MAN — 4.2 Starting the Engine, стр. 15

EuroV MBE 900 Operators Manual Add winter or summer grade fuel according to the season of the year. Work in the cleanest conditions possible. Prevent water from entering the fuel tank. For further information, Refer to Section "How to Select Diesel Fuel". 4.1.5 Checking Other Engine and ATS Related Parts Check the engine compartment as follows: Make sure the transmission is filled to the proper level with the fluid recommended by the gear manufacturer. Do not overfill. The Diesel Exhaust Fluid (DEF) must be checked and filled regularly with DEF meeting Detroit™ quality specification. Make sure cable connections to the storage batteries are clean and tight.

Check for cracks in the battery cases (1), for tightness of the cable clamps (2) at the terminals, and for corrosion of the To provide corrosion protection, apply dielectric grease liberally to the terminal pads. terminals (3). Service or replace as needed. 4.2 Starting the Engine 1. Place the transmission in neutral, and set the parking brake. NOTICE: To prevent serious starter motor damage, release the ignition switch immediately after the engine has started. 2. Turn on the ignition switch. 3. Wait for the engine system indicator lights on the instrument panel to go out. 4. With foot off the accelerator pedal, start the engine. 5. If the engine does not start after 20 seconds, stop.

Try again after waiting about 60 seconds. NOTICE: Do not increase engine speed if the oil pressure gauge indicates no oil pressure. Shut down the engine within approximately ten seconds to avoid engine damage. Check to determine the cause of the problem. NOTE: Do not place the engine under full load until it reaches operating temperature. Colder engine temperatures will cause the engine to preset idle up to 900 rpm. Even at a high idle condition, you do not have to wait for engine warm up and return to normal idle to drive the truck. 6. Monitor the oil pressure gauge immediately after starting the engine. All information subject to change without notice.