OM1201 9/11 Torque Tables And Conversion Charts - Section 12 Page 12-11 (1) Used for threaded areas (for example, plug, nipple, elbow etc.) which are removable, and a pressure of 1965 kPa (285 psi) or less. (2) Used for threaded areas (for example, stud, etc.) which are not removable, and a pressure of 1965 kPa (285 psi) or less. The sealants and adhesives listed below are manufactured and sold by Three Bond U.S.A., Inc. For information concerning Three Bond products, call or write to: Three Bond U.S.A., Inc. 6184 Schumacher Park Drive West Chester, OH 45069 Telephone: (513) 779-7300 Fax: (513) 779-7375 TABLE 14.
Sealants And Adhesives Nomenclature Code Three Bond * Applications Adhesives LT-1A TB1521 Used to apply rubber pads, rubber gaskets and cork plugs. LT-1B 1000B - 1000W Used to apply resin, rubber, metallic and non-metallic parts when a fast, strong seal is needed. LT-2 TB1374 Preventing bolts, nuts and plugs from loosening and leaking oil. LT-2A TB2411 Preventing bolts, nuts and plugs from loosening and leaking oil. (1) LT-2B TB2403 Preventing bolts, nuts and plugs from loosening and leaking oil. (2) LT-2C TB2430 or TB2440 Preventing bolts, nuts and plugs from loosening and leaking oil. (2) LT-3 Main bond Hardening agent TB2001 Provides an airtight, electrically insulating seal.
Used for aluminum surfaces. TB2105 Liquid Gasket LG-1 TB1108B Used with gaskets and packings to increase sealing effect. LG-3 TB1107 Heat-resistant gasket for precombustion chambers and exhaust piping. LG-4 TB1104 Used by itself on mounting surfaces on the final drive and transmission cases. Thickness after tightening: 0.07-0.08 mm (0.0027-0.0032 in) LG-5 TB1110B Used by itself to seal grease fittings, tapered screw fittings and tapered screw fit- tings in hydraulic circuits of less than 50 mm (2 in) in diameter. Anti-friction compound LM-P - Applied to bearings and taper shafts to facilitate press-fitting and to prevent stick- ing, burning or rusting.
Grease G2-LI - Applied to bearings, sliding parts and oil seals for lubrication, rust prevention and facilitation of assembling work. Vaseline - - Used for protecting battery electrode terminals from corrosion. * NOTE: The part numbers in this column are not Komatsu numbers. These are vendor designations. Part Numbers Three Bond Komatsu TB1374 09940-00030 TB1521 790-129-9030 TB1104 790-129-9020 TB1108B 790-129-9010 TB1110B 790-129-9080