BAIC Harness and Wire Electrical Schematic Symbols Manual PDF (EN)

KENR7847 May 2007 Harness And Wire Electrical Schematic Symbols Symbols Pressure Symbol Temperature Symbol Level Symbol Flow Symbol Circuit Breaker Symbol T Symbols and Definitions Fuse - A component in an electrical circuit that will open the circuit if too much current flows through it. Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it. Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component. Ground (Wired):

This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine. Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch. 330C MHPU Electrical System Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure. T Relay (Magnetic Switch):

A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay. MSL1-UP Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work. MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet.

It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches. Harness and Wire Symbols 1 2 Deutsch connector: Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins. Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets. Machine locations are repeated for components located close together. A = Located inside of cab. B = Located inside of right console. C = Located inside of left console. Harness Identification Letter(s):

(A, B, C, ..., AA, AB, AC, ...) F = Located inside of pump compartment D = Located under platform. E = Located around relay panel . G = Located around control valve H = Behind engine AG L C AG 325-PK-14 1 5A Single Wire Connector Socket Pin Receptacle Pin or Socket Number 9X-1123 Fuse (5 Amps) Plug Component Part Number 2 200-BK-14 ¹ The CID is a diagnostic code that indicates which component is faulty. Ground Connection Circuit Identification Number Wire Color Wire Gauge І The MID is a diagnostic code that indicates which electronic control module diagnosed the fault. © 2007 Caterpillar All Rights Reserved Printed in U.S.A.

25 25 1 11 11 9 E 6 24 24 15 15 2 C 46 46 13 13 28 28 A 42 42 36 36 50 50 49 49 37 37 4 B 9 KENR7847 30 Page, (Dimensions: 39 inches x 28 inches) 48 48 38 38 39 39 H 44 44 40 40 41 41 G 20 Parameter failures. A588 GN Hydraulic Lock Solenoid Relay To Solenoid 8630 BU Atch Beacon Relay 45 45 4I-5394 Sender: Hydraulic Oil Temperature 6134 to 7496 ¹The FMI is a diagnostic code that indicates what type of failure has occurred. 12 12 ¹ At room temperature unless otherwise noted. 43 Event Codes For Engine ECM Event Code Condition 19 19 18 18 F 9 A C CONN 42 G-1 B 49 49 48 48 20 20 B The connectors shown in this chart are for harness to harness connectors.

Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart. 45 45 42 42 36 36 37 37 4 24 24 43 23 23 E 38 38 39 39 1 2 12 12 44 44 40 40 41 41 50 50 46 46 17 F 15 15 28 28 51 51 52 52 19 19 18 18 25 25 53 53 7 22 22 26 26 27 27 10 10 6 13 13 54 54 21 21 D 29 29 11 11 Machine Harness Connector And Component Locations Related Electrical Service Manuals Alternator: 185-5294 SENR4130 Title Form Number Electric Starting Motor: 104-7040 Consist: 6V-5720 SENR3581 Consist: 106-8557 SENR3859 Engine/Pump Control: RENR3814 Engine Control:

SENR9506 Wire Description Wire Number Wire Color Description Wire Number Wire Color Description Power Circuits Accessory Circuits (Continued) 101 RD Battery (+) C537 GN A/C Photo Sensor (Y/W)To Sw Panel A/C + Heater 103 RD Dome Lamp / Memory C538 OR A/C Photo Sensor (Y/G)To Sw Panel A/C + Heater 105 RD Key Switch C569 YL Converter To 12V 10A Socket 108 RD Heater E554 PK A/C Unit To A/C Clutch Solenoid 109 RD Alternator B+ Term E562 PU Rotary Switch (Not Used) 110 RD Timer Relay E564 PK Quick Coupler Safety Lever Relays 112 PU Main Relay E565 BU Rotary Switch 113 OR Switch Panel / Radio Lighting Circuits 114 RD Horn 607 PK Chassis Lamp Relay Output 115 RD Cab Lamp Relay 615 YL Cab Lamp 118 GY Wiper/Washer 616 BU Boom Lamp (Not Used) 120 YL 12V 10A Converter 1 638 WH Atch Beacon Relay Output 123 WH Seat Heater 645 RD Boom Lamp (Sw Panel To Boom Lamp Relay) 124 GN A/C Unit 646 RD Cab Lamp (Sw Panel To Cab Lamp Relay) 129 BU Cigar Lighter A623 BU Chassis Lamp Relay To Diode 130 RD Engine Control Control Circuits 135 BU 12V Memory Out 763 BU Travel Speed Change Solenoid 139 143 147 OR BR PU Radio 12V Memory Atch Boom Float Disable Relay Atch Sol 779 780 788 WH PU YL Low Pressure Quick Coupler Solenoid Atch Quick Coupler Switch Speed Sensor (-) 149 150 151 RD OR GN Boom Lamp Quick Coupler Hydraulic Lock Solenoid Relay A746 A747 A755 PK GY PK Boost Pressure Atmospheric Pressure Throttle Position 1 152 BU Lower Wiper / Washer A756 BU Throttle Position 2 154 RD Neutral Start Relay A757 GY Throttle Position 3 160 168 PU RD Chassis Lamp Refueling Pump A758 A762 BR PU Throttle Position 4 Speed Sensor (+) 169 172 PK GN Backup / Monitor Control Product Link A768 A769 BU GY Power Shift Control Solenoid Power Shift Control Solenoid 175 RD A/C Blower A770 PK Backup Resistor To Backup EPR Valve Switch 179 BU 12V 10A Converter 2 E795 YL Oil Temperature 180 GN Aux Ckt F716 WH Secondary Shutdown Switch 184 RD E/P Control F773 OR Backup Gov Sw A/D To Eng Gov Actuator (Accel) 188 WH Fuel Pump F774 WH Backup Gov Sw A/D To Eng Gov Actuator (Decel) 189 RD Timer Relay Out H705 BR Fuel Pump Relay 196 BU INSP Lamp Socket J702 BK Air Heater Relay 199 OR Beacon Lamp M734 BR Travel Mode Switch Ground Circuits M736 BU Governor Command 200 BK Chassis Ground M737 WH Flow Limit Pressure PRV 201 210 BK BK Monitor Ground Converter 1 Ground M738 M739 OR YL Primary NFC Pressure PRV PRV Return (2) 211 BK Converter 2 Ground M740 PK Travel Straight Solenoid 229 BK Converter 2 Ground M741 GY Travel Alarm Cancel Switch 235 BK E/P Control Ground M742 PU AEC Mode Switch A278 BK Fuel Pump Ground M744 PK Atch Select Switch Bank Basic Machine Circuits 304 WH Start Relay To Motor Starter M746 M747 YL PU Atch Select Switch Bank Atch Select Switch Bank 306 GN Neutral Start Relay To Start Relay 892 BR Cat Data Link ( - ) 307 OR Key Switch To Neutral Start Relay 893 GN Cat Data Link (+) 308 YL Key Switch ON A893 OR Fuel Pump 310 PU Start Aid Sw To Start Aid Sol F889 WH Gov Command 320 RD Horn Switch To Horn Relay G826 BR Oil Pressure 321 BR Travel Alarm G827 BU Oil Presure ( - ) 322 GY Horn Relay To Horns G828 WH +5v From Engine Control To Sensors 323 WH Atch Refueling Pump G829 GN Sensor Common 325 PK Atch Refueling Stop Switch G831 GY Oil Temp +5v 326 RD Key Switch Off G833 PK Sensor Common 329 YL Atch Refueling Stop Rly To Refueling Power Relay G849 BR HEUI Rail Pressure 365 YL Atch Refueling Stop Switch To Refueling Relays G850 BU Air Heater Relay Monitoring Circuits G854 PK Conn HEP 403 GN Alt R Term To Service Meter And E/P Cont G855 PU Conn HEP 405 GN Eng Oil Pressure Switch G856 WH TDC Probe 405 GY Low Oil Pressure Output G857 YL TDC Probe 410 WH Action Alarm K843 GN Right Joystick Sw 1 412 BU Coolant Level Switch K844 GY Left Joystick Sw 1 430 BU Air Cleaner Switch K847 PU Right Joystick Sw 2 487 OR Hydraulic Oil Filter Switch K848 WH Left Joystick Sw 1 491 PK Hydraulic Oil Temperature Sensor K849 YL Atch Not Used 495 GN Fuel Level K850 BR Atch Not Used 496 WH Hyd Oil Level Switch K851 BU Atch Not Used A499 BU Hyd Tank Pressure Switch K852 GN Atch Not Used C468 BU Eng Oil Level Switch 994 GY Oil Pressure E469 YL Tool Pressure Sensor 995 BU Coolant Temperature E470 BR Neg Cont Pressure Sensor 1 998 BR Backup Gov Switch E471 BU Neg Cont Pressure Sensor 2 C967 BU Intake Air Temperature E472 GN +12v Joystick C987 RD Power To Atch Valve Control E473 GY (+) Modulation Joystick (RH) C991 PK Fuel Pressure E474 OR (+) Modulation Joystick (LH) E963 BK Dual Cam Speed/Timing (Run) E480 WH Over Load Alarm Cancel Switch E964 WH Dual Cam Speed/Timing (Run) H446 PK OLWD Pressure Sensor E965 BU Dual Cam Speed/Timing (Crank) H465 GN Action Alarm Cancel Indicator E966 YL Dual Cam Speed/Timing (Crank) H466 H467 BU WH AEC Mode Indicator Travel Mode Indicator G976 K904 BU GN Water Separator Level Switch Pump Discharge 1 Pressure Sensor H473 BR Straight Travel Pressure Switch K906 GN Swing Brake Solenoid H474 GN Travel Right Pressure Switch K907 BU Swing Brake Cancel Solenoid H475 BU Travel Left Pressure Switch L968 OR PRV Return (1) H476 WH Joystick Pressure Switch L969 WH PS Control PRV Accessory Circuits L972 BU One Touch Low Idle Switch 501 GN Wiper Low L973 GN Free Swing 506 508 PU PU Wiper Control To Washer Motor LH Speaker (+) L976 T951 GN YL Atch Refueling Start Switch Injector 1 Solenoid 509 511 512 WH BR GN LH Speaker (-) RH Speaker (+) RH Speaker (-) T952 T953 T954 BR BU GY Injector 2 Solenoid Injector 3 Solenoid Injector 4 Solenoid 530 535 OR BU Wash Signal (Switch Panel To Wiper Control) Lower Wiper Motor (+) T955 T956 GN GY Injector 5 Solenoid Injector 6 Solenoid 586 590 A537 A579 BR GY PK OR Atch Select Switch Bank Wiper INT (3) (Switch Panel To Wiper Control) Seat With Seat Heater Wiper CCW (Wiper Control To Wiper Motor) T957 T958 T959 T960 PU YL BR BU Injector 1 Solenoid Injector 2 Solenoid Injector 3 Solenoid Injector 4 Solenoid A580 A584 A586 BR BU OR Wiper CW (Wiper Control To Wiper Motor) Wiper Cut (Wiper Control To Window Limit Switch) Wiper INT (6) (Switch Panel To Wiper Control) T961 T962 T967 GN WH YL Injector 5 Solenoid Injector 6 Solenoid Pump Discharge 2 Pressure Sensor Component Location Schematic Machine Schematic Machine Component Location Locat Component ion Location Location Action Alarm F-2 A Sensor - A/C Photo Sensor - Atch OLWD Pressure Sensor - Atch Water Separator Level Sensor - Atmostpheric Pressure Sensor - Engine Coolant Temp Sensor - Fuel Level Sensor - Fuel Pressure Sensor - HEUI Rail Pressure Sensor - Intake Air Temp Sensor - Oil Pressure Sensor - Oil Temp Sensor - Pump Discharge Press 1 Sensor - Pump Discharge Press 2 Sensor - Turb Outlet Pressure Service Meter Solenoid - A/C Clutch Solenoid - Hydraulic Lock Solenoid - Injector 1 Solenoid - Injector 2 Solenoid - Injector 3 Solenoid - Injector 4 Solenoid - Injector 5 Solenoid - Injector 6 Solenoid - Power Shift Control Solenoid - Swing Brake Solenoid - Travel Speed Solenoid - Travel Straight Switch - Air Cleaner Switch - Atch Fine Swing Control Switch - Atch Refueling Switch - Atch Refueling Start (NO) Switch - Atch Refueling Stop (NC) Switch - Backup EPR Valve Switch - Backup Gov Switch - Coolant Level Switch - Disconnect Switch - Engine Oil Level Switch - Horn Switch - Hyd Oil Filter Switch - Hyd Oil Level Switch - Hyd Tank Pressure Switch - Joystick Pressure Switch - Key Switch - Neutral Start Limit Switch - One Touch Low Idle Switch - Secondary Shutdown Switch - Throttle Pos Switch - Travel Left Pressure Switch - Travel Right Pressure Switch - Window Limit Switch Panel TDC Probe F-1 A Air Heater E-10 H B-2 21 Alternator E-10 4 H-7 15 Atch A/C Unit D-5 28 C-11 44 Atch Battery E-12 6 B-11 H Atch Converter F-3 A A-4 17 Atch Converter 12V 7A F-3 D B-11 H Atch Heater Unit D-5 28 B-11 42 Atch Joystick (LH) I-3 C B-11 H Atch Joystick (RH) H-1 B C-11 H Battery F-11 6 B-11 49 Block As.

G-11 E A-11 F Breaker - Alternator H-9 E A-10 F Breaker - Heater Relay H-9 E B-11 45 Cigar Lighter F-2 A F-2 A Connector HEP A-11 48 D-11 50 Control - Engine F-12 H C-8 G Control - Engine/Pump E-8 1 C-10 36 Control - Wiper F-2 A C-10 37 Dual Cam Speed/Timing (Crank) B-11 H C-10 38 Dual Cam Speed/Timing (Run) B-11 H C-10 39 Engine Speed Pickup D-11 H Fuse I-7,9 E Horn C-2 7 C-10 C-10 A-11 40 41 F Indicator Unit H-1 B Lamp - Atch Cab G-1 9 Lamp - Chassis C-2 10 Lamp - Dome G-2 A C-9 C-9 C-9 F-9 G G G 24 Monitor F-1 A D-2 A Motor - Fuel Pump H-7 46 A-4 20 Motor - Starter D-11 12 Motor - Washer G-7 13 A-3 A-3 18 19 Motor - Wiper I-1 A Panel - A/C Switch D-1 A G-2 H-2 B B Panel - Atch Heater Switch D-1 A H-7 25 Pump - Atch Refueling A-2 21 G-9 E Relay - Air Heater E-11 H D-11 H Relay - Atch Beacon G-8 E I-3 C Relay - Atch Refueling Power A-2 26 A-5 F Relay - Atch Refueling Start A-3 29 A-4 F Relay - Atch Refueling Stop A-2 27 B-3 43 Relay - Boom Lamp I-8 E H-3 D Relay - Cab Lamp I-8 E G-1 B Relay - Chassis Lamp I-8 E I-3 D Relay - Fuel Pump G-8 E Relay - Horn H-8 E H-1 F-6 B 11 Relay - Hyd Lock H-8 E Relay - Main H-11 E H-1 H-1 B D Relay - Neutral Start H-8 E H-1 D Relay - Start H-11 E G-1 A Relay - Timer I-9 E F-1 A Resistor I-9 E Sender - Hyd Oil Temp A-5 F B-11 H Component Identifiers (CID¹) Module Identifier (MID²) Engine Control (MID² No.

24) CID Component 0001 Injector Solenoid 1st Cylinder 0002 Injector Solenoid 2nd Cylinder 0003 Injector Solenoid 3rd Cylinder 0004 Injector Solenoid 4th Cylinder 0005 Injector Solenoid 5th Cylinder 0006 Injector Solenoid 6th Cylinder 0041 8V + Power Supply 0042 Injector Actuation Control Valve 0091 Throttle Position Switch 0094 Fuel Pressure Sensor 0100 Engine Oil Pressure Sensor 0110 Engine Coolant Temperature Sensor 0164 Injector Pressure Sensor 0168 0172 0175 System Voltage Inlet Air Temperature Sensor Engine Oil Temperature Sensor 0190 0253 0261 Engine Speed Sensor Personality Module Timing Sensor Calibration 0262 Analog Sensor Power Supply Voltage 0268 0273 Programmable Parameters Turbocharger Compressor Outlet Pressure Sensor 0274 0286 Atmospheric Pressure Sensor EMS Oil Lamp 0342 Speed Timing Sensor 0617 Air Heater Relay 1627 Fuel Pump Relay 1715 Engine Oil Temperature Sensor 2 Engine/Pump Control (MID² No.

69) CID Component 0091 Throttle Position Signal 0096 0110 Fuel Level Sensor Engine Coolant Temperature Sensor 0167 Alternator 0168 Voltage Of The Power Supply (keyswitch) 0190 Speed Sensor 0286 Signal For Engine Oil Pressure Decrease 0374 Swing Brake Solenoid 0376 Travel Alarm 0581 Proportional Reducing Valve For The Power Shift Pressure 0586 Engine Speed Dial 0587 Feedback sensor for the govenor actuator 0590 Engine Control 0598 Travel Speed Solenoid 0600 Hydraulic Oil Temperature Sensor 1161 Pump Delivery Pressure Sensor (Drive) 1162 Pump Delivery Pressure Sensor 2 (Idle) 1525 Straight Travel Solenoid 2002 Action Alarm Tool Control (MID² No.

06A) CID Component 0145 12V DC Power Supply 1657 Left Joystick Slide Control 1658 Right Joystick Slide Control 1 2 Failure Mode Identifiers (FMI)¹ FMI No. Failure Description 0 Data valid but above normal operational range. 1 2 Data valid but below normal operational range. Data erratic, intermittent, or incorrect. 3 Voltage above normal or shorted high. 4 Voltage below normal or shorted low. 5 Current below normal or open circuit. 6 Current above normal or grounded circuit. 7 Mechanical system not responding properly. 8 Abnormal frequency, pulse width, or period. 9 10 11 Abnormal update. Abnormal rate of change. Failure mode not identifiable. 12 13 Bad device or component.

Стр. 1

10 11 12 9 8 7 6 5 4 3 2 1 RELAY PANEL OPERATOR STATION L60 A770-PK-18 D D BACKUP RESISTOR 7Y-8242 169-PK-18 DIODE 121-1022 D 646-RD-18 646-RD-18 INSP LAMP SOCKET 9R-7941 196-BU-16 200-BK-16 2 1 5 E E K848-WH-18 K844-GY-18 E474-OR-18 E472-GN-18 1 3 +12V ATCH JOYSTICK 000-0000 ATCH LOWER WIPER MOTOR 186-5763 169-PK-18 169-PK-18 A588-GN 147-PU 322-GY 607-PK 616-BU A623-BU-18 D CONN 29 3 4 4 6 5 SWITCH 2 SWITCH 1 PWM+ A L52 L52 L52 BOOM LAMP RELAY 161-3128 5A 143-BR-18 BOOM FLOAT 6 235-BK-18 235-BK-18 235-BK-18 235-BK-18 2 235-BK-18 COMMON GND L15 A580-GN-14 A579-OR-14 118-GY-14 200-BK-14 3 1 4 2 I 114-RD 115-RD 149-RD 8630-BU-18 149-RD 149-RD 149-RD 645-RD-18 10A 10A 5A D 196-BU-16 FUEL PUMP 188-WH-18 INSP LAMP CONN 30 HORN SW 128-2134 I 149-RD 115-RD D 616-BU 10A 10A 5A BACKUP/MONITOR CONT 5A 169-PK-18 160-PU-16 118-GY-14 CHASSIS LAMP WIPER/WASHER 200-BK-16 200-BK-16 200-BK-18 320-RD-18 200-BK-18 A 2 1 E E 320-RD-18 200-BK-18 CONSOLE(LH) 235-BK-18 235-BK-18 235-BK-18 235-BK-18 235-BK-18 114-RD RD-18 WH-18 160-PU 160-PU 160-PU CHASSIS LAMP RELAY 161-3128 A623-BU-18 10A 10A SW PANEL/RADIO 5A 152-BU-16 129-BU-16 123-WH-18 LOWER WIPER/WASHER CIGAR LIGHTER SEAT HEATER L17 L17 L17 320-RD-18 154-RD A A NEUTRAL START LIMIT SW 163-6785 235-BK-18 D 607-PK 607-PK 10A 10A 10A 5A 179-BU-16 120-YL-16 147-PU-16 113-OR-18 ATT SOL 12V 7A CONVERTOR 1 12V 7A CONVERTOR 2 147-PU 147-PU 147-PU GROUND STRAP 7G-1060 200-BK-16 200-BK-18 200-BK-16 200-BK-18 189-RD 151-GN 200-BK-18 A588-GN-18 C B BK-18 1 2 L15 235-BK-18 2 10A CAB LAMP RELAY 161-3128 15A 5A 124-GN-14 199-OR-16 BEACON LAMP A/C UNIT A 200-BK-14 200-BK-14 200-BK-14 A ATCH ANTI-DRIFT SOL L15 K849-YL-18 ATCH FOR HAMMER PRESS SW 1 114-RD 114-RD 115-RD 115-RD 115-RD D 646-RD-18 615-YL 10A 5A 180-GN-16 AUX CKT PLATFORM CHASSIS B A H473-BR-18 235-BK-18 A 2 1 167-3466 320-RD-18 HORN RELAY 161-3128 112-PU-6 SS 199-OR-16 199-OR-16 199-OR-16 199-OR-16 123-WH-18 308-YL 114-RD 129-BU 11 9 6 8 A588-GN-18 L15 235-BK-18 235-BK-18 235-BK-18 235-BK-18 L15 ATCH FOR STRAIGHT TRAVEL PRESS.SW 167-3466 H475-BU-18 235-BK-18 A 2 1 114-RD 114-RD 114-RD 322-GY L51 147-PU-16 120-YL-16 179-BU-16 124-GN-14 A770-PK-18 615-YL 645-RD-18 2 3 4 CONN 19 169-PK-18 169-PK-18 169-PK-18 189-RD 151-GN 154-RD 320-RD-18 L17 235-BK-18 H473-BR-18 TRAVEL LEFT PRESS.

SW 167-3466 HYDRAULIC LOCK SOLENOID RELAY 161-3128 D 123-WH-18 152-BU-16 129-BU-16 113-OR-18 151-GN 154-RD 105-RD 189-RD 320-RD-18 10 7 5 12 1 105-RD 307-OR A770-PK-18 L34 H473-BR-18 H476-WH-18 235-BK-18 235-BK-18 235-BK-18 H476-WH-18 235-BK-18 A 1 2 A JOYSTICK PRESSURE SWITCH 167-3466 L16 H474-GN-18 H475-BU-18 K849-YL-18 H474-GN-18 235-BK-18 1 2 151-GN 200-BK-18 A588-GN-16 114-RD-16 114-RD-16 8630-BU B 4 A CONN 18 8630-BU 638-WH H474-GN-18 K849-YL-18 H475-BU-18 L16 L16 L16 CONSOLE(RH) TRAVEL RIGHT PRESS.

SW 167-3466 H L54 189-RD 189-RD D A588-GN 199-OR 118-GY-14 638-WH 6 5 2 3 1 129-BU 113-OR-18 646-RD-18 118-GY 615-YL 123-WH-18 CONN 31 F K847-PU-18 K843-GN-18 E473-GY-18 E472-GN-18 L14 L14 E472-GN-18 E473-GY-18 K843-GN-18 K847-PU-18 3 1 5 6 4 2 +12V PWM+ SWITCH 1 SWITCH 2 COMMON H 189-RD L51 L36 L36 L36 L36 607-PK 103-RD 175-RD-14 307-OR B 5 A L25 12 235-BK-18 F F 235-BK-18 235-BK-18 ATCH JOYSTICK 000-0000 GND 154-RD-16 NEUTRAL START RELAY 161-3128 200-BK-18 FUEL PUMP 188-6121 1 8 7 12 3 120-YL-16 147-PU 645-RD-18 103-RD A770-PK-18 105-RD-16 307-OR-16 105-RD-16 A770-PK-18 169-PK-18 200-BK-18 C O N N 11 8 5 1 2 3 A758-BR-18 A757-GY-18 A756-BU-18 A755-PK-18 L972-BU-18 607-PK-16 200-BK-18 200-BK-18 200-BK-18 200-BK-18 A537-PK-18 2 1 L972-BU-18 607-PK 235-BK-18 235-BK-18 235-BK-18 235-BK-18 200-BK-18 +B L.

CHASSIS IND UNIT 163-6702 235-BK-18 307-OR-16 172-GN-18 307-OR-16 306-GN-16 D COOLANT LEVEL SW 245-9206 SIGNAL SIGNAL +B GROUND ATCH WTR SEPARATOR LEVEL SNSR 178-2345 MOTOR 120-YL 124-GN-14 2 4 CONN 17 308-YL 308-YL 308-YL 199-OR 114-RD 307-OR-16 307-OR-16 308-YL-16 3 2 4 F F A757-GY-18 A756-BU-18 A755-PK-18 5 4 3 2 S4 S3 S2 S1 235-BK-18 4 2 1 3 646-RD-18 113-OR-18 147-PU 169-PK-18 6 10 9 11 175-RD-14 124-GN-14 607-PK 607-PK 607-PK 607-PK A758-BR-18 A757-GY-18 A756-BU-18 A755-PK-18 L972-BU-18 607-PK-16 C O N N 9 10 6 7 M736-BU-18 169-PK-18 F774-WH-18 F773-OR-18 998-BR-18 BACKUP GOV SW 163-6711 F F 2 3 F773-OR-18 F774-WH-18 A758-BR-18 235-BK-18 F 6 1 THROTTLE POSITION SWITCH 106-0107 COM L972-BU-18 ONE TOUCH LOW IDLE SW 128-2134 151-GN-16 151-GN-16 L50 L50 B B 235-BK-18 G976-BU-18 147-PU 1 2 607-PK-16 200-BK-14 200-BK-14 124-GN-14 175-RD-14 L35 L18 L18 F774-WH-18 F773-OR-18 A 1 2 F F F889-WH-18 998-BR-18 F 1 BACKUP EPR VALVE SW 163-6710 235-BK-18 235-BK-18 235-BK-18 235-BK-18 L54 L49 H705-BR-18 FUEL PUMP RELAY 161-3128 229-BK-18 A893-OR-18 A278-BK-16 L26 K906-GN-18 A768-BU-18 A769-GY-18 L968-OR-18 L969-WH-18 K907-BU-18 M736-BU-18 3 3 A 3 9 8 11 6 5 A770-PK-18 K907-BU-18 A537-PK-18 K907-BU-18 K906-GN-18 A770-PK-18 169-PK-18 3 2 1 L13 K906-GN-18 308-YL R 308-YL-16 C987-RD-14 105-RD-16 184-RD--16 130-RD-14 235-BK-14 893-GN-18 892-BR-18 616-BU-16 607-PK-16 322-GY-16 147-PU-16 11 A588-GN-16 304-WH-8 109-RD-6 109-RD-4 101-RD-4 101-RD-4 108-RD-4 168-RD-10 151-GN-16 169-PK-18 A770-PK-18 646-RD-18 638-WH-16 8630-BU-18 L60 L60 L60 638-WH-16 188-WH-18 D A893-OR-18 235-BK-18 235-BK-18 412-BU-18 B L24 L24 L18 L25 CAB C O N N A769-GY-18 L968-OR-18 L969-WH-18 L969-WH-18 M736-BU-18 9 8 7 6 5 4 A768-BU-18 105-RD 307-OR 326-RD C S B OFF ON ST 150-OR-18 F F 780-PU-18 151-GN-16 L58 8630-BU-18 ATCH BEACON RELAY 161-3128 200-BK-18 H705-BR-18 607-PK 320-RD-18 A893-OR-18 645-RD-18 615-YL G 512-GN-18 511-BR-18 F889-WH-18 998-BR-18 326-RD-16 1 10 7 12 4 2 K906-GN-18 A768-BU-18 105-RD-16 307-OR-16 326-RD-16 308-YL-16 L13 F889-WH-18 235-BK-18 12 11 10 A769-GY-18 235-BK-18 CONN 42 KEY SWITCH 9G-7641 F L D 7 9 1 10 6 8 5 2 4 3 12 D PP NN EE XX DD YY D D 1 3 4 2 5 6 L57 L49 L51 BK-00 BK-00 JJ CC L49 199-OR-16 D 638-WH-16 154-RD 189-RD 118-GY ATCH SPEAKER (R) 7Y-5505 511-BR-18 512-GN-18 A537-PK-18 3 4 A F L968-OR-18 F L13 G CONN 2 L59 CONN 3 BLOCK AS.

121-1023 B B B B B B B L58 CONN 5 L59 L59 L58 320-RD-18 189-RD-16 154-RD-16 175-RD-14 103-RD-16 308-YL-16 645-RD-18 615-YL-16 607-PK-16 H705-BR-18 118-GY-14 A893-OR-18 A588-GN-16 114-RD-16 199-OR-16 123-WH-18 179-BU-16 124-GN-14 113-OR-18 147-PU-16 120-YL-16 129-BU-16 152-BU-16 172-GN-18 307-OR-16 L51 L49 L49 L51 235-BK-14 235-BK-14 B L26 ATCH SPEAKER (L) 7Y-5505 A 2 1 F 780-PU-18 150-OR-18 CONSOLE(RH) 780-PU-18 150-OR-18 G 304-WH-8 109-RD-4 101-RD-4 108-RD-4 168-RD-10 L58 147-PU-16 607-PK-16 A588-GN-16 130-RD-14 184-RD-16 105-RD-16 322-GY-16 235-BK-14 893-GN-18 892-BR-18 616-BU-16 304-WH-8 109-RD-4 101-RD-4 168-RD-10 638-WH-16 8630-BU-18 169-PK-18 A770-PK-18 646-RD-18 151-GN-16 D D GROUND STRAP 167-3583 DISCONNECT SW.

7N-0718 7N-0719 (NOTE D) L51 412-BU-18 147-PU-16 G976-BU-18 A893-OR-18 A278-BK-16 506-PU-18 506-PU-18 WASHER 7T-8890 MOTOR 200-BK-18 CAB 615-YL G 11 8 1 10 5 6 9 4 2 3 12 7 B 9 11 7 1 4 2 6 10 3 5 12 8 B 2 4 1 3 B RELAY PANEL 506-PU-18 412-BU-18 G976-BU-18 430-BU-18 L38 L38 103-RD G DOME LAMP 176-1986 200-BK L59 L59 L56 CONN 7 CONN 8 CONN 10 CHASSIS A278-BK-16 L46 200-BK-18 200-BK 200-BK-18 200-BK 615-YL G A893-OR-18 147-PU-16 L35 L18 CONN 200-BK-18 A584-BU-18 200-BK-18 G G WINDOW LIMIT SW 117-6306 L56 308-YL 308-YL 308-YL L46 L38 L25 L7 607-PK-16 780-PU-18 E562-PU-18 779-WH-18 E565-BU-18 A588-GN-16 101-RD-4 109-RD-4 168-RD-10 304-WH-8 130-RD-14 616-BU-16 322-GY-16 H705-BR-18 893-GN-18 892-BR-18 184-RD-16 A893-OR-18 A588-GN-16 169-PK-18 113-OR-18 147-PU-16 120-YL-16 646-RD-18 124-GN-14 638-WH-16 607-PK-16 103-RD-16 175-RD-14 307-OR-16 114-RD-16 8630-BU-18 118-GY-14 199-OR-16 189-RD-16 105-RD-16 154-RD-16 151-GN-16 320-RD-18 615-YL-16 645-RD-18 A770-PK-18 123-WH-18 129-BU-16 172-GN-18 235-BK-14 308-YL-16 308-YL L36 L36 A L26 G B 235-BK-18 3 1 2 F716-WH-18 235-BK-18 AM 2 1 F716-WH-18 235-BK-18 L24 200-BK-14 200-BK-14 200-BK-14 G A 14 1 6 CONN 26 200-BK-14 200-BK-14 G CIGAR LIGHTER 9W-0335 ACC GND 3 2 607-PK-18 169-PK-18 892-BR-18 893-GN-18 201-BK-18 L7 1 2 4 3 892-BR-18 893-GN-18 403-GN-18 308-YL-16 235-BK-18 172-GN-18 235-BK-14 235-BK-18 235-BK-18 235-BK-14 SECONDARY SHUTDOWN SW 4D1836 CONN 20 12 2 8 E562-PU-18 + - SERVICE METER 6T-7337 103-RD-18 L6 F 6 5 A893-OR-18 20 17 10 9 E565-BU-18 A579-OR-14 A580-GN-14 114-RD-16 200-BK-18 G MONITOR 157-3198 A/C PHOTO SENSOR 167-7083 (NOTE G) Y/G 8 F ATCH PRODUCT LINK L41 L40 893-GN-18 892-BR-18 184-RD-16 B A 21 11 7 607-PK 607-PK-18 607-PK 118-GY-14 118-GY-14 Y/W G G C537-GN-18 C538-OR-18 L5 F716-WH-18 L973-GN-16 F889-WH-18 C O N N 10 11 1 8 A758-BR-18 L968-OR-18 F889-WH-18 235-BK-18 F716-WH-18 K849-YL-18 235-BK-18 235-BK-18 L26 A537-PK-18 200-BK-16 307-OR-16 18 5 13 4 8630-BU-18 199-OR-16 147-PU-16 G WIPER CONTROL 155-7042 G A586-OR-18 530-OR-18 501-GN-18 590-GY-18 ENGINE CONTROL 157-3165 B L46 L39 L40 403-GN-18 M736-BU-18 K907-BU-18 L969-WH-18 L968-OR-18 1 6 5 6 4 9 A756-BU-18 A755-PK-18 E480-WH-18 H474-GN-18 H475-BU-18 H476-WH-18 H473-BR-18 235-BK-18 L35 L35 L18 L26 A580-GN-14 A579-OR-14 118-GY-14 235-BK-18 15 16 3 19 L973-GN-18 310-PU-16 307-OR-16 L11 MOT A580-BR-14 A579-OR-14 A584-BU-18 200-BK-18 645-RD-18 4 3 2 1 892-BR-18 L30 L30 H466-BU-18 H465-GN-18 12 3 2 L969-WH-18 410-WH-18 403-GN-18 308-YL-16 308-YL-16 114-RD-16 638-WH-16 607-PK-16 169-PK-18 123-WH-18 200-BK-14 INT +24 INT A586-OR-18 590-GY-18 501-GN-18 530-OR-18 118-GY-14 F889-WH-18 F716-WH-18 893-GN-18 H467-WH-18 410-WH-18 892-BR-18 C O N N 7 9 A757-GY-18 M734-BR-18 326-RD-16 K906-GN-18 A768-BU-18 A769-GY-18 L968-OR-18 L969-WH-18 K907-BU-18 M736-BU-18 F774-WH-18 F773-OR-18 A758-BR-18 A757-GY-18 A756-BU-18 A755-PK-18 L972-BU-18 L24 L25 199-OR-16 8630-BU-18 615-YL-16 123-WH-18 A 9 13 G CONN 25 169-PK-18 615-YL-16 113-OR-18 H467-WH-18 646-RD-18 M734-BR-18 M742-PU-18 M741-GY-18 H465-GN-18 H466-BU-18 403-GN-18 403-GN-18 403-GN-18 K907-BU-18 L969-WH-18 L968-OR-18 H466-BU-18 H465-GN-18 H467-WH-18 410-WH-18 L973-GN-16 M736-BU-18 403-GN-18 L30 L30 H473-BR-18 K849-YL-18 893-GN-18 7 11 1 4 H474-GN-18 L972-BU-18 H465-GN-18 M741-GY-18 L25 129-BU-16 113-OR-18 646-RD-18 17 16 12 7 H466-BU-18 H465-GN-18 M741-GY-18 M742-PU-18 M734-BR-18 646-RD-18 H467-WH-18 638-WH-16 200-BK-16 G 1 2 L9 H476-WH-18 H475-BU-18 H474-GN-18 L972-BU-18 A755-PK-18 A756-BU-18 A757-GY-18 A758-BR-18 1 5 10 5 2 6 M736-BU-18 H476-WH-18 H466-BU-18 L18 645-RD-18 147-PU-16 103-RD-16 120-YL-16 14 1 2 L9 SWITCH PANEL 163-6701 L6 L5 J2 E480-WH-18 ENGINE/PUMP CONTROL 157-3165 J1 L39 L29 12 3 8 H475-BU-18 M742-PU-18 H467-WH-18 L973-GN-16 118-GY-14 892-BR-18 893-GN-18 410-WH-18 H467-WH-18 M734-BR-18 M742-PU-18 M741-GY-18 H465-GN-18 H466-BU-18 201-BK-18 8 10 15 11 E480-WH-18 410-WH-18 H467-WH-18 H465-GN-18 H466-BU-18 L968-OR-18 L969-WH-18 K907-BU-18 L38 M741-GY-18 M742-PU-18 M734-BR-18 C O N N 11 8 1 A768-BU-18 E565-BU-18 310-PU-16 F889-WH-18 998-BR-18 114-RD-16 6 3 18 5 4 120-YL-16 113-OR-18 586-BR L6 E E480-WH-18 308-YL-16 10 6 5 E562-PU-18 506-PU-18 586-BR-16 E565-BU-18 403-GN-18 506-PU-18 310-PU-16 892-BR-18 893-GN-18 410-WH-18 H467-WH-18 M734-BR-18 M742-PU-18 M741-GY-18 H465-GN-18 H466-BU-18 A G 7 2 A537-PK-18 645-RD-18 506-PU-18 403-GN-18 129-BU-16 410-WH-18 L10 E KENR7847 30 Page, Color 2, (Dimensions:

39 inches x 28 inches) BK-00 RD-00 RD-00 RD-00 BK-00 403-GN-18 M736-BU-18 L973-GN-16 892-BR-18 892-BR-18 892-BR-18 892-BR-18 892-BR-18 892-BR-18 893-GN-18 893-GN-18 893-GN-18 893-GN-18 893-GN-18 K849-YL-18 K849-YL-18 K906-GN-18 A768-BU-18 A769-GY-18 F774-WH-18 F773-OR-18 E554-PK-18 E565-BU-18 506-PU-18 1 4 2 3 9 4 A769-GY-18 326-RD-16 893-GN-18 892-BR-18 506-PU-18 403-GN-18 310-PU-16 12 8 3 1 L12 508-PU-18 509-WH-18 103-RD-18 892-BR-18 893-GN-18 JJ HH POS NEG POS NEG GG CC NEG POS BB NEG A762-PU-18 788-YL-18 763-BU-18 F889-WH-18 235-BK-14 184-RD-16 L28 12 7 E554-PK-18 K849-YL-18 L973-GN-16 E480-WH-18 586-BR-16 10 6 9 235-BK-18 892-BR-18 893-GN-18 ATCH BATTERY 3T-5760 BATTERY 3T-5760 L48 M737-WH-18 T967-YL-18 491-PK-18 K904-GN-18 495-GN-18 M739-YL-18 321-BR-18 M738-OR-18 M740-PK-18 A499-BU-18 E562-PU-18 998-BR-18 C O N N 6 7 4 5 2 F716-WH-18 1 K907-BU-18 998-BR-18 L973-GN-16 E565-BU-18 E562-PU-18 114-RD-16 11 5 4 CONN 24 103-RD 103-RD 103-RD 511-BR-18 509-WH-18 135-BU-16 139-OR-18 512-GN-18 210-BK-16 508-PU-18 893-GN-18 K849-YL-18 1 3 3 8 F773-OR-18 F774-WH-18 K906-GN-18 E480-WH-18 E562-PU-18 586-BR-16 A B G M747-PU-18 M746-YL-18 M744-PK-18 L32 G L8 H446-PK-18 496-WH-18 405-GY-18 C468-BU-18 487-OR-18 L39 235-BK 235-BK 184-RD 184-RD H473-BR-18 235-BK-18 E554-PK-18 L24 C CONN 23 ATCH UPPER RADIO 8 4 5 6 1 7 3 2 235-BK-16 235-BK-16 CAB F716-WH-18 184-RD-16 184-RD-16 430-BU-18 G976-BU-18 L32 L5 L33 L31 K850-BR-18 892-BR-18 893-GN-18 412-BU-18 L38 L31 L31 K849-YL-18 892-BR-18 893-GN-18 L29 L28 E554-PK-18 200-BK-14 175-RD-14 124-GN-14 L24 607-PK-16 200-BK-14 ATCH 12V 7A SOCKET 121-0987 (NOTE F) C569-YL-14 211-BK-16 A537-PK-18 123-WH-18 200-BK-18 200-BK-18 607-PK-18 M746-YL-18 M747-PU-18 M744-PK-18 200-BK-18 C538-OR-18 C537-GN-18 229-BK-14 229-BK-14 229-BK-14 229-BK-14 L55 F774-WH-18 F773-OR-18 E554-PK-18 K906-GN-18 A768-BU-18 A769-GY-18 998-BR-18 K849-YL-18 K851-BU-18 K850-BR-18 K852-GN-18 K851-BU-18 G G G G G G G D 130-RD-14 130-RD-14 130-RD-14 130-RD-14 H473-BR-18 K852-GN-18 E480-WH-18 4 5 6 B K850-BR-18 K851-BU-18 K852-GN-18 A 6 4 5 1 3 2 ATCH 12V 7A SOCKET 121-0987 210-BK-14 135-BU-14 NOTE C NOTE C NOTE C G D H705-BR-18 130-RD-14 998-BR-18 L55 H476-WH-18 H475-BU-18 H474-GN-18 L972-BU-18 A755-PK-18 A756-BU-18 CONN 12 3 2 1 892-BR-18 893-GN-18 K849-YL-18 G R/L R B B BR G 114-RD E565-BU-18 E562-PU-18 E562-PU-18 ATCH O.L.W.D ALARM CANCEL SW 170-9317 F773-OR-18 892-BR-18 893-GN-18 L42 779-WH-18 E562-PU-18 E565-BU-18 506-PU-18 A588-GN-16 A757-GY-18 L29 E554-PK-18 L29 F889-WH-18 F774-WH-18 308-YL-16 405-GN-18 L33 A758-BR-18 M741-GY-18 M742-PU-18 M734-BR-18 L33 L28 L33 A768-BU-18 A769-GY-18 F774-WH-18 F773-OR-18 A/C UNIT 161-3779 E565-BU-18 E562-PU-18 G 3 4 2 ATCH FINE SWING CONT SW 163-6722 ATCH SEAT HEATER SW 163-6721 A/C SW PANEL 157-3210 ATCH HEATER SW PANEL 176-2005 STRAP ENG BLOCK L43 L43 L42 L42 CHASSIS L43 L42 L21 L37 B L33 L37 B 308-YL-16 L37 L37 E562-PU-18 K906-GN-18 998-BR-18 CAB OPERATOR STATION 114-RD 1 CAB AE L55 CONN 6 L42 E565-BU-18 506-PU-18 CONN 41 G850-BU-18 J702-BK-18 T953-BU-18 T959-BR-18 T954-GY-18 T960-BU-18 T955-GN-18 T961-GN-18 T956-GY-18 T962-WH-18 L55 T945-GY-18 T946-PU-18 T947-YL-18 T948-BR-18 T949-BU-18 T950-GN-18 T951-YL-18 T957-PU-18 T952-BR-18 T958-YL-18 T953-BU-18 T959-BR-18 T954-GY-18 T960-BU-18 T955-GN-18 T961-GN-18 T956-GY-18 T962-WH-18 13 AE 6 P T962-WH-18 T956-GY-18 T961-GN-18 T955-GN-18 T960-BU-18 T954-GY-18 T959-BR-18 T953-BU-18 T958-YL-18 T952-BR-18 T957-PU-18 235-BK-18 235-BK-18 235-BK-18 235-BK-18 L21 235-BK-18 235-BK-18 L21 L21 L21 ANTENNA 167-3492 322-GY-16 616-BU-16 168-RD-10 607-PK-16 L1 200-BK 616-BU B 14 15 5 235-BK-18 235-BK-18 235-BK-18 235-BK-18 235-BK-18 B M740-PK-18 K906-GN-18 235-BK-18 L22 L22 L22 H446-PK-18 235-BK-18 147-PU-16 L2 200-BK 322-GY 200-BK B M 1 2 322-GY M HORN 7T-0970 T952-BR-18 T958-YL-18 16 17 4 3 TRAVEL STRAIGHT SOL 121-1491 2 1 B 763-BU-18 M740-PK-18 235-BK-18 A588-GN-18 200-BK-18 A588-GN-16 A588-GN-16 A588-GN-18 A588-GN-18 A588-GN-16 L22 A588-GN-18 763-BU-18 K906-GN-18 M740-PK-18 780-PU-18 779-WH-18 147-PU-16 H446-PK-18 L973-GN-16 A769-GY-18 A768-BU-18 487-OR-18 496-WH-18 321-BR-18 495-GN-18 491-PK-18 M739-YL-18 M737-WH-18 M738-OR-18 T967-YL-18 K904-GN-18 147-PU-16 168-RD-10 607-PK-16 322-GY-16 616-BU-16 235-BK-18 L4 A768-BU-18 487-OR-18 496-WH-18 321-BR-18 495-GN-18 491-PK-18 M739-YL-18 M737-WH-18 M738-OR-18 T967-YL-18 K904-GN-18 147-PU-16 L4 CONN 40 T951-YL-18 T957-PU-18 18 1 2 T951-YL-18 TRAVEL SPEED SOL 121-1491 2 1 B B 763-BU-18 235-BK-18 SWING BRAKE SOL 121-1491 1 2 K906-GN-18 235-BK-18 2 1 200-BK-18 A588-GN-16 HYD LOCK SOL 121-1491 L4 L3 C T947-YL-18 T948-BR-18 T949-BU-18 T950-GN-18 10 11 12 7 8 9 T951-YL-18 T957-PU-18 T952-BR-18 T958-YL-18 T953-BU-18 T959-BR-18 T954-GY-18 T960-BU-18 T955-GN-18 T961-GN-18 T956-GY-18 T962-WH-18 C T945-GY-18 T946-PU-18 L4 A769-GY-18 L973-GN 2 1 200-BK B P P G826-BR-18 G827-BU-18 994-GY-18 G826-BR-18 G827-BU-18 994-GY-18 C B A OR BK WH SENSOR SIGNAL +5V SENSOR COMMON OIL PRESSURE 197-8394 P P P P 235-BK-18 L973-GN-16 779-WH-18 780-PU-18 G829-GN-18 G829-GN-18 G829-GN-18 AE 2 1 1 2 2 1 1 2 2 1 1 2 M740-PK-18 K906-GN-18 763-BU-18 A588-GN-18 235-BK-18 235-BK-18 200-BK 780-PU-18 780-PU-18 G829-GN-18 A747-GY-18 G828-WH-18 G828-WH-18 G829-GN-18 A747-GY-18 A B C YL GN OR SENSOR SIGNAL +5V SENSOR COMMON ATMOSPHERIC PRESSURE 197-8393 INJECTOR SOLENOID 1 INJECTOR SOLENOID 2 INJECTOR SOLENOID 3 INJECTOR SOLENOID 4 INJECTOR SOLENOID 5 INJECTOR SOLENOID 6 L22 200-BK-18 200-BK-18 B 200-BK-18 200-BK-18 200-BK-18 200-BK L3 L2 L1 780-PU-18 780-PU-18 G828-WH-18 G828-WH-18 200-BK-10 200-BK 200-BK 200-BK-18 780-PU-18 B 2 1 C991-PK-18 G828-WH-18 G829-GN-18 C991-PK-18 C B A YL GN OR SENSOR SIGNAL SENSOR COMMON +5V FUEL PRESSURE 197-8394 CHASSIS ATCH O.L.W.D PRESS SENSOR 157-3182 +B SIGNAL GROUND A C B BR-18 YL-18 BK-18 235-BK-18 H446-PK-18 147-PU-16 L2 780-PU-18 200-BK-18 1 2 IDENT PART NO.

LOC HARNESS AS.

NOTE G828-WH-18 G829-GN-18 A B OR BK SENSOR COMMON +5V HEUI RAIL PRESSURE 236-6220 A769-GY-18 L3 496-WH-18 495-GN-18 B 147-PU-16 200-BK-18 779-WH-18 B 1 2 B 254-7198 A-2 A 233-1032 G-3 G849-BR-18 G829-GN-18 G849-BR-18 C B YL WH SENSOR SIGNAL SENSOR COMMON +5V SENSOR SIGNAL TURBO OUTLET PRESSURE 210-1747 491-PK-18 M739-YL-18 M737-WH-18 M738-OR-18 T967-YL-18 K904-GN-18 487-OR-18 321-BR-18 A768-BU-18 325-PK-18 147-PU-16 495-GN-18 A499-BU-18 496-WH-18 235-BK-18 B BR BROWN GN GREEN BU BLUE C 197-4411 A-4 G 233-1036 D-1 F 186-4621 G-1 E 170-6959 I-3 D 235-3761 G-8 B A746-PK-18 G828-WH-18 A746-PK-18 A C GN OR B B CONN 35 HYDRAULIC TANK PRESSURE SWITCH P 215-3249 A-12 M 203-3063 C-2 L 170-6828 G-1 B G831-GY-18 G833-PK-18 E795-YL-18 E795-YL-18 G831-GY-18 G833-PK-18 G833-PK-18 C B A YL GN OR SENSOR COMMON +5V SENSOR SIGNAL OIL TEMPERATURE 204-0320 CONN 22 C 4 3 8 9 2 10 12 6 5 11 7 1 C 1 2 4 3 6 5 C 235-BK-18 A499-BU-18 1 2 T 238-2074 A-2 U 116-0098 A-3 V 116-0096 A-3 G833-PK-18 995-BU-18 995-BU-18 G833-PK-18 2 1 SENSOR COMMON SENSOR SIGNAL 2 YL GN GN YL SENSOR COMMON 274-7396 ENGINE COOLANT TEMP A768-BU-18 A769-GY-18 K904-GN-18 T967-YL-18 M738-OR-18 M737-WH-18 M739-YL-18 487-OR-18 491-PK-18 147-PU-16 147-PU-16 321-BR-18 325-PK-18 147-PU-16 495-GN-18 A499-BU-18 496-WH-18 235-BK-18 235-BK-18 235-BK-18 235-BK-18 235-BK-18 235-BK-18 VV 167-3456 G-1 AE 230-6279 C-11 AM 204-1816 G-5 INTAKE AIR TEMPERATURE 274-7395 SENSOR SIGNAL E964-WH-18 E964-WH-18 E963-BK-18 E963-BK-18 C967-BU-18 C967-BU-18 2 1 1 GN S/T - S/T + RUN DUAL CAM SPEED/TIMING 236-6221 T B CONN 36 200-BK-10 NN 167-3618 H-10 WIRE AS.

168-RD-10 E966-YL-18 E966-YL-18 E965-BU-18 E965-BU-18 1 2 YL YL GN S/T + S/T - DUAL CAM SPEED/TIMING 236-6221 CRANK POWER SHIFT CONTROL SOLENIOD 111-9916 1 2 A769-GY-18 A768-BU-18 L19 607-PK L1 200-BK B CHASSIS LAMP 153-2523 BLADE, SPADE, RING OR SCREW TERMINAL RR 167-3619 H-10 PP 111-4829 H-10 SS 224-2859 I-7 G857-YL-18 G857-YL-18 G856-WH-18 G856-WH-18 TDC PROBE C 147-PU-16 T967-YL-18 147-PU-16 K904-GN-18 A769-GY-18 A768-BU-18 L20 L20 L20 A769-GY-18 A768-BU-18 235-BK-18 607-PK SPLICE UU 238-1721 A-4 FF 197-4304 H-9 EE 213-0562 H-9 DD 197-4353 H-9 CC 204-1601 G-9 BB 170-6929 E-11 AA 186-4708 D-10 CABLE AS.

CONNECTOR HEP CONNECTOR HEP 61 62 G855-PU-18 G854-PK-18 G854-PK-18 G855-PU-18 CONNECTOR HEP GROUND +B SIGNAL YL-18 BR-18 BK-18 YL-18 SIGNAL GROUND A B A C C C 147-PU-16 147-PU-16 K904-GN-18 235-BK-18 +B BK-18 BR-18 B C T967-YL-18 235-BK-18 235-BK-18 CONN 11 K904-GN-18 T967-YL-18 147-PU L19 L19 235-BK-18 235-BK-18 235-BK-18 B 2 1 200-BK-10 200-BK-18 200-BK-10 AE AE PUMP DISCHARGE PRESS SENSOR1 157-3182 PUMP DISCHARGE PRESS SENSOR 2 157-3182 235-BK-18 A C B M739-YL-18 M739-YL-18 M737-WH-18 M737-WH-18 M738-OR-18 M738-OR-18 HYDRAULIC OIL LEVEL SWITCH 170-9376 C 1 2 496-WH-18 235-BK-18 T 325-PK-18 CONN 37 C 235-BK-18 235-BK-18 235-BK-18 487-OR-18 491-PK-18 L976-GN-18 L976-GN-18 365-YL-18 365-YL-18 365-YL-18 L976-GN-18 DIODE 121-1022 HH 170-6929 E-12 XX 213-0561 H-9 GG 193-3377 D-10 JJ 193-3515 G-9 NOTE D NOTE D NOTE D 235-BK-18 HYDRAULIC OIL TEMPERATURE SENDER 4I-5394 235-BK-18 FUEL LEVEL SENDER 163-6700 BK YL 2 1 C 495-GN-18 T CONN 38 CONN 39 T L976-GN-18 200-BK-10 323-WH-10 WIPER/WASHER CIRCUIT.

NOTE C: NOT USE ON THIS VEHICLE. A 491-PK-18 235-BK-18 C C T° 235-BK-18 U 325-PK-18 1 2 365-YL-18 V 168-RD-18 1 2 L976-GN-18 168-RD-18 365-YL-18 L976-GN-18 L976-GN-18 L976-GN-18 200-BK-18 365-YL-18 329-YL-18 329-YL-18 168-RD-18 168-RD-18 168-RD-18 168-RD-18 168-RD-10 NOTE G: NOT USE WITH HEATER UNIT. NOTE F: USE WITH 12V 7A X 2 CONVERTER NOTE D: USE WITH COLD WEATHER. A 487-OR-18 235-BK-18 C HYDRAULIC OIL FILTER SWITCH 173-3518 2 1 GROUND SIGNAL ATCH TRAVEL ALARM 3E-7738 1 2 C 235-BK-18 T T 239-0012 V01 APRIL 20O7.

Стр. 2