LUBRICATION CHARTS 2 1 Chain 2 Differential 3 Front wheel bearing 4 Brake master cylinder (1 .O - 1.75 ton models) I 5 Transmission case 3 6 Rear wheel bearing 7 Steering knuckle kingpin 8 Bell crank pin 16 9 Oil tank 15 10 Engine crank case 11 Rear axle beam front 4 12 Rearaxlebeam rear 13 Tilt steering universal joint 13 14 Tilt steering liocking meachanism 15 Mast support bushing 5 16 Tilt cylinder front pin 11 17 Propeller shaft I I11 Inspect every 170 hours (monthly) 6 IV I1 Inspect every 40 hours (weekly) lnspectevery8hours(daily) 7 y) V l nspect every 1000 hours lnspectevery2000hours(annually) (6 month1 o lnspect and service Replace 1 MP grease 2 Engine oil 3 Hypoid gear oil 4 Hydraulic oil 5 Gear oil 6 Brake fluid (1 .O - 1.75 ton models) Clutch Model Lubrication Chart LAOM136 Chain Differential Front wheel bearing Brake master cylinder (1 .O - 1.75 ton models) Torque converter case Rear wheel bearing Steering knuckle king pin Bell crank pin Oil tank Engine crank case Rear axle beam front Rear axle beam rear Tilt steering universal joint Tilt steering liocking meachanism Mast support bushing Tilt cylinder front pin Propeller shaft 1 lnspect every 40 hours (weekly) lnspect every 170 hours (monthly) lnspect every 1000 hours (6 monthly) lnspect every 2000 hours (annually) Inspect and service Replace MP grease Engine oil l nspect every 8 hours (daily Hypoid gear oil Hydraulic oil Automatic transmission fluid Brake fluid (1 .O - 1.75 ton models) Torque Converter Model Lubrication Chart