Caterpillar PK-18 — инструкция

SENR1295 July 1998 20 4 5 13 3 18 21 12 11 22 7 25 17 19 10 26 23 24 A 8 15 16 6 2 1 14 27 9 B C 902 and 906 Compact Wheel Loader Electrical System 902: 7ES1-Up 906: 6ZS1-Up 4 19 20 11 12 10 B A 25 17 18 21 5 8 9 22 C 13 16 6 26 27 7 1 2 14 15 24 3 23 Machine locations are repeated for components located close together. A = Components located on or in the Dash. B = Components located on or in the Right Console. Machine Harness Connector and Component Locations C = Components located on or in the Fuse Panel. E52651 ©1998 Caterpillar All Rights Reserved Printed in U.S.A.

Harness And Wire Electrical Schematic Symbols Electrical Schematic Symbols And Definitions A AA 1 Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins. Typical representation of a Sure-Seal connector. The plugand receptacle contain both pins and sockets. Plug Receptacle T 2 Pressure Symbol Temperature Symbol Level Symbol Flow Symbol Pin or Socket Number Wire, Cable, or Harness Assembly Identification Component Part Number The connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart.

Normally open switch that will close with an increase of a specific condition (temp-press-etc.). Single Wire Connector 325-PK-14 C A A AA 9X-1123 Normally open switch that is closed due to an applied condition, and will open again with a specific decrease in that condition. 325-PK-14 Wire Color Socket Pin Normally closed switch that will open with an increase of a specific condition. 200-BK-14 Circuit Number Identification Wire Gauge Normally closed switch that is open due to an applied condition, and will close again with a specific decrease in that condition.

Electrical Schematic Symbols And Definitions The circle indicates that the component has screw terminals and a wire can be disconnected from it. FUSE - A component in an electrical circuit that will open the circuit if too much current flows through it. Resistor, Sender and Solenoid Specifications Part No. 141-2968 REED SWITCH - A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch. 142-9804 No circle indicates that the wire cannot be disconnected from the component. ¹ At room temperature unless otherwise noted.

SENDER - A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure. T This indicates that the component has a wire connected to it that is connected to ground. RELAY (Magnetic Switch) - A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay. This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine.

CIRCUIT BREAKER (C/B) - A component in an electrical circuit that will open the circuit if too much current flows through it. This does not destroy the circuit breaker and it can be reset to become part of the circuit again. SOLENOID - A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work. MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is activated by electricity and held latch by a permanent magnet.

It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

Component Location Schematic Machine Schematic Machine Component Component Location Location Location Location Action Lamps G-6 A Resistor - Rear Window Defrost F-8 22 Alarm - Backup E-11 6 Sender - Fuel Level E-8 7 Alternator (902) G-10 18 Sender - Trans Speed E-9 26 Alternator (906) G-12 18 Sender/Switch - Hydraulic Temperature D-8 27 Backlight Lamp Beams H-6 A Solenoid - Boom Lower C-2 25 Backlight Lamp LH G-6 A Solenoid - Coupler D-2 25 Backlight Lamp RH H-6 A Solenoid - Forward Pump Valve Group E-12 15 Battery H-8 5 Solenoid - Fuel Shutdown (902) I-10 21 Breaker - A/C 30 Amp H-8 4 Solenoid - Fuel Shutdown (906) H-11 21 Breaker - Alternator 60 Amp (902) G-10 3 Solenoid - Hydraulic Shutoff D-9 24 Breaker - Alternator 60 Amp (906) G-12 3 Solenoid - Implement Detents Valve Group C-12 B Breaker - Main 60 Amp H-8 4 Solenoid - Implement Detents Valve Group C-12 B Breaker - Roading Lamps 20 Amp H-8 4 Solenoid - Motor Reversing Motor Valve Group D-8 23 Control - FNR C-11 B Solenoid - Reverse Pump Valve Group E-12 15 Flasher I-8 A Solenoid - Speed Select Motor Valve Group D-8 23 Function Lamps G-6 A Switch - 4th Function A-9 B Fuses B,C-3 C Switch - Air Conditioning A-12 B Gauge - Fuel G-7 A Switch - Beacon H-8 A Gauge - Hydraulic Oil Temp H-7 A Switch - Blower C-12 B Gauge - Speed H-7 A Switch - Brake Lamp D-3 8 Glow Plugs (902) I-10 19 Switch - Brake Level D-3 8 Glow Plugs (906) H-12 19 Switch - Cold Start A-10 B Ground - Cab Mount Plate H-8 5 Switch - Coolant (902) H-10 18 Ground - Engine Frame F-12 17 Switch - Coolant (906) H-12 18 Ground Stud - Cab Rear H-8 5 Switch - Coupler A-8 B Ground Stud - Engine End Frame F-10 3 Switch - Dead Engine Lower A-8 B Ground Stud - Machine A-5 11 Switch - Defrost A-12 B Ground Stud - Nose Cone H-2 8 Switch - Dimmer I-4 A Horn - Forward D-3 2 Switch - Disconnect I-8 5 Meter - Service G-7 A Switch - Engine Oil Press (902) H-10 20 Meter Filter G-7 A Switch - Engine Oil Press (906) H-12 20 Motor - Blower F-8 22 Switch - Filter Bypass F-11 14 Motor - Front Washer D-11 9 Switch - FNR C-12 B Motor - Front Wiper F-3 8 Switch - Forward Horn H-7 A Motor - Rear Washer E-11 9 Switch - Front Washer F-6 A Motor - Rear Wiper Motor G-8 10 Switch - Front Wiper F-5 A Motor - Starter (902) G-10 17 Switch - Hazard I-7 A Motor - Starter (906) F-12 17 Switch - Hydraulic Shutoff B-8 B Relay - Backup Alarm A-4 C Switch - Key Start B-12 B Relay - Detent A-4 C Switch - Parking Brake G-8 13 Relay - Front Floods A-3 C Switch - Rear Wiper F-7 A Relay - Main A-6 C Switch - Roading Lamp I-5 A Relay - Rear Floods A-3 C Switch - Speed Selector B-9 B Relay - Start Aid (902) I-10 3 Switch - Tools A-11 B Relay - Start Aid (902) I-10 3 Switch - Turn Signal I-7 A Relay - Start Aid (906) H-11 3 Switch - Working Lamps I-5 A Relay - Start Aid (906) H-11 3 Switch/Sender - Hydraulic Temperature D-8 27 Action Lamps G-6 A Resistor - Rear Window Defrost F-8 22 Alarm - Backup E-11 6 Sender - Fuel Level E-8 7 Alternator (902) G-10 18 Sender - Trans Speed E-9 26 Alternator (906) G-12 18 Sender/Switch - Hydraulic Temperature D-8 27 Backlight Lamp Beams H-6 A Solenoid - Boom Lower C-2 25 Backlight Lamp LH G-6 A Solenoid - Coupler D-2 25 Backlight Lamp RH H-6 A Solenoid - Forward Pump Valve Group E-12 15 Battery H-8 5 Solenoid - Fuel Shutdown (902) I-10 21 Breaker - A/C 30 Amp H-8 4 Solenoid - Fuel Shutdown (906) H-11 21 Breaker - Alternator 60 Amp (902) G-10 3 Solenoid - Hydraulic Shutoff D-9 24 Breaker - Alternator 60 Amp (906) G-12 3 Solenoid - Implement Detents Valve Group C-12 B Breaker - Main 60 Amp H-8 4 Solenoid - Implement Detents Valve Group C-12 B Breaker - Roading Lamps 20 Amp H-8 4 Solenoid - Motor Reversing Motor Valve Group D-8 23 Control - FNR C-11 B Solenoid - Reverse Pump Valve Group E-12 15 Flasher I-8 A Solenoid - Speed Select Motor Valve Group D-8 23 Function Lamps G-6 A Switch - 4th Function A-9 B Fuses B,C-3 C Switch - Air Conditioning A-12 B Gauge - Fuel G-7 A Switch - Beacon H-8 A Gauge - Hydraulic Oil Temp H-7 A Switch - Blower C-12 B Gauge - Speed H-7 A Switch - Brake Lamp D-3 8 Glow Plugs (902) I-10 19 Switch - Brake Level D-3 8 Glow Plugs (906) H-12 19 Switch - Cold Start A-10 B Ground - Cab Mount Plate H-8 5 Switch - Coolant (902) H-10 18 Ground - Engine Frame F-12 17 Switch - Coolant (906) H-12 18 Ground Stud - Cab Rear H-8 5 Switch - Coupler A-8 B Ground Stud - Engine End Frame F-10 3 Switch - Dead Engine Lower A-8 B Ground Stud - Machine A-5 11 Switch - Defrost A-12 B Ground Stud - Nose Cone H-2 8 Switch - Dimmer I-4 A Horn - Forward D-3 2 Switch - Disconnect I-8 5 Meter - Service G-7 A Switch - Engine Oil Press (902) H-10 20 Meter Filter G-7 A Switch - Engine Oil Press (906) H-12 20 Motor - Blower F-8 22 Switch - Filter Bypass F-11 14 Motor - Front Washer D-11 9 Switch - FNR C-12 B Motor - Front Wiper F-3 8 Switch - Forward Horn H-7 A Motor - Rear Washer E-11 9 Switch - Front Washer F-6 A Motor - Rear Wiper Motor G-8 10 Switch - Front Wiper F-5 A Motor - Starter (902) G-10 17 Switch - Hazard I-7 A Motor - Starter (906) F-12 17 Switch - Hydraulic Shutoff B-8 B Relay - Backup Alarm A-4 C Switch - Key Start B-12 B Relay - Detent A-4 C Switch - Parking Brake G-8 13 Relay - Front Floods A-3 C Switch - Rear Wiper F-7 A Relay - Main A-6 C Switch - Roading Lamp I-5 A Relay - Rear Floods A-3 C Switch - Speed Selector B-9 B Relay - Start Aid (902) I-10 3 Switch - Tools A-11 B Relay - Start Aid (902) I-10 3 Switch - Turn Signal I-7 A Relay - Start Aid (906) H-11 3 Switch - Working Lamps I-5 A Relay - Start Aid (906) H-11 3 Switch/Sender - Hydraulic Temperature D-8 27 Wire Description Wire Number Wire Color Description Wire Number Wire Color Description Power Circuits Accessory Circuits 101 RD Battery (+) 500 BR Front Wiper - Park 102 RD Lighting Power 501 GN Front Wiper - Low 103 RD Air Conditioning Power 502 OR Front Wiper - Hi 104 RD Glow Plug Power 503 BR Rear Wiper - Park 105 RD Key Start Switch Power 504 YL Rear Wiper - Low 109 110 RD GN Alternator Output (+) Fuel Shutoff Power 506 507 PU WH Front Washer Rear Washer 112 PU Main Power Relay Output 508 PU Radio Speaker Left 114 GN Forward Horn Power 509 WH Radio Speaker Left - Common 117 RD Main Breaker Output 511 BR Radio Speaker Right 118 GY Wiper/Washer Power 512 GN Radio Speaker Right - Common 120 YL Back-Up Alarm Power 515 GY Blower Motor - Hi 122 BU Miscellaneous Power 516 GN Blower Motor - Medium 123 WH Gauge Power 517 BU Blower Motor - Low 124 GN Heater Blower Power 521 YL Air Conditioner 126 PK Transmission ECM Power 536 WH Hazard Switch Signal 127 OR Start-Aid Power 537 GN Flasher Output 128 PK Implement Detent Power 567 WH Air Conditioner Switch Enable 129 BU Detent Relay Output A538 OR Rear Window Defrost 130 GN Stop Lamp Power Lighting Circuits 135 BU Radio Power 603 PK Beacon 140 BU Rear Window Defrost Power 604 OR Stop Lamp 144 GN Beacon Power 605 YL Left Turn Lamp 161 PK Front Flood Power 606 GY Right Turn Lamp 162 YL Rear Flood Power 607 PK Front Flood Lamp Relay Output 197 GN 4th Function Power 608 GN Rear Flood Lamp Relay Output Ground Circuits 610 OR Head Lamp Signal 200 BK Main Chassis Ground 611 PU Head Lamp Hi-Beam 201 BK ECM Ground 614 PU Park/Tail/Dash Lamp 202 BK ECM Relay Return 617 BR Left Tail Lamp Basic Machine Circuits 618 YL Right Tail Lamp 304 WH Start Relay Output 619 GN Head Lamp Lo-Beam 306 GN ECM Start Output Control Circuits 307 OR Key Switch Start Signal 751 GN Motor Reversing Solenoid 308 YL Key Switch Run Signal 780 BU Coupler Solenoid 321 BR Back-Up Alarm Relay Output 781 PK 4th Function Control 1 322 GY Forward Horn 782 GY 4th Function Control 2 330 YL ECM Neutral Output A751 YL Auxiliary Tool Power Monitoring Circuits A752 BR Auxiliary Tool Signal 403 GN Alternator Pulse Output E783 WH Dead Engine Boom Lower 404 YL Hydraulic Oil Temp Switch F747 OR Speed Select 405 GY Oil Pressure F765 BR Park Brake Disengaged 406 PU Coolant Temperature G750 BU Forward Switch Signal 419 YL Park Brake Engaged G755 GY Reverse Switch Signal 442 GY Hydraulic Oil Temp Sender G763 PU Neutral Switch Signal 447 PK Fuel Level H791 GN Rear Flood Lamp Signal 449 BU Speed H792 BU Front Flood Lamp Signal 483 PK Brake Fluid Level E801 OR ECM Forward Output C444 YL Alternator Indicator Lamp E802 YL ECM Reverse Output E417 OR ECM Park Brake Alarm Output 975 WH Forward/Reverse Solenoid Return E455 BR Hydraulic Oil Filter L981 YL Hydraulic Shutoff L987 WH Start-Aid Signal Connector Location Connector Number Schematic Location Machine Location CONN 1 G-10,11 16 CONN 2 E-10 12 CONN 3 ACC Socket CONN 4 G-8 G-8 13 5 CONN 5 G-8 5 CONN 6 E-7 12 CONN 7 E-5 9 CONN 8 D-3 2 CONN 9 D-3 2 CONN 10 G-3 8 CONN 11 G-3 8 CONN 12 Tool D-3 1 CONN 13 H-8 5 1 2 1 2 1 2 Off Machine Switch Specification Part No.

Function Actuate Deactuate Contact Position 142-9804 Hydraulic Temperature Sender 102.0 ± 3 °C (215.6 ± 5.4 °F) 90 °C (194.0 °F) Normally Open Component Description Resistance (Ohms)¹ Sender - Fuel Level Full: Empty: 27.5 - 39.5 240 - 260 Sender/Switch - Hydraulic Oil Temperature 79 to 100 @ 80 °C (176 °F) 263 to 283 @ 110 °C (230 °F) Related Electrical Service Manuals Title Form Number Transmission Electronic Control SENR1258

Стр. 1

1 12 200-C12 BK-18 L15 L12 L15 607-C11 PK-18 REAR FLOOD LH 138-4929 607-C11 PK-18 DASH DASH DASH L12 200-C12 BK-18 FRONT FLOOD LH 138-4929 STOP BK OR YL GY H-C4 3E3373 ENGINE 902 608-C13 GN-18 200-C14 BK-18 L12 HAZARD SW 138-4892 G-C16 1117898 537-G2 GN-18 102-G14 RD-18 200-G15 BK-18 G-C33 1116795 1 2 3 GROUND + BATTERY OUT (LAMP) FLASHER 7T-4848 ROADING LAMP SW 138-4885 G-C11 1117898 TAIL 2 3 4 1 200-H15 BK-18 604-H12 OR-18 617-H11 PU-18 L18 2 5 2 5 LH SPEAKER 6T-7695 -+ 509-C16 WH-18 508-C15 PU-18 537-G2 GN-18 1 2 102-G83 RD-18 1 2 1 2 G-C22 1117898 FRONT FRAME F-C2 3E3379 I REAR LAMPS LH 138-4945 TURN 605-H10 YL-18 104-EA21 RD-10 EA-C5 9X1054 4 1 EA-C6 9X1054 4 1 DISCONNECT SW ATCH 537-G4 GN-18 3 4 5 536-G1 WH-18 102-G13 RD-18 102-G33 RD-14 3 4 5 610-G18 OR-14 610-G18 OR-14 3 4 5 619-G28 GN-14 611-G29 PU-14 611-G5 PU-18 L1 605-F5 YL-18 614-F4 PU-18 1 3 BR-16 WH-16 YL-16 RD-16 GN-16 I L18 L18 START AID RELAY.

115-1615 3 109-EA20 RD-10 109-EA20 RD-10 200-EA18 BK-18 L987-EA9 WH-18 202-EA15 BK-18 202-EA15 BK-18 306-EA16 GN-18 306-EA16 GN-18 304-EA11 WH-10 START RELAY. 3 115-1615 109-EA17 RD-10 200-CH1 BK-00 TO BATTERY 200-G10 BK-18 200-G7 BK-18 7 6 200-G20 BK-18 200-G24 BK-18 7 6 614-G19 PU-18 200-G20 BK-18 200-G32 BK-18 7 6 619-G6 GN-18 619-F1 GN-18 611-F3 PU-18 200-F2 BK-18 6 2 4 5 GLOW PLUGS.

DISCONNECT SW 7N0718 L8 614-G107 BK-18 8 200-G15 BK-18 614-G76 PU-18 8 614-G21 PU-18 614-G31 PU-18 8 DIMMER SW 138-4890 HEAD TURN LAMP LH 138-4941 ENGINE 906 200-CE1 BK-00 DASH DASH DASH TURN SIGNAL SW 138-4894 2 1 G-C1 1117898 537-G3 GN-18 L6 L6 102-G14 RD-18 605-G17 YL-18 606-G36 GY-18 L5 102-G13 RD-18 102-G33 RD-14 L9 (RH DIPPED) 138-4943 (LH DIPPED) NOTE B 2 5 2 5 CAB MOUNT PLATE (EEF) 2 M10 GND STUD 606-G79 GY-18 605-G17 YL-18 606-G36 GY-18 5 4 3 536-G1 WH-18 536-G16 WH-18 536-G16 WH-18 605-G75 YL-18 606-G79 GY-18 614-G11 PU-18 144-G65 GN-18 WORKING LAMPS 138-4884 G-C19 1117898 L1 L1 FRONT FRAME 104-E21 RD-10 3 E-C5 9X-1054 4 1 3 E-C6 9X-1054 4 1 110-EA8 YL-18 DISCONNECT SW ATCH 605-G75 YL-18 6 537-G4 GN-18 537-G3 GN-18 1 2 G-C37 1117898 102-G23 RD-18 102-G83 RD-18 1 2 3 4 5 L3 L3 200-G32 BK-18 614-G31 PU-18 102-G13 RD-18 L4 DASH START AID RELAY 115-1615 109-E20 RD-10 200-E18 BK-18 L987-E9 WH-18 202-E15 BK-18 306-E16 GN-18 304-E11 WH-10 START RELAY 115-1615 109-E17 RD-10 ENGINE 902 ENGINE 902 FUEL SHUTDOWN.

EA-C4 1003320 537-G4 GN-18 144-G65 GN-18 3 4 5 603-G12 PK-18 102-G23 RD-18 6 H791-G25 GN-18 H792-G26 BU-18 102-G33 RD-14 614-G19 PU-18 H791-G25 GN-18 H792-G26 BU-18 GLOW PLUGS 1 2 200-EA7 BK-18 406-EA6 PU-18 ENGINE 902 101-CG1 RD-00 200-CC1 BK-00 CAB GROUND STRAP 8I-4640 606-G79 GY-18 605-G75 YL-18 605-G17 YL-18 L6 7 6 BEACON SW 109-2350 200-G24 BK-18 614-G76 PU-18 200-G10 BK-18 7 8 T COOLANT SW.

NEG POS L8 L8 614-G11 PU-18 606-G36 GY-18 200-G7 BK-18 614-G11 PU-18 8 614-G21 PU-18 614-G21 PU-18 E-C3 3E3367 BATTERY 3T-5760 CAB MOUNT PLATE (EEF) 1 M10 GND STUD CAB REAR GND STUD M10 GND STUD FORWARD HORN SW 2T-3360 200-G10 BK-18 200-G7 BK-18 614-G107 BK-18 614-G107 BK-18 L5 L5 200-G20 BK-18 L12 L12 304-E12 WH-14 110-E8 YL-18 200-E4 BK-18 405-EA5 GY-18 109-EA17 RD-10 200-EA18 BK-18 200-EA7 BK-18 304-EA11 WH-10 L987-EA9 WH-18 ROADING LAMPS 9H-1958 322-G97 GY-18 L4 L4 H H ENGINE 906 ENGINE 906 E-C4 1003320 FUEL SHUTDOWN 906 ENGINE OIL SW.

7W-1238 109-WA1 RD-10 20A MAIN BREAKER 9S-0174 102-P2 RD-12 HYD OIL TEMP GAUGE 141-2971 G-C32 1135183 123-G77 WH-18 BACKLIGHT LAMP BEAMS 144-9933 HI BEAM LAMP LO BEAM LAMP GROUND GROUND YL BU YL 1 3 2 4 G-C4 3E3373 619-G6 GN-18 611-G5 PU-18 L1 L1 1 2 406-E6 PU-18 200-E7 BK-18 ENGINE 906 109-P1 RD-4 109-WA1 RD-10 60A 117-P3 RD-6 S I 614-G71 PU-18 200-G69 BK-18 200-G70 BK-18 BU 200-G8 BK-18 200-G9 BK-18 G-C20 7X6222 A-C16 9X0145 T COOLANT SW - 200-E18 BK-18 202-E15 BK-18 109-E17 RD-10 109-E20 RD-10 C444-EA1 YL-18 308-EA3 YL-18 403-EA2 GN-18 109-WC1 RD-10 A/C BREAKER 1394724 G-C29 1141749 G LAMP 7X9065 200-G80 BK-18 614-G72 PU-18 G-C6 3E3373 200-G27 BK-18 L4 102-G33 RD-14 H791-G25 GN-18 H792-G26 BU-18 619-G28 GN-14 611-G29 PU-14 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 102-A32 RD-14 619-A82 GN-14 611-A84 PU-14 H792-A44 BU-18 H791-A43 GN-18 102-A55 RD-18 200-A140 BK-18 614-A88 PU-14 200-A140 BK-18 200-A143 BK-18 200-E18 BK-18 200-E7 BK-18 306-E16 GN-18 L987-E9 WH-18 304-E11 WH-10 403-EA2 GN-18 308-EA3 YL-18 C444-EA1 YL-18 405-EA5 GY-18 406-EA6 PU-18 110-EA8 YL-18 109-EA17 RD-10 109-EA20 RD-10 200-EA13 BK-18 202-EA15 BK-18 304-EA11 WH-10 306-EA16 GN-18 L987-EA9 WH-18 L10 103-P4 RD-10 109-WC1 RD-10 30A 442-G67 GY-18 BACKLIGHT LAMP RH 144-9933 614-G30 PU-18 606-G36 GY-18 200-G22 BK-18 200-G15 BK-18 144-G65 GN-18 102-G14 RD-18 200-G62 BK-14 200-G32 BK-18 102-G13 RD-18 200-A142 BK-18 L20 FRONT FRAME FRONT FRAME 405-E5 GY-18 EA-C2 1073134 CONN 13 P-C3 1275485 SPEED GAUGE 141-4125 123-G78 WH-18 G-C5 3E3373 L5 603-G12 PK-18 614-G19 PU-18 614-G31 PU-18 200-G58 BK-14 200-G59 BK-18 122-G45 BU-18 614-G87 PU-18 122-A67 BU-18 403-A77 GN-18 449-A63 BU-18 442-A75 GY-18 NOSE CONE GND M-10 GND STUD ENGINE OIL SW 7W-1238 1 2 3 I L P EA-C1 3E5179 CONN 1 A-C29 1275484 P-C1 1275483 103-P4 RD-10 S I 614-G74 PU-18 614-G72 PU-18 BACKLIGHT LAMP LH 144-9933 BACKLIGHT LAMP GROUND LH TURN LAMP GROUND YL BU YL 1 2 3 4 614-G34 PU-18 605-G17 YL-18 605-G17 YL-18 200-G35 BK-18 614-G56 PU-18 605-G75 YL-18 606-G79 GY-18 614-G11 PU-18 449-G84 BU-18 442-G67 GY-18 447-G85 PK-18 403-G44 GN-18 447-A64 PK-18 102-A32 RD-14 102-A55 RD-18 483-A5 PK-18 200-A141 BK-14 102-A56 RD-12 B+ 109-EA19 RD-4 403-EA2 GN-18 C444-EA1 YL-18 1 2 3 4 5 6 7 8 9 10 11 12 117-A126 RD-6 A-C15 1297163 CONN 5 1 P-C2 1275486 117-P3 RD-6 G-C26 1141749 G L7 BU 200-G37 BK-18 606-G36 GY-18 614-G11 PU-18 102-G14 RD-18 614-G86 PU-18 102-A144 RD-18 614-A89 PU-14 606-A95 GY-18 605-A96 YL-18 200-A142 BK-18 603-A104 PK-14 144-A30 GN-18 322-A94 GY-18 118-A137 GY-16 118-A138 GY-16 102-A144 RD-18 118-A27 GY-16 118-A167 GY-18 C444-E1 YL-18 308-E3 YL-18 403-E2 GN-18 403-E2 GN-18 308-E3 YL-18 C444-E1 YL-18 405-E5 GY-18 406-E6 PU-18 110-E8 YL-18 200-E4 BK-18 109-E17 RD-10 109-E20 RD-10 200-E13 BK-18 202-E15 BK-18 304-E11 WH-10 306-E16 GN-18 L987-E9 WH-18 ALTERNATOR.

55A 144-9952 90A 144-9963 (ATTACH.) 308-EA3 YL-18 405-EA5 GY-18 L987-EA9 WH-18 102-A56 RD-12 CONN 4 1 102-P2 RD-12 449-G84 BU-18 200-G81 BK-18 G-C3 3E3385 E801-G40 OR-18 202-G38 BK-18 200-G8 BK-18 200-G9 BK-18 606-G36 GY-18 605-G17 YL-18 200-G59 BK-18 605-G75 YL-18 606-G79 GY-18 200-G62 BK-14 603-G12 PK-18 122-A70 BU-18 122-A67 BU-18 122-A71 BU-18 123-A29 WH-18 144-A30 GN-18 406-EA6 PU-18 306-EA16 GN-18 202-EA15 BK-18 L14 A-C35 7T5957 1 FUEL GAUGE 113-5314 G-C31 1135183 123-G73 WH-18 FUNCTION LAMPS 144-9931 E802-G42 YL-18 330-G41 YL-18 200-G22 BK-18 200-G27 BK-18 200-G35 BK-18 200-G58 BK-14 322-G97 GY-18 144-G65 GN-18 330-A100 YL-18 322-A94 GY-18 202-A66 BK-18 E-C2 1073134 ACC SOCKET 117-2311 110-EA8 YL-18 109-EA20 RD-10 109-EA17 RD-10 304-EA11 WH-10 200-EA13 BK-18 L14 101-CG1 RD-00 102-A56 RD-12 109-P1 RD-4 L10 135-A112 BU-18 200-A160 BK-14 2 CONN 3 S I 200-G69 BK-18 614-G74 PU-18 614-G56 PU-18 123-G46 WH-18 419-G43 YL-18 200-G37 BK-18 200-G48 BK-18 330-G41 YL-18 404-G53 YL-18 202-G38 BK-18 CONN 11 404-A90 YL-18 405-A87 GY-18 406-A80 PU-18 403-A77 GN-18 G 1 2 3 I L P E-C1 3E5179 CONN 1 H-C8 3E5176 ALT BRK.

9S-0174 109-EA19 RD-4 117-A126 RD-6 201-A169 BK-18 G-C28 1141749 G LAMP 7X9065 200-G82 BK-18 G-C2 3E5176 405-G49 GY-18 406-G55 PU-18 419-G43 YL-18 G-C21 9X7144 A-C31 9X7143 442-A75 GY-18 419-A81 YL-18 447-A64 PK-18 L21 G ALTERNATOR B+ 109-E19 RD-4 403-E2 GN-18 C444-E1 YL-18 1 2 3 4 5 6 7 8 9 10 11 12 1 2 3 4 5 6 7 8 9 10 11 12 308-H25 YL-18 403-H26 GN-18 C444-H23 YL-18 60A 109-EA20 RD-10 109-EA17 RD-10 109-EA17 RD-10 109-EA20 RD-10 135-A112 BU-18 200-A160 BK-14 201-A169 BK-18 419-A81 YL-18 F765-A117 BR-18 C NC NO PARKING BRAKE SW A 6G-4195 METER FILTER 447-G85 PK-18 POWER IN 1 405-G49 GY-18 123-G47 WH-18 200-G48 BK-18 C444-G50 YL-18 483-G51 BR-18 406-G55 PU-18 404-G53 YL-18 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 406-A80 PU-18 404-A90 YL-18 E455-A92 BR-18 483-A5 PK-18 C444-A78 YL-18 449-A63 BU-18 504-A65 YL-18 503-A76 BR-18 55A 144-9954 90A 144-9964 (ATTACH.) 308-E3 YL-18 200-E4 BK-18 405-E5 GY-18 L987-E9 WH-18 405-H22 GY-18 200-H32 BK-14 L987-H20 WH-18 101-EA10 RD-4 419-A81 YL-18 F765-A117 BR-18 A-C26 3E3379 NOTE H L 141-7556 2 3 1 G-C30 3E3367 403-G44 GN-18 200-G39 BK-18 ACTION LAMPS 144-9930 404-G53 YL-18 E455-G52 BR-18 483-G51 BR-18 483-G51 BR-18 C444-G50 YL-18 E801-G40 OR-18 E417-G54 OR-18 E455-G52 BR-18 E802-G42 YL-18 E455-G52 BR-18 C444-G50 YL-18 605-A96 YL-18 603-A104 PK-14 507-A79 WH-18 506-A72 PU-18 605-A23 YL-18 ALT BRK 9S-0174 406-E6 PU-18 306-E16 GN-18 202-E15 BK-18 406-H21 PU-18 202-H24 BK-18 306-H19 GN-18 G S 304-EA11 WH-10 304-EA11 WH-10 L17 118-A167 GY-18 504-A65 YL-18 4 1 2 6 3 5 MOTOR GN-18 GND T H I 1 122-G45 BU-18 406-G55 PU-18 E417-G54 OR-18 123-G47 WH-18 614-G56 PU-18 123-G46 WH-18 123-G68 WH-18 123-G68 WH-18 123-G105 WH-18 506-G94 PU-18 123-A29 WH-18 122-A70 BU-18 506-A72 PU-18 606-A95 GY-18 606-A22 GY-18 606-A98 GY-18 605-A97 YL-18 60A 109-E19 RD-4 109-E20 RD-10 109-E17 RD-10 110-H30 GN-18 110-E8 YL-18 109-E20 RD-10 109-E17 RD-10 304-E11 WH-10 200-E13 BK-18 200-H27 BK-18 MTR BAT MOTOR STARTER MOTOR.

144-9956 101-EA10 RD-4 200-A158 BK-18 200-A52 BK-14 200-A159 BK-14 200-A10 BK-14 200-A158 BK-18 118-A167 GY-18 503-A76 BR-18 BK-18 GY-18 BR-18 OR-18 P B+ GR-18 BR-18 3 S G HOUR METER 161-3934 123-G73 WH-18 614-G56 PU-18 122-G45 BU-18 507-G96 WH-18 503-G57 BR-18 503-A76 BR-18 507-A79 WH-18 504-A65 YL-18 118-A137 GY-16 200-A141 BK-14 E802-A93 YL-18 330-A100 YL-18 E801-A99 OR-18 419-A81 YL-18 405-A87 GY-18 E417-A68 OR-18 614-A88 PU-14 614-A89 PU-14 611-A84 PU-14 614-A145 PU-14 614-A28 PU-18 614-A85 PU-14 109-P1 RD-4 504-A65 YL-18 515-A11 GY-14 503-A76 BR-18 REAR WIPER MOTOR 152-7691 BK-18 2 L7 L7 123-G77 WH-18 123-G78 WH-18 403-G44 GN-18 322-G97 GY-18 123-G105 WH-18 200-G63 BK-14 504-G95 YL-18 118-G92 GY-14 C444-A78 YL-18 E417-A68 OR-18 619-A82 GN-14 101-E10 RD-4 304-E12 WH-14 109-E17 RD-10 109-E20 RD-10 A538-A118 OR-14 516-A13 GN-14 517-A19 BU-14 517-A19 BU-14 A-C27 3E3373 1 2 3 4 1 2 3 4 504-G95 YL-18 507-G96 WH-18 504-G95 YL-18 504-G95 YL-18 507-G96 WH-18 507-G96 WH-18 503-G57 BR-18 503-G57 BR-18 506-G94 PU-18 506-G94 PU-18 449-G84 BU-18 442-G67 GY-18 447-G85 PK-18 E802-G42 YL-18 330-G41 YL-18 419-G43 YL-18 E801-G40 OR-18 H791-A43 GN-18 E455-A92 BR-18 E802-A93 YL-18 E801-A99 OR-18 304-E11 WH-10 304-E12 WH-14 304-E11 WH-10 109-P1 RD-4 109-P1 RD-4 ENGINE 902 515-A11 GY-14 516-A13 GN-14 200-A52 BK-14 MOTOR REAR WIPER SW 138-4883 1 2 G-C25 1117898 118-G93 GY-14 501-G91 GN-14 501-G91 GN-14 118-G92 GY-14 118-G92 GY-14 G-C23 1117898 200-G70 BK-18 200-G80 BK-18 200-G81 BK-18 200-G106 BK-18 E417-G54 OR-18 405-G49 GY-18 202-G38 BK-18 202-A66 BK-18 H792-A44 BU-18 FRONT FRAME G S MTR BAT 101-CG1 RD-00 101-E10 RD-4 101-CG1 RD-00 504-G95 YL-18 3 4 5 118-G104 GY-14 118-G93 GY-14 503-G57 BR-18 G-C24 1117898 1 2 500-G88 BR-18 200-G82 BK-18 200-G39 BK-18 200-G60 BK-18 200-G63 BK-14 118-G66 GY-14 CONN 10 118-A138 GY-16 MOTOR STARTER MOTOR 144-9953 200-CF1 BK-00 200-A10 BK-14 (A/C FREEZER SW) 507-G96 WH-18 6 118-G64 GY-14 118-G104 GY-14 1 2 3 4 5 506-G94 PU-18 118-G93 GY-14 501-G91 GN-14 118-G92 GY-14 3 4 5 501-G89 GN-14 614-G71 PU-18 200-G99 BK-18 614-G98 PU-18 614-G86 PU-18 200-G61 BK-14 200-CF1 BK-00 200-CF1 BK-00 200-H5 BK-18 200-H32 BK-14 200-H33 BK-18 BLOWER MOTOR 138-0268 614-G102 PU-18 200-G103 BK-18 7 8 6 200-G100 BK-18 200-G99 BK-18 7 6 FRONT WIPER SW 138-4881 502-G90 OR-14 118-G92 GY-14 500-G88 BR-18 501-G91 GN-14 501-G91 GN-14 G-C38 3E3379 4 1 2 6 3 5 MOTOR GN-18 GND L H F F TO ENGINE FRAME 200-H16 BK-18 200-H15 BK-18 200-H27 BK-18 200-A159 BK-14 T REAR WINDOW DEFROST 138-0219 614-G102 PU-18 200-G103 BK-18 200-G103 BK-18 200-G100 BK-18 614-G102 PU-18 614-G101 PU-18 7 8 FRONT WASHER SW 138-4882 614-G101 PU-18 614-G98 PU-18 8 502-G90 OR-14 506-G94 PU-18 507-G96 WH-18 504-G95 YL-18 503-G57 BR-18 500-G88 BR-18 200-G61 BK-14 118-G66 GY-14 BK-18 GY-18 BR-18 OR-18 P B+ ENGINE 906 ENGINE END FRAME M10 GND STUD A538-A118 OR-14 614-G101 PU-18 200-G100 BK-18 200-G99 BK-18 614-G98 PU-18 502-G90 OR-14 FRONT WIPER MOTOR 147-3058 FILTER BYPASS SW 7X8549 E455-H18 PK-18 101-CG1 RD-00 ANTENNA 8E-1118 DASH DASH DASH 109-P1 RD-4 L14 L14 L13 L13 L18 L18 617-H11 PU-18 605-H10 YL-18 200-H15 BK-18 605-H10 YL-18 200-H15 BK-18 617-H11 PU-18 306-H19 GN-18 H-C1 7X6222 CONN 2 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 A-C5 9X0145 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 306-A106 GN-18 ANTENNA RIGHT SPKR + GY/VI GY/BK, VI/BK CBL 8 7 3 2 1 6 5 4 C-C2 3E3385 511-C18 BR-18 512-C19 GN-18 RH SPEAKER 6T7695 - + 200-K20 BK-14 114-K25 GN-18 200-K13 BK-14 200-K15 BK-18 135-C22 BU-18 604-H12 OR-18 604-H3 OR-18 604-H7 OR-18 308-H25 YL-18 403-H26 GN-18 202-H24 BK-18 308-A119 YL-18 403-A77 GN-18 202-A25 BK-18 RIGHT SPKR - GROUND LEFT SPKR + BK WH/GN WH/BK, BN/BK 200-C20 BK-18 508-C15 PU-18 L11 L11 606-K19 GY-18 605-K24 YL-18 322-K26 GY-18 200-C17 BK-18 608-C21 GN-18 122-C23 BU-18 L13 L19 L19 618-H2 PU-18 606-H1 GY-18 200-H5 BK-18 618-H2 PU-18 606-H1 GY-18 200-H5 BK-18 406-H21 PU-18 405-H22 GY-18 L987-H20 WH-18 L987-A116 WH-18 405-A87 GY-18 406-A80 PU-18 LEFT SPKR - + BATTERY (12V) +B MEMORY RD YL 509-C16 WH-18 509-C16 WH-18 135-C22 BU-18 122-C23 BU-18 611-K21 PU-14 614-K22 PU-14 619-K23 GN-14 200-C20 BK-18 508-C15 PU-18 H-C9 3E3361 E802-H17 YL-18 975-H14 WH-18 E455-H18 PK-18 C444-H23 YL-18 C444-A78 YL-18 E802-A121 YL-18 975-A114 WH-18 E455-A92 BR-18 NC CAB RADIO 126-4953 L13 L13 A752-K18 BR-14 781-K12 PK-18 782-K14 GY-18 780-K31 BU-18 200-C12 BK-18 509-C16 WH-18 508-C15 PU-18 L12 L12 LICENSE LAMP 1 2 614-H9 PU-18 200-H33 BK-18 E801-H4 OR-18 110-A183 GN-18 110-H30 GN-18 617-H11 PU-18 E801-A120 OR-18 617-A187 BR-18 L22 NOTE A E783-K30 PU-18 322-A94 GY-18 A-C4 3E3385 C-C1 3E3387 608-C13 GN-18 200-C14 BK-18 607-C11 PK-18 DOME LAMP 084-4277 REVERSE SOL 4 3 2 1 1 2 3 4 H-C5 3E3373 E802-H17 YL-18 321-H8 BR-18 605-H10 YL-18 618-H2 PU-18 321-A110 BR-18 605-A23 YL-18 618-A188 YL-18 REAR FLOOD RH 138-4929 200-C17 BK-18 608-C21 GN-18 447-A64 PK-18 404-A90 YL-18 442-A75 GY-18 449-A63 BU-18 608-A42 GN-14 122-A161 BU-18 200-A147 BK-14 200-A149 BK-14 1 2 3 4 5 6 7 8 608-C4 GN-14 200-C5 BK-14 122-C7 BU-18 200-C6 BK-18 122-C24 BU-18 200-C6 BK-18 122-C24 BU-18 200-C6 BK-18 E FORWARD SOL 975-H14 WH-18 975-H13 WH-18 975-H6 WH-18 E801-H4 OR-18 606-H1 GY-18 604-H7 OR-18 614-H9 PU-18 606-A22 GY-18 604-A105 OR-18 614-A28 PU-18 L11 L11 606-A98 GY-18 605-A97 YL-18 611-A84 PU-14 135-A34 BU-18 607-A41 PK-14 200-A148 BK-14 200-C2 BK-14 607-C3 PK-14 135-C22 BU-18 C-C3 7T5957 BEACON 1 128-6985 E 902 137-7738 906 137-7739 VALVE GP (PUMP) 521-A135 YL-14 FUEL LEVEL SENDER 141-2968 447-K1 PK-18 619-K23 GN-14 605-K24 YL-18 K-C1 9X7144 1 2 3 4 5 6 7 8 9 10 11 13 12 16 14 17 15 18 19 20 21 22 23 24 1 2 3 4 5 6 7 8 9 10 11 13 12 16 14 17 15 18 19 20 21 22 23 24 A-C2 9X7143 611-A84 PU-14 614-A85 PU-14 619-A82 GN-14 605-A97 YL-18 200-A157 BK-18 200-A62 BK-18 200-A150 BK-14 751-A61 GN-18 114-A40 GN-18 619-A82 GN-14 614-A85 PU-14 603-A104 PK-14 603-A104 PK-14 CONN 7 603-C1 PK-18 200-C10 BK-18 603-C1 PK-18 1 BK-14 PK-14 BACKUP ALARM 1384946 L22 L17 L11 614-K22 PU-14 611-K21 PU-14 200-K20 BK-14 606-K19 GY-18 A752-K18 BR-14 114-K25 GN-18 322-K26 GY-18 781-K12 PK-18 782-K14 GY-18 118-A27 GY-16 102-A56 RD-12 118-A167 GY-18 200-C9 BK-18 607-C8 PK-18 200-C10 BK-18 L11 L11 BEACON SOCKET 9R-7941 2 200-H16 BK-18 321-H8 BR-18 200-K17 BK-18 606-A98 GY-18 A752-A132 BR-14 200-A150 BK-14 F747-A131 OR-18 782-A57 GY-14 781-A60 PK-14 123-A29 WH-18 144-A30 GN-18 122-A71 BU-18 603-C1 PK-18 607-C8 PK-18 FRONT FLOOD RH 138-4929 L19 L19 A-C24 7T5957 200-A153 BK-18 200-A154 BK-18 506-A72 PU-18 507-A79 WH-18 110-A183 GN-18 202-A25 BK-18 306-A106 GN-18 308-A119 YL-18 321-A110 BR-18 403-A77 GN-18 405-A87 GY-18 406-A80 PU-18 521-A135 YL-14 604-A105 OR-18 605-A23 YL-18 606-A22 GY-18 614-A28 PU-18 617-A187 BR-18 618-A188 YL-18 975-A114 WH-18 C444-A78 YL-18 E455-A92 BR-18 E801-A120 OR-18 E802-A121 YL-18 L987-A116 WH-18 102-A56 RD-12 117-A126 RD-6 118-A167 GY-18 135-A112 BU-18 200-A10 BK-14 200-A52 BK-14 200-A158 BK-18 200-A159 BK-14 200-A160 BK-14 201-A169 BK-18 419-A81 YL-18 503-A76 BR-18 504-A65 YL-18 515-A11 GY-14 516-A13 GN-14 517-A19 BU-14 A538-A118 OR-14 F765-A117 BR-18 TRANS SPEED SENSOR 3E-8848 K-C3 3E3361 322-A94 GY-18 782-A57 GY-14 114-A40 GN-18 781-A60 PK-14 L981-A174 YL-18 780-A173 BU-18 202-A115 BK-18 A752-A132 BR-14 330-A100 YL-18 322-A94 GY-18 403-A77 GN-18 202-A66 BK-18 L20 L21 200-C9 BK-18 L21 TURN MOTOR REAR WASHER 107-6819 1 2 507-A79 WH-18 200-A154 BK-18 1 2 449-K3 BU-18 200-K9 BK-18 200-K13 BK-14 200-K15 BK-18 780-K31 BU-18 200-K2 BK-14 780-A173 BU-18 200-A157 BK-18 E783-A175 WH-18 780-A173 BU-18 L981-A174 YL-18 E783-A175 WH-18 404-A90 YL-18 405-A87 GY-18 406-A80 PU-18 L20 114-K25 GN-18 - + FORWARD HORN 1 7T-0635 TAIL GY YL OR BK 1 4 3 2 H-C3 3E3373 618-H2 PU-18 606-H1 GY-18 L19 A-C25 7T5957 HYD SHUTOFF SOL K-C7 3E3361 200-K17 BK-18 447-K1 PK-18 L981-K28 YL-18 E783-K30 PU-18 200-K16 BK-18 200-A62 BK-18 L981-A174 YL-18 E783-A175 WH-18 447-A64 PK-18 202-A115 BK-18 A752-A132 BR-14 449-A63 BU-18 442-A75 GY-18 419-A81 YL-18 447-A64 PK-18 L21 L20 200-A143 BK-18 130-A39 GN-18 322-K26 GY-18 STOP 604-H3 OR-18 200-H5 BK-18 MOTOR FRONT WASHER 107-6819 1 2 506-A72 PU-18 200-A153 BK-18 1 2 200-K9 BK-18 L981-K28 YL-18 200-K29 BK-18 F747-K4 OR-18 200-K29 BK-18 449-K3 BU-18 202-K5 BK-18 449-A63 BU-18 202-A115 BK-18 F747-A131 OR-18 781-A60 PK-14 782-A57 GY-14 F747-A131 OR-18 506-A72 PU-18 504-A65 YL-18 503-A76 BR-18 483-A5 PK-18 114-K25 GN-18 604-A105 OR-18 NC NO C BRAKE LAMP SW 6G-4195 REAR LAMPS RH 138-4945 751-K6 GN-18 404-A90 442-A75 GY-18 751-A61 GN-18 YL-18 L25 200-A157 BK-18 200-A62 BK-18 200-A150 BK-14 751-A61 GN-18 114-A40 GN-18 507-A79 WH-18 605-A23 YL-18 606-A22 GY-18 605-A97 YL-18 130-A39 GN-18 122-A162 BU-18 200-K20 BK-14 322-K26 GY-18 200-A143 BK-18 122-A162 BU-18 A-C19 3E3367 BRAKE LEVEL SW 1 2 3 1 2 3 141-0374 RD BK WH VS GND ALM 975-A114 WH-18 202-A25 BK-18 L987-A116 WH-18 306-A106 GN-18 308-A119 YL-18 515-A11 GY-14 516-A13 GN-14 517-A19 BU-14 521-A135 YL-14 A538-A118 OR-14 F765-A117 BR-18 E801-A120 OR-18 E802-A121 YL-18 110-A183 GN-18 117-A126 RD-6 135-A112 BU-18 200-A10 BK-14 200-A52 BK-14 200-A153 BK-18 200-A154 BK-18 200-A158 BK-18 200-A159 BK-14 200-A160 BK-14 201-A169 BK-18 321-A110 BR-18 617-A187 BR-18 618-A188 YL-18 102-A56 RD-12 118-A167 GY-18 403-A77 GN-18 405-A87 GY-18 406-A80 PU-18 419-A81 YL-18 503-A76 BR-18 504-A65 YL-18 506-A72 PU-18 507-A79 WH-18 604-A105 OR-18 605-A23 YL-18 606-A22 GY-18 614-A28 PU-18 C444-A78 YL-18 E455-A92 BR-18 MOTOR REVERSING 1 2 3 4 4 3 2 1 K-C2 3E3373 751-K6 GN-18 CONN 6 118-A27 GY-16 122-A71 BU-18 614-A28 PU-18 606-A98 GY-18 611-A84 PU-14 604-A105 OR-18 606-K19 GY-18 605-K24 YL-18 483-A5 PK-18 SPEED SELECT 202-K8 BK-18 202-K7 BK-18 F747-K4 OR-18 123-A29 WH-18 122-A161 BU-18 122-A162 BU-18 614-A145 PU-14 614-A85 PU-14 619-A82 GN-14 611-K21 PU-14 614-K22 PU-14 619-K23 GN-14 K-C6 3E3385 F-C1 3E3388 FRONT FRAME D D 902 137-7741 906 137-7742 VALVE GP (MOTOR) 144-A30 GN-18 135-A34 BU-18 130-A39 GN-18 200-A147 BK-14 C444-A78 YL-18 E455-A92 BR-18 E801-A99 OR-18 E417-A68 OR-18 E783-K30 PU-18 780-K31 BU-18 614-K22 PU-14 619-K23 GN-14 605-K24 YL-18 1 2 3 4 5 6 7 8 614-F7 PU-14 611-F6 PU-14 619-F9 GN-14 605-F5 YL-18 619-F1 GN-18 614-F4 PU-18 605-F5 YL-18 L9 L9 HYD SW SENDER 142-9804 607-A41 PK-14 608-A42 GN-14 200-A148 BK-14 200-A149 BK-14 H792-A44 BU-18 E802-A93 YL-18 H791-A43 GN-18 606-K19 GY-18 200-K20 BK-14 611-K21 PU-14 200-F10 BK-14 606-F8 GY-18 611-F3 PU-18 200-F2 BK-18 F-C3 3E3379 5 4 L24 L29 L28 L27 T BR-16 WH-16 BK-16 3 1 2 K-C4 3E3367 200-K27 BK-18 442-K10 GY-18 H791-A43 GN-18 H792-A44 BU-18 614-A145 PU-14 130-A39 GN-18 122-A162 BU-18 114-K25 GN-18 E783-K30 PU-18 780-K31 BU-18 CONN 9 780-F16 BU-18 E783-F18 PU-18 200-F14 BK-14 619-F11 GN-18 619-F11 GN-18 614-F12 PU-18 614-F12 PU-18 611-F13 PU-18 606-F8 GY-18 606-F8 GY-18 611-F13 PU-18 200-F14 BK-14 2 6 3 1 BR-16 WH-16 YL-16 RD-16 GN-16 T A= SENDER B= TEMP C= GROUND 404-K11 YL-18 102-A56 RD-12 118-A167 GY-18 200-K20 BK-14 200-K13 BK-14 200-K15 BK-18 K-C5 3E3379 T-C1 3E3382 156-1460 T-C2 F-C4 3E3361 RIGHT CONSOLE 405-A87 GY-18 406-A80 PU-18 419-A81 YL-18 403-A77 GN-18 604-A105 OR-18 606-K19 GY-18 605-K24 YL-18 322-K26 GY-18 A752-K18 BR-14 781-K12 PK-18 782-K14 GY-18 200-K13 BK-14 1 2 3 4 5 6 1 2 3 4 5 6 200-T1 BK-14 A752-T2 BR-14 781-T3 PK-18 782-T4 GY-18 1 2 3 4 5 6 T O O L 780-F16 BU-18 200-F15 BK-18 2 1 COUPLER SOL HEAD TURN LAMP RH 138-4940 138-4942 (LH DIPPED) NOTE B (RH DIPPED) VALVE GP 1 2 A-C33 3E3361 129-A163 BU-18 L27 L27 L27 506-A72 PU-18 504-A65 YL-18 503-A76 BR-18 611-K21 PU-14 614-K22 PU-14 619-K23 GN-14 200-K15 BK-18 CONN 8 200-T5 BK-18 200-T6 BK-18 200-T7 BK-18 E783-F18 PU-18 200-F17 BK-18 F-C5 3E3361 BOOM LOWER SOL 141-9113 200-A155 BK-18 L29 L28 L29 L28 507-A79 WH-18 605-A23 YL-18 604-A105 OR-18 781-K12 PK-18 782-K14 GY-18 780-K31 BU-18 CONN 12 VALVE GP 141-9114 2 1 A-C32 3E3361 200-A37 BK-18 L30 RIGHT CONSOLE C444-A78 YL-18 606-A22 GY-18 E455-A92 BR-18 614-A28 PU-18 A752-K18 BR-14 E783-K30 PU-18 PLATFORM FRONT FRAME FRONT FRAME PLATFORM 129-A164 BU-18 L30 L30 200-A37 BK-18 L26 L26 202-A66 BK-18 330-A100 YL-18 112-A108 PU-12 A-C20 1249636 WIRES THAT HAVE BATTERY VOLTAGE WHEN THE KEY SWITCH IS OFF.

IMPLEMENT DETENTS 129-A163 BU-18 200-A155 BK-18 129-A164 BU-18 E802-A93 YL-18 E801-A99 OR-18 E417-A68 OR-18 FUSES 113-8490 - 10 A 113-8491 - 15 A 113-8492 - 20 A 113-8493 - 25 A 140-A36 BU-16 112-A45 PU-10 126-A18 PK-18 110-A183 GN-18 120-A51 YL-18 WIRES THAT HAVE BATTERY VOLTAGE WHEN THE KEY SWITCH IS ON. STARTING CIRCUIT. C C 1 F N R SW 145-0876 GND 4 4 1 2 3 A-C17 3E3373 201-A151 BK-18 L24 L24 975-A114 WH-18 202-A25 BK-18 RIGHT CONSOLE 118-A27 GY-16 114-A40 GN-18 A1 A2 A3 A4 A5 A6 A7 A8 A9 FUEL SHUTOFF 10A DEFROST 15A XMSN CONTROL 10A BACK UP ALARM 10A GAUGE CIRCUIT.

3 4 2 FOR NEU REV 1 2 3 G750-A103 BU-18 G763-A102 PU-18 G755-A101 GY-18 L31 L31 G750-A103 BU-18 G763-A102 PU-18 G755-A101 GY-18 201-A151 BK-18 124-A26 GN-14 105-A31 RD-18 975-A114 WH-18 202-A25 BK-18 122-A161 BU-18 123-A29 WH-18 122-A71 BU-18 122-A162 BU-18 FUSE BLOCK 116-4159 BASE 123-A29 WH-18 112-A46 PU-10 PANEL LAMP CIRCUIT. WASHER/WIPER CIRCUIT.

RIGHT CONSOLE RIGHT CONSOLE F N R CONTROL 161-8629 A-C1 1338748 126-A18 PK-18 127-A33 OR-18 308-A119 YL-18 515-A11 GY-14 306-A106 GN-18 F765-A117 BR-18 A538-A118 OR-14 521-A135 YL-14 517-A19 BU-14 516-A13 GN-14 515-A11 GY-14 308-A119 YL-18 306-A106 GN-18 135-A34 BU-18 130-A39 GN-18 144-A30 GN-18 135-A34 BU-18 A751-A12 YL-14 112-A107 PU-12 161-A53 PK-14 HEATER AND AIR CONDITIONER CIRCUIT. GROUND CIRCUIT.

Стр. 2