Table of Contents N40469 When required............................................................................................24 Daily............................................................................................................24 Every week.................................................................................................24 Initial 500 service hours..............................................................................24 Every 500 service hours or 1 year..............................................................24 Every 1000 service hours...........................................................................25 Every 2000 service hours...........................................................................25 Every 3000 service hours or 2 years..........................................................25 Every 3000 service hours or 3 years..........................................................25 Every 4000 service hours...........................................................................25 Every 6000 service hours or 3 years..........................................................25 How to fill the coolant circuit.................................................................................26 How to drain the coolant circuit............................................................................27 Engines fitted with keel coolers..................................................................27 How to check the specific gravity of the coolant..................................................28 How to drain the auxiliary water system...............................................................29 How to check the impeller of the auxiliary water pump........................................30 How to check the drive belt of the alternator........................................................31 How to adjust the belt tension..............................................................................32 How to check the condition of the heat exchanger..............................................33 Cleaning the Heat Exchanger..............................................................................33 If tubestack is greasy..................................................................................34 Tubestack is not greasy..............................................................................34 How to renew the element on the primary fuel filter.............................................35 How to renew the element on the secondary fuel filter........................................37 How to renew the lubricating oil of the engine.....................................................38 How to renew the canister of the lubricating oil filter............................................39 How to renew the engine breather.......................................................................40 How to clean the air filter......................................................................................41 How to check the condition of the vibration damper............................................42 How to check the valve tip clearances.................................................................43 TC Compression Stroke.............................................................................43 TC Exhaust Stroke......................................................................................44 Corrosion..............................................................................................................45 Supplementary tools............................................................................................45 6 Engine preservation.....................................................................
47 Introduction..........................................................................................................47 Procedure.............................................................................................................47 How to add antifreeze to the auxiliary water system for engine preservation purposes...................................................................48 7 Parts and service.........................................................................
49 Introduction..........................................................................................................49 Service literature..................................................................................................49 Training................................................................................................................49