WARRANTY applicable U.S. Environmental Protection Agency regulations under 40 CFR Part 90: and, Warranty • Free from defects in materials and workmanship which cause such engine to fail to conform with applicable regulations for a period of two years of engine use from the date of sale to the ultimate purchaser. Product Warranty Product warranty is provided as part of John Deere’s support program for customers who operate and maintain their equipment as described in this manual. Emissions Warranty Interpretation Engine related warranties stated in this manual refer only to emissions- related parts and components of your engine.
The complete engine warranty, less emission-related parts and components, is provided separately as the Limited Warranty for New John Deere Commercial & Consumer Equipment. • Any warranted part that is not scheduled for replacement as required by the maintenance instructions in the Operator’s Manual is warranted for two years. If any such part fails during the period of warranty coverage it will be repaired or replaced by John Deere. Any such part repaired or replaced under warranty is warranted for the remaining warranty period. • Any warranted part that is scheduled only for regular inspection in the maintenance instructions in the Operator’s Manual is warranted for two years.
A statement in the Operator’s Manual to the effect of “repair or replace as necessary” does not reduce the period of warranty coverage. Any such part repaired or replaced under warranty is warranted for the remaining warranty period. California and U.S. EPA Emissions Control System Warranty Statement (Small Off-Road Gas Engines) Your Warranty Rights and Obligations The California Air Resources Board, John Deere, and the United States Environmental Protection Agency are pleased to explain the emissions control system’s warranty on your 2009 and later small off-road engine equipment.
In California, new equipment that uses small off-road engines must be designed, built and equipped to meet the State’s stringent anti- smog standards. John Deere must warrant the emissions control system on your small off-road engine equipment for the period listed below provided there has been no abuse, neglect or improper maintenance of your equipment. • Any warranted part that is scheduled for replacement as required maintenance in the Operator’s Manual is warranted for the period of time prior to the first scheduled replacement point for that part. If the part fails prior to the first scheduled replacement, the part will be repaired or replaced by John Deere.
Any such part repaired or replaced under warranty is warranted for the remainder of the period prior to the first scheduled replacement point for the part. • Repair or replacement of any warranted part under the warranty will be performed at no charge to the owner at any authorized John Deere Commercial and Consumer Equipment Retailer. Your emissions control system may include parts such as: carburetors or fuel-injection system, ignition system, catalytic converters, fuel tanks, valves, filters, clamps, connectors, and other associated components. Also, included may be hoses, belts, sensors and other emission-related assemblies.
• The owner will not be charged for diagnostic labor which leads to the determination that a warranted part is defective, provided such work is performed by John Deere. Where a warrantable condition exists, John Deere will repair your small off-road engine equipment at no cost to you including diagnosis, parts and labor. • John Deere will repair damages to other engine components proximately caused by a failure under warranty of any emissions-related warranted part. Manufacturer’s Warranty Coverage: • Add-on or modified parts that are not exempted by the Air Resources Board may not be used. The use of any non-exempted add-on or modified parts will be grounds for disallowing a warranty claim.
John Deere will not be liable to warrant failures of warranted parts caused by the use of a non- exempted add-on or modified part. This emissions control system is warranted for two years. If any emissions related part on your equipment is defective, the part will be repaired or replaced by John Deere. Owner’s Warranty Responsibilities: • As the small off-road equipment owner, you are responsible for the performance of the required maintenance listed in your Operator’s Manual.
John Deere recommends that you retain all receipts covering maintenance on your small off-road engine equipment, but John Deere can not deny warranty solely for lack of receipts or for your failure to ensure the performance of all scheduled maintenance. Emission Warranty Parts List Fuel Metering System: • Carburetor and internal parts (or fuel injection system). • Air/fuel ratio feedback and control system. • Cold start enrichment system. • As the small off-road engine equipment owner, you should however be aware that John Deere may deny you warranty coverage if your small off- road equipment or a part has failed due to abuse, neglect, or improper maintenance or unapproved modifications.
Evaporative System: • Fuel tank, fuel cap and tether. • Fuel hose, line, fittings, clamps. • You are responsible for presenting your small off-road engine equipment to an authorized John Deere Commercial and Consumer Equipment Retailer as soon as a problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. If you have a question regarding your warranty coverage, you should contact your John Deere Commercial and Consumer Equipment Retailer, or the John Deere Customer Contact Center at 1-800-537-8233. • Fuel pump, fuel shut-off valve. • Fuel vapor hoses, fittings. • Carbon canister. • Rollover/slant valve for fuel vapor control.
Air Induction System: • Air cleaner General Emissions Warranty Coverage: • Intake manifold. Ignition System: The warranty period begins on the date the equipment is delivered to an ultimate purchaser. John Deere warrants to the ultimate purchaser and each subsequent purchaser that the small off-road engine equipment is: • Spark plugs. • Designed, built and equipped so as to conform to all applicable regulations adopted by the Air Resources Board; • Magneto or electronic ignition system. • Spark advance/retard system. •Designed, built and equipped so as to conform at the time of sale with Exhaust System: Warranty - 46