14 Maintenance 14 Maintenance 14.1 MBE 900 EuroV Preventive Maintenance Tables - 93K222(CK-4) and 93K218(CJ-4) NOTE: DFS 93K223(FA-4) oils should not be used in an MBE900 EuroV engine. NOTE: Refer to DTNAConnect.com for most current information. DFS 93K222(CK-4) and 93K218(CJ-4) Oil Service Interval Definitions (applies to the following tables): Long Haul Applies to vehicles that travel more than 100,000 kilometers annually, with an average fuel economy greater than 2.6 km/l, with load factor up to 44%, idle time up to 20%. Examples: Long distance road service (interstate transport), minimum stop operation and city start.
Short Haul Applies to vehicles that travel annually from 48,000 to 100,000 kilometers, with average fuel economy between 2.2 and 2.5 km / l, with load factor greater than or equal to 45%, idle time between 25% -30%. Examples: operation mainly in cities and densely populated areas, local transport with intermittent road trips, high percentage of stoppage and start operation. Severe Applies to vehicles that travel annually up to 48,000 kilometers or that operate under severe conditions, with average fuel economy up to 2.1 km/l, load factor greater than 55%, idle time greater than 35%. Examples:
operating on roads that are unpaved or extremely damaged operating in an environment with a high accumulation of dust operating with constant exposure to extreme heat, cold, salt-air or other extreme climates operating on frequent trips of short distances operating on construction sites or farms Table 8. 28 All information subject to change without notice. Copyright © 2019 DETROIT DIESEL CORPORATION DDC-SVC-MAN-0207 MBE 900: Maintenance Intervals (Note:
Up to 50 ppm Sulfur Fuel is acceptable for this application.) EuroV Using DFS 93K222(CK-4) or DFS 93K218(CJ-4) Approved Oils DFS 93K223(FA-4) oils should not be used in an MBE900 EuroV engine Component Long Haul † Greater than2.6 km/l*** (6.0 to 6.9 mpg) Short Haul † 2.2 to 2.5 km/l*** (5.1 to 5.9 mpg) Severe † Up to 2.1 km/l*** (Up to 5.0 mpg) Oil Filter Replace every 60,000 km Replace every 45,000 km, 800 hrs or 12 months † Replace every 30,000 km, 500 hrs or 12 months † Lubricating Oil Replace every 60,000 km Replace every 45,000 km, 800 hrs or 12 months † Replace every 30,000 km, 500 hrs or 12 months † Engine Fuel Filter * Replace every 60,000 km Replace every 45,000 km, 800 hrs or 12 months † Replace every 30,000 km, 500 hrs or 12 months † Engine Fuel Filter * w/ Frame- Mounted Filter Replace every 60,000 km Replace every 45,000 km, 800 hrs or 12 months † Replace every 30,000 km, 500 hrs or 12 months † Frame Mounted Fuel Filters ‡ Replace every 60,000 km Replace every 45,000 km, 800 hrs or 12 months † Replace every 30,000 km, 500 hrs or 12 months † Valve Lash Adjustment Adjust at first oil change, and then every other oil change thereafter.
Coolant - Standard Life Maintain every 60,000 km or 12 months Replace every 480,000 km or 24 months Maintain every 45,000 km, 800 hrs or 6 months † Replace every 450,000 km or 24 months Maintain every 30,000 km, 500 hrs or 3 months † Replace every 450,000 km or 24 months