Volvo Truck Corporation Date Group No. Release Page Service Bulletin 12.05 175 09 18 14(47) D12F EM JPN04 For definitions and abbreviations see “Definitions” page 3. Engine Operating Conditions (EOC) 1 Includes timber trucks, tippers, dumpers, load exchangers, concrete mixers, waste compressors and special vehicles. 2 Only 4x2/6x2, without power take off, max 90 kph 3 Max. 90 km/h Oil change interval 1 D12 F can be fitted with DPF-filter. In this case VDS-3 LSA quality oil must be used. VDS–3 LSA is VDS-3 oil with low sulphate content, max 1.1%. The same interval as for VDS-3 oils applies, as shown in the above table. 2 Maximum permitted fuel consumption 15 000 litres (37.5 litres/hour).
3 Maximum permitted fuel consumption 12 000 litres (40 litres/hour). 4 Maximum permitted fuel consumption 8 000 litres (40 litres/hour). Preventive maintenance 1 Whichever occurs first. Valves and unit injectors, adjustment EGR pipe, clean Trans- port cycle Long distance driving Distribution, regional Distribution, Town Construction sites 1 GCW ≤44 45 - 68 ≥69 ≤32 32–44 45–68 ≤32 32–44 ≤44 ≤32 33–44 45–68 To- pog- ra- phy PF H PF H H H H VH EOC M 2 H 3 S 3 VS 3 M H S S VS VS H S VS VS+ EOC M H S VS VS+ Maximum permitted fuel consumption (l/100km) ≤ 39 ≤ 50 ≤ 64 ≤ 120 - Mileage (km) / time (hours) NB! No oil change interval is allowed to exceed 6 months.
Oil grade VDS-3 1 50000/650 40000/500 30000/400 15000/400 2 -/400 2 Oil grade VDS-2 35000/450 25000/350 20000/300 10000/300 3 -/300 3 Oil grade VDS / Other oil grades 20000/300 15000/250 10000/200 7500/200 4 -/200 4 For waste collection, mine operation, airport service etc, engine hours (hours) can be used instead. EOC M H S VS VS+ km/max. months H/max.
months Full service - / 12 Basic service 50000/6 1 40000/6 1 30000/6 1 15000/6 1 400/6 1 EOC M H S VS VS+ Interval D12F 390–500 200,000 km or every 12 months, whichever occurs first¹ 100,000 km or every 6 months, whichever occurs first ¹ The service interval shall be halved in the case of frequent driving at more than 90km/h Service interval 200,000 km or every 24 months, whichever occurs first