OPERATING INSTRUCTIONS FOR STARTING THE ENGINE through oil fill cap located on the top of the engine. See Figure 12 condensation and helps keep fuel cool, which is important to engine performance. Full tanks also reduce the chance for microbe (black slime) growth. For fuel recommendations, refer to the How to Select Diesel Fuel section in this guide. Make sure the fuel shutoff valve (if used) is open. PERSONAL INJURY To avoid injury from slipping and falling, immediately clean up any spilled liquids. NOTICE: Prolonged use of the starting motor and engine fuel pump to prime the fuel system can result in damage to the starter, fuel pump and injectors.
Extended Storage An engine in storage for an extended period of time (over winter, for example) may accumulate water in the oil pan through normal condensation of moisture (always present in the air) on the cold, internal surfaces of the engine. This may cause erratic engine operation due to the amount of air in the lines and filters from the fuel supply tank to the cylinder head NOTICE: Failure to eliminate water-diluted lubricating oil may lead to serious engine damage at startup. Lube oil diluted by water cannot provide adequate bearing protection at engine startup. For this reason, Detroit Diesel recommends replacing the engine lubricating oil and filters after extended storage.
Fuel System Checks Fill the tanks with the recommended fuel. Keeping tanks full reduces water 24 All information subject to change without notice. (Rev. 04/08) DDC-SVC-MAN-0040 0704 Copyright © 2008 DETROIT DIESEL CORPORATION