PERIODIC SERVICE 66 B Checking Brake Light Switch 1. Park the vehicle on a flat surface and raise the cargo bed. 2. Turn the key switch to the "ON" position. 3. Step on the brake pedal to check if the brake light comes on. 4. If it does not, check the bulb or brake light switch. (1) Radiator hoses (2) Clamp bands C Precaution at Overheating Take the following actions in the event the coolant temperature is close to or more than the boiling point, which is called "Overheating". 1. Stop the vehicle operation in a safe place and keep the engine unloaded idling. 2. Don't stop the engine suddenly, but stop it after about 5 minutes of unloaded idling. 3.
Keep yourself well away from the vehicle for at least 10 minutes or while the steam is blowing out. 4. Check to see if there is no danger such as burning, get rid of the causes of overheating according to the "TROUBLESHOOTING" section of this manual, and then start the engine again. (1) Brake light switch B Checking Radiator Hose and Clamp Park the vehicle on a flat surface and raise the cargo bed. Check to see if radiator hoses are properly fixed every 200 hours of operation or six months, whichever comes first. 1. If hose clamps are loose or water leaks, tighten bands securely. 2. Replace hoses and tighten hose clamps securely, if radiator hoses are swollen, hardened or cracked.
Replace hoses and hose clamps every 2 years or earlier if checked and found that hoses are swollen, hardened or cracked.