MBE 900 ENGINE 2007 OPERATOR'S GUIDE When the request is accepted, the DPF Regeneration Lamp will turn on for one second and then go off for the rest of the parked regeneration. The engine speed will increase to 1200 rpm. NOTE: This is for hazardous applications only. There are two CPC options: DPF Stationary Regen Only = 0 Disabled With completion of regeneration, the following should occur: DPF Stationary Regen Only = 1 Enabled The HEST lamp will remain illuminated until the exhaust outlet temperature is below 525°C (977°F) or the vehicle speed exceeds 5 mph.
DPF Stationary Regen Only = 0-Disabled This option allows the DPF Regeneration Switch to request a parked regeneration or an over-the-road regeneration. If the conditions previously mentioned are met, a parked regen will be initiated. If the conditions are not met, then the over-the-road regeneration will occur. The DPF regeneration lamp will turn off, along with all other associated warning lamps. If any of the above requirements are removed, the engine will return to idle. To cancel the parked regeneration, the driver can toggle the Regen Switch to ON for five seconds.
The DPF Regeneration Lamp will turn on for one second to show acceptance of the cancellation request and then return to the appropriate state as defined by the current level of soot in the DPF. DPF Stationary Regen Only = 1-Enabled This option allows the DPF Regeneration Switch to only request a parked regeneration. If the conditions previously mentioned are met, a parked regen will be initiated. If the conditions are not met, nothing will happen. Hazardous Applications Service Record The MCM should be configured to not allow automatically triggered over-the-road regenerations (DPF Manual Regen Only Enable = Enabled).
It is mandatory that customers or distributors maintain a proper record of the particulate filter servicing and cleaning. This record is an agent to warranty considerations. The record must include information such as: All information subject to change without notice. (Rev. 04/08) 65 DDC-SVC-MAN-0040 0704 Copyright © 2008 DETROIT DIESEL CORPORATION