Mack Trucks Electronic Vehicle Management Manual (EN)

Page 1

Mack E L E C T R O N I C V-MAC IV ® V-MAC V-MAC IV E L E C T R O N I C ® ® VEHICLE MANAGEMENT VEHICLE MANAGEMENT AND CONTROL WITH CO-PILOT DISPLAY ® AND CONTROL WITH CO-PILOT DISPLAY ® IV ® 21968603 January 2013 © Mack Trucks, 2013 21968603 21968603

Стр. 1

Page 1

Foreword This manual contains information concerning the operation and function of the Electronic Vehicle Management and Control (V-MAC) IV Vehicle Management and Control with Co-Pilot Display. The information in this manual applies to vehicles built January 2013 and later. Please keep this manual in the vehicle at all times. Note: Illustrations in this manual are used for reference only and may differ slightly from the actual vehicle. However, key components addressed in this document are represented as accurately as possible. Mack Trucks Wacol , QLD, Australia Order number: PV776- 21968603 © 2013 Mack Trucks Wacol , QLD, Australia All rights reserved.

No part of this publication may be reproduced, stored in retrieval system, or transmitted in any forms by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of Mack Trucks.

Стр. 3

Page 1

Contents Introduction.............................................................................................................................. 1 SAFETY INFORMATION.................................................................................................... 2 Service Procedures and Tool Usage................................................................................... 3 V-MAC Co-Pilot Operator's Manual..................................................................................... 7 SYSTEM OVERVIEW..........................................................................................................

7 System Summary ............................................................................................................... 7 SYSTEM COMPONENTS.................................................................................................... 9 Vehicle Electronic Control Unit (VECU) ..........................................................................

9 Engine Control Module (ECM) .........................................................................................11 INDICATORS, LIGHTS AND DASHBOARD SWITCHES...............................................15 Cab and Dashboard Switches.............................................................................................15 Electronic Malfunction Indicator.......................................................................................16 High Exhaust System Temperature (HEST) Indicator.......................................................17 Shutdown Warning Indicator .............................................................................................18 Engine Derate (For Mack Engines Only) ..........................................................................19 Aftertreatment DPF Smart Switch (If Equipped) ..............................................................21 EXHAUST AFTERTREATMENT SYSTEM.......................................................................23 Aftertreatment DPF Regeneration, Cummins ISX ............................................................23 Aftertreatment DPF Passive Regeneration, Cummins ISX ...............................................24 Aftertreatment DPF Parked Regeneration, Cummins ISX ................................................25 Aftertreatment DPF Inhibit/Stop Regeneration .................................................................26 Aftertreatment DPF Regeneration and PTO Operation (Cummins ISX) ..............................32 STARTING THE VEHICLE .................................................................................................32 CRUISE AND ENGINE SPEED CONTROL.......................................................................33 Cruise Control....................................................................................................................33 Engine Speed Control ........................................................................................................38 Engine Brake......................................................................................................................41 ACCESSORY RELAY CONTROL ......................................................................................41 PROGRAMMABLE FEATURES.........................................................................................42 Cruise 'N Brake Engagement Delay ..................................................................................44 Engine High Idle Speed if Stopped....................................................................................44 Engine High Idle Speed in Upper Gears............................................................................44 Low Idle Adjustment .........................................................................................................44 Smart Idle Elevated Idle RPM Time..................................................................................46 Idle Shutdown....................................................................................................................46 Speed Sensor Tamper Detection ........................................................................................47 ELECTRICAL ACCESSORY CONNECTION POINTS.....................................................48 Battery Post (BATT) ..........................................................................................................48 Ignition Post (IGN) ............................................................................................................48 Ground Post (GND)...........................................................................................................48 RPM Output.......................................................................................................................48 Km/h Output ......................................................................................................................49 SAE/ATA J-1708 Posts (Series Link A and B)..................................................................49 CB Radio Power Jack (CB Radio +) (Located on Dashboard)..........................................49 CB Radio Ground Jack (CB Radio −) (Located on Dashboard)........................................49

Стр. 5

Page 1

INSTRUMENT CLUSTER DISPLAY .................................................................................50 Dash Cluster Set-Up Programming ...................................................................................50 Instrument Cluster Components ........................................................................................51 Driver Information Display................................................................................................53 Diagnostic Trouble Codes (DTCs) ........................................................................................54 Electronic Dash Display ....................................................................................................54 CO-PILOT® DISPLAY.........................................................................................................58 Introduction and Purpose...................................................................................................58 CO-PILOT SYSTEM OVERVIEW ......................................................................................59 Set-Up Programming .........................................................................................................59 CO-PILOT® OPERATIONS.................................................................................................63 Using the Co-Pilot® ..........................................................................................................63 CO-PILOT SYSTEM OVERVIEW ......................................................................................64 ESC Button ........................................................................................................................64 Enter ( ) Button ...............................................................................................................64 Up & Down Buttons ..........................................................................................................64 CO-PILOT® LAYOUT .........................................................................................................65 Screen Types ......................................................................................................................65 Driver's ID Screens ............................................................................................................66 Change Driver ID...............................................................................................................70 CO-PILOT® START UP SCREENS ....................................................................................72 MACK Logo Intro .............................................................................................................72 Current Conditions.............................................................................................................73 CO-PILOT® MENU SCREENS...........................................................................................74 Main Menu — Stationary Vehicle .....................................................................................74 Main Menu — Moving Vehicle.........................................................................................75 CO-PILOT® ANYTIME SCREENS ....................................................................................77 Fuel Economy....................................................................................................................77 Trip Information.................................................................................................................78 Gauges................................................................................................................................80 Black Panel ........................................................................................................................81 CO-PILOT® STATIONARY SCREENS ..............................................................................82 Diagnostics.........................................................................................................................83 Maintenance.......................................................................................................................84 DEL Messages ...................................................................................................................85 Set Up.................................................................................................................................86 CO-PILOT® INTERRUPT SCREENS.................................................................................87 Idle Shutdown Warning .....................................................................................................87 Driver Overspeed Warning (if Available)..........................................................................87 Warning Severe Engine Overspeed....................................................................................88 Engine Brake Overspeed Warning.....................................................................................89 Severe Engine & Engine Brake Overspeed Warning.........................................................90 Maintenance Reminder (for Future Support).....................................................................90 Low Voltage Disconnect Active ........................................................................................91 Inter Wheel Lock ...............................................................................................................91

Стр. 6