ENGINE STORAGE or higher. Charge the battery, if necessary. 10. Service the air cleaner, if required. PERSONAL INJURY 11. Transmission: Follow the manufacturer's recommendations covering the return of the transmission to service. Diesel engine exhaust and some of its constituents are known to the State of California to cause cancer, birth defects, and other reproductive harm. 12. Power Take-Off: If equipped, follow the manufacturer's recommendations covering the return of the power take-off to service. Always start and operate an engine in a well ventilated area. If operating an engine in an enclosed area, vent the exhaust to the outside. 13. Turbocharger:
Remove the covers from the turbocharger air inlet and turbine outlet connections. Reconnect piping as required. Prelube the turbocharger center bearing housing. Refer to Lubrication System Checks in the OPERATING INSTRUCTIONS for a first time start section of this guide. Do not modify or tamper with the exhaust system or emission control system. 14. After all preparations are completed, start the engine. NOTE: The small amount of rust preventive which remains in the fuel system will cause smoky exhaust for a few minutes. NOTE: Before subjecting the engine to a load or high speed, allow it to reach normal operating temperature. Then check for trouble codes.
118 All information subject to change without notice. DDC-SVC-MAN-0039 Copyright © 2009 DETROIT DIESEL CORPORATION