SAFETY PRECAUTIONS If the machine is equipped with a cab, the right hand side door of the cab serves as an emergency exit. Use only if the left hand side door is blocked. The operator must be alert, physically fit and free from the influences of alcohol, drugs and medications that might affect his eyesight, hearing or reactions. Safety must always be the operators most important concern. He must refuse to operate when he knows it is unsafe and consult his supervisor when safety is in doubt. START-UP Never start the engine indoors unless proper exhaust ventilation is provided to remove deadly exhaust gases. Once the engine is running, move the machine outdoors as soon as possible.
Exhaust gases are hazardous and can cause unconsciousness and death. Sit in the operator’s seat before operating any controls. Keep hands and footwear free of grease, water and mud to insure positive control movement. Before starting the engine, or when machine is standing with the engine running: place the transmission directional lever in neutral (N), apply the parking brake and lower any raised equipment. DO NOT SMOKE when using the ether start. Do not use the ether start when the air temperature is above freezing. Follow the correct method for starting the engine. Refer to “STARTING ENGINE” in Section 2. Before driving the machine, adjust the seat and fasten the seat belt.
Adjust the seat for maximum comfort and control of the machine. Adjust the seat belt to fit snugly and low around the hips to lessen the chance and severity of injury in the event of an accident. Never wear the seat belt across the abdomen. Use of the seat belt with the ROPS is strongly recommended. In the event of a rollover, stay with the machine. Experience has shown this will reduce the chance and seriousness of injury. Before moving the machine, check the brakes, steering, attachment controls and safety devices. DO NOT operate the machine until any unsafe conditions have been corrected. Before moving the machine, sound the horn to warn nearby personnel.
Release the parking brake before moving the machine. The brake could burn or be damaged if the machine is driven with it applied. Turn off the defroster fan before adjusting it to avoid injury NEVER HAUL PASSENGERS. Only the operator should be on the machine when it is moving. Use caution and follow the manufacturer’s instructions when using external heaters to warm the power train in cold weather. GENERAL OPERATING PRECAUTIONS Stay alert and aware of what you are doing. Use common sense. Do not operate when fatigued or ill. Know your machine and its capabilities. Use the machine only for its intended purposes.
For your safety, read the Operation and Maintenance Manual carefully and follow all instructions and precautions. 1-4