1 page 1 Models J08C-TP and J08C-TR 3-1-4 ENGINE Symptom Possible cause Remedy/Prevention Excessive oil consumption Oil leakage from miscellaneous parts G Oil leakage from oil seal................................ Replace oil seal G Cracks or blowhole in cylinder block ............. Replace cylinder block G Oil leakage from connections of oil lines ...... Tighten connections of oil lines G Oil leakage from oil cooler ............................ Replace oil cooler G Oil leakage from oil pan gasket .................... Replace oil pan gasket G Oil leakage from O-ring ................................. Replace O-ring Other problems G Overcooled engine ........................................
Warm up engine before moving (low temperature wear) vehicle Check cooling system NOTE: If oil consumption is excessive, the problems above will occur. Complaints from the customer are often related to such problems. 1. White smoke is emitted continuously when the engine is run at high speed. 2. White smoke is emitted only immediately after the engine speed is abruptly raised when idling. 3. The tail pipe is blackened with oil. 4. Oil leaks from the flanges of the exhaust manifold. 5. Lack of power. 6. Excessive blow-by gas. Piston seizure and cylinder liner cylinder liner and piston pin as required and cylinder liner and cylinder liner Pistons, cylinder liners and piston rings