Draining V-Belt Cover NOTE: If the vehicle has been driven through water, the V-belt cover must be drained of any water. The use of worn-out tires on this vehicle is very dangerous. A tire is considered to be worn out when the depth of the tread is less than 3 mm (1/8 in.). Be sure to replace the tires before reaching this min- imum specification. 1. Place the vehicle on a level surface. 2. Remove the drain bolt from the cover and allow the water to drain out. ! WARNING The use of worn-out tires is danger- ous and can increase the risk of an accident. 3. Shift the range lever to the neutral position; then start the engine.
CAUTION Tire Replacement This vehicle has low-pressure tubeless tires. Air is sealed by the contact surfaces of the inner wheel rim and the tire bead. If either the inner wheel rim or tire bead is damaged, air may leak. Be extremely careful not to damage these areas when replacing tires. Do not attempt to clear water with the vehicle in park. The transmission is locked and belt or clutch damage could occur. 4. Increase and decrease engine RPM several times to “blow out” any water; then stop the engine. It is very important to use the proper tools when repairing or replacing tires to prevent damage to the tire bead or wheel rims.
If proper tools and related items are not available, have this maintenance per- formed by an authorized Arctic Cat dealer or a qualified tire repair station. 5. Install the drain bolt and tighten securely. NOTE: The V-belt and pulleys should be inspected every 500 miles and the belt replaced (if necessary). CAUTION Tires ! WARNING When breaking the tire bead loose from the wheel, be extremely careful not to damage the inner wheel sur- face or the tire bead. Always use the size and type of tires as specified. Refer to the specifica- tions chart for proper tire inflation pressure, and always maintain proper tire inflation pressure. !
WARNING Use only Arctic Cat approved tires when replacing tires. Failure to do so could result in unstable operation. Tire Tread Condition Tubeless Tire Repair Should a leak or flat tire occur due to a punc- ture, the tire may be repaired using a plug- type repair. If the damage is from a cut or if the puncture cannot be repaired using a plug, the tire must be replaced. When operating the vehicle in areas where transportation or service facilities are not readily available, it is strongly recommended to carry a plug- type repair kit and a tire pump along. 0732-649 Wheels 1. Park the vehicle on level ground and engage the differential lock. 2. Loosen the lug nuts on the wheel to be removed.
49