Caterpillar Electrical System Manual (EN)

UENR4049 April 2013 UENR4049 VOL 1 OF 2 42 Page, (Dimensions: 56 inches x 35 inches) 416F, 422F, 428F, and 434F Electrical System Backhoe Loader 416F: LWT323-UP 422F: LRH696-UP 428F: LBH1573-UP SJW437-UP 434F: LDH1-UP FLY1-UP Volume 1 of 2: Mechanical Control © 2013 Caterpillar, All Rights Reserved Printed in U.S.A. Harness And Wire Electrical Schematic Symbols Symbols Pressure Symbol T Temperature Symbol Level Symbol Flow Symbol Circuit Breaker Symbol Symbols and Definitions Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it. Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.).

The circle indicates that the component has screw terminals and a wire can be disconnected from it. Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component. Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine. Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. Reed Switch: A switch whose contacts are controlled by a magnet.

A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch. Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure. T Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay. The connectors shown in this chart are for harness to harness connectors.

Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart. Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work. Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them.

It also has an internal switch that places the latch coil circuit open at the time the coil latches. Resistor, Sender and Solenoid Specifications Harness and Wire Symbols Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes (see sample). Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness (C1, C2, C3, ...). Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...) AG-C4 111-7898 L-C12 3E-5179 L-C12 3E-5179 Part Number: for Connector Receptacle Part Number: for Connector Plug ¹ At room temperature unless otherwise noted.

Plug Pin or Socket Number Receptacle 5A 1 2 Deutsch connector: Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins. Fuse (5 Amps) 9X-1123 Component Part Number 1 Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets. Harness identification code: This example indicates wire group 325, wire 135 in harness "AG".

325-AG135 PK-14 2 Wire Color Wire Gauge CONN 15 CONN 25 CONN 30 15 144 46 20 17 95 116 19 CONN 26 22 136 CONN 14 CONN 29 CONN 24 28 145 30 98 50 18 CONN 18 49 42 16 UNDER PLATFORM - FRONT VIEW UNDER PLATFORM - FRONT VIEW 140 14 CONN 12 CONN 9 CONN 6 CONN 11 CONN 20 CONN 10 159 67 CONN 8 9 CONN 5 CONN 13 CONN 4 162 UNDER RIGHT CONSOLE 61 48 59 60 52 62 25 63 7 64 8 65 53 66 54 12 47 11 57 55 58 51 56 CONN 27 10 BLOCK GP - RELAY / FUSE Component Location (Volume 1) Schematic Machine Schematic Machine Component Component Location Location Location Location Alarm - Action D-15 1 Solenoid - Cold Start Adv F-3 82 Alarm - Action A-15 2 Solenoid - Diff Lock AS J-1 83 Alarm - Backup (CP) H-16 3 Solenoid - Diff Lock As STD J-3 84 Alarm - Backup (SS) J-16 4 Solenoid - Fuel Shutoff Turbo F-3 85 Alternator F-3 5 Solenoid - FWD High J-1 86 Battery F-5 6 Solenoid - FWD Low I-1 87 Block As - Fuse I-8 7 Solenoid - FWD Low STD J-3 88 Block As - Fuse G-8 8 Solenoid - HYD Torque Limit STD J-3 89 Blower Gp - Cab heater H-15 9 Solenoid - LH Lock Valve D-3 90 Bus Bar 1 J-8 10 Solenoid - Lockout I-15 91 Bus Bar 2 J-7 11 Solenoid - Lockup Clutch J-1 92 Bus Bar 3 J-7 12 Solenoid - REV AS I-1 93 Compressor Gp - A/C Clutch H-3 13 Solenoid - REV As STD J-3 94 Control Gp - AWS A-9 14 Solenoid - RH Lock Valve D-3 95 Diode - Blocking 1 C-5 15 Solenoid - Ride Control 1 E-10 96 Diode - Blocking 2 C-5 16 Solenoid - Ride Control 2 E-10 97 Diode - Fuel Lift Pump E-8 17 Solenoid - RTD F-11 98 Diode - Lights (FR) E-12 18 Solenoid - Side Shift Left J-14 99 Diode - Lights (RR) E-12 19 Solenoid - Side Shift Lock J-16 100 Diode - Neut Lock Alarm E-9 20 Solenoid - Side Shift Right I-15 101 Diode - REV Solenoid J-3 21 Solenoid - Speed Clutch 1 J-1 102 Diode - Roading E-12 22 Solenoid - Speed Clutch 2 J-1 103 Diode - Side Shift 1 I-15 23 Solenoid - Speed Clutch 3 J-1 104 Diode - Side Shift 2 I-15 24 Solenoid - STD AWD J-3 105 Flasher F-8 25 Stud - Cab Power G-4 106 Glow Plugs F-3 26 Stud - Jump Start G-5 107 Ground - Cab RF D-10 27 Stud - Power F-4 108 Ground - Control F-8 28 Suppressor - Lockout I-15 109 Ground - Engine H-4 29 Suppressor - ARC Ride Control E-10 110 Ground - Lower Cab F-8 30 Suppressor - ARC (Side Shift Left) J-14 111 Ground - Upper Cab C-9 31 Suppressor - ARC (Side Shift Right) I-14 112 Ground - Upper Cab G-14 32 Suppressor - ARC (SS Lock) J-16 113 Horn - Forward G-3 33 Suppressor - ARC HVAC H-3 114 Horn - RR J-16 34 Suppressor - ARC Load Check Disable 1 D-3 115 Motor Gp - Front Washer G-3 35 Suppressor - ARC Load Check Disable 2 D-3 116 Motor Gp - Front Wiper D-7 36 Switch - A/C Refrigerant Pressure H-3 117 Motor Gp - Front Wiper C-9 37 Switch - Air Filter G-3 118 Motor Gp - Fuel Lift Pump F-3 38 Switch - Attach Rear Work Lamp B-14 119 Motor Gp - Rear Washer G-3 39 Switch - Attch Front Work Lamp D-14 120 Motor Gp - Rear Wiper D-9 40 Switch - Attch Front Work Lamp A-14 121 Motor Gp - Rear Wiper C-12 41 Switch - Attch Rear Work Lamp D-14 122 Motor Gp - Seat E-5 42 Switch - AWD J-9 123 Motor Gp - Starter E-4 43 Switch - AWS A-11 124 Panel Gp - Instrument E-15 44 Switch - Battery Disconnect F-5 125 Panel Gp - Instrument B-15 45 Switch - Beacon G-10 126 Radio - Prod Link I-4 46 Switch - Blower Speed H-15 127 Relay - A/C Shutoff H-13 47 Switch - Brake (LH) I-10 128 Relay - AWD H-8 48 Switch - Brake (RH) I-10 129 Relay - Dead Engine Lower Command C-3 49 Switch - Bucket POS F-10 130 Relay - Dead Engine Lower Enable C-3 50 Switch - Cold Start Adv F-3 131 Relay - Fuel Lift Pump E-8 51 Switch - Column Multi Function H-10 132 Relay - FWD Horn I-8 52 Switch - Crab Circle A-11 133 Relay - Hi Speed H-13 53 Switch - Differential Lock I-10 134 Relay - Low Side Control F-8 54 Switch - Engine Oil Pressure G-3 135 Relay - Neut Lock Alarm D-8 55 Switch - Float Detent Pressure D-3 136 Relay - Neutral Start E-8 56 Switch - FNR Control I-10 137 Relay - Neutralizer F-8 57 Switch - Hazard H-10 138 Relay - Park Brake Alarm E-8 58 Switch - Heater A/C H-15 139 Relay - POS Lamp H-8 59 Switch - Horn E-14 140 Relay - Rear Horn H-8 60 Switch - HYD Oil Filter Bypass H-3 141 Relay - Ride Control H-8 61 Switch - Key D-15 142 Relay - Start B-5 62 Switch - Key A-15 143 Relay As - PRM Module 1 J-8 63 Switch - Neutralizer Loader Handle E-5 144 Relay As - PRM Module 2 J-7 64 Switch - Neutralizer XMSN Handle E-5 145 Relay As - PRM Module ENG J-7 65 Switch - Park Brake E-13 146 Relay As - PRM Module HVAC J-6 66 Switch - RC Pressure E-10 147 Resistor - Motor Speed G-15 67 Switch - Rear Fog Lamp I-9 148 Sender - Conv Temp I-3 68 Switch - Rear Wiper E-14 149 Sender - Conv Temp I-1 69 Switch - Rear Wiper B-14 150 Sender - Coolant Temp G-3 70 Switch - Return to Dig F-10 151 Sender - Fuel Level G-3 71 Switch - Ride Control I-9 152 Sensor - FR Axle Posn A-11 72 Switch - Roading H-9 153 Sensor - Fuel Water Separator G-3 73 Switch - Side Shift Lock D-14 154 Sensor - HYD Load Auto J-2 74 Switch - Stability Pressure B-7 155 Sensor - HYD Load STD J-5 75 Switch - Stability Warning B-10 156 Sensor - Hyd Oil Temp H-3 76 Switch - Start Aid C-14 157 Sensor - RR Axle Posn A-8 77 Switch - Start Aid A-14 158 Sensor - XMSN Out SPD J-2 78 Switch - Thermostat H-15 159 Sensor - XMSN Out SPD STD J-5 79 Switch - XMSN Lock J-9 160 Solenoid - AWD AS J-1 80 Valve Gp - AWS A-8 161 Solenoid - Bleed Valve B-8 81 Valve Gp - Stabilizer I-14 162 Alarm - Action D-15 1 Solenoid - Cold Start Adv F-3 82 Alarm - Action A-15 2 Solenoid - Diff Lock AS J-1 83 Alarm - Backup (CP) H-16 3 Solenoid - Diff Lock As STD J-3 84 Alarm - Backup (SS) J-16 4 Solenoid - Fuel Shutoff Turbo F-3 85 Alternator F-3 5 Solenoid - FWD High J-1 86 Battery F-5 6 Solenoid - FWD Low I-1 87 Block As - Fuse I-8 7 Solenoid - FWD Low STD J-3 88 Block As - Fuse G-8 8 Solenoid - HYD Torque Limit STD J-3 89 Blower Gp - Cab heater H-15 9 Solenoid - LH Lock Valve D-3 90 Bus Bar 1 J-8 10 Solenoid - Lockout I-15 91 Bus Bar 2 J-7 11 Solenoid - Lockup Clutch J-1 92 Bus Bar 3 J-7 12 Solenoid - REV AS I-1 93 Compressor Gp - A/C Clutch H-3 13 Solenoid - REV As STD J-3 94 Control Gp - AWS A-9 14 Solenoid - RH Lock Valve D-3 95 Diode - Blocking 1 C-5 15 Solenoid - Ride Control 1 E-10 96 Diode - Blocking 2 C-5 16 Solenoid - Ride Control 2 E-10 97 Diode - Fuel Lift Pump E-8 17 Solenoid - RTD F-11 98 Diode - Lights (FR) E-12 18 Solenoid - Side Shift Left J-14 99 Diode - Lights (RR) E-12 19 Solenoid - Side Shift Lock J-16 100 Diode - Neut Lock Alarm E-9 20 Solenoid - Side Shift Right I-15 101 Diode - REV Solenoid J-3 21 Solenoid - Speed Clutch 1 J-1 102 Diode - Roading E-12 22 Solenoid - Speed Clutch 2 J-1 103 Diode - Side Shift 1 I-15 23 Solenoid - Speed Clutch 3 J-1 104 Diode - Side Shift 2 I-15 24 Solenoid - STD AWD J-3 105 Flasher F-8 25 Stud - Cab Power G-4 106 Glow Plugs F-3 26 Stud - Jump Start G-5 107 Ground - Cab RF D-10 27 Stud - Power F-4 108 Ground - Control F-8 28 Suppressor - Lockout I-15 109 Ground - Engine H-4 29 Suppressor - ARC Ride Control E-10 110 Ground - Lower Cab F-8 30 Suppressor - ARC (Side Shift Left) J-14 111 Ground - Upper Cab C-9 31 Suppressor - ARC (Side Shift Right) I-14 112 Ground - Upper Cab G-14 32 Suppressor - ARC (SS Lock) J-16 113 Horn - Forward G-3 33 Suppressor - ARC HVAC H-3 114 Horn - RR J-16 34 Suppressor - ARC Load Check Disable 1 D-3 115 Motor Gp - Front Washer G-3 35 Suppressor - ARC Load Check Disable 2 D-3 116 Motor Gp - Front Wiper D-7 36 Switch - A/C Refrigerant Pressure H-3 117 Motor Gp - Front Wiper C-9 37 Switch - Air Filter G-3 118 Motor Gp - Fuel Lift Pump F-3 38 Switch - Attach Rear Work Lamp B-14 119 Motor Gp - Rear Washer G-3 39 Switch - Attch Front Work Lamp D-14 120 Motor Gp - Rear Wiper D-9 40 Switch - Attch Front Work Lamp A-14 121 Motor Gp - Rear Wiper C-12 41 Switch - Attch Rear Work Lamp D-14 122 Motor Gp - Seat E-5 42 Switch - AWD J-9 123 Motor Gp - Starter E-4 43 Switch - AWS A-11 124 Panel Gp - Instrument E-15 44 Switch - Battery Disconnect F-5 125 Panel Gp - Instrument B-15 45 Switch - Beacon G-10 126 Radio - Prod Link I-4 46 Switch - Blower Speed H-15 127 Relay - A/C Shutoff H-13 47 Switch - Brake (LH) I-10 128 Relay - AWD H-8 48 Switch - Brake (RH) I-10 129 Relay - Dead Engine Lower Command C-3 49 Switch - Bucket POS F-10 130 Relay - Dead Engine Lower Enable C-3 50 Switch - Cold Start Adv F-3 131 Relay - Fuel Lift Pump E-8 51 Switch - Column Multi Function H-10 132 Relay - FWD Horn I-8 52 Switch - Crab Circle A-11 133 Relay - Hi Speed H-13 53 Switch - Differential Lock I-10 134 Relay - Low Side Control F-8 54 Switch - Engine Oil Pressure G-3 135 Relay - Neut Lock Alarm D-8 55 Switch - Float Detent Pressure D-3 136 Relay - Neutral Start E-8 56 Switch - FNR Control I-10 137 Relay - Neutralizer F-8 57 Switch - Hazard H-10 138 Relay - Park Brake Alarm E-8 58 Switch - Heater A/C H-15 139 Relay - POS Lamp H-8 59 Switch - Horn E-14 140 Relay - Rear Horn H-8 60 Switch - HYD Oil Filter Bypass H-3 141 Relay - Ride Control H-8 61 Switch - Key D-15 142 Relay - Start B-5 62 Switch - Key A-15 143 Relay As - PRM Module 1 J-8 63 Switch - Neutralizer Loader Handle E-5 144 Relay As - PRM Module 2 J-7 64 Switch - Neutralizer XMSN Handle E-5 145 Relay As - PRM Module ENG J-7 65 Switch - Park Brake E-13 146 Relay As - PRM Module HVAC J-6 66 Switch - RC Pressure E-10 147 Resistor - Motor Speed G-15 67 Switch - Rear Fog Lamp I-9 148 Sender - Conv Temp I-3 68 Switch - Rear Wiper E-14 149 Sender - Conv Temp I-1 69 Switch - Rear Wiper B-14 150 Sender - Coolant Temp G-3 70 Switch - Return to Dig F-10 151 Sender - Fuel Level G-3 71 Switch - Ride Control I-9 152 Sensor - FR Axle Posn A-11 72 Switch - Roading H-9 153 Sensor - Fuel Water Separator G-3 73 Switch - Side Shift Lock D-14 154 Sensor - HYD Load Auto J-2 74 Switch - Stability Pressure B-7 155 Sensor - HYD Load STD J-5 75 Switch - Stability Warning B-10 156 Sensor - Hyd Oil Temp H-3 76 Switch - Start Aid C-14 157 Sensor - RR Axle Posn A-8 77 Switch - Start Aid A-14 158 Sensor - XMSN Out SPD J-2 78 Switch - Thermostat H-15 159 Sensor - XMSN Out SPD STD J-5 79 Switch - XMSN Lock J-9 160 Solenoid - AWD AS J-1 80 Valve Gp - AWS A-8 161 Solenoid - Bleed Valve B-8 81 Valve Gp - Stabilizer I-14 162 123 160 126 148 152 124 134 128 137 129 138 132 153 133 STEERING CONSOLE 142 157 158 1 2 44 45 154 149 150 143 139 120 121 127 119 122 156 RIGHT CONSOLE 100 3 4 111 112 CONN 22 109 23 24 101 81 77 161 99 91 UNDER PLATFORM - REAR VIEW CONN 1 CONN 23 CONN 7 CONN 16 113 96 97 147 110 CONN 2 CONN 21 UNDER PLATFORM - RIGHT SIDE VIEW Connector Location (Volume 1) Connector Number Schematic Location Connector Number Schematic Location CONN 1 J-14 CONN 17 C-11 CONN 2 H-16, J-14 CONN 18 A-11 CONN 3 I-16 CONN 19 C-7, C-10 CONN 4 A-14, D-15, G-14 CONN 20 B-10 CONN 5 D-12, E-13, F-14 CONN 21 B-9 CONN 6 F-13, F-14 CONN 22 B-8 CONN 7 I-13 CONN 23 A-9 CONN 8 E-13, H-13 CONN 24 J-2, J-4, J-5 CONN 9 C-7, C-12, E-13 CONN 25 I-5 CONN 10 B-12, D-13 CONN 26 I-3, I-5 CONN 11 A-12, C-13 CONN 27 I-5 CONN 12 A-12, C-13 CONN 28 H-5 CONN 13 B-11, C-13 CONN 29 D-5 CONN 14 A-11, G-10 CONN 30 D-5 CONN 15 F-10, F-11 CONN 31 H-3 CONN 16 E-11 CONN 32 F-4 115 71 90 FUEL TANK Part No.

Component Description Resistance (Ohms)¹ 244-3106 Sender: Coolant Temp 54°C (130°F) - 560 to 716 110°C (230°F) - 72 to 81.8 362-3089 Sender: Fuel Level (EST) Empty: 246-252 Full: 27-33 363-8475 Sender: Fuel Level (NON-EST) Empty: 246-252 Full: 27-33 299-2212 Solenoid: A/C Clutch 3.50 ± 0.15 305-3423 Solenoid: Diff Lock, STD AWD, Speed Clutch 1 8.8 ± 0.4 238-4626 Solenoid: Side Shift Left / Right 8.8 238-4628 Solenoid: Ride Control / Lockout 7.3 274-8041 Solenoid: Diff Lock 8 ± 0.5 1 2 Related Electrical Service Manuals Title Form Number Starting Motor:

149-0539 SENR3828 26 118 73 38 35 39 70 114 5 94 21 75 89 33 CONN 28 125 141 106 76 88 108 6 82 131 CONN 32 135 85 29 84 105 79 68 43 117 CONN 31 13 ENGINE WITH STD XMSN 74 87 93 104 69 80 102 92 78 103 86 83 XMXN - AUTOSHIFT CONN 19 36 37 72 CONN 17 CONN 3 155 34 40 41 146 107 31 32 27 130 151 MACHINE TOP VIEW - CAB ROOF REMOVED

Стр. 1

1 16 RT-C1 3E5179 PM-C16 1552252 200-RT1 BK-18 REAR LH STT LAMP 336-9096 GND TAIL 3 4 5 6 7 8 9 10 11 12 BK-18 BK-18 257-0478 STOP TURN YL OR GY BK 1 2 RT-C3 1552272 605-RT15 YL-18 605-RT15 YL-18 604-RT13 OR-18 617-RT17 BR-18 604-RT12 OR-18 367-RT10 BU-18 1 2 3 4 5 6 7 8 9 10 11 12 1 2 617-PM125 BR-18 604-PM209 OR-18 605-PM211 YL-18 606-PM210 GY-18 618-PM149 YL-18 367-PM11 BU-18 1 2 3 4 5 6 7 8 9 10 11 12 XK-C8 3E5179 H705-XK30 BR-18 XK-C14 1552269 RD-18 RD-18 1 2 (89) SOLENOID HYD TORQUE LIMIT STD 1 2 3 4 5 6 7 8 9 10 11 12 XA-C8 3E5179 751-XA1 GN-18 H803-XA16 BU-18 J879-XA31 GN-18 H705-XA30 BR-18 XA-C14 1552269 NOTE D 1 2 3 4 200-RT3 BK-18 200-RT3 BK-18 200-RT4 BK-18 617-RT18 BR-18 200-RT7 BK-18 200-RT6 BK-18 200-RT5 BK-18 200-RT2 BK-14 H771-RT23 BR-16 627-RT21 YL-18 618-RT20 YL-18 606-RT16 GY-18 H771-PM145 BR-16 627-PM206 YL-18 702-PM194 OR-18 911-PM196 YL-18 PM-C21 1552269 1 2 NOTE V TO PM HARNESS CONNECTOR PM-C52 LOC J-5 H803-XK8 BU-18 J879-XK3 GN-18 NOTE D 263-5516 TO PM HARNESS CONNECTOR PM-C52 LOC J-5 903-XA3 GY-18 900-XA7 PU-18 552-XA33 WH-18 324-XA22 BU-18 902-XA5 BR-18 J832-XA28 YL-18 XA-C15 1552269 1 2 RD-18 RD-18 (92) SOLENOID LOCKUP CLUTCH (100) SOLENOID SIDE SHIFT LOCK 1 2 RT-C4 1552269 H771-RT25 BR-16 200-RT8 BK-16 200-RT8 BK-16 367-RT10 BU-18 200-RT2 BK-14 CONN 1 200-PM159 BK-14 AWD CONT BRAKING SW 283-7616 PM-C52 1552252 1 2 752-XK9 YL-18 754-XK12 BU-18 552-XK33 WH-18 324-XK22 BU-18 452-XK18 PU-18 200-XK24 BK-18 H801-XK25 PU-18 200-XK24 BK-18 324-XK22 BU-18 XK-C11 1552269 1 2 RD-18 RD-18 (84) SOLENOID DIFF LOCK AS STD CONN 24 752-XA9 YL-18 754-XA12 BU-18 452-XA18 PU-18 J879-XA32 GN-18 XA-C11 1552269 (83) SOLENOID DIFF LOCK AS 238-4626 RT-C5 1552269 604-RT13 OR-18 604-RT14 OR-18 604-RT12 OR-18 754-RT22 BU-18 200-RT1 BK-18 RT-C2 3E3364 1 2 CONN 2 1 2 PM-C58 1552269 200-PM278 BK-18 754-PM77 BU-18 102-PM176 RD-14 131-PM63 BR-16 131-PM126 BR-16 NOTE X 552-PM162 WH-18 200-PM267 BK-18 3 4 5 6 7 8 9 10 11 12 TO XK HARNESS CONNECTOR XK-C8 LOC J-4 OR TO XA HARNESS CONNECTOR XA-C8 LOC J-2 CONN 24 200-XK24 BK-18 324-XK22 BU-18 552-XK33 WH-18 752-XK9 YL-18 754-XK12 BU-18 452-XK18 PU-18 305-3423 200-XA24 BK-18 H801-XA25 PU-18 200-XA24 BK-18 324-XA22 BU-18 452-XA18 PU-18 324-XA22 BU-18 200-XA24 BK-18 552-XA33 WH-18 XA-C6 1552269 1 2 RD-18 RD-18 274-8041 UENR4049 VOL 1 OF 2 42 Page, (Dimensions:

56 inches x 35 inches) J (113) SUPPRESSOR ARC (SS LOCK) 189-3158 1 2 H771-RT24 BR-16 200-RT6 BK-18 617-RT17 BR-18 617-RT19 BR-18 617-RT18 BR-18 605-RT15 YL-18 606-RT16 GY-18 TO RC HARNESS CONNECTOR RC-C2 LOC H-16 202-PM83 BK-18 614-PM189 PU-18 N945-PM228 OR-18 131-PM126 BR-16 911-PM195 YL-18 552-PM42 WH-18 H9 H9 452-PM139 PU-18 752-PM212 YL-18 754-PM208 BU-18 324-PM19 BU-16 1 2 3 4 5 6 7 8 9 10 11 12 XK-C3 1907612 E901-XK19 GN-18 E900-XK20 WH-18 H705-XK30 BR-18 E901-XK19 GN-18 E900-XK20 WH-18 552-XK33 WH-18 H803-XK8 BU-18 XK-C6 1552269 1 2 305-3423 (105) SOLENOID STD AWD 1 2 3 4 5 6 7 8 9 10 11 12 XA-C7 1907612 E901-XA19 GN-18 E900-XA20 WH-18 752-XA9 YL-18 754-XA12 BU-18 900-XA7 PU-18 751-XA1 GN-18 552-XA33 WH-18 H803-XA16 BU-18 1 2 RD-18 RD-18 305-3423 (80) SOLENOID AWD AS J 618-RT20 YL-18 627-RT21 YL-18 754-RT22 BU-18 102-PM176 RD-14 102-PM170 RD-14 111-PM73 RD-18 202-PM161 BK-18 202-PM8 BK-18 PM-S39 202-PM40 BK-18 202-PM186 BK-18 202-PM188 BK-18 202-PM52 BK-18 (123) SWITCH AWD 362-3298 8 1 3 4 6 10 105-PM18 RD-18 123-PM143 WH-18 106-PM32 RD-12 123-PM150 WH-18 123-PM88 WH-18 310-PM93 PU-18 308-PM124 YL-18 200-PM108 BK-18 200-PM181 BK-18 H801-PM23 PU-18 CONN 24 NOTE C J879-XK3 GN-18 X800-XK1 OR-18 H705-XK30 BR-18 XK-C5 1552269 H705-XA30 BR-18 J879-XA29 GN-18 J832-XA28 YL-18 975-XA13 WH-18 902-XA5 BR-18 903-XA3 GY-18 975-XA2 WH-18 975-XA2 WH-18 751-XA1 GN-18 XA-C1 1552269 1 2 RD-18 RD-18 (102) SOLENOID SPEED CLUTCH 1 RT-C6 1552269 H771-RT24 BR-16 H771-RT25 BR-16 H771-RT23 BR-16 131-PM126 BR-16 111-PM74 RD-18 118-PM45 GY-16 131-PM63 BR-16 136-PM157 GN-16 308-PM109 YL-18 552-PM162 WH-18 601-PM15 GY-16 202-PM282 BK-18 202-PM186 BK-18 NOTE X 7 2 5 PM-C45 2285856 9 200-PM234 BK-14 200-PM240 BK-14 200-PM181 BK-18 180-PM238 GN-14 (11) BUS BAR 2 (12) BUS BAR 3 (10) BUS BAR 1 275-0570 275-0570 275-0553 308-PM106 YL-18 200-PM46 BK-18 J984-XK7 PK-18 J764-XK6 BR-18 X800-XK1 OR-18 H801-XK25 PU-18 H803-XK8 BU-18 H801-XK10 PU-18 H801-XK10 PU-18 H801-XK11 PU-18 X752-XK2 GY-18 278-0209 RD-18 RD-18 1 2 (ET SOL 3) (94) SOLENOID REV AS STD X800-XA14 OR-18 J764-XA15 BR-18 J984-XA17 PK-18 975-XA8 WH-18 975-XA13 WH-18 E900-XA20 WH-18 975-XA6 WH-18 975-XA4 WH-18 903-XA3 GY-18 XA-C3 1552269 1 2 RD-18 RD-18 (ET SOL 4) (103) SOLENOID SPEED CLUTCH 2 305-3423 (4) ALARM BACKUP (SS) 154-5428 RD-16 BK-16 + - 1 2 754-RT22 BU-18 200-RT1 BK-18 PE-C3 1552269 200-PM182 BK-18 200-PM159 BK-14 161-PM264 RD-16 144-PM187 GN-16 159-PM100 BU-16 200-PM1 BK-18 102-PM176 RD-14 131-PM63 BR-16 610-PM204 OR-14 610-PM153 OR-16 202-PM83 BK-18 552-PM162 WH-18 702-PM193 OR-18 202-PM3 BK-18 202-PM92 BK-18 200-PM267 BK-18 202-PM31 BK-18 202-PM65 BK-18 (63) RELAY AS PRM MODULE 1 276-7290 276-7291 (64) RELAY AS PRM MODULE 2 (66) RELAY AS PRM MODULE HVAC (65) RELAY AS PRM MODULE ENG 322-6827 276-7287 (75) SENSOR HYD LOAD STD (21) DIODE REV SOL XK-C7 2304013 J984-XK7 PK-18 J764-XK6 BR-18 J879-XK3 GN-18 XK-C10 1552269 XA-C9 2304013 E901-XA19 GN-18 H705-XA30 BR-18 975-XA4 WH-18 XA-C2 1552269 (ET SOL 5) 278-0213 (99) SOLENOID SIDE SHIFT LEFT BK-18 BK-18 238-4626 1 2 200-PE10 BK -18 M719-PE17 GN -18 200-PE5 BK -18 605-PM211 YL-18 200-PM278 BK-18 604-PM209 OR-18 606-PM210 GY-18 367-PM11 BU-18 200-PM44 BK-18 202-PM161 BK-18 202-PM161 BK-18 202-PM164 BK -18 202-PM165 BK-18 202-PM43 BK-18 308-PM109 YL -18 552-PM162 WH-18 131-PM126 BR-16 614-PM218 PU-18 614-PM189 PU-18 614-PM191 PU-18 614-PM147 PU-18 614-PM281 PU-18 614-PM191 PU-18 766-PM175 GN-18 G763-PM257 PU-18 202-PM178 BK-18 304-PM113 WH-12 202-PM119 BK-18 202-PM134 BK-18 PRM FUSES 30A 274-9872 40A 278-6377 60A 267-2701 +BAT 60A +BAT +BAT 40A +BAT +5V GROUND SIGNAL 344-7391 RD-18 YL-18 GN-18 1 2 3 X800-XK1 OR-18 J764-XK6 BR-18 J984-XK7 PK-18 X752-XK2 GY-18 754-XK12 BU-18 1 2 189-3158 (74) SENSOR HYD LOAD AUTO V +(POS) GROUND SIGNAL 344-7391 1 2 3 X800-XA14 OR-18 J764-XA15 BR-18 J984-XA17 PK-18 H801-XA25 PU-18 H801-XA10 PU-18 H801-XA11 PU-18 902-XA5 BR-18 975-XA6 WH-18 XA-C4 1552269 1 2 (ET SOL 6) (104) SOLENOID SPEED CLUTCH 3 278-0213 (34) HORN RR 164-9425 1 2 RT-C7 1552269 200-RT7 BK-18 367-RT10 BU-18 NOTE:

SIDE SHIFT RIGHT SOL IS 362-3212 WHEN USED WITH REAR AUX (8TH FUNCTION.

PE-C6 1552269 200-PE6 BK -18 200-PE8 BK -18 200-PE7 BK -18 200-PE10 BK -18 200-PE15 BK -18 PE-C1 3E3370 PM-C38 1552267 627-PM206 YL-18 617-PM125 BR -18 618-PM149 YL-18 308-PM75 YL-18 202-PM280 BK-18 202-PM174 BK-18 308-PM109 YL-18 610-PM204 OR-14 610-PM153 OR-16 601-PM15 GY-16 702-PM131 OR-18 702-PM193 OR-18 702-PM194 OR-18 627-PM206 YL-18 (160) SWITCH XMSN LOCK 8 1 3 4 6 10 309-PM95 GY-18 306-PM101 GN-18 308-PM37 YL-18 60A 60A 30A 40A (79) SENSOR XMSN OUT SPD STD SIG + SIG - 1 2 XK-C12 1552269 E900-XK20 WH-18 752-XK9 YL-18 XK-C13 1552269 1 2 (88) SOLENOID FWD LOW STD XA-C12 1552269 J764-XA15 BR-18 H803-XA16 BU-18 J832-XA28 YL-18 975-XA8 WH-18 900-XA7 PU-18 1 2 280-7010 (86) SOLENOID FWD HIGH STOP TURN YL OR GY BK 1 2 RT-C8 1552272 604-RT14 OR-18 (111) SUPPRESSOR ARC (SIDE SHIFT LEFT) 189-3158 1 2 200-PE6 BK -18 M719-PE18 GN -18 200-PE5 BK -18 M719-PE16 GN -18 M719-PE16 GN -18 M719-PE17 GN -18 M719-PE18 GN -18 M721-PE20 WH -18 200-PE23 BK -18 A B C A B C M719-PM183 M721-PM184 200-PM182 BK-18 M719-PM183 GN-18 GN-18 WH-18 H771-PM145 BR-16 M721-PM184 WH-18 754-PM77 BU-18 102-PM176 RD-14 102-PM246 RD-14 102-PM268 RD-14 102-PM170 RD-14 324-PM19 BU-16 330-PM29 YL-18 308-PM202 YL-18 419-PM25 YL-18 320-PM128 OR-18 627-PM206 YL-18 614-PM218 PU-18 766-PM175 GN-18 911-PM5 YL-18 702-PM131 OR-18 911-PM5 YL-18 766-PM175 GN-18 911-PM195 YL-18 911-PM196 YL-18 202-PM40 BK-18 214-4716 7 2 5 PM-C43 2285856 9 384-PM110 BU-12 384-PM66 BU-12 322-PM167 GY-18 405-PM122 GY-18 324-PM19 BU-16 200-PM9 BK-18 308-PM17 YL-18 PM-C29 2304011 1 2 85 30 PM-C30 2304011 1 2 85 30 PM-C51 2304011 1 2 85 30 PM-C31 2304011 1 2 85 30 191-8304 E901-XK19 GN-18 NOTE C H801-XK11 PU-18 (ET SOL 1) 324-2579 (78) SENSOR XMSN OUT SPD 191-8304 SIG + SIG - 1 2 E901-XA19 GN-18 E900-XA20 WH-18 J879-XA32 GN-18 J879-XA29 GN-18 J879-XA31 GN-18 H801-XA10 PU-18 754-XA12 BU-18 XA-C5 1552269 1 2 RD-18 RD-18 (ET SOL 2) (93) SOLENOID REV AS REAR RH STT LAMP 336-9096 GND TAIL 3 4 200-RT4 BK-18 618-RT20 YL-18 606-RT16 GY-18 (101) SOLENOID SIDE SHIFT RIGHT BK-18 BK-18 238-4626 1 2 PE-C5 1552269 200-PE7 BK -18 M721-PE22 WH -18 M720-PE13 BU -18 M720-PE14 BU -18 M720-PE24 BU -18 M719-PE27 GN -18 CONN 7 105-PM62 RD-16 105-PM18 RD-18 105-PM60 RD-16 502-PM34 OR-16 501-PM179 GN-16 500-PM203 BR-16 506-PM255 PU-18 F739-PM152 GN-18 N945-PM228 OR-18 G763-PM257 PU-18 F739-PM152 GN-18 G763-PM257 PU-18 N945-PM228 OR-18 202-PM52 BK-18 308-PM109 YL-18 439-PM70 YL-18 420-PM169 OR-18 441-PM38 OR-18 H9 86 RELAY 87 87A 86 RELAY 87 87A 86 RELAY 87 87A 86 RELAY 87 87A 452-XK18 PU-18 T 4W-9972 (68) SENDER CONV TEMP GEAR DIAGRAM SOLENOIDS ET SOL 1F FWD LOW & CLUTCH 1 1&4 2F FWD HIGH & CLUTCH 1 2&4 1R RVS & CLUTCH 1 3&4 2R RVS & CLUTCH 2 3&5 3R RVS 7 CLUTCH 3 3&6 X800-XA14 OR-18 J984-XA17 PK-18 XA-C13 1552269 (ET SOL 3) 278-0209 NOTE:

SIDE SHIFT RIGHT SOL IS 362-3212 WHEN USED WITH REAR AUX (8TH FUNCTION.

M721-PE20 WH -18 M721-PE22 WH -18 M721-PE21 WH -18 M720-PE26 BU -18 111-PM41 RD-16 111-PM73 RD-18 111-PM74 RD-18 590-PM192 GY-18 552-PM162 WH-18 518-PM120 OR-16 537-PM219 GN-18 537-PM230 GN-18 LOAD CHECK DISABLE SW 253-9395 MOM 507-PM114 WH-18 506-PM116 PU-18 450-PM185 YL-18 450-PM67 YL-18 447-PM156 PK -18 452-PM139 PU-18 SB USB SB USB SB USB SB USB NOTE T STD XMSN SOL - ATCH 752-XA9 YL-18 H801-XA11 PU-18 1 2 (ET SOL 1) (87) SOLENOID FWD LOW 280-7009 LF-C3 2304011 LF-C1 3E3370 RT-C9 1552267 (112) SUPPRESSOR ARC (SIDE SHIFT RIGHT) 1 2 PE-C4 1552269 M721-PE21 WH -18 200-PE8 BK -18 M721-PE25 WH -18 116-PM243 BR-16 117-PM242 YL-16 115-PM190 RD-18 603-PM237 PK-16 601-PM15 GY-16 604-PM71 OR-18 PM-C28 2059362 (134) SWITCH DIFFERENTIAL LOCK NOTE:

OPTIONAL RIDE CONTROL SW MAY BE REPLACED WITH LOAD CHECK DISABLE SW. CONNECT TO PM-C12 IF REQUIRED.

521-PM226 YL-18 552-PM162 WH-18 605-PM89 YL-18 606-PM50 GY-18 106-PM32 RD-12 384-PM66 BU-12 384-PM110 BU-12 106-PM32 RD-12 384-PM66 BU-12 384-PM110 BU-12 452-XA18 PU-18 (69) SENDER CONV TEMP REAR FOG LAMP 262-4727 1 2 627-LF5 YL-18 200-LF2 BK-18 200-LF1 BK-18 B A C CONN 3 200-RT5 BK-18 627-RT21 YL-18 617-RT19 BR-18 189-3158 PE-C10 1552269 118-PM148 GY-16 118-PM45 GY-16 119-PM166 PK-14 119-PM239 PK-16 118-PM180 GY-16 119-PM241 PK-16 605-PM172 YL-18 606-PM86 GY-18 605-PM90 YL-18 605-PM91 YL-18 604-PM72 OR-18 324-PM19 BU-16 G795-PM135 OR-16 A B 204-0775 F739-PM152 GN-18 614-PM147 PU-18 619-PM213 GN-14 611-PM51 PU-14 618-PM217 YL-18 617-PM215 BR-18 146-PM47 GY-10 112-PM10 PU-10 146-PM36 GY-10 112-PM20 PU-10 AUTOSHIFT XMSN SOL - ATCH T 4W-9972 LF-C2 1552269 (91) SOLENOID LOCKOUT BK-18 BK-18 238-4628 1 2 M720-PE13 BU -18 200-PE23 BK -18 (162) VALVE GP STABILIZER (128) SWITCH BRAKE (LH) 123-PM6 WH-18 123-PM88 WH-18 123-PM2 WH-18 123-PM79 WH-18 606-PM171 GY-18 607-PM274 PK-16 606-PM87 GY-18 PM-C8 1082253 (152) SWITCH RIDE CONTROL 214-4719 8 1 3 4 6 10 766-PM112 GN-18 766-PM82 GN-18 752-PM212 YL-18 754-PM208 BU-18 POWER DISTRIBUTION BLOCK 103-PM39 RD-10 103-PM35 RD-10 PM-C32 1552272 WT-C1 3E3376 WT-C2 1552252 I LIC LAMP.

196-0030 1 2 200-LF3 BK-18 617-LF4 BR-18 (109) SUPPRESSOR LOCKOUT SOL 1 2 PE-C7 1552269 M720-PE14 BU -18 200-PE15 BK -18 374-6870 PM-C25 3E3364 124-PM227 GN-18 123-PM143 WH-18 123-PM150 WH-18 610-PM153 OR-16 610-PM204 OR-14 610-PM115 OR-14 608-PM275 GN-16 702-PM131 OR-18 604-PM71 OR-18 111-PM73 RD-18 A B C 105-8034 NOTE E 202-PM8 BK-18 NOTE P 7 2 5 PM-C12 2285856 9 P832-PM24 WH-18 N939-PM137 GN-18 H801-PM23 PU-18 X977-PM254 YL-18 102-PM246 RD-14 111-PM41 RD-16 104-PM197 RD-18 104-PM197 RD-18 105-PM60 RD-16 105-PM60 RD-16 102-PM246 RD-14 115-PM190 RD-18 111-PM41 RD-16 450-PM185 YL-18 308-PM37 YL-18 202-PM31 BK-18 105-PM18 RD-18 1 2 3 4 1 2 3 4 105-WT1 RD-18 202-WT2 BK-18 308-WT3 YL-18 450-WT4 YL-18 3 4 5 6 7 8 9 10 11 12 1 2 ANTENNA AS.

284-8531 I REAR FOG LAMPS (ATCH) & LICENSE PLATE REAR END-BHL SS NOTE H 189-3158 PE-C8 1552269 1 2 J881-PM121 YL-18 J881-PM121 YL-18 G981-PM127 PU-18 G981-PM127 PU-18 G981-PM133 PU-18 G981-PM142 PU-16 J881-PM121 YL-18 J881-PM123 YL-18 J881-PM121 YL-18 J881-PM123 YL-18 G981-PM142 PU-16 131-PM140 BR-16 131-PM138 BR-16 131-PM99 BR-16 131-PM126 BR-16 131-PM63 BR-16 614-PM173 PU-18 614-PM4 PU-18 611-PM85 PU-14 611-PM49 PU-18 PM-C7 1082253 131-PM63 BR-16 627-PM206 YL-18 600-PM12 BR-18 600-PM12 BR-18 161-PM103 RD-16 161-PM103 RD-16 115-PM190 RD-18 CONN 25 TO WR HARNESS CONNECTOR WR-C2 LOC I-3 ANTENNA WR-C1 1552252 125-WR1 OR-18 200-WR2 BK-18 308-WR3 YL-18 403-WR4 YL-18 WR-C2 3E5179 1 2 3 4 5 6 7 8 9 10 11 12 (23) DIODE 1 189-3158 1 2 M720-PE24 BU -18 M721-PE25 WH -18 LH STAB LEG UP PM-C26 3E3364 J881-PM123 YL-18 143-PM265 BR-16 133-PM84 OR-16 136-PM157 GN-16 627-PM206 YL-18 619-PM213 GN-14 614-PM279 PU-18 668-PM270 BU-18 614-PM218 PU-18 111-PM74 RD-18 720-PM130 PU-18 604-PM72 OR-18 A B C 105-8034 (129) SWITCH BRAKE (RH) 614-PM281 PU-18 (148) SWITCH REAR FOG LAMP 8 1 3 4 6 10 102-PM246 RD-14 104-PM197 RD-18 102-PM268 RD-14 617-PM214 BR-18 600-PM14 BR-18 600-PM14 BR-18 618-PM216 YL-18 600-PM13 BR-18 600-PM13 BR-18 614-PM26 PU-18 (7) BLOCK AS FUSE 614-PM26 PU-18 617-PM214 BR-18 618-PM216 YL-18 N979-WT5 GN-16 N960-WT6 OR-16 N957-WT7 PK-16 CONN 26 BAT + BAT - KEY SW RUN R TERM RS-232-TXD 3 4 5 6 7 8 9 10 11 12 1 2 125-WR1 OR-18 200-WR2 BK-18 308-WR3 YL-18 403-WR4 YL-18 TO WT HARNESS CONNECTOR WT-C2 LOC I-5 (24) DIODE 2 1 2 PE-C11 1552269 M720-PE26 BU -18 M719-PE27 GN -18 RH STAB LEG UP 1 2 G981-PM133 PU-18 J881-PM123 YL-18 105-PM62 RD-16 157-PM244 YL-16 158-PM245 BR-16 668-PM271 BU-18 668-PM272 BU-18 NOTE E 214-4721 7 2 5 PM-C60 2285856 9 104-PM201 RD-18 104-PM199 RD-18 104-PM198 RD-18 104-PM200 RD-18 PM-C41 2929784 N979-WT5 GN-16 WT-C3 9X4813 SERVICE PORT CONNECTIONS A = GND B = RXD C = TXD RS-232-RXD RS-232-GND RS-232-DTR RS-232-DSR N957-WR7 PK-18 N970-WR8 YL-18 N979-WR5 GN-18 N979-WR5 GN-18 N960-WR6 OR-18 N960-WR6 OR-18 N957-WR7 PK-18 CONN 26 189-3158 POWERED SIDESHIFT - ATCH (SS ONLY) STABILIZER ALARM - ATCH 117-PM242 YL-16 116-PM243 BR-16 115-PM190 RD-18 118-PM148 GY-16 116-PM243 BR-16 119-PM166 PK-14 161-PM263 RD-16 200-PM97 BK-18 161-PM264 RD-16 200-PM44 BK-18 161-PM103 RD-16 200-PM1 BK-18 752-PM212 YL-18 752-PM212 YL-18 720-PM130 PU-18 702-PM131 OR-18 308-PM202 YL-18 PM-C10 1552273 1 2 (137) SWITCH FNR CONTROL 310-9356 610-PM204 OR-14 610-PM153 OR-16 202-PM282 BK-18 115-PM190 RD-18 105-PM60 RD-16 111-PM41 RD-16 106-PM32 RD-12 104-PM198 RD-18 104-PM199 RD-18 (52) RELAY FWD HORN 86 D1 C1 30 B1 AA1 A1 BACKLIGHT 10A F1 600-PM13 BR-18 614-PM26 PU-18 N957-WT7 PK-16 N960-WT6 OR-16 CONN 27 A B C N973-WR9 BR-18 WR-C3 3E3364 123-PM6 WH-18 124-PM227 GN-18 119-PM239 PK-16 131-PM140 BR-16 200-PM182 BK-18 200-PM278 BK-18 200-PM159 BK-14 200-PM220 BK-14 200-PM181 BK-18 200-PM267 BK-18 200-PM94 BK-18 911-PM5 YL-18 F739-PM152 GN-18 754-PM28 BU-18 766-PM175 GN-18 320-PM128 OR-18 330-PM29 YL-18 754-PM28 BU-18 3 4 5 6 N F N R NOTE R 601-PM15 GY-16 8 1 3 4 6 10 123-PM2 WH-18 118-PM180 GY-16 117-PM242 YL-16 119-PM241 PK-16 146-9439 K1 87 D2 C2 B2 87A 85 AA2 A2 LH TAIL 10A F2 600-PM14 BR-18 PRODUCT LINK JUMPER - ATCH 336-3545 (46) RADIO PROD LINK N973-WR9 BR-18 N970-WR8 YL-18 1 2 CONNECTOR NOT USED HEATER / A/C SW FUNCTION CONNECTIONS HEATER ON 2&3 5&6 A/C ON 2&1 5&4 614-AC15 PU-18 133-PM84 OR-16 157-PM244 YL-16 158-PM245 BR-16 161-PM263 RD-16 143-PM265 BR-16 200-PM104 BK-18 200-PM7 BK-18 N945-PM228 OR-18 G795-PM135 OR-16 G763-PM257 PU-18 200-PM44 BK-18 HORN (153) SWITCH ROADING 214-4711 7 2 5 PM-C37 2285856 9 123-PM88 WH-18 124-PM227 GN-18 131-PM99 BR-16 123-PM79 WH-18 131-PM138 BR-16 322-PM167 GY-18 104-PM201 RD-18 104-PM200 RD-18 320-PM128 OR-18 D3 B3 C3 RH TAIL 10A F3 617-PM214 BR-18 PRODUCT LINK 121SR - ATCH RC-C1 1552269 RC-C2 3E3364 TO PM HARNESS CONNECTOR PM-C58 LOC J-14 E528-AC13 PU-14 E528-AC12 PU-14 522-AC20 WH-18 614-AC23 PU-18 NOTE M VENT SW 214-4703 569-AC31 PK-18 521-AC29 YL-18 (47) RELAY A/C SHUTOFF 4 5 2 200-PM221 BK-18 202-PM69 BK-18 202-PM144 BK-18 200-PM97 BK-18 200-PM221 BK-18 202-PM61 BK-18 202-PM134 BK-18 (132) SWITCH COLUMN MULTI FUNCTION 202-PM188 BK-18 102-PM176 RD-14 143-PM265 BR-16 144-PM187 GN-16 133-PM84 OR-16 136-PM157 GN-16 (60) RELAY REAR HORN 146-9439 86 30 A3 AA3 600-PM12 BR-18 618-PM216 YL-18 (3) ALARM BACKUP (CP) RD-16 BK-16 + - 1 2 200-RC4 BK-18 321-RC3 BR-18 CONN 2 1 2 (139) SWITCH HEATER AC 214-4718 8 1 3 4 6 10 122-AC1 BU-12 122-AC24 BU-12 122-AC26 BU-12 140-9378 K19 1 3 AC-C8 2579257 309-PM95 GY-18 310-PM93 PU-18 307-PM146 OR-16 308-PM59 YL-16 405-PM122 GY-18 202-PM69 BK-18 202-PM178 BK-18 202-PM160 BK-18 202-PM31 BK-18 202-PM256 BK-18 202-PM65 BK-18 PM-C9 1552264 273-9190 159-PM100 BU-16 161-PM103 RD-16 157-PM244 YL-16 180-PM238 GN-14 158-PM245 BR-16 367-PM11 BU-18 A305-PM151 YL-18 K2 87 B4 C4 D4 87A 85 A4 AA4 KEY 10A F4 103-PM48 RD-14 105-PM60 RD-16 (141) SWITCH HYD OIL FILTER BYPASS 134-0404 154-5428 REAR END HARNESS - BHL CP NOTE M 7 2 5 AC-C3 2285856 9 200-AC22 BK-14 124-AC5 GN-18 122-AC1 BU-12 200-AC8 BK-14 200-AC9 BK-18 200-AC8 BK-14 200-AC10 BK-12 124-AC5 GN-18 133-AC30 OR-18 C511-AC7 WH-18 420-PM169 OR-18 419-PM55 YL-18 441-PM38 OR-18 439-PM70 YL-18 202-PM207 BK-16 202-PM164 BK-18 202-PM165 BK-18 202-PM43 BK-18 105-PM18 RD-18 102-PM246 RD-14 102-PM268 RD-14 619-PM213 GN-14 610-PM115 OR-14 102-PM170 RD-14 1 2 3 4 5 6 7 8 YL BK/PU WH/YL 56b 56 15/1 L R TURN SIGNALS HEADLIGHT FLASH FRONT DASH PANEL 200-PM108 BK-18 200-PM46 BK-18 200-PM9 BK-18 200-PM105 BK-18 668-PM269 BU-18 102-PM268 RD-14 (59) RELAY POS LAMP D5 C5 B5 A5 AA5 ACC SKT 10A F5 103-PM53 RD-14 E455-EF10 BR-16 L740-EF12 BR-18 442-EF11 GY-18 NOTE D 200-AC25 BK-14 200-AC22 BK-14 200-AC2 BK-18 200-AC27 BK-12 K20 9 10 7 501-PM179 GN-16 500-PM203 BR-16 450-PM33 YL-18 447-PM156 PK-18 452-PM139 PU-18 202-PM144 BK-18 202-PM280 BK-18 202-PM3 BK-18 202-PM92 BK-18 202-PM174 BK-18 115-PM190 RD-18 116-PM243 BR-16 117-PM242 YL-16 111-PM41 RD-16 105-PM60 RD-16 537-PM230 GN-18 606-PM86 GY-18 611-PM85 PU-14 605-PM90 YL-18 WH PU/GN PU/RD PU/WH 56a LOW BEAM 49a L R 202-PM102 BK-18 200-PM258 BK-18 202-PM61 BK-18 200-PM222 BK-18 200-PM129 BK-18 146-9439 K3 86 87 87A 30 85 BRAKE LAMPS 15A F6 115-PM190 RD-18 EF-C3 1552269 1 2 H E529-AC21 YL-14 614-AC14 PU-18 517-AC19 BU-14 516-AC18 GN-14 515-AC4 GY-18 E528-AC28 PU-14 516-AC18 GN-14 517-AC19 BU-14 515-AC4 GY-18 6 8 506-PM252 PU-18 502-PM34 OR-16 503-PM177 BR-16 202-PM119 BK-18 202-PM229 BK-16 202-PM161 BK-18 123-PM79 WH-18 123-PM2 WH-18 118-PM180 GY-16 119-PM241 PK-16 PM-C55 1552273 WIPER HIGH BEAM 102-PM246 RD-14 307-PM118 OR-18 202-PM160 BK-18 202-PM256 BK-18 306-PM101 GN-18 600-PM277 BR-18 200-PM129 BK-18 D6 C6 B6 A6 AA6 103-PM58 RD-14 111-PM41 RD-16 103-PM39 RD-10 H9 202-PM65 BK-18 123-PM150 WH-18 PM-C15 2584170 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 EF-C26 2584172 123-EF62 WH-18 202-EF67 BK-18 322-EF26 GY-16 441-EF19 OR-18 NOTE D (76) SENSOR HYD OIL TEMP T H (127) SWITCH BLOWER SPEED 8 1 3 4 6 10 522-AC20 WH-18 521-AC29 YL-18 124-AC5 GN-18 614-AC6 PU-18 521-AC29 YL-18 AC-C7 3E3370 A B C TO PM HARNESS CONNECTOR PM-C35 LOC E-13 568-PM80 GN-18 564-PM224 GY-16 521-PM226 YL-18 507-PM114 WH-18 307-PM118 OR-18 307-PM146 OR-16 308-PM75 YL-18 307-PM163 OR-18 308-PM37 YL-18 123-PM150 WH-18 123-PM88 WH-18 123-PM143 WH-18 124-PM227 GN-18 131-PM99 BR-16 590-PM192 GY-18 502-PM34 OR-16 500-PM203 BR-16 501-PM179 GN-16 1 2 3 4 5 6 WASHER BK/BU BK/YL BK/BU/BN BN/BU BK/BU/WH BK/BU/YL 31b 53b 53 J 15 53c 102-PM268 RD-14 104-PM197 RD-18 104-PM198 RD-18 104-PM199 RD-18 308-PM124 YL-18 308-PM106 YL-18 307-PM163 OR-18 308-PM17 YL-18 308-PM132 YL-18 720-PM130 PU-18 911-PM5 YL-18 (48) RELAY AWD 86 D7 C7 30 B7 HORN RELAYS 10A A7 AA7 F7 103-PM76 RD-14 104-PM197 RD-18 441-PM38 OR-18 521-PM226 YL-18 447-PM156 PK-18 322-PM167 GY-18 123-EF62 WH-18 123-EF23 WH-18 123-EF28 WH-18 123-EF52 WH-18 DELUXE CAB (OPTION) 264-4297 E529-AC21 YL-14 214-4695 7 2 5 AC-C2 2285856 9 200-AC25 BK-14 E528-AC11 PU-14 200-AC9 BK-18 614-AC23 PU-18 614-AC15 PU-18 614-AC14 PU-18 614-AC6 PU-18 CONN 8 H8 590-PM192 GY-18 603-PM237 PK-16 604-PM27 OR-18 308-PM59 YL-16 308-PM106 YL-18 308-PM17 YL-18 308-PM109 YL-18 308-PM202 YL-18 136-PM157 GN-16 143-PM265 BR-16 133-PM84 OR-16 131-PM138 BR-16 118-PM45 GY-16 506-PM255 PU-18 105-PM18 RD-18 105-PM60 RD-16 104-PM200 RD-18 104-PM201 RD-18 308-PM247 YL-18 310-PM93 PU-18 320-PM128 OR-18 322-PM167 GY-18 146-9439 K4 87 D8 87A C8 85 B8 A8 AA8 HAZARD 15A F8 103-PM78 RD-14 103-PM35 RD-10 447-EF22 PK-18 521-EF14 YL-18 L740-EF12 BR-18 E455-EF10 BR-16 442-EF11 GY-18 200-EF6 BK-16 200-EF30 BK-18 200-EF3 BK-18 521-AE4 YL-18 513-AE3 OR-18 AE-C3 1684999 A B (117) SWITCH A/C REFRIGERANT PRESS C568-AC17 WH-12 C568-AC16 WH-12 C511-AC7 WH-18 C568-AC3 WH-12 AC-C1 1116795 30 (53) RELAY HI SPD 606-PM232 GY-18 605-PM30 YL-18 608-PM236 GN-16 607-PM276 PK-16 607-PM235 PK-16 309-PM95 GY-18 308-PM124 YL-18 308-PM247 YL-18 308-PM132 YL-18 157-PM244 YL-16 158-PM245 BR-16 144-PM187 GN-16 161-PM103 RD-16 159-PM100 BU-16 605-PM172 YL-18 606-PM171 GY-18 111-PM41 RD-16 115-PM190 RD-18 106-PM32 RD-12 330-PM64 YL-18 384-PM110 BU-12 330-PM250 YL-18 384-PM66 BU-12 367-PM11 BU-18 976-PM98 OR-18 N945-PM228 OR-18 131-PM99 BR-16 200-PM105 BK-18 D9 C9 B9 F9 161-PM103 RD-16 506-PM116 PU-18 507-PM114 WH-18 506-EF79 PU-18 507-EF81 WH-18 200-EF41 BK-16 200-EF82 BK-18 200-EF83 BK-18 AE-C2 1552269 236-6923 (9) BLOWER GP CAB HEATER MOTOR 358-7085 1 2 AC-C6 1779646 C568-AC16 WH-12 200-AC10 BK-12 E528-AC28 PU-14 E528-AC13 PU-14 E528-AC12 PU-14 E528-AC11 PU-14 122-AC24 BU-12 515-AC4 GY-18 200-AC2 BK-18 C568-AC3 WH-12 1 5 2 4 3 87a 87 85 86 3E-9362 K9 617-PM261 BR-18 614-PM225 PU-18 608-PM273 GN-16 614-PM155 PU-18 310-PM93 PU-18 324-PM19 BU-16 320-PM128 OR-18 200-PM220 BK-14 200-PM104 BK-18 200-PM181 BK-18 200-PM7 BK-18 161-PM264 RD-16 614-PM173 PU-18 159-PM100 BU-16 8 1 3 4 17 18 (138) SWITCH HAZARD 116-PM243 BR-16 117-PM242 YL-16 118-PM180 GY-16 119-PM241 PK-16 123-PM2 WH-18 123-PM79 WH-18 419-PM253 YL-18 518-PM120 OR-16 537-PM223 GN-18 (61) RELAY RIDE CONTROL 146-9439 86 30 A9 AA9 384-PM110 BU-12 384-PM66 BU-12 384-EF50 BU-12 384-EF9 BU-12 200-EF46 BK-14 513-AE5 OR-18 200-AE6 BK-18 1 2 BK-14 BK-14 (13) COMPRESSOR GP A/C CLUTCH 299-2212 AC-C4 3E3364 618-PM262 YL-18 630-PM233 GY-16 620-PM231 WH-16 330-PM64 YL-18 330-PM250 YL-18 330-PM29 YL-18 202-PM31 BK-18 200-PM221 BK-18 202-PM3 BK-18 202-PM61 BK-18 200-PM267 BK-18 306-7346 PM-C24 1387675 123-PM150 WH-18 123-PM143 WH-18 123-PM88 WH-18 568-PM80 GN-18 600-PM12 BR-18 600-PM14 BR-18 600-PM13 BR-18 600-PM277 BR-18 202-PM102 BK-18 N939-PM107 GN-18 K5 87 C10 D10 87A 85 B10 ROADING LIGHTS 20A A10 AA10 F10 102-PM246 RD-14 103-PM96 RD-14 304-PM113 WH-12 CONN 28 304-EF64 WH-12 (29) GROUND ENGINE EF-C15 1552269 AE-C4 3E3364 AE-C1 1552269 (114) SUPPRESSOR ARC HVAC NOTE N NOTE B (159) SWITCH THERMOSTAT THERMOSTAT WIRE AS 220-3762 1 2 522-AC20 WH-18 C511-AC7 WH-18 TO RF HARNESS CONNECTOR RF-C5 LOC A-14 OR TO RH HARNESS CONNECTOR RH-C5 LOC D-15 122-AC26 BU-12 TO PRM MODULE - HVAC (SH 1 LOC I-3) NOTE T E727-PM141 BU-18 H771-PM145 BR-16 G981-PM142 PU-16 A305-PM151 YL-18 367-PM11 BU-18 405-PM122 GY-18 202-PM119 BK-18 202-PM92 BK-18 202-PM65 BK-18 202-PM134 BK-18 518-PM120 OR-16 202-PM174 BK-18 10 2 5 7 131-PM99 BR-16 131-PM138 BR-16 133-PM84 OR-16 124-PM227 GN-18 617-PM214 BR-18 618-PM216 YL-18 614-PM26 PU-18 668-PM269 BU-18 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 202-EF67 BK-18 202-EF4 BK-18 NOTE A 521-EF14 YL-18 200-EF41 BK-16 CONN 31 1 2 513-AE1 OR-18 200-AE2 BK-18 200-AE7 BK-18 200-AE7 BK-18 1 2 189-3158 119-9631 T AC-C9 1779654 1 2 AC-C5 3E3364 133-AC30 OR-18 569-AC31 PK-18 M719-PM183 GN-18 M721-PM184 WH-18 419-PM55 YL-18 R912-PM266 OR-16 420-PM169 OR-18 439-PM70 YL-18 419-PM253 YL-18 419-PM25 YL-18 202-PM178 BK-18 202-PM207 BK-16 202-PM229 BK-16 202-PM160 BK-18 202-PM256 BK-18 537-PM219 GN-18 143-PM265 BR-16 157-PM244 YL-16 158-PM245 BR-16 144-PM187 GN-16 136-PM157 GN-16 976-PM98 OR-18 720-PM130 PU-18 911-PM5 YL-18 766-PM111 GN-18 A305-PM151 YL-18 (8) BLOCK AS FUSE PM-C47 2757877 112-PM10 PU-10 112-PM20 PU-10 146-PM36 GY-10 146-PM47 GY-10 202-EF44 BK-18 202-EF59 BK-18 202-EF7 BK-18 202-EF13 BK-18 123-EF52 WH-18 202-EF44 BK-18 439-EF16 YL-18 EF-C16 1552267 A B C PK-18 BATTERY GROUND 192-7876 (73) SENSOR FUEL WATER SEPARATOR HVAC - ATCH (67) RESISTOR MOTOR SPD 204-9921 1 2 3 4 C568-AC17 WH-12 516-AC18 GN-14 517-AC19 BU-14 CONN 4 200-AC27 BK-12 TO CAB GROUND STUD (SH 1 LOC D-6) 450-PM67 YL-18 450-PM33 YL-18 447-PM156 PK-18 441-PM38 OR-18 308-PM37 YL-18 307-PM163 OR-18 308-PM17 YL-18 307-PM118 OR-18 419-PM25 YL-18 202-PM165 BK-18 1B 2B 161-PM103 RD-16 159-PM100 BU-16 180-PM238 GN-14 J881-PM81 YL-18 H801-PM23 PU-18 G763-PM257 PU-18 E727-PM141 BU-18 AIR SEAT 20A L2 L1 FR FLOOD 15A FUSES 10A 113-8490 15A 113-8491 20A 113-8492 405-PM122 GY-18 405-EF39 GY-18 309-EF21 GY-18 322-EF26 GY-16 384-EF9 BU-12 304-EF64 WH-12 YL-18 BK-18 LAMP EF-C28 1237615 HVAC - ATCH H8 H8 452-PM139 PU-18 500-PM203 BR-16 501-PM179 GN-16 502-PM34 OR-16 450-PM185 YL-18 309-PM95 GY-18 308-PM124 YL-18 308-PM106 YL-18 308-PM247 YL-18 308-PM132 YL-18 LH IND LAMP 214-4717 LEFT TURN PARK BRAKE 200-PM221 BK-18 200-PM68 BK-14 200-PM104 BK-18 200-PM105 BK-18 200-PM222 BK-18 200-PM258 BK-18 200-PM129 BK-18 P832-PM24 WH-18 N945-PM228 OR-18 J881-PM205 YL-18 J881-PM57 YL-18 N939-PM107 GN-18 180-PM238 GN-14 158-PM245 BR-16 C1 F1 F11 AA1 D1 A1 439-PM70 YL-18 450-PM67 YL-18 439-EF16 YL-18 450-EF38 YL-18 405-EF39 GY-18 420-EF60 OR-18 384-EF50 BU-12 506-EF79 PU-18 200-EF82 BK-18 1 2 MOTOR 6T-1375 (35) MOTOR GP FRONT WASHER 506-PM255 PU-18 506-PM252 PU-18 330-PM64 YL-18 310-PM93 PU-18 324-PM19 BU-16 320-PM128 OR-18 308-PM75 YL-18 605-PM91 YL-18 1A 2A PM-C19 2055471 200-PM7 BK-18 200-PM108 BK-18 200-PM46 BK-18 200-PM9 BK-18 X977-PM248 YL-18 X977-PM251 YL-18 X977-PM249 YL-18 P915-PM22 PK-18 116-PM243 BR-16 C2 RR FLOOD 15A F12 AA2 D2 FR FLOOD ATCH 15A A2 F2 420-PM169 OR-18 420-EF60 OR-18 309-EF21 GY-18 X977-EF8 YL-18 447-EF22 PK-18 450-EF38 YL-18 506-EF79 PU-18 507-EF81 WH-18 521-EF14 YL-18 439-EF16 YL-18 441-EF19 OR-18 442-EF11 GY-18 507-EF81 WH-18 200-EF83 BK-18 1 EF-C31 1237615 (39) MOTOR GP REAR WASHER 507-PM114 WH-18 518-PM120 OR-16 506-PM116 PU-18 419-PM253 YL-18 330-PM250 YL-18 420-PM169 OR-18 367-PM11 BU-18 405-PM122 GY-18 202-PM164 BK-18 200-PM220 BK-14 200-PM181 BK-18 200-PM56 BK-12 200-PM240 BK-14 117-PM242 YL-16 157-PM244 YL-16 RR FLOOD ATCH 15A C3 AA3 D3 A3 FR WIPER 20A 309-PM95 GY-18 X977-PM254 YL-18 E455-EF10 BR-16 EF-C23 1761477 2 MOTOR 6T-1375 G STOP TAIL TURN LAMP 172-6490 TURN GND TAIL 1 2 RN-C17 1552272 200-RN13 BK-18 605-RN38 YL-18 H7 H7 RN-C15 1552269 521-PM226 YL-18 537-PM223 GN-18 537-PM219 GN-18 441-PM38 OR-18 447-PM156 PK-18 439-PM70 YL-18 202-PM43 BK-18 RH IND LAMP 214-4723 HI BEAM 1B RIGHT TURN 2B 202-PM3 BK-18 202-PM31 BK-18 202-PM61 BK-18 200-PM267 BK-18 118-PM180 GY-16 RR WIPER 20A F13 AIR CON COMP 10A F3 X977-EF8 YL-18 L740-EF12 BR-18 420-EF60 OR-18 202-EF59 BK-18 1 2 (118) SWITCH AIR FILTER 276-4836 G STOP 3 4 604-RN41 OR-18 617-RN45 BR-18 200-RN15 BK-18 200-RN16 BK-18 200-RN17 BK-18 200-RN5 BK-18 200-RN4 BK-18 200-RN7 BK-18 200-RN6 BK-18 200-RN15 BK-18 605-RN39 YL-18 1 2 FRONT LH TURN LAMP 172-6489 BK-18 YL-18 568-PM80 GN-18 552-PM162 WH-18 537-PM230 GN-18 450-PM185 YL-18 507-PM114 WH-18 450-PM67 YL-18 506-PM116 PU-18 452-PM139 PU-18 1A 2A PM-C17 2055471 202-PM92 BK-18 202-PM65 BK-18 202-PM102 BK-18 119-PM241 PK-16 124-PM227 GN-18 C4 F14 AA4 D4 A4 F4 441-EF19 OR-18 202-EF4 BK-18 EF-C12 1552269 1 2 (70) SENDER COOLANT TEMP REAR LH ATCH FLOOD 234-4329 1 2 RN-C1 1552269 200-RN7 BK-18 630-RN24 GY-18 200-RN1 BK-10 200-RN14 BK-16 200-RN18 BK-18 200-RN9 BK-18 200-RN8 BK-18 200-RN13 BK-18 200-RN11 BK-18 604-RN42 OR-18 604-RN41 OR-18 200-RN16 BK-18 607-RN32 PK-18 RN-C7 1552269 1 2 FRONT LH STD FLOOD 234-4328 604-PM27 OR-18 590-PM192 GY-18 603-PM237 PK-16 604-PM71 OR-18 518-PM120 OR-16 537-PM223 GN-18 552-PM162 WH-18 521-PM226 YL-18 611-PM49 PU-18 606-PM87 GY-18 202-PM119 BK-18 202-PM178 BK-18 202-PM160 BK-18 202-PM134 BK-18 143-PM265 BR-16 IMP DISABLE 15A C5 F15 AA5 D5 MONITORING 15A A5 F5 (107) STUD JUMP START CBL-JJ1 RD-00 EF-C32 1552269 T 244-3106 RN-C11 1552269 608-RN29 GN-18 608-RN29 GN-18 H7 (32) GROUND UPPER CAB 200-RN8 BK-18 200-RN4 BK-18 200-RN11 BK-18 200-RN6 BK-18 606-RN36 GY-18 605-RN38 YL-18 H7 620-RN27 WH-18 RN-C13 1552269 1 2 FRONT LH ATCH FLOOD 234-4329 605-PM30 YL-18 604-PM209 OR-18 605-PM211 YL-18 604-PM72 OR-18 605-PM90 YL-18 605-PM91 YL-18 606-PM50 GY-18 605-PM89 YL-18 605-PM89 YL-18 568-PM80 GN-18 614-PM26 PU-18 611-PM51 PU-14 603-PM237 PK-16 614-PM279 PU-18 8 1 3 4 6 10 (126) SWITCH BEACON 261-5050 202-PM207 BK-16 202-PM229 BK-16 202-PM256 BK-18 306-PM101 GN-18 133-PM84 OR-16 159-PM100 BU-16 TURN SIGNAL 10A C6 AA6 D6 A6 BEACON 15A 106-0800 NOTE A 405-EF39 GY-18 202-EF13 BK-18 1 2 (135) SWITCH ENGINE OIL PRESS 237-4894 REAR LH STD FLOOD 234-4328 1 2 RN-C12 1552269 200-RN3 BK-10 200-RN6 BK-18 NOTE A 200-RN13 BK-18 200-RN7 BK-18 618-RN44 YL-18 608-RN30 GN-18 630-RN24 GY-18 617-RN45 BR-18 630-RN23 GY-18 200-RN17 BK-18 RN-C14 1552269 606-PM86 GY-18 606-PM50 GY-18 605-PM172 YL-18 617-PM214 BR-18 617-PM215 BR-18 618-PM216 YL-18 618-PM217 YL-18 7 2 5 PM-C59 2285856 9 308-PM17 YL-18 308-PM37 YL-18 307-PM118 OR-18 307-PM163 OR-18 144-PM187 GN-16 DIFF LOCK 15A F16 FUEL PUMP 15A F6 CBL-TT1 RD-2 (106) STUD CAB POWER CBL-MM1 RD-00 447-EF22 PK-18 202-EF7 BK-18 EF-C10 1552269 1 2 RD-18 BK-18 363-8475 (NON-EST) 362-3089 (EST) (71) SENDER FUEL LEVEL REAR RH STD FLOOD 234-4328 1 2 200-RN4 BK-18 608-RN30 GN-18 200-RN18 BK-18 620-RN26 WH-18 1 2 FRONT RH ATCH FLOOD 234-4329 606-PM232 GY-18 607-PM276 PK-16 606-PM210 GY-18 607-PM235 PK-16 607-PM274 PK-16 606-PM87 GY-18 606-PM171 GY-18 720-PM130 PU-18 619-PM213 GN-14 668-PM269 BU-18 752-PM212 YL-18 754-PM208 BU-18 202-PM280 BK-18 144-PM187 GN-16 308-PM124 YL-18 308-PM132 YL-18 308-PM247 YL-18 309-PM95 GY-18 308-PM106 YL-18 131-PM138 BR-16 123-PM79 WH-18 C7 AA7 D7 A7 F7 373-9138 (TO POWER STUD) NOTE A EF-C19 1552269 EP-C1 3E3364 EP-C2 1552269 REAR RH ATCH FLOOD 234-4329 RN-C2 1552269 630-RN23 GY-18 RN-C4 3E3382 603-RN43 PK-16 604-RN40 OR-18 604-RN41 OR-18 603-RN43 PK-16 200-RN15 BK-18 200-RN16 BK-18 200-RN9 BK-18 200-RN5 BK-18 200-RN14 BK-16 607-RN33 PK-18 200-RN5 BK-18 RN-C8 1552269 1 2 FRONT RH STD FLOOD 234-4328 608-PM273 GN-16 608-PM275 GN-16 608-PM236 GN-16 911-PM5 YL-18 766-PM112 GN-18 766-PM82 GN-18 766-PM111 GN-18 136-PM157 GN-16 PM-C54 3463496 A B C D PM-C44 3463506 136-PM54 GN-16 IF AWS IS INSTALLED, REMOVE JUMPER AND CONNECT 310-PM93 PU-18 320-PM128 OR-18 322-PM167 GY-18 202-PM102 BK-18 C8 AA8 D8 A8 AWS 10A F8 (TO NEG TERM) NOTE A CONN BATT POS 260-5151 CONN BATT NEG 356-2508 NOTE A (TO POS TERM) CBL-SS1 RD-00 322-EF26 GY-16 200-EF3 BK-18 1 2 322-EP1 GY-16 200-EP2 BK-16 1 2 (33) HORN FORWARD 164-9425 STOP TAIL TURN LAMP 172-6490 1 2 RN-C18 1552272 200-RN8 BK-18 TO PM HARNESS CONNECTOR PM-C22 LOC E-13 1 2 3 4 5 6 608-RN28 GN-16 607-RN31 PK-16 620-RN25 WH-16 603-RN43 PK-16 605-RN37 YL-18 605-RN38 YL-18 605-RN39 YL-18 605-RN39 YL-18 604-RN42 OR-18 200-RN17 BK-18 200-RN18 BK-18 603-RN43 PK-16 RN-C16 1552269 610-PM153 OR-16 610-PM204 OR-14 610-PM115 OR-14 611-PM49 PU-18 J881-PM121 YL-18 976-PM98 OR-18 G763-PM257 PU-18 E727-PM141 BU-18 A305-PM151 YL-18 G795-PM135 OR-16 614-PM4 PU-18 200-PM1 BK-18 CONN 14 TO WP HARNESS CONNECTOR WP-C1 LOC A-11 324-PM19 BU-16 367-PM11 BU-18 330-PM64 YL-18 330-PM250 YL-18 384-PM66 BU-12 202-PM207 BK-16 202-PM229 BK-16 (28) GROUND CONTROL 136-PM157 GN-16 C9 AA9 D9 A9 SPARE 2 15A (108) STUD POWER 263-6556 EF-C17 1552269 EP-C1 3E3364 EP-C2 1761477 (85) SOLENOID FUEL SHUTOFF TURBO HORN JUMPER STOP TAIL TURN GND 1 2 3 4 200-RN11 BK-18 606-RN36 GY-18 618-RN44 YL-18 604-RN42 OR-18 CONN 5 630-RN22 GY-16 606-RN34 GY-18 606-RN36 GY-18 607-RN33 PK-18 607-RN32 PK-18 606-RN35 GY-18 606-RN35 GY-18 606-RN35 GY-18 620-RN26 WH-18 607-RN33 PK-18 607-RN32 PK-18 200-RN9 BK-18 1 2 FRONT RH TURN LAMP 172-6489 BK-18 YL-18 614-PM4 PU-18 611-PM85 PU-14 611-PM51 PU-14 N939-PM107 GN-18 N939-PM137 GN-18 N945-PM228 OR-18 J881-PM123 YL-18 405-PM122 GY-18 419-PM253 YL-18 420-PM169 OR-18 439-PM70 YL-18 441-PM38 OR-18 447-PM156 PK-18 450-PM67 YL-18 384-PM110 BU-12 NOTE A C10 D10 SPARE 1 10A SPARE 3 20A F9 CBL-EE BK-00 NEG POS BATTERY - STD CBL-AA1 RD-00 123-EF28 WH-18 200-EF6 BK-16 327-EP1 PK-18 200-EP2 BK-18 CONN 32 1 2 FUEL SHUTOFF WIRE 178-8465 A B 176-6219 1 2 3 4 5 6 7 8 RN-C3 3E3388 604-RN40 OR-18 607-RN31 PK-16 608-RN28 GN-16 608-RN29 GN-18 608-RN30 GN-18 620-RN27 WH-18 200-RN14 BK-16 603-RN43 PK-16 ROTATING BEACON 180-3664 614-PM225 PU-18 614-PL155 PU-18 614-PM279 PU-18 614-PM26 PU-18 614-PM218 PU-18 614-PM173 PU-18 TO PM HARNESS CONNECTOR PM-C39 LOC F-11 A B C 206-1486 PX-C1 3E3370 143-PX1 BR-18 762-PX2 YL-18 (151) SWITCH RETURN TO DIG 200-PM234 BK-14 200-PM240 BK-14 200-PM220 BK-14 200-PM56 BK-12 C10 AA10 D10 A10 F10 (6) BATTERY 230-6368 1 2 WC-C1 3E3364 327-WC1 PK-16 TO FUEL SHUTOFF SOLENOID (N/A ENGINES ONLY) TO PM HARNESS CONNECTOR PM-C3 LOC F-13 606-RN34 GY-18 605-RN37 YL-18 618-RN44 YL-18 617-RN45 BR-18 618-RN44 YL-18 617-RN45 BR-18 617-RN45 BR-18 618-RN44 YL-18 BEACON SOCKET 1787539 617-PM261 BR-18 618-PM149 YL-18 617-PM125 BR-18 617-PM214 BR-18 617-PM215 BR-18 618-PM216 YL-18 PM-C39 1552267 TO PX HARNESS CONNECTOR PX-C1 LOC F-10 OR TO PV HARNESS CONNECTOR PV-C2 LOC F-10 CONN 15 452-PM139 PU-18 506-PM116 PU-18 450-PM185 YL-18 (30) GROUND LOWER CAB PM-C20 1116795 CBL-HH1 BK-00 CBL-GG1 RD-00 NEG POS 230-6368 BATTERY - HD CONN 6 620-RN25 WH-16 630-RN22 GY-16 620-RN27 WH-18 620-RN26 WH-18 630-RN24 GY-18 630-RN23 GY-18 618-PM262 YL-18 627-PM206 YL-18 619-PM213 GN-14 618-PM217 YL-18 200-PM94 BK-18 762-PM16 YL-18 R912-PM266 OR-16 A B C RTD (LOADER) (ST) 537-PM223 GN-18 552-PM162 WH-18 518-PM120 OR-16 507-PM114 WH-18 521-PM226 YL-18 NOTE A 518-PM120 OR-16 200-PM222 BK-18 1 5 2 4 3 + BATTERY LAMP OUT GROUND 374-9636 K6 (25) FLASHER BATTERY 123-EF23 WH-18 (131) SWITCH COLD START ADV T NOTE Z (82) SOLENOID COLD START ADV (EMISSIONS ENGINE) F ROOF (CP ONLY) 668-PM270 BU-18 668-PM272 BU-18 668-PM269 BU-18 CONN 15 568-PM80 GN-18 600-PM12 BR-18 600-PM13 BR-18 537-PM223 GN-18 BATTERY (NON-EST) NOTE A (TO FRAME GROUND) EF-C7 1552269 235-1790 F 720-PM130 PU-18 668-PM271 BU-18 606-PM50 GY-18 605-PM89 YL-18 600-PM14 BR-18 600-PM277 BR-18 J881-PM205 YL-18 308-PM247 YL-18 (125) SWITCH BATT DISCONNECT CBL-FF BK-00 X977-EF8 YL-18 200-EF30 BK-18 1 2 MOTOR (38) MOTOR GP FUEL LIFT PUMP 349-1063 752-PM212 YL-18 754-PM28 BU-18 PM-C5 1552269 350-8887 (98) SOLENOID RTD PV-C2 3E3370 PV-C1 2228935 (130) SWITCH BUCKET POS 284-0078 611-PM51 PU-14 614-PM26 PU-18 617-PM214 BR-18 617-PM215 BR-18 618-PM216 YL-18 (57) RELAY NEUTRALIZER 140-9378 K17 4 5 2 7N-0718 GROUND CAB 8X-9618 134-3355 GROUND FRAME GROUND ENGINE 309-EF21 GY-18 D+ 225-3145 (5) ALTERNATOR 120A 1 2 3 4 5 6 7 8 PM-C3 1552264 604-PM27 OR-18 754-PM77 BU-18 766-PM112 GN-18 754-PM208 BU-18 766-PM111 GN-18 766-PM175 GN-18 766-PM111 GN-18 762-PM16 YL-18 200-PM7 BK-18 1 2 TO PM HARNESS CONNECTOR PM-C39 LOC F-11 A B C R912-PW1 OR-18 762-PW2 YL-18 1 2 1 2 618-PM217 YL-18 619-PM213 GN-14 720-PM130 PU-18 668-PM269 BU-18 H801-PM23 PU-18 202-PM61 BK-18 1 3 PM-C48 2579257 450-EF38 YL-18 W B+ 105-RH51 RD-1.00 105-RH60 RD-0.75 TO RN HARNESS CONNECTOR RN-C3 LOC F-14 CONN 6 605-PM30 YL-18 606-PM232 GY-18 617-PM261 BR-18 618-PM262 YL-18 911-PM5 YL-18 766-PM82 GN-18 CONN 15 RTD (LOADER) (PL) 754-PM208 BU-18 752-PM212 YL-18 766-PM82 GN-18 766-PM111 GN-18 330-PM64 YL-18 (54) RELAY LOW SIDE CTRL 9 10 7 CBL-CC1 RD-2 EF-C11 2219804 (4 LIGHT) NOTE L STD FRONT WORK LAMP SW.

214-4697 133-RH13 OR-0.75 202-RH8 BK-0.75 202-RH2 BK-0.75 133-RH12 OR-0.75 F739-PM152 GN-18 976-PM98 OR-18 E727-PM141 BU-18 A305-PM151 YL-18 (117) SWITCH BUCKET POS 766-PM112 GN-18 911-PM5 YL-18 E727-PM141 BU-18 A305-PM151 YL-18 976-PM98 OR-18 140-9378 K18 6 8 384-EF50 BU-12 384-EF9 BU-12 384-EF24 BU-10 1 H3 H3 307-RH56 OR-0.75 308-RH61 YL-1.00 309-RH72 GY-0.75 310-RH59 PU-0.75 TO TP HARNESS CONNECTOR TP-C12 LOC C-12 OR TO HL HARNESS CONNECTOR HL-C7 LOC C-7 3 4 5 6 7 8 9 10 11 12 1 2 PM-C6 1552252 119-PM166 PK-14 503-PM177 BR-16 161-PM263 RD-16 G981-PM142 PU-16 G763-PM257 PU-18 G763-PM257 PU-18 H801-PM23 PU-18 202-PM160 BK-18 J881-PM57 YL-18 306-PM101 GN-18 304-EF64 WH-12 8 1 3 4 6 10 (140) SWITCH HORN 614-RH81 PU-0.75 105-RH51 RD-1.00 A305-RH10 YL-0.75 432-RH7 PK-0.75 420-RH79 OR-0.75 405-RH55 GY-0.75 404-RH76 YL-0.75 105-RH60 RD-0.75 105-RH64 RD-1.00 123-PM6 WH-18 564-PM224 GY-16 118-PM148 GY-16 500-PM203 BR-16 501-PM179 GN-16 502-PM34 OR-16 J881-PM121 YL-18 J881-PM123 YL-18 H771-PM145 BR-16 J881-PM121 YL-18 J881-PM123 YL-18 J881-PM121 YL-18 J881-PM123 YL-18 (20) DIODE NUET LOCK ALARM J881-PM81 YL-18 J881-PM205 YL-18 J881-PM154 YL-18 J881-PM57 YL-18 330-PM250 YL-18 (56) RELAY NEUTRAL START 4 5 2 PM-C11 1552269 S G 304-EF64 WH-12 (26) GLOW PLUGS (4 LIGHT) NOTE L STD REAR WORK LAMP SW.

214-4699 MOM RH-C2 2285856 9 214-4701 450-RH57 YL-0.75 439-RH58 YL-0.75 441-RH17 OR-0.75 447-RH16 PK-0.75 119-RH40 PK-1.00 116-RH22 BR-1.00 117-RH23 YL-1.00 119-RH94 PK-1.00 CONN 9 590-PM192 GY-18 506-PM252 PU-18 M721-PM184 WH-18 M719-PM183 GN-18 189-3158 1 2 PM-C14 1552269 J881-PM154 YL-18 P915-PM22 PK-18 140-9378 K13 1 3 PM-C49 2579257 180-PM238 GN-14 200-PM234 BK-14 1 2 MOTOR 304-1039 (42) MOTOR GP SEAT BAT MTR MOTOR CBL-CC1 RD-2 CBL-CC1 RD-2 MOM MOM POWER SIDE SHIFT SW 261-5070 NOTE W 7 2 5 202-RH25 BK-0.75 202-RH71 BK-0.75 568-RH80 GN-0.75 614-RH92 PU-0.75 E727-RH28 BU-0.75 452-RH84 PU-0.75 E479-RH98 YL-0.75 119-RH41 PK-1.00 131-RH96 BR-1.00 PM-C22 1552273 N939-PM107 GN-18 N939-PM136 GN-18 N939-PM137 GN-18 TO PM HARNESS CONNECTOR PM-C40 LOC E-11 1 2 3 4 PM-C18 3E3376 976-PM21 OR-18 IF LOAD CHECK DISABLE IS INSTALLED WITHOUT RIDE CONTROL, INSTALL JUMPER TO PLATFORM CONN PM-C40 N939-PM137 GN-18 N939-PM107 GN-18 N945-PM228 OR-18 P832-PM24 WH-18 P832-PM24 WH-18 200-PM258 BK-18 307-PM163 OR-18 X977-PM251 YL-18 PM-C33 1552269 (43) MOTOR GP STARTER NOTE A (TO POS TERM) CBL-AA1 RD-00 M936-RH93 BR-0.75 M937-RH69 GN-0.75 614-RH66 PU-0.75 G423-RH77 PK-0.75 F420-RH86 GN-0.75 G981-RH11 PU-0.75 133-RH13 OR-0.75 133-RH52 OR-0.75 133-RH12 OR-0.75 143-RH95 BR-1.00 157-RH35 YL-1.00 158-RH34 BR-1.00 TO RN HARNESS CONNECTOR RN-C4 LOC F-14 OR TO TP HARNESS CONNECTOR TP-C1 LOC D-12 1 2 3 4 5 6 620-PM231 WH-16 607-PM276 PK-16 608-PM273 GN-16 603-PM237 PK-16 R912-PM266 OR-16 N945-PM228 OR-18 CONN 16 X977-PM248 YL-18 X977-PM249 YL-18 (51) RELAY FUEL LIFT PUMP 140-9378 K14 9 10 7 202-PM92 BK-18 766-PM82 GN-18 1 2 (145) SWITCH NEUTRALIZER XMSN HANDLE 263-7261 143-0539 TIER 2 303-5795 TIER 3 CBL-AA1 RD-00 E SIDE SHIFT SOLENOID STATUS FUNCTION SIDE SHIFT LOCK SIDE SHIFT LEFT SIDE SHIFT RIGHT LOCKOUT 8 NOTE D 1 3 4 6 10 200-RH24 BK-0.75 CONN 5 630-PM233 GY-16 H8 (22) DIODE ROADING 1 2 PM-C53 1552269 668-PM270 BU-18 X977-PM254 YL-18 X977-PM251 YL-18 123-PM2 WH-18 X977-PM249 YL-18 6 8 PM-C36 1552269 (144) SWITCH NEUTRALIZER LOADER HANDLE ENGINE E SHIFT RIGHT ENERGIZE OFF ENERGIZE ENERGIZE STATIONARY OFF OFF OFF OFF SHIFT LEFT ENERGIZE ENERGIZE OFF ENERGIZE 7 2 5 RH-C11 2285856 9 J878-RH65 YL-0.75 200-RH19 BK-0.75 202-RH2 BK-0.75 200-RH73 BK-1.00 200-RH99 BK-1.00 POWER PORT 178-7539 115-PM190 RD-18 200-PM221 BK-18 189-3158 PM-C56 1552269 601-PM15 GY-16 N939-RA9 GN-18 200-RA10 BK-18 RA-C5 1552269 1 2 (110) ARC SUPPRESSOR RIDE CONTROL PM-C23 1552269 (17) DIODE FUEL LIFT PUMP 766-PM112 GN-18 202-PM3 BK-18 1 2 9R-9868 PWR BEYOND OFF OFF OFF ENERGIZE (44) PANEL GP INSTRUMENT 202-RH67 BK-0.75 614-RH48 PU-0.75 202-RH71 BK-0.75 202-RH89 BK-0.75 202-RH8 BK-0.75 202-RH82 BK-0.75 (18) DIODE LIGHTS (FR) 189-3158 1 2 668-PM271 BU-18 607-PM274 PK-16 RA-C2 1552269 189-3158 (96) SOLENOID RIDE CTRL 1 X977-PM248 YL-18 307-PM118 OR-18 1 2 189-3158 RL-C2 1552273 12V BATTERY (+)POS GROUND 386-1737 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 RH-C17 3402564 105-RH60 RD-0.75 564-RH21 GY-0.75 119-RH40 PK-1.00 503-RH43 BR-1.00 507-RH42 WH-0.75 202-RH32 BK-0.75 202-RH62 BK-0.75 202-RH82 BK-0.75 (146) SWITCH PARK BRAKE 154-5416 PM-C27 3E3364 (19) DIODE LIGHTS (RR) 189-3158 1 2 PM-C57 1552269 668-PM272 BU-18 608-PM275 GN-16 PM-C40 1552272 RA-C1 3E3376 200-RA1 BK-18 123-RA2 WH-18 200-RA3 BK-18 200-RA8 BK-18 N939-RA6 GN-18 200-RA3 BK-18 RA-C4 1552269 1 2 RD-18 RD-18 238-4628 J881-PM81 YL-18 308-PM132 YL-18 (58) RELAY PARK BRAKE ALARM 605-RL9 YL-18 200-RL1 BK-14 617-RL7 BR-18 611-RL11 PU-16 1 2 3 4 5 6 TURN BU BK BR RD POSN 12V KEY SWITCH (+)POS ALT "W" (TACH) ENG COOLANT TEMP FUEL LEVEL TORQUE CONV TEMP BRAKE PRESS./LEVEL HYD OIL HI TEMP AUTOMATIC ENGINE SPEED CONTROL ALT "D+" ENG OIL LO PRESS.

Стр. 2

UENR4049 April 2013 UENR4049 VOL 2 OF 2 42 Page, (Dimensions: 56 inches x 35 inches) 416F, 422F, 428F, and 434F Electrical System Backhoe Loader 416F: LWT323-UP 422F: LRH696-UP 428F: LBH1573-UP SJW437-UP 434F: LDH1-UP FLY1-UP Volume 2 of 2: Electronic Control © 2013 Caterpillar, All Rights Reserved Printed in U.S.A. Harness And Wire Electrical Schematic Symbols Symbols Pressure Symbol T Temperature Symbol Level Symbol Flow Symbol Circuit Breaker Symbol Symbols and Definitions Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it. Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.).

The circle indicates that the component has screw terminals and a wire can be disconnected from it. Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component. Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine. Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. Reed Switch: A switch whose contacts are controlled by a magnet.

A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch. Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure. T The connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart. Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it.

The electromagnet can open or close the switch part of the relay. Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work. Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

Harness and Wire Symbols Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes (see sample). Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness (C1, C2, C3, ...). Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...) ¹ At room temperature unless otherwise noted. AG-C4 111-7898 L-C12 3E-5179 L-C12 3E-5179 Part Number: for Connector Receptacle Part Number: for Connector Plug 1 2 Plug Pin or Socket Number Receptacle 5A 1 2 Deutsch connector: Typical representation of a Deutsch connector.

The plug contains all sockets and the receptacle contains all pins. Fuse (5 Amps) 9X-1123 Component Part Number 1 Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets. Harness identification code: This example indicates wire group 325, wire 135 in harness "AG".

325-AG135 PK-14 2 Wire Color Wire Gauge CONN 46 CONN 57 CONN 62 178 305 206 180 255 276 CONN 58 CONN 45 297 CONN 61 187 306 190 258 210 CONN 49 209 202 179 UNDER PLATFORM - FRONT VIEW UNDER PLATFORM - FRONT VIEW 301 176 CONN 43 CONN 40 CONN 42 CONN 51 CONN 41 319 225 CONN 39 171 CONN 37 CONN 44 CONN 36 322 UNDER RIGHT CONSOLE 217 208 216 212 218 184 CONN 59 219 170 220 221 169 222 213 174 173 207 215 211 CONN 66 214 223 172 BLOCK GP - RELAY / FUSE Component Location (Volume 2) Schematic Machine Schematic Machine Component Component Location Location Location Location Alarm - Action D-16 163 Solenoid - Diff Lock As STD I-1 243 Alarm - Action A-16 164 Solenoid - Fuel Shutoff Turbo E-1 244 Alarm - Backup (CP) H-16 165 Solenoid - FWD High J-1 245 Alarm - Backup (SS) J-16 166 Solenoid - FWD Low I-1 246 Alternator E-1 167 Solenoid - FWD Low STD H-1 247 Battery E-3 168 Solenoid - Hyd Torque Limit J-1 248 Block As - Fuse H-6 169 Solenoid - HYD Torque Limit STD I-1 249 Block As - Fuse I-6 170 Solenoid - LH Lock Valve D-5 250 Blower Gp - Cab heater H-15 171 Solenoid - Lockout I-15 251 Bus Bar 1 J-6 172 Solenoid - Lockup Clutch J-1 252 Bus Bar 2 J-5 173 Solenoid - Rev As I-1 253 Bus Bar 3 J-5 174 Solenoid - REV As STD I-1 254 Compressor Gp - A/C Clutch G-1 175 Solenoid - RH Lock Valve D-5 255 Control Gp - AWS A-9 176 Solenoid - Ride Control 1 E-9 256 Control Gp - Machine ECM I-11 177 Solenoid - Ride Control 2 E-9 257 Diode - Blocking 1 C-6 178 Solenoid - RTD E-11 258 Diode - Blocking 2 C-6 179 Solenoid - Side Shift Left J-15 259 Diode - Fuel Lift Pump F-6 180 Solenoid - Side Shift Lock J-16 260 Diode - REV Solenoid H-1 181 Solenoid - Side Shift Right I-15 261 Diode - Side Shift 1 I-15 182 Solenoid - Speed Clutch 1 J-1 262 Diode - Side Shift 2 I-15 183 Solenoid - Speed Clutch 2 J-1 263 Flasher F-6 184 Solenoid - Speed Clutch 3 J-1 264 Glow Plugs D-1 185 Solenoid - STD AWD I-1 265 Ground - Cab RF D-10 186 Stud - Cab Power F-3 266 Ground - Control G-6 187 Stud - Jump Start F-3 267 Ground - ECM Cab F-11 188 Stud - Power E-2 268 Ground - Engine G-2 189 Suppressor - Lockout Solenoid I-15 269 Ground - Lower Cab G-6 190 Suprerssor - ARC Ride Control E-9 270 Ground - Upper Cab C-9 191 Supressor - ARC (Side Shift Left) J-15 271 Ground - Upper Cab G-15 192 Supressor - ARC (Side Shift Right) I-15 272 Horn - Forward E-1 193 Supressor - ARC (SS Lock) J-16 273 Horn - RR J-16 194 Supressor - ARC HVAC G-1 274 Motor Gp - Front Washer F-1 195 Supressor - ARC Load Check Disable 1 D-5 275 Motor Gp - Front Wiper C-9 196 Supressor - ARC Load Check Disable 2 C-5 276 Motor Gp - Front Wiper D-7 197 Switch - A/C Refrigerant Pressure G-1 277 Motor Gp - Fuel Lift Pump E-2 198 Switch - Air Filter F-2 278 Motor Gp - Rear Washer F-1 199 Switch - Attach Rear Work Lamp B-15 279 Motor Gp - Rear Wiper D-9 200 Switch - Attch Front Work Lamp D-15 280 Motor Gp - Rear Wiper B-12 201 Switch - Attch Front Work Lamp B-15 281 Motor Gp - Seat D-4 202 Switch - Attch Rear Work Lamp D-15 282 Motor Gp - Starter D-2 203 Switch - Auto Man H-7 283 Panel Gp - Instrument E-16 204 Switch - AWD J-7 284 Panel Gp - Instrument B-16 205 Switch - AWS A-11 285 Radio - Prod Link H-2 206 Switch - Battery Disconnect E-3 286 Relay - A/C Shutoff H-13 207 Switch - Beacon H-8 287 Relay - AWD H-6 208 Switch - Blower Speed H-15 288 Relay - Dead Engine Lower Command C-5 209 Switch - Brake (LH) I-8 289 Relay - Dead Engine Lower Enable C-5 210 Switch - Brake (RH) I-8 290 Relay - Fuel Lift Pump F-6 211 Switch - Bucket POS E-10 291 Relay - FWD Horn I-6 212 Switch - Cold Start Adv F-1 292 Relay - Hi Speed H-13 213 Switch - Column Multi Function H-8 293 Relay - Neutral Start F-6 214 Switch - Crab Circle A-11 294 Relay - Park Brake Alarm E-6 215 Switch - Differential Lock I-8 295 Relay - Rear Horn I-6 216 Switch - Engine Oil Pressure F-2 296 Relay - Ride Control H-6 217 Switch - Float Detent Pressure D-5 297 Relay - Start C-4 218 Switch - FNR Control I-8 298 Relay As - PRM Module 1 J-6 219 Switch - Hazard G-8 299 Relay As - PRM Module 2 J-5 220 Switch - Heater A/C H-15 300 Relay As - PRM Module ENG J-5 221 Switch - Horn E-15 301 Relay As - PRM Module HVAC J-5 222 Switch - HYD Oil Filter Bypass G-1 302 Resistor - Can Terminating 1 F-10 223 Switch - Key D-16 303 Resistor - Can Terminating 2 I-14 224 Switch - Key A-16 304 Resistor - Motor Speed G-15 225 Switch - Neutralizer Loader Handle D-4 305 Sender - Conv Temp H-1 226 Switch - Neutralizer XMSN Handle D-4 306 Sender - Conv Temp I-1 227 Switch - Park Brake E-14 307 Sender - Coolant Temp F-2 228 Switch - Rear Fog Lamp H-7 308 Sender - Fuel Level F-2 229 Switch - Rear Wiper E-15 309 Sensor - FR Axly Posn A-11 230 Switch - Rear Wiper B-15 310 Sensor - Fuel Water Separator F-1 231 Switch - Return to Dig E-10 311 Sensor - Hyd Load Auto J-3 232 Switch - Ride Control I-7 312 Sensor - HYD Load STD H-3 233 Switch - Roading I-7 313 Sensor - Hyd Oil Temp G-1 234 Switch - Side Shift Lock D-15 314 Sensor - Ride Control D-10 235 Switch - Stability Pressure B-7 315 Sensor - RR Axle Posn A-8 236 Switch - Stabliity Warning B-10 316 Sensor - XMSN out SPD J-3 237 Switch - Start Aid D-15 317 Sensor - XMSN Out SPD STD H-3 238 Switch - Start Aid A-15 318 Solenoid - AWD As J-1 239 Switch - Thermostat G-15 319 Solenoid - Bleed Valve B-8 240 Switch - XMSN Lock J-7 320 Solenoid - Cold Start Adv E-1 241 Valve Gp - AWS A-8 321 Solenoid - Diff Lock As J-1 242 Valve Gp - Stabilizer I-14 322 Alarm - Action D-16 163 Solenoid - Diff Lock As STD I-1 243 Alarm - Action A-16 164 Solenoid - Fuel Shutoff Turbo E-1 244 Alarm - Backup (CP) H-16 165 Solenoid - FWD High J-1 245 Alarm - Backup (SS) J-16 166 Solenoid - FWD Low I-1 246 Alternator E-1 167 Solenoid - FWD Low STD H-1 247 Battery E-3 168 Solenoid - Hyd Torque Limit J-1 248 Block As - Fuse H-6 169 Solenoid - HYD Torque Limit STD I-1 249 Block As - Fuse I-6 170 Solenoid - LH Lock Valve D-5 250 Blower Gp - Cab heater H-15 171 Solenoid - Lockout I-15 251 Bus Bar 1 J-6 172 Solenoid - Lockup Clutch J-1 252 Bus Bar 2 J-5 173 Solenoid - Rev As I-1 253 Bus Bar 3 J-5 174 Solenoid - REV As STD I-1 254 Compressor Gp - A/C Clutch G-1 175 Solenoid - RH Lock Valve D-5 255 Control Gp - AWS A-9 176 Solenoid - Ride Control 1 E-9 256 Control Gp - Machine ECM I-11 177 Solenoid - Ride Control 2 E-9 257 Diode - Blocking 1 C-6 178 Solenoid - RTD E-11 258 Diode - Blocking 2 C-6 179 Solenoid - Side Shift Left J-15 259 Diode - Fuel Lift Pump F-6 180 Solenoid - Side Shift Lock J-16 260 Diode - REV Solenoid H-1 181 Solenoid - Side Shift Right I-15 261 Diode - Side Shift 1 I-15 182 Solenoid - Speed Clutch 1 J-1 262 Diode - Side Shift 2 I-15 183 Solenoid - Speed Clutch 2 J-1 263 Flasher F-6 184 Solenoid - Speed Clutch 3 J-1 264 Glow Plugs D-1 185 Solenoid - STD AWD I-1 265 Ground - Cab RF D-10 186 Stud - Cab Power F-3 266 Ground - Control G-6 187 Stud - Jump Start F-3 267 Ground - ECM Cab F-11 188 Stud - Power E-2 268 Ground - Engine G-2 189 Suppressor - Lockout Solenoid I-15 269 Ground - Lower Cab G-6 190 Suprerssor - ARC Ride Control E-9 270 Ground - Upper Cab C-9 191 Supressor - ARC (Side Shift Left) J-15 271 Ground - Upper Cab G-15 192 Supressor - ARC (Side Shift Right) I-15 272 Horn - Forward E-1 193 Supressor - ARC (SS Lock) J-16 273 Horn - RR J-16 194 Supressor - ARC HVAC G-1 274 Motor Gp - Front Washer F-1 195 Supressor - ARC Load Check Disable 1 D-5 275 Motor Gp - Front Wiper C-9 196 Supressor - ARC Load Check Disable 2 C-5 276 Motor Gp - Front Wiper D-7 197 Switch - A/C Refrigerant Pressure G-1 277 Motor Gp - Fuel Lift Pump E-2 198 Switch - Air Filter F-2 278 Motor Gp - Rear Washer F-1 199 Switch - Attach Rear Work Lamp B-15 279 Motor Gp - Rear Wiper D-9 200 Switch - Attch Front Work Lamp D-15 280 Motor Gp - Rear Wiper B-12 201 Switch - Attch Front Work Lamp B-15 281 Motor Gp - Seat D-4 202 Switch - Attch Rear Work Lamp D-15 282 Motor Gp - Starter D-2 203 Switch - Auto Man H-7 283 Panel Gp - Instrument E-16 204 Switch - AWD J-7 284 Panel Gp - Instrument B-16 205 Switch - AWS A-11 285 Radio - Prod Link H-2 206 Switch - Battery Disconnect E-3 286 Relay - A/C Shutoff H-13 207 Switch - Beacon H-8 287 Relay - AWD H-6 208 Switch - Blower Speed H-15 288 Relay - Dead Engine Lower Command C-5 209 Switch - Brake (LH) I-8 289 Relay - Dead Engine Lower Enable C-5 210 Switch - Brake (RH) I-8 290 Relay - Fuel Lift Pump F-6 211 Switch - Bucket POS E-10 291 Relay - FWD Horn I-6 212 Switch - Cold Start Adv F-1 292 Relay - Hi Speed H-13 213 Switch - Column Multi Function H-8 293 Relay - Neutral Start F-6 214 Switch - Crab Circle A-11 294 Relay - Park Brake Alarm E-6 215 Switch - Differential Lock I-8 295 Relay - Rear Horn I-6 216 Switch - Engine Oil Pressure F-2 296 Relay - Ride Control H-6 217 Switch - Float Detent Pressure D-5 297 Relay - Start C-4 218 Switch - FNR Control I-8 298 Relay As - PRM Module 1 J-6 219 Switch - Hazard G-8 299 Relay As - PRM Module 2 J-5 220 Switch - Heater A/C H-15 300 Relay As - PRM Module ENG J-5 221 Switch - Horn E-15 301 Relay As - PRM Module HVAC J-5 222 Switch - HYD Oil Filter Bypass G-1 302 Resistor - Can Terminating 1 F-10 223 Switch - Key D-16 303 Resistor - Can Terminating 2 I-14 224 Switch - Key A-16 304 Resistor - Motor Speed G-15 225 Switch - Neutralizer Loader Handle D-4 305 Sender - Conv Temp H-1 226 Switch - Neutralizer XMSN Handle D-4 306 Sender - Conv Temp I-1 227 Switch - Park Brake E-14 307 Sender - Coolant Temp F-2 228 Switch - Rear Fog Lamp H-7 308 Sender - Fuel Level F-2 229 Switch - Rear Wiper E-15 309 Sensor - FR Axly Posn A-11 230 Switch - Rear Wiper B-15 310 Sensor - Fuel Water Separator F-1 231 Switch - Return to Dig E-10 311 Sensor - Hyd Load Auto J-3 232 Switch - Ride Control I-7 312 Sensor - HYD Load STD H-3 233 Switch - Roading I-7 313 Sensor - Hyd Oil Temp G-1 234 Switch - Side Shift Lock D-15 314 Sensor - Ride Control D-10 235 Switch - Stability Pressure B-7 315 Sensor - RR Axle Posn A-8 236 Switch - Stabliity Warning B-10 316 Sensor - XMSN out SPD J-3 237 Switch - Start Aid D-15 317 Sensor - XMSN Out SPD STD H-3 238 Switch - Start Aid A-15 318 Solenoid - AWD As J-1 239 Switch - Thermostat G-15 319 Solenoid - Bleed Valve B-8 240 Switch - XMSN Lock J-7 320 Solenoid - Cold Start Adv E-1 241 Valve Gp - AWS A-8 321 Solenoid - Diff Lock As J-1 242 Valve Gp - Stabilizer I-14 322 284 320 287 308 283 312 285 295 289 298 290 299 293 313 294 STEERING CONSOLE 303 304 317 318 163 164 204 205 314 300 280 281 279 288 282 316 309 310 RIGHT CONSOLE 260 165 166 271 272 CONN 53 269 182 183 261 240 236 321 259 251 UNDER PLATFORM - REAR VIEW CONN 33 CONN 54 CONN 38 CONN 47 273 224 256 257 235 270 CONN 34 CONN 52 UNDER PLATFORM - RIGHT SIDE VIEW Connector Location (Volume 2) Connector Number Schematic Location Connector Number Schematic Location CONN 33 J-14 CONN 50 C-7, C-10 CONN 34 H-16, J-14 CONN 51 B-10 CONN 35 I-16 CONN 52 B-9 CONN 36 B-16, D-16, G-14 CONN 53 B-8 CONN 37 D-12, F-16 CONN 54 A-9 CONN 38 J-14 CONN 55 I-2, J-3, J-4 CONN 39 E-14, H-13 CONN 56 I-2, J-3, J-4 CONN 40 C-7, C-12, E-14 CONN 57 H-3 CONN 41 B-14, D-14 CONN 58 H-1, H-3 CONN 42 A-14, D-14 CONN 59 H-3 CONN 43 A-14, C-14 CONN 60 G-4 CONN 44 B-12, C-14 CONN 61 C-4 CONN 45 A-11, F-9 CONN 62 C-4, D-6 CONN 46 E-11 CONN 63 F-1 CONN 47 E-11 CONN 64 E-2 CONN 48 B-11 CONN 65 F-10 CONN 49 A-11 275 229 250 FUEL TANK Resistor, Sender and Solenoid Specifications Part No.

Component Description Resistance (Ohms)¹ 244-3106 Sender: Coolant Temp 54°C (130°F) - 560 to 716 110°C (230°F) - 72 to 81.8 362-3089 Sender: Fuel Level (EST) Empty: 246-252 Full: 27-33 363-8475 Sender: Fuel Level (NON-EST) Empty: 246-252 Full: 27-33 299-2212 Solenoid: A/C Clutch 3.50 ± 0.15 274-8304 Solenoid: Diff Lock, STD AWD, Speed Clutch 1 8.8 ± 0.4 238-4626 Solenoid: Side Shift Left / Right 8.8 238-4628 Solenoid: Ride Control 7.3 Related Electrical Service Manuals Title Form Number Starting Motor: 149-0539 SENR3828 Control:

Machine UENR2484 185 278 231 198 195 199 228 274 167 254 181 233 CONN 56 CONN 55 249 193 CONN 60 286 302 266 234 247 268 168 241 292 CONN 64 296 244 189 243 265 238 226 203 277 CONN 63 175 ENGINE WITH STD XMSN 232 246 253 264 227 248 239 262 252 237 263 245 242 XMXN - AUTOSHIFT CONN 50 177 188 196 197 230 CONN 48 CONN 35 315 194 200 201 307 267 191 192 186 291 311 MACHINE TOP VIEW - CAB ROOF REMOVED

Стр. 3

1 16 REAR LH STT LAMP 336-9096 GND TAIL STOP TURN YL OR GY BK 1 2 RT-C3 1552272 605-RT15 YL-18 604-RT13 OR-18 200-RT1 BK-18 200-RT1 BK-18 617-RT17 BR-18 RT-C1 3E5179 1 2 1 2 PL-C16 1552252 617-PL125 BR-18 627-PL206 YL-18 XA-C14 1552269 (248) SOLENOID HYD TORQUE LIMIT 3 4 200-RT3 BK-18 200-RT3 BK-18 200-RT4 BK-18 617-RT18 BR-18 200-RT7 BK-18 200-RT6 BK-18 200-RT5 BK-18 200-RT2 BK-14 605-RT15 YL-18 618-RT20 YL-18 604-RT12 OR-18 606-RT16 GY-18 367-RT10 BU-18 3 4 5 6 7 8 9 10 11 12 3 4 5 6 7 8 9 10 11 12 367-PL11 BU-18 604-PL209 OR-18 605-PL211 YL-18 606-PL210 GY-18 618-PL149 YL-18 102-PL170 RD-14 102-PL176 RD-14 102-PL246 RD-14 111-PL73 RD-18 111-PL74 RD-18 102-PL170 RD-14 102-PL176 RD-14 106-PL32 RD-12 123-PL143 WH-18 105-PL18 RD-18 H6 123-PL88 WH-18 H6 PL-C52 1552252 1 2 3 4 5 6 7 8 9 10 11 12 XA-C8 3E5179 900-XA7 PU-18 751-XA1 GN-18 H803-XA16 BU-18 J879-XA31 GN-18 H705-XA30 BR-18 XA-C15 1552269 RD-18 RD-18 1 2 263-5516 (260) SOLENOID SIDE SHIFT LOCK BK-18 BK-18 257-0478 1 2 RT-C4 1552269 H771-RT25 BR-16 200-RT8 BK-16 200-RT8 BK-16 367-RT10 BU-18 367-RT10 BU-18 200-RT2 BK-14 627-RT21 YL-18 H771-RT23 BR-16 200-PL159 BK-14 H771-PL145 BR-16 627-PL206 YL-18 105-PL62 RD-16 105-PL60 RD-16 105-PL18 RD-18 118-PL45 GY-16 143-PL157 BR-16 131-PL61 BR-18 144-PL187 GN-16 102-PL176 RD-14 131-PL61 BR-18 PL-C50 1552269 123-PL150 WH-18 200-PL181 BK-18 180-PL238 GN-14 200-PL63 BK-18 200-PL63 BK-18 308-PL124 YL-18 200-PL108 BK-18 308-PL106 YL-18 200-PL46 BK-18 310-PL93 PU-18 751-PL296 GN-18 900-PL77 PU-18 3 4 5 6 7 8 9 10 11 12 1 2 CONN 55 903-XA3 GY-18 902-XA5 BR-18 552-XA33 WH-18 324-XA22 BU -18 J879-XA32 GN-18 J832-XA28 YL-18 XA-C11 1552269 1 2 RD-18 RD-18 (252) SOLENOID LOCKUP CLUTCH 238-4626 RT-C5 1552269 604-RT13 OR-18 604-RT14 OR-18 604-RT12 OR-18 CONN 33 111-PL74 RD-18 111-PL41 RD-16 111-PL73 RD-18 202-PL43 BK-18 159-PL100 BU-16 200-PL1 BK-18 200-PL44 BK-18 161-PL264 RD-16 202-PL8 BK-18 202-PL83 BK-18 202-PL186 BK-18 202-PL40 BK-18 202-PL27 BK-18 911-PL111 YL-18 702-PL102 OR-18 NOTE V 1 2 202-PL65 BK-18 202-PL119 BK-18 202-PL31 BK-18 200-PL240 BK-14 200-PL234 BK-14 (173) BUS BAR 2 (174) BUS BAR 3 (172) BUS BAR 1 275-0570 257-0570 275-0553 (221) RELAY AS PRM MODULE ENG (219) RELAY AS PRM MODULE 1 (220) RELAY AS PRM MODULE 2 (222) RELAY AS PRM MODULE HVAC 324-PL19 BU-16 903-PL297 GY-18 902-PL298 BR-18 552-PL162 WH-18 CONN 55 754-XA12 BU-18 452-XA18 PU-18 200-XA24 BK-18 H801-XA25 PU-18 200-XA24 BK -18 752-XA9 YL-18 324-XA22 BU-18 200-XA24 BK-18 452-XA18 PU -18 324-XA22 BU-18 1 2 RD-18 RD-18 (242) SOLENOID DIFF LOCK AS 274-8041 UENR4049 VOL 2 OF 2 42 Page, (Dimensions:

56 inches x 35 inches) J (273) SUPPRESSOR ARC (SS LOCK) 189-3158 1 2 H771-RT24 BR-16 200-RT6 BK-18 617-RT17 BR-18 617-RT19 BR-18 605-RT15 YL-18 606-RT16 GY-18 617-RT18 BR-18 605-RT15 YL-18 606-RT16 GY-18 RT-C2 3E3364 PL-C58 1552269 115-PL190 RD-18 116-PL243 BR-16 117-PL242 YL-16 202-PL165 BK-18 202-PL161 BK-18 202-PL164 BK-18 202-PL92 BK-18 627-PL206 YL-18 202-PL161 BK-18 308-PL109 YL-18 202-PL188 BK-18 202-PL333 BK-18 AWD CONT BRAKING SW.

283-7616 202-PL361 BK-18 306-PL101 GN-18 304-PL113 WH-12 PRM FUSES 30A 274-9872 40A 278-6377 60A 267-2701 276-7290 +BAT 276-7291 +BAT 275-0490 +BAT 276-7287 +BAT H801-PL23 PU-18 200-PL181 BK-18 754-PL202 BU-18 752-PL212 YL-18 452-PL139 PU-18 1 2 3 4 5 6 7 8 9 10 11 12 XA-C7 1907612 E901-XA19 GN-18 E900-XA20 WH-18 552-XA33 WH-18 751-XA1 GN-18 754-XA12 BU-18 752-XA9 YL-18 552-XA33 WH-18 H803-XA16 BU-18 XA-C6 1552269 1 2 RD-18 RD-18 (239) SOLENOID AWD AS J 627-RT21 YL-18 754-RT22 BU-18 618-RT20 YL-18 618-RT20 YL-18 627-RT21 YL-18 754-RT22 BU-18 754-RT22 BU-18 200-RT1 BK-18 1 2 CONN 34 1 2 200-PL278 BK-18 321-PL304 BR-18 119-PL239 PK-16 119-PL166 PK-14 118-PL148 GY-16 118-PL45 GY-16 119-PL241 PK-16 118-PL180 GY-16 202-PL174 BK-18 308-PL359 YL-18 308-PL109 YL-18 308-PL334 YL-18 308-PL75 YL-18 202-PL161 BK-18 308-PL109 YL-18 102-PL176 RD-14 131-PL61 BR-18 552-PL336 WH-18 601-PL15 GY-16 308-PL334 YL-18 552-PL337 WH-18 308-PL359 YL-18 552-PL336 WH-18 NOTE X 324-PL19 BU-16 308-PL37 YL-18 309-PL95 GY-18 322-PL167 GY-18 60A 30A NOTE C PL-C64 1552253 H705-XA30 BR-18 J832-XA28 YL-18 975-XA13 WH-18 J879-XA29 GN-18 903-XA3 GY-18 900-XA7 PU-18 902-XA5 BR-18 975-XA2 WH-18 975-XA2 WH-18 751-XA1 GN-18 XA-C1 1552269 RD-18 RD-18 (262) SOLENOID SPEED CLUTCH 1 305-3423 RT-C6 1552269 H771-RT24 BR-16 H771-RT25 BR-16 H771-RT23 BR-16 123-PL6 WH-18 123-PL79 WH-18 123-PL143 WH-18 123-PL292 WH-18 320-PL128 OR-18 324-PL19 BU-16 500-PL203 BR-16 501-PL179 GN-16 308-PL359 YL-18 552-PL336 WH-18 308-PL334 YL-18 552-PL337 WH-18 610-PL204 OR-14 610-PL153 OR-16 614-PL30 PU-18 911-PL105 YL-18 N945-PL57 OR-18 614-PL189 PU-18 131-PL61 BR-18 405-PL306 GY-18 420-PL169 OR-18 384-PL66 BU-12 384-PL110 BU-12 PL-C29 2304011 60A PL-C30 2304011 60A PL-C51 2304011 50A PL-C31 2304011 40A E900-PL280 WH-18 E901-PL281 GN-18 975-PL299 WH-18 3 4 5 6 7 8 9 10 11 12 1 2 CONN 56 X800-XA14 OR-18 J764-XA15 BR-18 J984-XA17 PK-18 975-XA8 WH-18 975-XA13 WH-18 975-XA4 WH-18 975-XA6 WH-18 XA-C3 1552269 1 2 (ET SOL 4) (263) SOLENOID SPEED CLUTCH 2 274-8034 (166) ALARM BACKUP (SS) 154-5428 RD-16 BK-16 + - 1 2 754-RT22 BU-18 200-RT1 BK-18 PE-C3 1552269 124-PL227 GN-18 123-PL150 WH-18 123-PL88 WH-18 123-PL354 WH-18 537-PL230 GN-18 537-PL219 GN-18 518-PL120 OR-16 506-PL255 PU-18 502-PL34 OR-16 614-PL218 PU-18 601-PL15 GY-16 610-PL204 OR-14 702-PL345 OR-18 610-PL153 OR-16 614-PL218 PU-18 614-PL147 PU-18 614-PL189 PU-18 614-PL191 PU-18 614-PL332 PU-18 (283) SWITCH AWD 362-3298 8 1 3 4 6 10 447-PL156 PK-18 441-PL38 OR-18 439-PL70 YL-18 450-PL67 YL-18 200-PL9 BK-18 308-PL17 YL-18 1 2 85 86 87 87A 30 1 2 85 86 87 87A 30 1 2 85 86 87 87A 30 1 2 85 86 87 87A 30 J832-PL347 YL-18 J879-PL348 GN-18 CONN 56 E901-XA19 GN-18 E900-XA20 WH-18 H705-XA30 BR-18 903-XA3 GY-18 975-XA4 WH-18 XA-C2 1552269 1 2 RD-18 RD-18 (ET SOL 5) 278-0213 (259) SOLENOID SIDE SHIFT LEFT BK-18 BK-18 238-4626 1 2 200-PE10 BK -18 M719-PE17 GN -18 200-PE5 BK -18 131-PL140 BR-16 131-PL99 BR-16 131-PL138 BR-16 131-PL61 BR-18 590-PL192 GY-18 601-PL15 GY-16 552-PL336 WH-18 552-PL337 WH-18 708-PL55 YL-18 911-PL42 YL-18 973-PL330 BR-18 977-PL331 YL-18 702-PL345 OR-18 627-PL206 YL-18 702-PL98 OR-18 702-PL98 OR-18 702-PL102 OR-18 202-PL186 BK-18 NOTE X 7 2 5 PL-C45 2285856 9 450-PL185 YL-18 452-PL139 PU-18 521-PL226 YL-18 507-PL114 WH-18 506-PL116 PU-18 RELAY RELAY RELAY RELAY (232) SENSOR HYD LOAD AUTO +V GROUND SIGNAL 344-7391 XA-C9 2304013 1 2 3 X800-XA14 OR-18 J764-XA15 BR-18 J984-XA17 PK-18 H801-XA25 PU-18 H801-XA11 PU-18 H801-XA10 PU-18 902-XA5 BR-18 975-XA6 WH-18 1 2 (264) SOLENOID SPEED CLUTCH 3 278-0213 (194) HORN RR 164-9425 1 2 RT-C7 1552269 200-RT7 BK-18 367-RT10 BU-18 NOTE:

SIDE SHIFT RIGHT SOL IS 362-3212 WHEN USED WITH REAR AUX (8TH FUNCTION.

PE-C6 1552269 200-PE6 BK -18 200-PE8 BK -18 200-PE7 BK -18 200-PE10 BK -18 200-PE15 BK -18 200-PE5 BK -18 M719-PE16 GN -18 PE-C1 3E3370 A B C A B C PL-C38 1552267 200-PL182 BK-18 133-PL323 OR-16 133-PL324 OR-16 133-PL84 OR-16 136-PL157 GN-16 603-PL237 PK-16 604-PL72 OR-18 604-PL71 OR-18 605-PL91 YL-18 605-PL90 YL-18 E701-PL356 PK-18 N945-PL57 OR-18 F748-PL357 WH-18 J878-PL52 YL-16 C720-PL313 BU-18 911-PL42 YL-18 708-PL55 YL-18 911-PL111 YL-18 911-PL105 YL-18 202-PL83 BK-18 552-PL337 WH-18 605-PL89 YL-18 606-PL50 GY-18 552-PL162 WH-18 611-PL51 PU-14 SB USB SB USB SB USB SB USB NOTE T (237) SENSOR XMSN OUT SPD XA-C12 1552269 J764-XA15 BR-18 H803-XA16 BU-18 J832-XA28 YL-18 900-XA7 PU-18 975-XA8 WH-18 XA-C4 1552269 1 2 (ET SOL 6) (245) SOLENOID FWD HIGH 280-7010 STOP TURN YL OR GY BK 1 2 RT-C8 1552272 604-RT14 OR-18 (271) SUPPRESSOR ARC (SIDE SHIFT LEFT) 189-3158 1 2 200-PE6 BK -18 M719-PE18 GN -18 M719-PE16 GN -18 M719-PE17 GN -18 M719-PE18 GN -18 200-PE23 BK -18 M721-PE20 WH -18 CONN 38 M719-PL183 GN-18 M721-PL184 WH-18 200-PL278 BK-18 200-PL159 BK-14 200-PL182 BK-18 321-PL304 BR-18 157-PL244 YL-16 158-PL245 BR-16 143-PL265 BR-16 606-PL86 GY-18 606-PL87 GY-18 605-PL172 YL-18 606-PL171 GY-18 973-PL330 BR-18 977-PL331 YL-18 C720-PL313 BU-18 708-PL55 YL-18 614-PL191 PU-18 C720-PL313 BU-18 751-PL296 GN-18 618-PL217 YL-18 617-PL215 BR-18 752-PL212 YL-18 619-PL213 GN-14 106-PL32 RD-12 106-PL32 RD-12 384-PL66 BU-12 384-PL110 BU-12 384-PL66 BU-12 384-PL110 BU-12 112-PL10 PU-10 SIG + SIG - 191-8304 1 2 E900-XA20 WH-18 E901-XA19 GN-18 J879-XA32 GN-18 J879-XA29 GN-18 J879-XA31 GN-18 H801-XA10 PU-18 754-XA12 BU-18 XA-C5 1552269 1 2 RD-18 RD-18 (ET SOL 2) (253) SOLENOID REV AS REAR RH STT LAMP 336-9096 GND TAIL 3 4 200-RT4 BK-18 618-RT20 YL-18 606-RT16 GY-18 (261) SOLENOID SIDE SHIFT RIGHT BK-18 BK-18 238-4626 1 2 PE-C5 1552269 200-PE7 BK -18 M721-PE22 WH -18 M720-PE13 BU -18 M720-PE14 BU -18 M720-PE24 BU -18 M719-PE27 GN -18 606-PL210 GY-18 604-PL209 OR-18 605-PL211 YL-18 367-PL11 BU-18 161-PL263 RD-16 161-PL103 RD-16 161-PL264 RD-16 610-PL153 OR-16 611-PL85 PU-14 611-PL49 PU-18 610-PL115 OR-14 610-PL204 OR-14 J878-PL52 YL-16 E701-PL356 PK-18 F748-PL357 WH-18 J878-PL341 YL-18 J878-PL338 YL-18 (320) SWITCH XMSN LOCK 214-4716 8 1 3 4 6 PL-C43 2285856 9 10 766-PL349 GN-18 754-PL202 BU-18 766-PL350 GN-18 H6 146-PL47 GY-10 146-PL36 GY-10 112-PL20 PU-10 103-PL39 RD-10 103-PL35 RD-10 GEAR DIAGRAM SOLENOIDS ET SOL 1F FWD LOW & CLUTCH 1 1&4 2F FWD HIGH & CLUTCH 1 2&4 X800-XA14 OR-18 J984-XA17 PK-18 XA-C13 1552269 (ET SOL 3) 278-0209 NOTE:

SIDE SHIFT RIGHT SOL IS 362-3212 WHEN USED WITH REAR AUX (8TH FUNCTION.

M721-PE20 WH -18 M721-PE22 WH -18 M721-PE21 WH -18 M720-PE26 BU -18 618-PL149 YL-18 F711-PL318 GN-18 617-PL125 BR-18 627-PL206 YL-18 200-PL97 BK-18 200-PL159 BK-14 200-PL182 BK-18 200-PL44 BK-18 614-PL4 PU-18 200-PL1 BK-18 200-PL63 BK-18 200-PL94 BK-18 614-PL173 PU-18 614-PL64 PU-18 N945-PL57 OR-18 J878-PL360 YL-18 308-PL109 YL-18 202-PL40 BK-18 7 2 5 E900-PL280 WH-18 903-PL297 GY-18 902-PL298 BR-18 975-PL299 WH-18 900-PL77 PU-18 104-PL197 RD-18 102-PL246 RD-14 POWER DISTRIBUTION BLOCK NEUT ALL OFF 1R REV & CLUTCH 1 3&4 3F FWD HIGH & CLUTCH 2 2&5 4F FWD LOW & CLUTCH 3 1&6 H801-XA11 PU-18 752-XA9 YL-18 1 2 (ET SOL 1) (246) SOLENOID FWD LOW 280-7009 LF-C3 2304011 LF-C1 3E3370 RT-C9 1552267 (272) SUPPRESSOR ARC (SIDE SHIFT RIGHT) 1 2 PE-C4 1552269 M721-PE21 WH -18 200-PE8 BK -18 M721-PE25 WH -18 M719-PL183 GN-18 M721-PL184 WH-18 F712-PL322 GY-18 H771-PL145 BR-16 200-PL278 BK-18 200-PL181 BK-18 200-PL220 BK-14 200-PL7 BK-18 614-PL218 PU-18 702-PL345 OR-18 619-PL213 GN-14 J878-PL338 YL-18 NOTE:

OPTIONAL RIDE CONTROL SW SHOULD BE REPLACED WITH LOAD CHECK DISABLE SW IF LOAD CHECK ONLY IS FITTED, OR WITH RIDE CONT LL SW IF BOTH RIDE CONTROL AND LOAD CHECK ARE FITTED E901-PL281 GN-18 J878-PL314 YL-18 J832-PL347 YL-18 H801-PL23 PU-18 105-PL60 RD-16 126-PL285 RD-14 115-PL190 RD-18 111-PL41 RD-16 104-PL197 RD-18 105-PL60 RD-16 115-PL190 RD-18 111-PL41 RD-16 102-PL246 RD-14 3R REV 7 CLUTCH 3 3&6 2R REV & CLUTCH 2 3&5 452-XA18 PU-18 T 4W-9972 (227) SENDER CONV TEMP REAR FOG LAMP 262-4727 1 2 627-LF5 YL-18 627-LF5 YL-18 200-LF2 BK-18 200-LF1 BK-18 A B C CONN 35 200-RT5 BK-18 627-RT21 YL-18 617-RT19 BR-18 189-3158 PE-C10 1552269 PL-C21 1552267 200-PL221 BK-18 202-PL1 BK-16 200-PL104 BK-18 708-PL55 YL-18 973-PL330 BR-18 977-PL331 YL-18 720-PL130 PU-18 911-PL42 YL-18 PL-C28 2059362 (295) SWITCH DIFFERENTIAL LOCK X977-PL254 YL-18 N939-PL137 GN-18 J879-PL348 GN-18 J878-PL351 YL-18 161-PL103 RD-16 601-PL13 GY-18 601-PL14 GY-18 601-PL12 GY-18 126-PL285 RD-14 161-PL103 RD-16 601-PL12 GY-18 AUTOSHIFT XMSN SOL - ATCH LF-C2 1552269 (251) SOLENOID LOCKOUT BK-18 BK-18 238-4628 1 2 M720-PE13 BU -18 200-PE23 BK -18 (224) RESISTOR CAN TERMINATING 2 134-2540 A B C F711-PL318 GN-18 F712-PL322 GY-18 NOTE C 202-PL65 BK-18 202-PL164 BK-18 202-PL207 BK-16 202-PL31 BK-18 C704-PL142 GY-18 C707-PL175 PK-18 C720-PL313 BU-18 C743-PL303 PK-18 H4 G795-PL81 OR-16 324-PL19 BU-16 1 2 204-0775 SWITCH LOADER LOCK 348-3064 MOM 614-PL147 PU-18 E701-PL356 PK-18 F748-PL357 WH-18 F739-PL358 GN-18 614-PL26 PU-18 618-PL216 YL-18 617-PL214 BR-18 PL-C41 2929784 (170) BLOCK AS FUSE 601-PL13 GY-18 614-PL26 PU-18 617-PL214 BR-18 601-PL14 GY-18 XK-C8 3E5179 XK-C14 1552269 (249) SOLENOID HYD TORQUE LIMIT STD I LIC LAMP.

196-0030 1 2 200-LF3 BK-18 617-LF4 BR-18 617-LF4 BR-18 (269) SUPPRESSOR LOCKOUT SOL 189-3158 1 2 PE-C7 1552269 M720-PE14 BU -18 200-PE15 BK -18 202-PL144 BK-18 202-PL165 BK-18 202-PL43 BK-18 202-PL174 BK-18 202-PL92 BK-18 E701-PL356 PK-18 F748-PL357 WH-18 G760-PL195 WH-18 G761-PL196 YL-18 G762-PL208 BR-18 PL-C8 1082253 (289) SWITCH BRAKE (LH) NOTE P (312) SWITCH RIDE CONTROL 214-4710 8 1 3 4 6 10 104-PL198 RD-18 104-PL199 RD-18 BACKLIGHT 10A F1 618-PL216 YL-18 1 2 3 4 5 6 7 8 9 10 11 12 H803-XK8 BU-18 J879-XK3 GN-18 H705-XK30 BR-18 RD-18 RD-18 1 2 263-5516 I REAR FOG LAMPS (ATCH) & LICENSE PLATE PE-C8 1552269 202-PL361 BK-18 202-PL161 BK-18 202-PL325 BK-16 202-PL119 BK-18 202-PL229 BK-16 J878-PL129 YL-18 G763-PL193 PU-18 J878-PL52 YL-16 G768-PL194 GN-18 331-5459 (177) CONTROL GP MACHINE ECM J1 PL-C59 1471445 111-PL73 RD-18 604-PL71 OR-18 702-PL345 OR-18 A B C 105-8034 NOTE E SWITCH RIDE CONT LL 253-9396 MOM MOM 202-PL8 BK-18 NOTE P 7 2 5 PL-C12 2285856 9 136-PL157 GN-16 102-PL246 RD-14 123-PL88 WH-18 (212) RELAY FWD HORN 146-9439 86 D1 C1 30 B1 AA1 A1 601-PL13 GY-18 614-PL26 PU-18 CONN 55 552-XK33 WH-18 324-XK22 BU-18 752-XK9 YL-18 754-XK12 BU-18 324-XK22 BU-18 XK-C11 1552269 1 2 RD-18 RD-18 (243) SOLENOID DIFF LOCK AS STD (182) DIODE SIDE SHIFT 1 189-3158 1 2 M720-PE24 BU -18 M721-PE25 WH -18 (322) VALVE GP STABILIZER 374-6870 307-PL146 OR-16 307-PL326 OR-18 307-PL163 OR-18 308-PL37 YL-18 N945-PL57 OR-18 G795-PL81 OR-16 KEY SWITCH RUN XMSN OUTPUT SPEED SNSR (+) XMSN OUTPUT SPEED SNSR (-) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 308-PL279 YL-18 E900-PL280 WH-18 E901-PL281 GN-18 NOTE C PL-C7 1082253 NOTE P 308-PL359 YL-18 J878-PL360 YL-18 104-PL197 RD-18 104-PL198 RD-18 104-PL3 RD-18 104-PL5 RD-18 104-PL199 RD-18 322-PL167 GY-18 320-PL128 OR-18 K1 87 D2 C2 B2 87A 85 LH TAIL 10A AA2 A2 F2 601-PL14 GY-18 617-PL214 BR-18 452-XK18 PU-18 200-XK24 BK-18 H801-XK25 PU-18 200-XK24 BK-18 200-XK24 BK-18 324-XK22 BU-18 552-XK33 WH-18 752-XK9 YL-18 754-XK12 BU-18 452-XK18 PU-18 274-8034 1 2 LP-C3 1552269 200-LP7 BK-18 617-LP8 BR-18 LP-C2 3E3370 A B C TO REAR END - BHL SS CONN RT-C9 (LOC I-16) (183) DIODE SIDE SHIFT 2 1 2 PE-C11 1552269 M720-PE26 BU -18 M719-PE27 GN -18 1 2 PL-C25 3E3364 T907-PL127 GN-18 J878-PL290 YL-18 J878-PL290 YL-18 T907-PL127 GN-18 T907-PL133 GN-18 T907-PL289 GN-18 308-PL17 YL-18 308-PL359 YL-18 308-PL109 YL-18 308-PL334 YL-18 308-PL75 YL-18 604-PL72 OR-18 111-PL74 RD-18 720-PL130 PU-18 A B C (290) SWITCH BRAKE (RH) 105-8034 601-PL15 GY-16 610-PL204 OR-14 (313) SWITCH ROADING 8 1 3 4 6 10 104-PL200 RD-18 104-PL200 RD-18 104-PL201 RD-18 104-PL201 RD-18 105-PL60 RD-16 106-PL32 RD-12 D3 B3 C3 RH TAIL 10A F3 601-PL12 GY-18 1 2 3 4 5 6 7 8 9 10 11 12 XK-C3 1907612 E901-XK19 GN-18 E900-XK20 WH-18 E900-XK20 WH-18 H803-XK8 BU-18 552-XK33 WH-18 XK-C6 1552269 1 2 (265) SOLENOID STD AWD 274-8034 LIC LAMP 196-0030 CONN 35 POWERED SIDESHIFT - ATCH (SS ONLY) 189-3158 LH STAB LEG UP PL-C26 3E3364 J878-PL290 YL-18 J878-PL291 YL-18 J878-PL291 YL-18 T907-PL289 GN-18 308-PL59 YL-16 308-PL279 YL-18 308-PL106 YL-18 308-PL124 YL-18 308-PL29 YL-18 MACHINE GROUND (BATT-) (1) CAT DATA LINK (+) 893-PL282 GN-16 202-PL294 BK-14 PL-C10 1552252 (298) SWITCH FNR CONTROL NOTE E NOTE:

SS ONLY 214-4711 7 2 5 PL-C37 2285856 9 116-PL243 BR-16 111-PL41 RD-16 118-PL180 GY-16 115-PL190 RD-18 117-PL242 YL-16 (216) RELAY REAR HORN 146-9439 K2 86 87 87A 30 85 A3 AA3 KEY 10A F4 618-PL216 YL-18 CONN 56 NOTE C H705-XK30 BR-18 J879-XK3 GN-18 E901-XK19 GN-18 X800-XK1 OR-18 H705-XK30 BR-18 XK-C5 1552269 LICENSE PLATE LAMP ONLY (ATCH) REAR END-BHL SS NOTE H RH STAB LEG UP 1 2 J878-PL291 YL-18 T907-PL133 GN-18 309-PL95 GY-18 310-PL93 PU-18 320-PL128 OR-18 NOTE C 202-PL325 BK-16 133-PL324 OR-16 308-PL29 YL-18 J878-PL129 YL-18 C704-PL142 GY-18 C707-PL175 PK-18 3 4 5 6 7 8 9 10 11 12 1 2 310-9354 F N 102-PL176 RD-14 202-PL188 BK-18 123-PL292 WH-18 119-PL241 PK-16 123-PL79 WH-18 123-PL354 WH-18 A305-PL151 YL-18 367-PL11 BU-18 B4 C4 D4 A4 AA4 105-PL60 RD-16 103-PL48 RD-14 X800-XK1 OR-18 J764-XK6 BR-18 H801-XK25 PU-18 H801-XK10 PU-18 H801-XK10 PU-18 H801-XK11 PU-18 X752-XK2 GY-18 278-0209 RD-18 RD-18 1 2 (ET SOL 3) (254) SOLENOID REV AS STD 367-PL11 BU-18 321-PL304 BR-18 324-PL19 BU-16 133-PL324 OR-16 202-PL325 BK-16 MACHINE GROUND (BATT-) (2) CAT DATA LINK (-) 202-PL284 BK-14 892-PL283 BR-16 308-PL279 YL-18 405-PL307 GY-18 420-PL310 OR-18 G763-PL193 PU-18 200-PL44 BK-18 G768-PL194 GN-18 320-PL128 OR-18 R HORN N 973-PL330 BR-18 977-PL331 YL-18 614-PL332 PU-18 131-PL138 BR-16 131-PL99 BR-16 126-PL285 RD-14 133-PL84 OR-16 124-PL227 GN-18 D5 C5 B5 ACC SKT 10A A5 AA5 F5 115-PL190 RD-18 103-PL53 RD-14 XK-C7 2304013 J984-XK7 PK-18 J984-XK7 PK-18 J764-XK6 BR-18 H803-XK8 BU-18 J879-XK3 GN-18 XK-C10 1552269 RC-C1 1552269 RC-C2 3E3364 STABILIZER ALARM - ATCH 420-PL309 OR-18 405-PL122 GY-18 405-PL306 GY-18 405-PL307 GY-18 405-PL307 GY-18 420-PL169 OR-18 308-PL279 YL-18 420-PL310 OR-18 308-PL29 YL-18 XMSN AUTO/MAN (AUTO) (SWG) XMSN AUTO/MAN (MAN) (SWG) 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 973-PL330 BR-18 977-PL331 YL-18 568-PL80 GN-18 450-PL305 YL-18 439-PL312 YL-18 H4 G760-PL195 WH-18 G761-PL196 YL-18 G762-PL208 BR-18 1 2 3 4 GEAR (283) SWITCH AUTO MAN 214-4691 8 1 3 4 6 10 144-PL187 GN-16 157-PL244 YL-16 158-PL245 BR-16 143-PL265 BR-16 K3 D6 C6 B6 BRAKE LAMPS 15A F6 103-PL58 RD-14 103-PL39 RD-10 (233) SENSOR HYD LOAD STD (181) DIODE REV SOL +5V GROUND SIGNAL 344-7391 RD-18 YL-18 GN-18 1 2 3 X800-XK1 OR-18 J764-XK6 BR-18 J984-XK7 PK-18 X752-XK2 GY-18 754-XK12 BU-18 1 2 189-3158 (165) ALARM BACKUP (CP) RD-16 BK-16 + - 1 2 TO PLATFORM HARNESS CONN PL-C58 (LOC J-14) 200-RC4 BK-18 321-RC3 BR-18 1 2 HEATER / AC SW 439-PL311 YL-18 420-PL310 OR-18 439-PL312 YL-18 439-PL70 YL-18 708-PL55 YL-18 568-PL80 GN-18 450-PL305 YL-18 439-PL312 YL-18 UNSWITCHED BATTERY 1 (+) 126-PL286 RD-14 708-PL55 YL-18 (293) SWITCH COLUMN MULTI FUNCTION 273-9190 202-PL333 BK-18 308-PL334 YL-18 7 2 5 PL-C14 2285856 9 159-PL100 BU-16 161-PL103 RD-16 200-PL22 BK-18 180-PL238 GN-14 200-PL9 BK-18 720-PL130 PU-18 911-PL42 YL-18 HORN RELAYS 10A A6 AA6 F7 111-PL41 RD-16 (238) SENSOR XMSN OUT SPD STD SIG + SIG - 1 2 XK-C12 1552269 E900-XK20 WH-18 752-XK9 YL-18 XK-C13 1552269 1 2 (247) SOLENOID FWD LOW STD 154-5428 CONN 34 HEATER ON 2&3 5&6 FUNCTION CONNECTIONS AC ON 2&1 5&4 614-AC15 PU-18 E528-AC13 PU-14 E528-AC12 PU-14 522-AC20 WH-18 614-AC23 PU-18 521-AC29 YL-18 569-AC31 PK-18 450-PL67 YL-18 450-PL33 YL-18 441-PL38 OR-18 447-PL156 PK-18 C704-PL142 GY-18 973-PL330 BR-18 977-PL331 YL-18 976-PL329 OR-18 STAB NEUTRAL SW (SWG) T907-PL289 GN-18 892-PL283 BR-16 893-PL282 GN-16 PL-C9 1552264 614-PL30 PU-18 627-PL206 YL-18 J878-PL341 YL-18 200-PL46 BK-18 200-PL108 BK-18 200-PL222 BK-18 (208) RELAY AWD 146-9439 86 D7 C7 30 B7 A7 AA7 104-PL197 RD-18 103-PL76 RD-14 191-8304 NOTE C E901-XK19 GN-18 H801-XK11 PU-18 (ET SOL 1) 324-2579 REAR END HARNESS - BHL CP (300) SWITCH HEATER AC 8 1 3 4 6 10 SWITCH VENT 214-4703 1 (207) RELAY A/C SHUTOFF 140-9378 K19 4 5 2 452-PL139 PU-18 500-PL203 BR-16 501-PL179 GN-16 502-PL34 OR-16 450-PL185 YL-18 450-PL305 YL-18 C743-PL121 PK-18 C707-PL175 PK-18 E701-PL356 PK-18 C720-PL313 BU-18 H4 RIDE CONTROL ON/DEAD ENG LOWER (SWG) UNSWITCHED BATTERY 4 (+) UNSWITCHED BATTERY 2 (+) 126-PL287 RD-14 126-PL288 RD-14 F748-PL357 WH-18 C707-PL175 PK-18 C704-PL142 GY-18 973-PL330 BR-18 977-PL331 YL-18 976-PL329 OR-18 605-PL90 YL-18 610-PL115 OR-14 102-PL170 RD-14 619-PL213 GN-14 1 2 3 4 5 6 7 8 YL BK/PU WH/YL PU/GN PU/RD 56b 56 15/1 L R TURN SIGNALS HEADLIGHT FLASH (309) SWITCH REAR FOG LAMP 8 1 3 4 6 10 306-PL327 GN-18 307-PL163 OR-18 306-PL328 GN-18 200-PL258 BK-18 N945-PL57 OR-18 200-PL22 BK-18 K4 87 D8 87A C8 85 B8 A8 AA8 HAZARD 15A F8 161-PL103 RD-16 103-PL78 RD-14 103-PL35 RD-10 452-XK18 PU-18 (226) SENDER CONV TEMP H 214-4718 NOTE M NOTE M 7 2 5 AC-C3 2285856 9 200-AC22 BK-14 124-AC5 GN-18 122-AC1 BU-12 200-AC8 BK-14 C511-AC7 WH-18 133-AC30 OR-18 3 AC-C8 2579257 506-PL116 PU-18 F711-PL318 GN-18 F748-PL357 WH-18 F712-PL322 GY-18 F420-PL300 GN-18 XMSN LOCK SW - ENABLE STATE (SWG) 8V SENSOR SUPPLY (PWM SENSORS) 8V SENSOR RETURN (PWM SENSORS) PARKING BRAKE SW (SWG 10) C743-PL121 PK-18 708-PL55 YL-18 J764-PL352 BR-18 X800-PL353 OR-18 C743-PL121 PK-18 E701-PL356 PK-18 C720-PL313 BU-18 611-PL85 PU-14 606-PL86 GY-18 537-PL230 GN-18 WH PU/WH 56a LOW BEAM 49a L R HIGH BEAM 202-PL27 BK-18 261-5048 7 2 5 PL-C3 2285856 9 NOTE J 308-PL106 YL-18 307-PL326 OR-18 308-PL124 YL-18 308-PL17 YL-18 131-PL99 BR-16 123-PL354 WH-18 D9 C9 B9 ECM 20A F9 103-PL295 RD-14 STD XMSN SOL - ATCH T 4W-9972 H 122-AC1 BU-12 122-AC24 BU-12 122-AC26 BU-12 9 10 7 506-PL255 PU-18 506-PL252 PU-18 507-PL114 WH-18 G763-PL250 PU-18 G763-PL193 PU-18 G760-PL195 WH-18 G761-PL196 YL-18 G762-PL208 BR-18 XMSN - REVERSE CLUTCH (PWM DRV 2) XMSN - FOWARD CLUTCH (PWM DRV 1) XMSN RETURN (PWM DRV RTN 1-4) H801-PL23 PU-18 754-PL202 BU-18 752-PL212 YL-18 F711-PL316 GN-18 F711-PL317 GN-18 F711-PL318 GN-18 F711-PL315 GN-16 PL-C55 1552273 31b 53b 53 J 15 53c WIPER 610-PL153 OR-16 331-PL25 OR-18 321-PL304 BR-18 310-PL93 PU-18 322-PL167 GY-18 320-PL128 OR-18 (217) RELAY RIDE CONTROL 146-9439 K5 86 87 87A 30 85 ROADING LIGHTS 20A A9 AA9 F10 126-PL285 RD-14 PL-C32 1552272 WT-C1 3E3376 WT-C2 1552252 614-AC14 PU-18 517-AC19 BU-14 516-AC18 GN-14 515-AC4 GY-18 E528-AC28 PU-14 124-AC5 GN-18 200-AC2 BK-18 200-AC27 BK-12 124-AC5 GN-18 K20 6 8 521-PL226 YL-18 518-PL120 OR-16 537-PL219 GN-18 J878-PL69 YL-18 J878-PL52 YL-16 G768-PL194 GN-18 J764-PL352 BR-18 F712-PL319 GY-18 F712-PL320 GY-18 F712-PL321 GY-16 F712-PL322 GY-18 118-PL45 GY-16 590-PL192 GY-18 500-PL203 BR-16 501-PL179 GN-16 502-PL34 OR-16 1 2 3 4 5 6 WASHER BK/BU BK/YL BK/BU/BN BN/BU BK/BU/WH BK/BU/YL FRONT DASH PANEL 367-PL11 BU-18 518-PL120 OR-16 384-PL66 BU-12 384-PL110 BU-12 N939-PL107 GN-18 F738-PL355 WH-18 C10 D10 B10 A10 AA10 102-PL246 RD-14 103-PL96 RD-14 450-PL185 YL-18 308-PL37 YL-18 202-PL31 BK-18 105-PL18 RD-18 1 2 3 4 CONN 57 1 2 3 4 105-WT1 RD-18 202-WT2 BK-18 308-WT3 YL-18 450-WT4 YL-18 3 4 5 6 7 8 9 10 11 12 1 2 TO PRODUCT LINK HARN CONN WR-C2 (LOC H-1) ANTENNA AS.

263-7802 WR-C2 3E5179 E529-AC21 YL-14 (288) SWITCH BLOWER SPEED 8 1 3 4 6 10 200-AC10 BK-12 200-AC25 BK-14 200-AC22 BK-14 200-AC9 BK-18 200-AC8 BK-14 AC-C7 3E3370 537-PL230 GN-18 537-PL223 GN-18 552-PL336 WH-18 J878-PL291 YL-18 J878-PL290 YL-18 J878-PL129 YL-18 T907-PL289 GN-18 X800-PL353 OR-18 MACHINE GROUND (BATT -) LOCKUP CLUTCH CONTROL (PWM DRV 5) 202-PL28 BK-14 J832-PL347 YL-18 F748-PL357 WH-18 F420-PL300 GN-18 G760-PL195 WH-18 G761-PL196 YL-18 G762-PL208 BR-18 506-PL255 PU-18 601-PL13 GY-18 601-PL14 GY-18 601-PL12 GY-18 537-PL223 GN-18 112-PL10 PU-10 112-PL20 PU-10 146-PL36 GY-10 CONN 58 CONN 58 BAT + BAT - KEY SW RUN R TERM RS-232-TXD ANTENNA 1 2 WR-C1 1552252 125-WR1 OR-18 125-WR1 OR-18 200-WR2 BK-18 308-WR3 YL-18 403-WR4 GN-18 1 2 3 4 5 6 7 8 9 10 11 12 TO PROD LINK JUMPER HARN CONN WT-C2 (LOC H-3) 214-4695 7 2 5 AC-C2 2285856 9 516-AC18 GN-14 515-AC4 GY-18 515-AC4 GY-18 124-AC5 GN-18 614-AC6 PU-18 521-AC29 YL-18 CONN 39 A B C TO PLATF HARN PS CONN PL-C35 (LOC E-14) 105-PL62 RD-16 115-PL190 RD-18 116-PL243 BR-16 117-PL242 YL-16 590-PL192 GY-18 568-PL80 GN-18 552-PL337 WH-18 123-PL88 WH-18 LOCK-UP CLUTCH RTN (PWM DRV RTN 5-8) J879-PL348 GN-18 G763-PL293 PU-18 G763-PL250 PU-18 G763-PL193 PU-18 614-PL64 PU-18 603-PL237 PK-16 614-PL26 PU-18 618-PL216 YL-18 617-PL214 BR-18 (169) BLOCK AS FUSE PL-C47 2757877 146-PL47 GY-10 N979-WT5 GN-16 N960-WT6 OR-16 N957-WT7 PK-16 3 4 5 6 7 8 9 10 11 12 200-WR2 BK-18 308-WR3 YL-18 403-WR4 GN-18 N957-WR7 PK-18 E529-AC21 YL-14 200-AC25 BK-14 E528-AC11 PU-14 200-AC9 BK-18 517-AC19 BU-14 521-AC29 YL-18 AC-C1 1116795 119-PL166 PK-14 119-PL239 PK-16 124-PL227 GN-18 118-PL148 GY-16 123-PL6 WH-18 603-PL237 PK-16 601-PL15 GY-16 105-PL60 RD-16 111-PL41 RD-16 105-PL18 RD-18 102-PL246 RD-14 G768-PL194 GN-18 J764-PL352 BR-18 J878-PL69 YL-18 J878-PL52 YL-16 8 1 3 4 6 10 214-4693 (287) SWITCH BEACON A305-PL151 YL-18 720-PL130 PU-18 911-PL42 YL-18 F738-PL355 WH-18 180-PL238 GN-14 AIR SEAT 20A C1 AA1 D1 L2 L1 FR FLOOD 15A A1 FUSES 10A 113-8490 15A 113-8491 20A 113-8492 N957-WT7 PK-16 N960-WT6 OR-16 N979-WT5 GN -16 WT-C3 9X4813 A B C SERVICE PORT CONNECTIONS A = GND B = RXD C = TXD RS-232-RXD RS-232-GND RS-232-DTR RS-232-DSR N973-WR9 BR-18 N970-WR8 YL-18 N979-WR5 GN-18 N979-WR5 GN-18 N960-WR6 OR-18 N960-WR6 OR-18 N957-WR7 PK-18 (171) BLOWER GP CAB HEATER MOTOR 358-7085 1 2 AC-C6 1779646 C568-AC16 WH-12 200-AC10 BK-12 522-AC20 WH-18 614-AC23 PU-18 614-AC15 PU-18 614-AC14 PU-18 122-AC24 BU-12 515-AC4 GY-18 200-AC2 BK-18 C568-AC3 WH-12 1 5 2 4 3 87a 87 85 86 30 (213) RELAY HI SPD 3E-9362 143-PL265 BR-16 131-PL140 BR-16 117-PL242 YL-16 157-PL244 YL-16 158-PL245 BR-16 133-PL323 OR-16 604-PL209 OR-18 604-PL71 OR-18 604-PL72 OR-18 605-PL89 YL-18 605-PL90 YL-18 119-PL241 PK-16 115-PL190 RD-18 118-PL180 GY-16 116-PL243 BR-16 PL-C60 1471446 J878-PL68 YL-16 J878-PL314 YL-18 J878-PL351 YL-18 J878-PL291 YL-18 J878-PL290 YL-18 J878-PL129 YL-18 202-PL92 BK-18 144-PL187 GN-16 7 2 5 PL-C48 2285856 9 126-PL285 RD-14 N945-PL57 OR-18 G763-PL250 PU-18 X977-PL248 YL-18 N939-PL107 GN-18 158-PL245 BR-16 RR FLOOD 15A F1 F11 FR FLOOD ATCH 15A CONN 59 (206) RADIO PRODUCT LINK N970-WR8 YL-18 WR-C3 3E3364 1 2 CONNECTOR NOT USED AC-C4 3E3364 C511-AC7 WH-18 C511-AC7 WH-18 614-AC6 PU-18 K9 200-PL97 BK-18 200-PL221 BK-18 202-PL144 BK-18 161-PL263 RD-16 605-PL211 YL-18 605-PL172 YL-18 606-PL50 GY-18 605-PL91 YL-18 123-PL143 WH-18 123-PL79 WH-18 123-PL150 WH-18 123-PL292 WH-18 XMSN CLUTCH RETURN 1 (DRV 1-3) KEY SWITCH RUN XMSN FWD HIGH CLUTCH (DRV 1) J2 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 900-PL77 PU-18 975-PL299 WH-18 308-PL29 YL-18 T907-PL289 GN-18 X800-PL353 OR-18 202-PL165 BK-18 C743-PL303 PK-18 202-PL2 BK-14 751-PL296 GN-18 331-PL25 OR-18 752-PL212 YL-18 X977-PL251 YL-18 X977-PL249 YL-18 157-PL244 YL-16 116-PL243 BR-16 C2 F12 AA2 D2 A2 F2 PRODUCT LINK JUMPER - ATCH 336-3545 N973-WR9 BR-18 NOTE N NOTE B THERMOSTAT WIRE AS 220-3762 (319) SWITCH THERMOSTAT 1 2 522-AC20 WH-18 C511-AC7 WH-18 E528-AC28 PU-14 E528-AC13 PU-14 E528-AC12 PU-14 E528-AC11 PU-14 C568-AC17 WH-12 C568-AC16 WH-12 C568-AC3 WH-12 122-AC26 BU-12 TO PRM MODULE - HVAC (SH 1 LOC I-3) NOTE T 308-PL59 YL-16 309-PL95 GY-18 310-PL93 PU-18 307-PL146 OR-16 606-PL210 GY-18 606-PL171 GY-18 606-PL86 GY-18 606-PL87 GY-18 610-PL115 OR-14 131-PL138 BR-16 124-PL227 GN-18 131-PL99 BR-16 133-PL84 OR-16 123-PL354 WH-18 XMSN CLUTCH SPEED 1 (DRV 3) XMSN CLUTCH SPEED 2 (DRV 4) XMSN CLUTCH SPEED 3 (DRV 5) XMSN CLUTCH RET 2 (DRV 4-5) 751-PL296 GN-18 903-PL297 GY-18 902-PL298 BR-18 161-PL264 RD-16 202-PL92 BK-18 144-PL187 GN-16 159-PL100 BU-16 202-PL43 BK-18 LH IND LAMP.

214-4717 LEFT TURN 1B PARK BRAKE 2B 766-PL349 GN-18 766-PL82 GN-18 754-PL202 BU-18 766-PL350 GN-18 117-PL242 YL-16 RR FLOOD ATCH 15A C3 F13 AA3 D3 FR WIPER 20A A3 F3 PRODUCT LINK 121SR - ATCH 119-9631 T AC-C9 1779654 405-PL122 GY-18 439-PL311 YL-18 420-PL309 OR-18 447-PL156 PK-18 441-PL38 OR-18 611-PL49 PU-18 610-PL204 OR-14 118-PL180 GY-16 610-PL153 OR-16 136-PL157 GN-16 159-PL100 BU-16 157-PL244 YL-16 158-PL245 BR-16 143-PL265 BR-16 BACKUP ALARM RELAY (300mA SINK 5) RIDE CONT RELAY (300mA SINK 1) ACTION LAMP PARK BRAKE F738-PL355 WH-18 331-PL25 OR-18 F420-PL300 GN-18 568-PL80 GN-18 202-PL165 BK-18 202-PL174 BK-18 202-PL164 BK-18 308-PL75 YL-18 605-PL91 YL-18 1A 2A PL-C19 2055471 H5 903-PL297 GY-18 902-PL298 BR-18 975-PL299 WH-18 900-PL77 PU-18 119-PL241 PK-16 RR WIPER 20A C4 AA4 D4 AIR CON COMP 10A A4 (302) SWITCH HYD OIL FILTER BYPASS (225) RESISTOR MOTOR SPD 204-9921 1 2 3 4 C568-AC17 WH-12 516-AC18 GN-14 517-AC19 BU-14 TO SIDE CONSOLE HARNESS (SS) CONN RH-C5 (LOC D-16) OR TO SIDE CONSOLE HARNESS (CP) CONN RF-C5 (LOC B-16) 1 2 AC-C5 3E3364 133-AC30 OR-18 569-AC31 PK-18 200-AC27 BK-12 TO CAB GROUND STUD (SH 1 LOC D-6) 452-PL139 PU-18 501-PL179 GN-16 450-PL33 YL-18 500-PL203 BR-16 611-PL51 PU-14 614-PL26 PU-18 611-PL85 PU-14 614-PL4 PU-18 202-PL1 BK-16 161-PL103 RD-16 200-PL7 BK-18 144-PL187 GN-16 ALT "W" (TACHO) 450-PL305 YL-18 603-PL237 PK-16 605-PL91 YL-18 518-PL120 OR-16 537-PL219 GN-18 308-PL75 YL-18 F738-PL355 WH-18 E900-PL280 WH-18 E901-PL281 GN-18 H801-PL23 PU-18 202-PL1 BK-16 202-PL2 BK-14 202-PL207 BK-16 202-PL229 BK-16 124-PL227 GN-18 IMP DISABLE 15A F14 MONITORING 15A F4 E455-EF10 BR-16 L740-EF12 BR-18 442-EF11 GY-18 134-0404 HVAC - ATCH CONN 36 503-PL177 BR-16 507-PL114 WH-18 506-PL252 PU-18 502-PL34 OR-16 503-PL177 BR-16 614-PL155 PU-18 614-PL225 PU-18 614-PL173 PU-18 614-PL218 PU-18 614-PL64 PU-18 200-PL220 BK-14 200-PL181 BK-18 200-PL104 BK-18 200-PL63 BK-18 RETURN FOR ALL SWG SWITCHES J878-PL68 YL-16 605-PL172 YL-18 611-PL49 PU-18 606-PL87 GY-18 606-PL171 GY-18 202-PL43 BK-18 202-PL164 BK-18 1B 2B J878-PL314 YL-18 J832-PL347 YL-18 J879-PL348 GN-18 J878-PL351 YL-18 (187) GROUND CONTROL NOTE A 133-PL84 OR-16 143-PL265 BR-16 C5 F15 AA5 D5 A5 F5 EF-C3 1552269 G RN-C17 1552272 521-PL226 YL-18 564-PL224 GY-16 564-PL224 GY-16 568-PL80 GN-18 617-PL125 BR-18 618-PL149 YL-18 618-PL217 YL-18 618-PL216 YL-18 617-PL214 BR-18 617-PL215 BR-18 200-PL221 BK-18 202-PL207 BK-16 202-PL65 BK-18 202-PL31 BK-18 202-PL119 BK-18 SHUTTLE FWD (SWG/PWM) SHUTTLE REV (SWG/PWM) 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 C704-PL142 GY-18 614-PL64 PU-18 C743-PL303 PK-18 614-PL173 PU-18 RH IND LAMP.

Стр. 4