MAINTENANCE GENERAL VEHICLE INSPECTION AND MAINTENANCE FUEL SYSTEM AND AIR INTAKE Fuel System Pre-ride / Daily Inspection WARNING 2 Perform the following pre-ride inspection daily, and when servicing the vehicle at each scheduled maintenance. Tires - check condition and tire pressure Gasoline is extremely flammable and explosive under certain conditions. Fuel and oil - fill both to their proper level; do not overfill Always stop the engine and refuel outdoors or in a well ventilated area.
All brakes - check operation (includes auxiliary brake) Throttle - check for free operation Do not smoke or allow open flames or sparks in or near the area where refueling is performed or where gasoline is stored. Headlight / Taillight / Brakelight - check operation of all indicator lights and switches Engine stop switch (key switch) - check for proper function Do not overfill the tank. Do not fill the tank neck. Wheels - check for loose wheel nuts If you get gasoline in your eyes or if you swallow gasoline, seek medical attention immediately.
Air cleaner element - check for dirt or water; clean or replace If you spill gasoline on your skin or clothing, immediately wash it off with soap and water and change clothing. Steering - check for free operation, noting any unusual looseness in any area Loose parts - visually inspect vehicle for any damaged or loose nuts, bolts or other fasteners Never start the engine or let it run in an enclosed area. Engine exhaust fumes are poisonous and can result loss of consciousness or death in a short time. Engine coolant - check for proper level at the recovery bottle Never drain the fuel when the engine is hot. Severe burns may result.
Frame, Nuts, Bolts, Fasteners Periodically inspect the torque of all fasteners in accordance with the maintenance schedule. Check that all cotter pins are in place. Refer to specific fastener torques listed in each chapter. Fuel Lines 1. Check fuel lines for signs of wear, deterioration, damage, or leakage. Replace if necessary. 2. Be sure fuel lines are routed properly and secured with cable ties where applicable. Controls Check handlebar controls for proper operation, positioning and adjustment. CAUTION Make sure lines are not kinked or pinched 3. Replace all fuel lines every two years. 2.9