OPERATING INSTRUCTIONS FOR STARTING THE ENGINE Starting the Engine-For The First Time To start an MBE 900 engine, make sure the transmission is in neutral and turn the ignition key on. Before starting the engine the first time, perform the operations listed in the System Checks section. NOTICE: ENGINE EXHAUST The turbocharger may be seriously damaged if the engine is cranked with the air shutdown in the closed position. To avoid injury from inhaling engine exhaust, always operate the engine in a well-ventilated area. Engine exhaust is toxic. The engine may require the use of a cold weather starting aid if the ambient temperature is below 40°F (4°C).
PERSONAL INJURY FLAMES, EXPLOSION AND TOXICITY To avoid injury when working near or on an operating engine, remove loose items of clothing and jewelry. Tie back or contain long hair that could be caught in any moving part causing injury. To avoid injury from flames, explosion, and toxicants when using ether, the following precautions must be taken: Do not smoke when servicing ether system. You will notice that both the Amber Warning Lamp (AWL)/Check Engine and the Red Stop Lamp (RSL)/Stop Engine will come on. This is the result of the Detroit Diesel Electronic Control (DDEC®) computer diagnosing the system to ensure everything is functional, including the light bulbs for the warning lights.
If everything is OK, both lights will go out in approximately five seconds. Work in well ventilated area. Do not work near open flames, pilot flames (gas or oil heaters), or sparks. Do not weld or carry an open flame near the ether system if you smell ether or otherwise suspect a leak. 28 All information subject to change without notice. (Rev. 04/08) DDC-SVC-MAN-0040 0704 Copyright © 2008 DETROIT DIESEL CORPORATION