ENGINE STORAGE a separate, portable supply of recommended fuel. plug both to retain the fuel in the engine. NOTE: If engines are stored where condensation of water in the fuel tank may be a problem, additives containing methyl carbitol or butyl cellusolve may be added to the fuel. Follow manufacturer's instructions for treatment. Where biological contamination of fuel may be a problem, add a biocide such as Biobor® JF (or equivalent) to the fuel. When using a biocide, follow the manufacturer's concentration recommendations and observe all cautions and warnings. 10. Transmission: Follow the manufacturer's recommendations for prolonged storage. 11. Power Take-Off:
If equipped, follow manufacturer's recommendations for prolonged storage. NOTICE: Failure to properly seal off the turbocharger air inlet and exhaust outlet openings before engine storage may permit air drafts to circulate through the turbocharger and rotate the turbine/compressor shaft without an adequate flow of lubricating oil to the center housing bearings. This can result in severe bearing damage. 7. Drain the fuel system and remove the fuel filters. Dispose of used filters in an environmentally responsible manner, according to state and/or federal EPA recommendations. Fill the new filters with No. 1 diesel fuel or pure kerosene and install on the engine. 12. Turbocharger:
Since turbocharger bearings are pressure lubricated through the external oil line leading from the oil filter adaptor while the engine is operating, no further attention is required. However, the turbocharger air inlet and turbine exhaust outlet connection should be sealed off with moisture-resistant tape. 8. Operate the engine for five (5) minutes to circulate the clean fuel throughout the engine. Be sure the engine fuel system is full. 9. Stop the engine and allow to cool. Then disconnect the fuel return line and the inlet line at the primary filter and securely 13. Apply a non-friction rust preventive compound to all 134 All information subject to change without notice. (Rev.
04/08) DDC-SVC-MAN-0040 0704 Copyright © 2008 DETROIT DIESEL CORPORATION