00 00 Maintenance and general instructions Contents Page Tightening torques ......................................................................................................................3 Table of operating fluids ...........................................................................................................9 Key to maintenance intervals ..............................................................................................11 Reading out MoDiTeC fault memory ...............................................................................11 (Inspections I, II, III and IV) Checking throttle cable play, adjusting if necessary ..............................................................................................................11 (Inspections I and III) Changing engine oil, renew oil filter element .............................................................12 (Inspections I, II, III and IV) Changing oil in gearbox ..........................................................................................................13 (Inspections III and IV) or at least every 2 years Changing oil in rear wheel drive; cleaning inductive signal transmitter at rear wheel .......................................................................................................................................13 (Inspections I, III and IV) Every 40 000 km (24 000 miles) or at least every 2 years Renewing fuel filter ...................................................................................................................14 (Inspection III) In normal operating conditions every 40 000 km (24 000 miles); if fuel quality is poor every 20 000 km (12 000 miles) Checking battery acid level/topping up if necessary, cleaning/greasing battery posts .................................................................................................................................16 (Inspections III and IV) Renewing intake air cleaner element ............................................................................................................................................16 (Inspection III) In very dirty and dusty operating conditions, renew every 10 000 km (6 000 miles) or even more fre- quently if necessary Renewing Poly-V belt ...............................................................................................................17 (every 60 000 km/36 000 miles) (Inspection III) Poly-V belt adjusting procedure:
Checking brake fluid level .........................................................................................................18 Front brake 00.1