General Information Argo Service Manual Check coolant level (Avenger) Check fan belt tension (Avenger) Check fuel level Check tire inflation Check twist grip throttle operation Check handlebar travel Check engine intake/exhaust for obstructions Check that drain plugs are in place Check engine oil level Change engine oil & oil filter - Kohler - Briggs & Stratton Check transmission oil level Change transmission oil Clean air pre-cleaner (Briggs only) Check clean/replace air filter Replace fuel filter (Kohler high pressure every 1000 hrs.) Service driver & driven clutch Lubricate drive chains Remove, clean & lube drive chains Lubricate idler chains (if equipped) Remove, clean & lube idler chains (if equipped) Lubricate axle flange - outer cavity Lubricate axle flange - inner cavity Lubricate outer axle bearings (if required) Lubricate inner axle bearings (if required) Lubricate output shafts Lubricate idler bearings Check battery fluid level & caps Clean battery terminals & connections Clean battery Clean, adjust/replace spark plugs Check the drive belt Check nylon sliders - driven clutch Check sliders - chain take-up system Check & adjust idler chains Inspect brake pads Inspect/adjust emergency/parking brake Check hydraulic brake fluid level/condition Check fuel tank connections/lines Inspect wiring harness Tighten bearing extension bolts Clean out spark arrester The intervals shown on the schedule are based on average operating conditions.
Vehicles which are subjected to severe use and wet or dusty conditions will require more frequent servicing. Use only Argo replacement parts to ensure safe operation of the vehicle and to comply with the warranty coverage. We strongly recommend that an Argo Dealer perform a complete check-over of your vehicle after the initial 20 hours of operation, then once each year. This will reduce maintenance costs over the life of your vehicle. GI-12 Ontario Drive & Gear Limited www.argoutv.com PH.(519)- 662-2840 FAX (519)- 662-2421 BEFORE EACH USE AFTER INITIAL EVERY 2hrs. 8hrs. 20hrs. 10hrs. 25hrs. 50hrs. 100hrs. 250hrs.
X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X