Volvo Bus Manual (EN)

06_chn132839_134628_D9B.pdf

Service Manual Buses Group 37 Release 01 Multiplex electrical system Version 2 Wiring Diagram B9TL with D9B (chno 132839 - 134628) TP 17036

Стр. 1

Foreword

Foreword The information in this manual is based on present design in April 2009. The products are under continuous development. This may effect the correctness of the information in this manual. If the differences are significant, new editions of this manual will be released to cover the changes. Order number: TP 17036 © 2009 Volvo Bus Corporation, G ц teborg, Sweden All rights reserved. No part of this publication may be reproduced, stored in retrieval system, or transmitted in any forms by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of Volvo Bus Corporation.

Стр. 2

Foreword

EDM-W 2000-04-01 Engineering Release Notice (ERN) Location Change Description A = Added W = Was U = Deleted Document Release Status RELEASED D-14046-88 Date 2009-04-15 Modification Count WIRING DIAGRAM INDEX, B7, B9, B12 NAME DESCRIPTION PAGE NAME DESCRIPTION PAGE AA IGNITION AND STARTING SYSTEM 02 FA ECS, AIR SUSPENSION 35 AB POWER SUPPLY 03 FB ECS, AIR SUSPENSION 36 AC STARTER MOTOR AND ALTERNATORS 04 FC AMECU 37 AD STARTER AND ALTERNATORS FOR MD7 05 FO ELECTRONIC STEERED AXLE 38 AE STARTER MOTOR AND ALTERNATORS 06 FOR R9L, R9TL, B9R AF STARTER AND ALTERNATORS MD12 07 GA LCM, REAR LIGHTS 39 AG START/STOP SWITCHES REAR 08 GB LCM, FRONT LIGTHS 40 AH STARTER MOTOR AND ALTERNATORS GC LCM, REAR LIGHTS 41 09 FOR D9B :

B9S GD LCM, ARTIC LIGHTS, PULLER 42 BA VECU, VEHICLE ECU 10 GE LCM, BI-XENON LIGHT 43 BB BBM, BODY BUILDER MODULE 11 GF LCM, BIARTIC LIGHTS 44 BC BBM, BODY BUILDER MODULE 12 GM WIPER, WASHER 45 BD FIRE ALARM 13 GN LCM, XENON LIGHT RELAY 46 CA EECU D9B, ENGINE 14 IS HORN SWM, STEERING WHEEL 47 MODULE CB EECU G9A, ENGINE 15 IU AUDIO 48 CC EECU D12D, ENGINE 16 CG FTM, FUEL TANK MONITOR 17 LA HÜBNER ECU 1ST TURNTABLE 49 CL BIO, BUS I/O 18 LB HÜBNER ECU 2ND TURNTABLE 50 CM EECU DH12E, ENGINE 19 CN EECU D7E, ENGINE 20 NA BIC, BUS INSTRUMENT CLUSTER 51 CO OILMASTER 21 NB TACHOGRAPH 52 CP BIC & RTVW 22 NC DYNAFLEET, ALCOLOCK 53 CU UDS, UREA DOSING SYSTEM 23 ND FMS 200, FLEET MANAGEMENT SYSTEM 54 CV CAN SAE 1939 7 24 NE FMS 200 GATEWAY, FLEET 55 _ MANAGEMENT SYSTEM NF VDV, INSTRUMENT CLUSTER 56 DA G8-EGS 25 NG VDV, INSTRUMENT CLUSTER 57 DB ECOMAT 4 ZF 26 DC VOITH, DIWA5 27 XC CAN SAE1939 58 DD ECOLIFE ZF 28 XD CAN SAE1587 59 DM RECU, RETARDER 29 XE CAN SAE 1587 UDS 60 DN I-SHIFT 30 DO VOITH, DIWA5 ARTIC 31 ZC GROUND 61 EO EBS, ELECTRONIC BRAKE SYSTEM 32 EP EBS, ELECTRONIC BRAKE SYSTEM 33 EX PARKING BRAKE RELEASE 34 VOLUME NO CONTENT PAGES 01 WIRING DIAGRAM 1-61 02 BILL OF MATERIAL/COMPONENT LIST 1-99 The copying, distribution and utilization of this document as well as the communication of its contents to others without expressed authorization is prohibited.

Offenders will be held liable for payment of damages. All rights reserved in the event of the grant of a patent, utility model or ornamental design registration.

Document Title WIRING DIAGRAM B7, B9, B12 Volvo Bus Corporation Document Type PRODUCT SCHEMATIC Owner Domain:Document Prefix Document No 20904123 Issue Index 06 Volume No 01(02) Page No 1(61) NAME DESCRIPTION PAGE NAME DESCRIPTION PAGE AA IGNITION AND STARTING SYSTEM 02 FA ECS, AIR SUSPENSION 35 AB POWER SUPPLY 03 FB ECS, AIR SUSPENSION 36 AC STARTER MOTOR AND ALTERNATORS 04 FC AMECU 37 AD STARTER AND ALTERNATORS FOR MD7 05 FO ELECTRONIC STEERED AXLE 38 AE STARTER MOTOR AND ALTERNATORS FOR R9L, R9TL, B9R 06 AF STARTER AND ALTERNATORS MD12 07 GA LCM, REAR LIGHTS 39 AG START/STOP SWITCHES REAR 08 GB LCM, FRONT LIGTHS 40 AH STARTER MOTOR AND ALTERNATORS FOR D9B :

B9S 09 GC LCM, REAR LIGHTS 41 GD LCM, ARTIC LIGHTS, PULLER 42 BA VECU, VEHICLE ECU 10 GE LCM, BI-XENON LIGHT 43 BB BBM, BODY BUILDER MODULE 11 GF LCM, BIARTIC LIGHTS 44 BC BBM, BODY BUILDER MODULE 12 GM WIPER, WASHER 45 BD FIRE ALARM 13 GN LCM, XENON LIGHT RELAY 46 CA EECU D9B, ENGINE 14 IS HORN SWM, STEERING WHEEL MODULE 47 CB EECU G9A, ENGINE 15 IU AUDIO 48 CC EECU D12D, ENGINE 16 CG FTM, FUEL TANK MONITOR 17 LA HÜBNER ECU 1ST TURNTABLE 49 CL BIO, BUS I/O 18 LB HÜBNER ECU 2ND TURNTABLE 50 CM EECU DH12E, ENGINE 19 CN EECU D7E, ENGINE 20 NA BIC, BUS INSTRUMENT CLUSTER 51 CO OILMASTER 21 NB TACHOGRAPH 52 CP BIC & RTVW 22 NC DYNAFLEET, ALCOLOCK 53 CU UDS, UREA DOSING SYSTEM 23 ND FMS 200, FLEET MANAGEMENT SYSTEM 54 CV CAN SAE 1939 7 _ 24 NE FMS 200 GATEWAY, FLEET MANAGEMENT SYSTEM 55 NF VDV, INSTRUMENT CLUSTER 56 DA G8-EGS 25 NG VDV, INSTRUMENT CLUSTER 57 DB ECOMAT 4 ZF 26 DC VOITH, DIWA5 27 XC CAN SAE1939 58 DD ECOLIFE ZF 28 XD CAN SAE1587 59 DM RECU, RETARDER 29 XE CAN SAE 1587 UDS 60 DN I-SHIFT 30 DO VOITH, DIWA5 ARTIC 31 ZC GROUND 61 EO EBS, ELECTRONIC BRAKE SYSTEM 32 EP EBS, ELECTRONIC BRAKE SYSTEM 33 EX PARKING BRAKE RELEASE 34 VOLUME NO CONTENT PAGES 01 WIRING DIAGRAM 1-61 02 BILL OF MATERIAL/COMPONENT LIST 1-99

Стр. 3

Foreword

D 0 1 2 3 4 5 4 5 IGNITION AND STARTING SYSTEM S15A 0 R I II III 50 0.5BL/SB S15.50B NG:3 B CNPB1:25 0.75BL/SB S15.50 0.75GN BBOX:1 Switch,Starter Key B+ K13.87A DASH_VDV 0.75VO K13.87E 0.5VO K13.87C 1.5Y XSB25 13 A B 14 ZC:1 A XSA35 KH3A:5 0.75W GND5N 0.5VO 1.5SB DASH_VDV NG:3 C CNPB1:24 21 C D 22 S15.DRA KH3A:3 KH3A:1 30 85 86 K13.87A IB2:17 ZC:5 C XSB10 0.5W GND1AP 9 7 8 3 10 0.5Y A90.A14B 0.75VO K13.87D S15B 1 2 0 0.75GN/R F57 5A FH3B:4 0.5R F57 K13 87 87A KH3A:6 0.5VO GND1APA 0.5W S12 2 0.5Y A27.D4BJ GB:1 D XSB13 Switch,Starter Feed 0.5Y CNPB3:2 S904 S904.3 1 0 0.5BL DASH_VDV 0.5BL DASH_VDV 0.5Y A90.A14 IB5:6 0.5Y A90.B15 BBOX UBBOX 0.5BL DASH_VDV 0.5BL DASH_VDV 0 1 0.5BL/OR C1 BMUX:3 A1 S40 B1 BMUX:4 CNPB3:1 A90.A14A 0.5Y CG:4 D FTM:8 A90.A14D 0.5Y A90.A4 0.75GN AB:5 C X903.XC109:10 0.5Y A90.A4C_2 0.5R F42 0.5R F42 A1 0.5BL/OR 0.5Y A90.A4A 0.5Y A90.A4 S904.3BB XSA26 F42 5A FH4B:7 IB5:5 BMUX:5 BB B1 0.5Y A90.A4BB 0.5BL DASH_VDV CNPB3:3 0.5BL DASH_VDV IB5:7 0.5Y A90.A4B BB2:11 BB 0.5Y A90.A4C_1 + +30 +DR D C B A 4 3 2 1 IGNITION AND STARTING SYSTEM WIRING DIAGRAM AA + +30 +DR XSA34 S15.DRB A90.A4C_2 0.5GN/R F42 F57 S15DRC FH2B:5 5A 5A 0.5GN/R 0.5GN/R 0.5GN/R 86 30 K17 FH4B:7 0.5Y FH3B:4 FTM:9 BIO:9 S15.DR A90.A1 1R7.A14 85 87 87A 0.5R F42 0.5R 0.5GAN/ 0.5GN/R IB5:5 ZC:1 A FH2A:5 KH3A:5 XSA35 F57 KH3A:1 0.5GN/R S15DRC0.5GN/R 0.75W S15A DASH_VDV0.5BL IB5:2 A17.A14 S15DRCA FEED_CNG GND4C BMUX:5 CNPB3:2 K13 30 85 0 IB5:13 BA:5 B 0.5RF42 0.75W Key BIO BB R B1 DASH_VDV0.5BL S90487A 87 86 I 0.5GN 1.5VO 0.75Y/SB A925.A1 A942.A1 GND5N Switch,Starter II F57A CG:4 C CL:4 C XSA52 KH3A:3 DASH_VDV KH3A:6 III ZC:2 B 0.5YA90.A4BB 0.5R 1 0 P 0.5VO A1 C1 0.5BL/OR 0.5BL/OR DASH_VDV K13.87A K13.87A B+ 15 S15.15CNPB1:22 0.5BL IB2:17 NG:3 B 0.5Y 0.5VO DASH_VDV ZC:5 C S904.3BB CNPB3:3 XSB10 1.5SB DR S15.DRC CNPB1:23 NG:3 B AG:3 B AG:1 B 0.5BL BMUX:3 50 AG:4 C S907.2 S907.2 A90.A4 S904.3 GND1APA GND1AP DASH_VDV 0.5GN/R DASH_VDV ENG1.A2:4 A S9G 0:

83 1B A S9G 0: 81 1B A S9G 0: 75 2B EA NG G: 13 B ENA GG 1: .4 C 0.5BL/SB KH3A:9 KH3A:8 . . . B :2 A 2:2 0.5W 0.5W IB5:7 A1 S12 2 7 9 CNPB1:24 87A 87 86 A S9G 0: 85 . 1B EA NG G: 13 B B :4 NG:3 C 0.5Y start engine 0.75BL/SB 0.75BL/SB 0.75BL/SB 0.75BL/SB 0.75BL/SB 0.75BL/W 0.75BL/W 0.75BL/W 0.75BL/W 0.75BL/W K11 0.5BL/SB S40 0 1 NG:3 B 30 85 CNPB1:25 3 8 10 B1 0.5Y A90.A4A DASH_VDV 0.5YA27.D4BJ DASH_VDV S15.50B S15.50A 0.75BL/SKBH3A:14 KH3A:12 Prevent K11.30A1 Artic1 K11.30A R7 K11.30B R9B R9S R9TL K11.30CT R9L_ K11.30D B12B B12M B12R A90.A29AA R7 A R9 90 B.

A R2 99 S A RB 9TL A90.A29ACT R9L_ A90.A29AD B12B B12M B12R A90.A29A1 Artic1 A90.A4B 0.5Y 0.5Y ENG1.A1:4 ENG1:4 ENG1:2 ENG1.A1:2 1.5Y IB5:4 S15.50 XSA28 S15.50C BB2:11 BMU CX N:4 PB3:1 X GS BB :11 3 D 0.5BL A90.A14 A90.A14B K13.87C 0.5VO 0.5BL/SB 0.5BL/SB 0.5BL/SB K11.30 BB A90.A14A XSB25 KH2B:1 DASH_VDV 0.75VO 0.75VO − A90.A29A_2 0.5Y K13.87D K13.87E CG:4 D D2 FTM:8 S15B 0.5BL Feed 21 13 Switch,Starter A90.A26 C A + IB5:6 KH2B:4 0.5BL/W A90.A4C_1 A90.A14D 0 1 2 0.75GN/R 0.75BL/SB D22 B14 ENG1:1 A90.A2T A90.A2 0.5Y 0.5Y A90.A209.5BL/W A90.B160.5BL 25BL/R 0.5BL/R 0.5BL/R S901.2 AG:2 B S15.50 R9L_ ENG1B:1 CNG 0.5Y A90.A0.

S15.DRA A90.A14 0.5BL/R 0.5BL/R XSA26 A90.A4 A90.A2A1 A90.A2A2 0.5Y 0.75GN A90.B15 A90.B15 ENG1.A1:1 Artic1 ENG1.A2:1 Artic2 ENG1.A3:1 BBOX UBBOX BBOX:1 0.75GN B15 A4 A14 A1 A26 A29 B16 A2 A90 X903.XC109:10 Control unit, BBM, Body Builder Module AB:5 C F57 5A FH3B:4 0.5R IB5:5 DAS BMUX:5 0.5RF42 BB DAS B1 0.5YA90.A4BB A1 0.5BL/OR 0.5BL 0.5Y DASH_VDV CNPB3:3 A90.A4 0.5BL DASH_VDV IB5:7 0.5Y A90.A4A 0.5Y A90.A4B BB2:11 BB CG FT XSA2 0.5B L/W

Стр. 4