18 893-C5 GN-18 997-C28 OR-18 F710-C31 BR-18 START AID RELAY GROUND STRAP TIE POINT BOTTOM SP/TMG+/TDC PROBE + F732-N31 PK-16 ENGINE T920-N21 YL-16 H-20 C 1 2 KA-C2 1552269 1 2 630-KA1 GY-16 200-KA2 BK-16 1 2 T-C122 1552269 NOTE G KA-C1 1552269 1 2 T-C6 3E3364 200-T22 BK-16 630-T9 GY-16 B B H LEFT WIPER SW 3T6655 525-HA12 GY-18 CONN 9 HA-C2 3E5179 H-C2 1552252 108-H32 BU-16 108-H22 BU-16 200-H11 BK-18 523-H12 BR-18 525-H14 GY-18 108-H20 BU-16 1 2 3 5 6 BR-16 GY-16 BK-16 OR-16 B+ P T° 1 BI DIRECTIONAL MODE SW 1339405 E-C13 1552267 F848-E14 OR-18 G939-E17 PK-18 LAMP 1239294 LAMP 1239294 C E-C12 3T3158 1 2 C E-C20 3T3158 893-E59 GN-18 892-E64 BR-18 E735-E23 PU-18 N931-E80 GY-18 663-E102 GY-18 200-E93 BK-14 124-E30 GN-14 200-E82 BK-18 200-E83 BK-18 F721-E107 GY-18 592-E78 BU-18 403-E69 GN-18 443-E68 YL-18 977-E18 YL-18 F721-M60 GY-18 443-M10 YL-18 403-M194 GN-18 308-M132 YL-18 307-M143 OR-18 308-M215 YL-18 308-M216 YL-18 308-M169 YL-18 308-M80 YL-18 308-M216 YL-18 200-M87 BK-14 592-M128 BU-18 592-M188 BU-12 H-10 G939-M196 PK-18 G939-M197 PK-18 F717-M53 YL-18 F721-M60 GY-18 F718-M2 BU-18 304-M96 WH-8 M-C29 1275485 1 1 304-C50 WH-8 C-C12 1275486 998-C26 BR-18 998-C35 BR-18 N942-C20 OR-18 JACKET WATER HEATER 1890751 C RIPPER FLOOD 1532073 CONN 7 W P L 524-HA13 BU-18 511-HA18 BR-18 512-HA19 GN-18 528-HA7 PK-18 108-HA6 BU-16 1 2 3 4 5 1 2 3 4 5 511-H30 BR-18 512-H29 GN-18 528-H9 PK-18 108-H32 BU-16 H-C5 1552273 LEFT WIPER 1171882 L 2 B1 GY-14 BR-14 PK-14 BU-14 PU-14 YL-14 OR-14 5 E-C5 1552264 651-E10 PK-14 116-E35 RD-14 609-E31 YL-14 115-E8 RD-14 610-E33 OR-14 651-E10 PK-14 BK-18 RD-18 WH-18 1 2 3 4 A B C 977-E18 YL-18 G939-E19 PK-18 200-E105 BK-18 200-E104 BK-18 663-E101 GY-18 C413-E43 YL-18 C413-E42 YL-18 C413-E44 YL-18 522-E92 WH-14 600-E81 BR-18 521-E85 YL-14 998-E111 BR-18 411-E1 PK-18 411-M89 PK-18 998-M102 BR-18 326-M4 PU-18 322-M90 GY-18 103-M77 RD-14 A513-M94 PK-18 105-M98 RD-18 CONN 50 998-C47 BR-18 GN BK BK IDENT PART NO CHG LOC DESCRIPTION NOTE HARNESS AS.

A 164-3742 09 I-7 FUSE PANEL C 164-3733 10 D-4 ENGINE E 190-1029 02 D-7 DASH G 185-7157 01 I-2 RADIATOR GUARD H 169-9635 03 D-13 ROOF ATCH J 206-3720 02 H-14 FTC DRIVETRAIN L 164-3736 04 A-12 RH FENDER M 205-3762 04 B-9 PLATFORM N 206-5016 02 D-2 BASIC ENGINE P 167-6834 02 I-13 BASIC TRANSMISSION R 194-9380 02 A-11 RH CONSOLE T 203-1248 02 C-14 FUEL TANK CA 168-8655 01 B-2 RH SWEEP LIGHTING ATCH NOTE B CC 183-1982 02 C-2 RH WDA LIGHTING ATCH NOTE B CE 189-5368 02 C-4 RH CONSTRUCTION APPL ATCH NOTE B CF 213-6948 00 H-5 PRELUBE CUSTOM CH 183-4273 07 G-4 AIR COMPRESSOR ATCH CJ 195-5934 01 E-4 FLEXXAIRE FAN CUSTOM CN 213-6949 00 I-5 PRELUBE CUSTOM CV 121-2844 02 B-4 CRANK W/O INJ EE 172-9290 01 E-10 BLOWER ATCH HA 169-9636 02 D-13 HEADLINER ATCH HH 186-4857 02 E-10 WASHER PUMP ATCH KA 190-1028 01 C-14 RIPPER LIGHT ATCH KK 164-9541 02 B-9 SERVICE BRAKE JUMPER KW 170-4891 02 C-19 REAR WINCH JUMPER ME 204-7563 00 C-14 BACKUP ALARM PIGTAIL MF 195-3312 04 A-7 LOCKOUT INDICATOR MG 185-5628 02 F-8 20A CONVERTER PIGTAIL ATCH ML 202-0985 01 I-13 PRODUCT LINK ATCH MP 210-2509 03 I-12 XMSN JUMPER MR 184-4761 00 I-10 LH FENDER LIGHTS ATCH MT 184-4761 00 A-11 RH FENDER LIGHTS ATCH NJ 180-5947 01 E-1 JUMPER - ENG OIL PRESS NG 180-5947 01 F-1 JUMPER - INLET AIR TEMP NN 4P-9537 07 E-3 INJECTOR PP 144-7871 01 I-14 TRANSMISSION RA 160-5574 05 B-10 THROTTLE SW RM 194-1094 00 B-10 EROPS THROTTLE JUMPER ATCH RW 165-0107 02 A-19 WINCH RH CONSOLE ATCH TA 186-0636 02 C-15 LH SWEEP LIGHTING ATCH TC 124-8490 04 F-15 ROPS A/C ATCH TE 167-2171 01 C-2 RH CYLINDER LIGHTING ATCH TF 199-7065 00 F-14 FUEL TANK TO ROPS A/C ATCH TG 186-0636 02 B-15 RH SWEEP LIGHTING ATCH TH 175-0451 05 A-15 ROPS, FUEL TANK LIGHTING ATCH NOTE A TL 175-0451 05 A-15 ROPS, FUEL TANK LIGHTING ATCH NOTE A TM 168-8655 01 H-2 LH SWEEP LIGHTING ATCH NOTE B TN 183-1982 02 H-2 LH WDA LIGHTING ATCH NOTE B TP 167-2171 01 H-1 LH CYLINDER LIGHTING ATCH TR 185-9607 03 E-14 ROPS LIGHTING ATCH TV 185-9607 03 E-14 ROPS LIGHTING ATCH TX 189-5368 02 H-3 LH CONSTRUCTION APPL ATCH NOTE B SWEEP LIGHTING (SIDE) 529-HA22 WH-18 108-HA6 BU-16 523-HA14 BR-18 530-HA21 OR-18 529-HA22 WH-18 506-HA23 PU-18 526-HA9 YL-18 527-HA8 GN-18 7 8 9 10 11 12 7 8 9 10 11 12 527-H8 GN-18 526-H7 YL-18 506-H4 PU-18 529-H3 WH-18 200-H16 BK-18 501-H18 GN-18 1 2 4 BR-16 GY-16 BK-16 GN-16 GND B+ P T° MOTOR H 3 B2 2 3 6 8 116-E35 RD-14 116-E35 RD-14 115-E8 RD-14 200-E87 BK-18 103-E7 RD-18 AUTO DOWNSHIFT SW 1339405 BK-18 RD-18 WH-18 1 2 3 4 E-C8 1552267 H-24 LAMP GEAR MODULE 1680369 OR-18 BK-18 GN-18 WH-18 YL-18 BU-18 E-C10 1552273 663-E102 GY-18 C414-E40 BU-18 C414-E41 BU-18 C414-E39 BU-18 103-E7 RD-18 115-E8 RD-14 198-E12 RD-18 G731-E20 GY-18 140-E34 BU-18 202-E89 BK-18 198-M71 RD-18 202-M198 BK-18 140-M58 BU-18 G731-M59 GY-18 411-M89 PK-18 403-M194 GN-18 334-M200 BU-18 108-M100 BU-16 113-M99 OR-18 114-M72 RD-18 113-M75 OR-18 CONN 59 CYL LIGHTS (STD/WD) 1 2 TA-C1 1552269 1 2 608-TA1 GN-14 200-TA2 BK-14 TA-C3 3E3376 B B H FRONT WIPER SW 3T6655 502-HA15 OR-18 507-HA20 WH-18 200-H33 BK-16 200-HA25 BK-16 6 6 507-H1 WH-18 530-H2 OR-18 502-H19 OR-18 500-H17 BR-18 108-H15 BU-16 CONN 23 3 5 6 OR-16 FRONT WIPER 1477976 4 1 4 7 103-E7 RD-18 600-E90 BR-18 600-E90 BR-18 600-E86 BR-18 600-E90 BR-18 610-E33 OR-14 609-E31 YL-14 608-E32 GN-14 600-E11 BR-18 600-E86 BR-18 OPERATOR MONITOR SW 1339405 A B C E735-E22 PU-18 201-E21 BK-18 +V DISPLAY GROUND CLOCK DATA LOAD HARNESS CODE 1 2 3 4 5 6 201-E53 BK-18 C414-E39 BU-18 C413-E44 YL-18 E708-E47 PK-18 E707-E50 GN-18 E707-E49 GN-18 E707-E48 GN-18 E707-E50 GN-18 600-E11 BR-18 600-E91 BR-18 200-E87 BK-18 F843-M214 YL-18 F843-E118 YL-18 F790-E106 BR-18 998-E116 BR-18 A700-E115 OR-18 F702-E117 GN-18 F790-M57 BR-18 A700-M54 OR-18 998-M55 BR-18 F702-M56 GN-18 426-M101 BR-18 442-M126 GY-18 140-M58 BU-18 115-M205 RD-14 116-M88 RD-14 124-M104 GN-14 140-M202 BU-18 FOR NORMAL OPERATING MODE CV-C1 3E3370 200 BK-16 CONN 51 C-C10 1552267 H-20 610-G11 OR-14 G-C3 1552269 1 2 G-C7 3E3364 NOTE G TE-C3 1552269 1 2 TE-C4 3E3364 200-TE4 BK-14 609-TE3 YL-14 CYL FLOOD STD1 1470319 1 2 FUEL TANK FLOOD 1 1470319 200-TA4 BK-14 609-TA3 YL-14 TA-C2 1552269 3 4 W P L 501-HA16 GN-18 500-HA17 BR-18 200-H6 BK-18 200-H11 BK-18 H-C7 1552272 E-C16 3E3376 B3 630-E73 GY-16 ACTION ALARM 3E6328 BK-16 PK-16 1 2 E-C3 1552269 201-E38 BK-18 E708-E46 PK-18 E708-E45 PK-18 E708-E47 PK-18 H-24 600-E114 BR-18 608-E32 GN-14 326-E51 PU-18 326-M4 PU-18 521-M180 YL-14 443-M10 YL-18 447-M150 PK-18 158-M185 BR-14 160-M201 PU-18 176-M184 YL-18 198-M71 RD-18 A B C A B C 998-C14 BR-18 F719-C36 BR-18 F720-C37 GN-18 CYLINDER LIGHTS (10) FOR WDA 200-G9 BK-14 SWEEP FLOOD SIDE 1 1532073 1 2 WH-18 BK-18 RD-18 HA-C4 1552267 A B C 102-HA24 RD-18 506-HA23 PU-18 200-H31 BK-16 200-H27 BK-18 200-H16 BK-18 200-H5 BK-18 592-H24 BU-18 A513-H23 PK-18 102-H21 RD-18 108-H10 BU-16 2 E-C102 1552272 NOTE G 1 2 3 4 1 3 4 A513-E77 PK-18 592-E78 BU-18 103-E55 RD-18 108-E56 BU-16 H-25 H-25 410-E37 WH-18 103-E55 RD-18 609-E31 YL-14 610-E33 OR-14 630-E73 GY-16 892-E64 BR-18 663-E103 GY-18 663-E101 GY-18 663-E102 GY-18 521-M68 YL-14 522-M193 WH-14 521-M159 YL-14 521-M67 YL-14 200-M207 BK-14 200-M152 BK-14 200-M74 BK-10 200-M149 BK-10 H-9 CV-C2 3E3370 201 BK-16 A B C 1552267 NOTE G CC-C1 3E3364 1 2 610-CC4 OR-14 610-CC3 OR-14 CC-C2 1552269 CYLINDER FLOOD 1 1470319 1 2 TG-C1 1552269 1 2 608-TG1 GN-14 TG-C3 3E3376 DOME LAMP 3E6389 200-HA26 BK-18 H-C8 1552264 CAB 12V RADIO NOTE F EROPS THROTTLE JUMPER CONN 32 A513-E77 PK-18 108-E56 BU-16 592-E78 BU-18 893-E59 GN-18 977-E18 YL-18 998-E116 BR-18 998-E111 BR-18 592-M129 BU-14 592-M128 BU-18 592-M188 BU-12 201-M145 BK-18 201-M91 BK-18 201-M151 BK-18 201-M127 BK-18 NOTE:

USE ONLY FOR CRANK WITHOUT FUEL INJECTION 1 2 200-CC2 BK-14 200-CC5 BK-14 610-CC1 OR-14 610-CC4 OR-14 200-CC6 BK-14 200-CC5 BK-14 CC-C3 1552269 FUEL TANK FLOOD 2 1470319 200-TG2 BK-14 200-TG4 BK-14 609-TG3 YL-14 TG-C2 1552269 3 4 RIGHT SPEAKER 6T7695 200-HA25 BK-16 200-HA5 BK-16 ANTENNA 8E1118 509-H25 WH-18 508-H26 PU-18 A513-H23 PK-18 592-H24 BU-18 5 6 1 2 WH/BK,GN/BK YL RD BK WH/GN +B MEMORY LEFT SPKR - + BATTERY (12V) LEFT SPKR + RM-C2 1950534 USED ON EROPS MACHINES ONLY RM-C1 1552264 SERVICE BRAKE PEDAL SW 1327077 1 2 G731-KK1 GY-18 198-KK2 RD-18 KK-C1 3E3376 1 2 E-C23 1552272 G731-E20 GY-18 198-E12 RD-18 E735-E23 PU-18 A513-E77 PK-18 A700-E115 OR-18 E735-E22 PU-18 592-M95 BU-18 308-M80 YL-18 403-M194 GN-18 893-M111 GN-18 892-M122 BR-18 N931-M133 GY-18 200-CC6 BK-14 610-CC3 OR-14 1 2 CYLINDER FLOOD 1 1470319 B 1 2 -+ 511-HA18 BR-18 512-HA19 GN-18 HEADLINER GND GY/PU HC 511-H30 BR-18 512-H29 GN-18 108-H28 BU-16 200-H27 BK-18 3 4 7 8 RIGHT SPKR - GY/BK,PU/BK GROUND NC RIGHT SPKR + WHEN USED PLUG INTO RA-C1 1 2 3 4 5 6 7 8 F715-RM1 PU-18 F716-RM2 WH-18 F717-RM3 YL-18 F718-RM4 BU-18 998-RM5 BR-18 600-RM6 BR-18 200-RM7 BK-18 1 2 3 4 5 6 7 8 WHEN USED PLUG INTO M-C1 3 4 3 4 E-C29 1552272 E735-E24 PU-18 F721-E107 GY-18 F702-E117 GN-18 600-M51 BR-18 608-M155 GN-14 609-M191 YL-14 201-M93 BK-18 200-M63 BK-14 H-4 SWEEP LIGHTING (08) CA-C2 1552269 B SWEEP FLOOD SIDE 2 1532073 OPERATOR PLATFORM CAB ANTENNA INCHING PEDAL POSITION 1618929 USED ON PSDD MACHINES ONLY WH-18 BK-18 OR-18 +BAT GROUND SIGNAL 1 2 3 4 1 2 3 4 140-E119 BU-18 F843-E118 YL-18 202-E121 BK-18 F843-E118 YL-18 F848-E14 OR-18 F849-E13 WH-18 F790-E106 BR-18 609-M187 YL-14 609-M191 YL-14 609-M189 YL-14 609-M204 YL-14 326-M4 PU-18 443-M10 YL-18 308-M215 YL-18 322-M90 GY-18 1 2 CA-C1 3E3364 1 2 610-CA1 OR-14 610-CA4 OR-14 610-CA3 OR-14 200-CA2 BK-14 200-CA5 BK-14 200-CA6 BK-14 200-CA5 BK-14 610-CA4 OR-14 CA-C3 1552269 WDA FLOOD 2 1470319 ROPS LIGHTING (10) FOR WDA OR CONSTRUCTION APPLICATIONS THROTTLE SW 3E9044 A B CONN 29 E-C103 3E3376 NOTE G E-C27 1552267 G939-E19 PK-18 G731-E20 GY-18 G939-E2 PK-18 610-M186 OR-14 892-M122 BR-18 779-M170 WH-18 630-M64 GY-16 780-M171 PU-18 998-M55 BR-18 522-M193 WH-14 521-M67 YL-14 610-M186 OR-14 H-12 610-CA3 OR-14 200-CA6 BK-14 1 2 WDA FLOOD 2 1470319 1 2 TL-C2 1552269 608-TL3 GN-14 200-TL7 BK-14 608-TL5 GN-14 TL-C4 3E3376 1 2 LIGHT 1260810 FORWARD HORN 1586632 BK-18 BK-18 2 1 1 2 R-C5 1552269 322-R1 GY-18 114-R2 RD-18 998-RA13 BR-18 200-RA8 BK-18 600-RA11 BR-18 1 2 A B 2 1 3 3 F715-RA1 PU-18 F715-RA1 PU-18 F716-RA2 WH-18 RA-C1 1552264 1 2 1 2 3 4 5 6 7 8 M-C1 3E3388 F715-M1 PU-18 F717-M53 YL-18 F716-M52 WH-18 BRAKE POSITION SNSR 1471680 A B C GROUND +BAT SIGNAL OR-18 BK-18 WH-18 A B C 140-E120 BU-18 F790-E106 BR-18 202-E122 BK-18 G939-E17 PK-18 N931-E80 GY-18 200-M22 BK-18 176-M184 YL-18 114-M72 RD-18 158-M185 BR-14 998-M55 BR-18 975-M168 WH-18 977-M113 YL-18 893-M111 GN-18 998-M102 BR-18 A700-M54 OR-18 F702-M56 GN-18 998-M70 BR-18 ABBREV COLOR RD WH OR YL PK BK GY PU BR GN BU RED WHITE ORANGE YELLOW PINK BLACK GREY PURPLE BROWN GREEN BLUE SYMBOL DESCRIPTION BLADE, SPADE, RING, OR SCREW TERMINAL CYLINDER LIGHTS (10) FOR CONSTRUCTION APPL CE-C2 1552269 ROPS FLOOD 1 1470319 TL-C1 1552269 200-TL4 BK-14 608-TL5 GN-14 608-TL3 GN-14 200-TL4 BK-14 608-TL1 GN-14 609-TL6 YL-14 200-TL8 BK-14 TL-C3 1552269 3 4 780-RW6 PU-18 779-RW4 WH-18 REAR ACTION LAMP 1151748 R-C6 1552269 998-RA10 BR-18 200-RA9 BK-18 600-RA12 BR-18 D C 6 5 D C 5 4 4 6 F718-RA4 BU-18 F718-RA4 BU-18 F716-RA2 WH-18 F717-RA3 YL-18 200-RA7 BK-18 200-M22 BK-18 F717-RA3 YL-18 600-RA6 BR-18 998-RA5 BR-18 3 4 5 6 7 8 998-M70 BR-18 F718-M2 BU-18 600-M51 BR-18 OR-18 BK-18 WH-18 DECEL PEDAL POSITION 1602443 A B C GROUND +8V SIGNAL A B C E-C28 1552267 A700-E115 OR-18 F702-E117 GN-18 998-E116 BR-18 411-M89 PK-18 200-M190 BK-14 201-M28 BK-18 201-M26 BK-18 322-M90 GY-18 998-M102 BR-18 998-M70 BR-18 A700-M54 OR-18 A513-M94 PK-18 E735-M140 PU-18 F721-M60 GY-18 F715-M1 PU-18 F716-M52 WH-18 F718-M2 BU-18 F717-M53 YL-18 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON. VOLTAGE CONVERTER OUTPUT CIRCUIT. STARTING CIRCUIT. GROUND CIRCUIT. STARTING AID CIRCUIT.

Стр. 2