4 RENR5042-02 Table of Contents CID 0247 FMI 09 J1939 Data Link communications .................................................. 69 CID 0253 FMI 02 Personality Module mismatch .. 69 CID 0261 FMI 13 Engine Timing Calibration required ............................................................... 69 CID 0262 FMI 03 5 Volt Sensor DC Power Supply short to +batt ....................................................... 70 CID 0262 FMI 04 5 Volt Sensor DC Power Supply short to ground .................................................... 70 CID 0268 FMI 02 Check Programmable Parameters .........................................................
70 CID 0273 FMI 00 Turbo Outlet Pressure above normal ................................................................. 71 CID 0274 FMI 03 Atmospheric Pressure open/short to +batt ................................................................ 71 CID 0274 FMI 04 Atmospheric Pressure short to ground ................................................................. 71 CID 0342 FMI 08 Secondary Engine Speed signal abnormal ............................................................. 72 CID 0545 FMI 05 Ether Start Relay open/short to +batt ....................................................................
72 CID 0545 FMI 06 Ether Start Relay short to ground ................................................................. 72 CID 1835 FMI 03 Auxiliary Pressure Sensor open/short to +batt .............................................. 72 CID 1835 FMI 04 Auxiliary Pressure Sensor short to ground ................................................................. 73 CID 1836 FMI 03 Auxiliary Temperature Sensor open/short to +batt .............................................. 73 CID 1836 FMI 04 Auxiliary Temperature Sensor short to ground .............................................................
73 CID 2417 FMI 05 Ether Injection Control Solenoid current low .......................................................... 74 CID 2417 FMI 06 Ether Injection Control Solenoid current high ......................................................... 74 Electrical Power Supply Circuit - Test ................. 125 Engine Pressure Sensor Open or Short Circuit - Test ................................................................... 129 Engine Speed/Timing Sensor Circuit - Test ........ 134 Engine Temperature Sensor Open or Short Circuit - Test ................................................................... 140 Ether Injection System - Test ..............................
146 Injector Solenoid Circuit - Test ............................ 152 Maintenance Due Lamp Circuit - Test ................. 160 PTO Switch Circuit - Test .................................... 163 Switch Circuits - Test .......................................... 168 Throttle Position Sensor Circuit - Test ................ 171 Warning Lamp Circuit - Test ................................ 176 Calibration Procedures Engine Speed/Timing Sensor - Calibrate ............ 180 Throttle Position Sensor - Calibrate .................... 182 Index Section Index ...................................................................
185 Troubleshooting with an Event Code Event Codes ........................................................ 75 E057 Low Engine Coolant Level Derate ............... 79 E058 Low Engine Coolant Level Shutdown .......... 79 E059 Low Engine Coolant Level Warning ............ 80 E096 High Fuel Pressure ...................................... 81 E360 Low Engine Oil Pressure ............................. 81 E361 High Engine Coolant Temperature .............. 82 E362 Engine Overspeed ....................................... 83 E363 High Fuel Temperature ................................ 83 E443 High Auxiliary Pressure ...............................
84 E445 High Auxiliary Temperature ......................... 84 E539 High Intake Manifold Air Temperature ......... 85 Diagnostic Functional Tests 5 Volt Engine Pressure Sensor Supply Circuit - Test ..................................................................... 87 Air Shutoff System - Test ...................................... 95 CAN Data Link Circuit - Test ............................... 100 Cat Data Link Circuit - Test ................................. 104 Coolant Level Sensor Circuit - Test .................... 106 Diagnostic Lamp Circuit - Test ............................. 110 Digital Sensor Supply Circuit - Test .....................
114 ECM/Personality Module - Test ........................... 118 Electrical Connectors - Inspect ........................... 120