TM1858 (30JUN04) 9015-2 700H Crawler Dozer 063004 PN=2 Contents Page Page Diagnostic Transmission Calibration Limits Diagnostic Procedures. . . . . . . . . . . . . .9015-15-103 Table . . . . . . . . . . . . . . . . . . . . . . . . . . . .9015-15-53 Under Seat Heater Circuit Diagnostic Transmission Controller Circuit Diagnostic Procedures . . . . . . . . . . . . . . . . . . . . . .9015-15-103 Procedures . . . . . . . . . . . . . . . . . . . . . . .9015-15-54 Front And Rear Light Circuit Transmission Controller Test. . . . . . . . . . . .9015-15-54 Operational Information . . . . . . . . . . . . .9015-15-106 Decelerator Sensor (B1) Circuit Test (S.N. — Theory Of Operation . . . . . . . . . . .
. . . .9015-15-106 920838) . . . . . . . . . . . . . . . . . . . . . . . . . .9015-15-55 Schematic . . . . . . . . . . . . . . . . . . . . . . .9015-15-107 Decelerator Sensor (B1) Circuit Test (S.N. Diagnostic Procedures. . . . . . . . . . . . . .9015-15-108 920839— ). . . . . . . . . . . . . . . . . . . . . . . .9015-15-58 Front And Rear Light Circuit Diagnostic Transmission Speed Control Switch (B4) Procedures . . . . . . . . . . . . . . . . . . . . . .9015-15-108 Test With Speed In Grip . . . . . . . . . . . . .9015-15-61 Radio Circuit Reverse Speed Ratio Switch (B19) Switch Operational Information . . . . . . . . . . . . .9015-15-110 Test . . . . . . . . . . . . . . . . . . . . . . . . .
. . . .9015-15-64 Theory Of Operation . . . . . . . . . . . . . . .9015-15-110 (R6) Motor Shift Resistor Module Test (S.N. Schematic . . . . . . . . . . . . . . . . . . . . . . .9015-15-111 —920838) . . . . . . . . . . . . . . . . . . . . . . . .9015-15-66 Diagnostic Procedures. . . . . . . . . . . . . .9015-15-112 (R4 and R5) Can Termination Resistor Radio Circuit Diagnostic Procedures . . . . .9015-15-112 Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9015-15-67 Left And Right Steer Sensor (B5) Test . . . .9015-15-68 Group 20—References FNR Sensor (B2) And Neutral Start Switch Alternators And Starting Motors—Use (S3) Test . . . . . . . . . . . . . . . . . . . . . . . .
.9015-15-71 CTM77. . . . . . . . . . . . . . . . . . . . . . . . . . . .9015-20-1 Hydrostatic Pump Speed Sensor B6 Service Equipment And Tools . . . . . . . . . . . .9015-20-1 Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9015-15-75 Batteries Left Track Motor Speed Sensor B7 Test . . .9015-15-77 Specifications. . . . . . . . . . . . . . . . . . . . . . .9015-20-2 Right Track Motor Speed Sensor B3 Operation. . . . . . . . . . . . . . . . . . . . . . . . . .9015-20-3 Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9015-15-80 Diagnose Malfunctions. . . . . . . . . . . . . . .
.9015-20-4 Rear Pump (LH) Pressure Control Pilot (PCP) Check Electrolyte Level And Terminals . . .9015-20-5 B8 Test . . . . . . . . . . . . . . . . . . . . . . . . . .9015-15-83 Procedure For Testing . . . . . . . . . . . . . . . .9015-20-7 Front Pump (RH) Pressure Control Pilot Using Booster Batteries—24 Volt System . . .9015-20-8 (PCP) B9 Test . . . . . . . . . . . . . . . . . . . . .9015-15-85 Alternator Operation—24V—55 Amp Bosch Right Motor (RH) Pressure Control Pilot Alternator. . . . . . . . . . . . . . . . . . . . . . . . . .9015-20-9 (PCP) B26 Test . . . . . . . . . . . . . . . . . . . .9015-15-87 Starter Motor Left Motor (LH) Pressure Control Pilot (PCP) Operation. . . . . . . . .
. . . . . . . . . . . . . . . .9015-20-11 B27 Test . . . . . . . . . . . . . . . . . . . . . . . . .9015-15-88 Display Monitor Diagnostic Trouble Codes Engine Controller Circuit Theory of (S.N. 910011—920838) . . . . . . . . . . . . . .9015-20-13 Operation (S.N. 920839— ) . . . . . . . . . . .9015-15-88 Wiper And Washer Circuit Display Monitor Diagnostic Trouble Codes Operational Information . . . . . . . . . . . . . .9015-15-89 (S.N. 920839— ) . . . . . . . . . . . . . . . . . . .9015-20-18 Theory Of Operation . . . . . . . . . . . . . . . .9015-15-89 Access Display Monitor Diagnostic Schematic . . . . . . . . . . . . . . . . . . . . . . . .9015-15-90 Trouble Codes (S.N. 910011— ) . . . . .
. .9015-20-21 Diagnostic Procedures. . . . . . . . . . . . . . .9015-15-91 Program Display Monitor (S.N. 910011— Wiper And Washer Circuit Diagnostic ). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9015-20-24 Procedures . . . . . . . . . . . . . . . . . . . . . . .9015-15-91 Engine Diagnostic Trouble Codes (S.N. Heater Blower Circuit 920839— ). . . . . . . . . . . . . . . . . . . . . . . .9015-20-25 Operational Information . . . . . . . . . . . . . .9015-15-94 Access Engine Diagnostic Trouble Codes Theory Of Operation . . . . . . . . . . . . . . . .9015-15-95 (S.N. 920839— ) . . . . . . . . . . . . . . . . . . .9015-20-30 Schematic . . . . . . . . . . . . . . . . . . . . . . .
.9015-15-96 Transmission Controller Diagnostic Diagnostic Procedures. . . . . . . . . . . . . . .9015-15-97 Trouble Codes And Calibration Codes. . .9015-20-33 Heater Blower Circuit Diagnostic !CAL Displayed On Controller and Check Procedures . . . . . . . . . . . . . . . . . . . . . . .9015-15-97 Service Code Light Flashing . . . . . . . . . .9015-20-36 Under Seat Heater Circuit F311 Transmission Shutdown (Service Operational Information . . . . . . . . . . . . .9015-15-101 Code) . . . . . . . . . . . . . . . . . . . . . . . . . . .9015-20-36 Theory Of Operation . . . . . . . . . . . . . . .9015-15-101 Schematic . . . . . . . . . . . . . . . . . . . . . .
.9015-15-102 Continued on next page 9015