Last Modified: 6-7-2017 6.8:8.0.40 Doc ID: RM00000188V003X agn Model Year Start: 2007 Model: Land Cruiser Prod Date Range: [08/2006 - ] Title: 2UZ-FE CHARGING: CHARGING SYSTEM: ON-VEHICLE INSPECTION; 2007 MY Land Cruiser [08/2006 - ] ON-VEHICLE INSPECTION 1. CHECK BATTERY CONDITION NOTICE: If the battery is weak or if the engine is difficult to start, perform the following procedures. (a) Check the battery for damage and deformation. If severe damage, deformation or leakage is found, replace the battery. (b) Check the electrolyte quantity of each cell. (1) For maintenance-free batteries: If the electrolyte quantity is below the lower line, replace the battery.
If the electrolyte quantity is above the lower line, check the battery voltage when cranking the engine. If the voltage is less than 9.6 V, recharge or replace the battery. HINT: Before checking the battery voltage, turn off all the electrical systems (headlights, blower motor, rear defogger, etc.). (2) For non-maintenance-free batteries: If the electrolyte quantity is below the lower line, add distilled water to each cell. Then, recharge the battery and check the electrolyte's specific gravity. Standard specific gravity: 1.25 to 1.29 at 20°C (68°F) If the electrolyte quantity is above the lower line, check the battery voltage when cranking the engine.
If the voltage is less than 9.6 V, recharge or replace the battery. HINT: Before checking the battery voltage, turn off all the electrical systems (headlights, blower motor, rear defogger, etc.). (c) Reference: Check the indicator as shown in the illustration. HINT: Blue: OK White: Charging necessary Red: Insufficient water 2. CHECK BATTERY TERMINALS, H-FUSES AND FUSES (a) Check that the battery terminals are not loose or corroded. (b) Check the resistance of the H-fuses and fuses. Standard resistance: Below 1 Ω If the H-fuse or fuse is not as specified, replace as necessary. 3. INSPECT DRIVE BELT (a) Visually check the belt for excessive wear, frayed cords, etc. HINT:
If any defect has been found, replace the drive belt. Cracks on the rib side of a belt are considered acceptable. If the belt has chunks missing from the ribs, it should be replaced. cardi